Aiwa HV-FX5200 User manual

Aiwa
Brand
Aiwa
Model
HV-FX5200
Category
Cassette players
Type
User manual
STEREO VIDEO CASSETTE RECORDER
HV-FX5200
S/M Code No. 09-996-332-8R1
LE
SERVICE MANUAL
DATA
BASIC TAPE MECHANISM : D-33
REVISION
This Service Manual is the "Revision Publishing" and replaces "Simple Manual"
(S/M Code No. 09-996-332-8T1).
2
TABLE OF CONTENTS
SPECIFICATIONS ............................................................ 3
ACCESSORIES LIST ....................................................... 3
DISASSEMBLY INSTRUCTIONS..................................... 4
SERVICE POSITION ........................................................ 5
VCR TEST TAPE INTERCHANGEABILITY TABLE ........ 6
ELECTRICAL MAIN PARTS LIST.............................. 7 ~ 9
TRANSISTOR ILLUSTRATION........................................ 9
WIRE HARNESS DIAGRAM .......................................... 10
BLOCK DIAGRAM ................................................. 11 ~ 20
SCHEMATIC DIAGRAM
1. POWER SECTION.............................................. 21 ~ 22
2. AUDIO/VIDEO SECTION.................................... 23 ~ 24
3. SYSTEM CONTROL/SERVO/OSD SECTION) .. 27 ~ 28
4. Hi-Fi/SCART SECTION ...................................... 29 ~ 30
5. TUNER/IF SECTION........................................... 31 ~ 32
6. NICAM SECTION................................................ 33 ~ 34
7. FRONT-1 C.B.............................................................. 37
8. FRONT-2 C.B.............................................................. 37
WAVEFORM
1. VIDEO SECTION ........................................................ 25
2. SERVO/OSD SECTION.............................................. 26
3. TUNER/IF SECTION................................................... 32
4. NICAM SECTION........................................................ 34
WIRING
1. MAIN C.B SECTION ........................................... 35 ~ 36
2. FRONT 1 C.B SECTION............................................. 38
3. FRONT 2 C.B SECTION............................................. 38
IC DESCRIPTION ................................................... 40 ~ 45
ADJUSTMENT........................................................ 46 ~ 47
MECHANICAL EXPLODED VIEW 1/1 ........................... 48
MECHANICAL PARTS LIST 1/1 ................................... 49
MECHANISM EXPLODED VIEW 1/3, 2/3, 3/3 ..... 50,52,54
MECHANISM PARTS LIST 1/3, 2/3, 3/3 .............. 51,53,55
DECK MECHANISM PARTS LOCATIONS
Top View.......................................................................... 56
Bottom View .................................................................... 56
DECK MECHANISM DISASSEMBLY
1. Drum Assembly ......................................................... 57
2. Plate Assembly Top................................................... 59
3. Holder Assembly CST ............................................... 59
4. Guide CST ................................................................ 59
5. Bracket Side (L)/Bracket Assembly Door .................. 59
6. Arm Assembly F/L ..................................................... 59
7. Lever Assembly S/W ................................................. 59
8. Arm Assembly Cleaner.............................................. 60
9. Head F/E ................................................................... 60
10. Base Assembly A/C Head ......................................... 60
11. Brake Assembly S ..................................................... 61
12. Brake Assembly T ..................................................... 61
13. Arm Assembly Tension .............................................. 61
14. Reel S & Reel T ........................................................ 61
15. Support CST ............................................................. 62
16. Base Assembly P4 .................................................... 62
17. Opener Lid ................................................................ 62
18. Arm Assembly T/up ................................................... 62
19. Arm Assembly Pinch ................................................. 62
20. Belt Capstan/Motor Capstan ..................................... 63
21.Clutch Assembly D33 ................................................. 63
22. Lever F/R .................................................................. 63
23. Gear Assembly H-Up/D or Gear Assembly Up/D ...... 63
24. Bracket Assembly Jog............................................... 64
25. Guide Rack F/L, Gear Rack F/L................................ 64
26. Brake Assembly Capstan .......................................... 64
27. Gear Drive/Gear Cam/Gear Connector .................... 65
28. Bracket Assembly L/D motor..................................... 65
29. Gear Sector............................................................... 66
30. Base Tension/Plate Slider/Lever Tension.................. 66
31. Gear Assembly P3/Gear Assembly P2 ..................... 67
32. Base Assembly P3/Base Assembly P2 ..................... 67
33. Arm Assembly Idler Jog or Arm assembly Idler......... 67
DECK MECHANISM ADJUSTMENT
Tools and Fixtures for service ......................................... 68
1. Mechanism Alignment Position Check ........................ 69
2. Preparation for Adjustment ......................................... 70
3. Checking Torque ......................................................... 70
4. Guide Roller Height Adjustment .................................. 71
4-1. Preliminary Adjustment .......................................... 71
4-2. Precise Adjustment ................................................ 71
5. Audio/Control (A/C) Head Adjustment......................... 72
5-1. Preliminary Adjustment .......................................... 72
5-2. Confirm that the Tape Path smoothly between
the Take-up Guide and Pinch Roller ..................... 73
5-3. Precise Adjustment (Azimuth Adjustment) ............. 73
6. X-Value Adjustment ..................................................... 73
7. Adjustment after Replacing Drum Assembly
(Video Heads) ............................................................. 74
8. Check the Tape Travel after Reassembling
Deck Mechanism......................................................... 74
8-1. Checking Audio and RF Locking Time
during Playback and after CUE or REV ................ 74
8-2. Check for Tape Curling or Jamming....................... 74
MAINTENANCE/INSPECTION PROCEDURE
1. Check before starting Repairs .................................... 75
2. Required Maintenance ................................................ 76
3. Scheduled Maintenance ............................................. 76
4. Supplies Required for Inspection and Maintenance ... 76
5. Maintenance Procedure.............................................. 76
5-1. Cleaning................................................................. 76
5-2. Greasing ................................................................ 77
MECHANISM TROUBLESHOOTING GUIDE
1. Deck Mechanism ........................................................ 78
2. Front Loading Mechanism .......................................... 81
3
REF. NO PART NO. KANRI DESCRIPTION
NO.
ACCESSORIES LIST
1 S8-35R-P00-36B INSTRUCTION ASSY(FX52OOLE)
2 S7-11R-1P0-16A REMOTE CONTROLLER ASSY
3 S5-640-18B-000 PLUG ASSY PHONO CORD
4 S8-610-33B-000 CABLE SET ASSY
5 S8-610-45F-000 CABLE,COAXIAL 1.2M/M
6 S8-615-05R-000 CABLE ASSY
SPECIFICATIONS
• Design and specifications are subject to change without notice.
Video recording system Rotary 2 head helical scanning system
Video head Double azimuth 4 heads
Tuner system Frequency synthesized tuner
TV system B/G, L/L’ SECAM, B/G PAL
Video signal system SECAM/MESECAM/PAL color signal,
625 lines, 50 fields
Usable cssettes VHS video cassettes
Recording/playback time PAL/SECAM/MESECAM
SP: 4 hours 20 minutes max. with
E-260 tape.
LP: 8 hours 40 minutes max. with
E-260 tape
NTSC (Playback only)
SP: 3 hours max. with T-180 tape
LP: 6 hours max. with T-180 tape
EP: 9 hours max. with T-180 tape
Tape speed PAL/SECAM/MESECAM
SP: 23.39 mm/sec.
LP: 11.69 mm/sec.]
NTSC (Playback only)
SP: 33.35 mm/sec.
LP: 16.67 mm/sec.
EP: 11.12 mm/sec.
Rewind time: Approx. 3 min. with E-180 tspe
Channel coverage VHF-low: C02 to C04, C13 to C20
(SECAM), S01 to S07
VHF-high: C05 to C12, S08 to S41
UHF: C21 to C71
Video input 0.5 - 2.0 Vp-p, 75 ohm, unbalanced
Video output 1.0 Vp-p, 75 ohm, unbalanced
Horizontal resolution 240 lines
Video S/N 43 dB (SP)
Audio track 3 tracks (Hi-Fi sound 2 tracks,
Normal sound 1 track)
Audio input SCART: -8 dBs, 22 k ohm
Audio output SCART: -8 dBs, less than 2.2 k ohm
Hi-Fi frequency response 20 Hz - 20 kHz
Hi-Fi dynamic range More than 80 dB
Hi-Fi wow & flutter Less than 0.01%(nominal)
Operating temperature: 5 °C to 40 °C
Power requirements 200 - 240 V AC, 50 Hz
Power consumption 20 watts
TYPE 3.5 watts (power save mode.)
Dimensions 360 (W) x 278 (D) x 95 (H) mm
(14
1
/
4
x 11 x 3
3
/
4
in.)
Weight Approx. 3.3 kg (7.26 lbs.)
4
DISASSEMBLY INSTRUCTIONS
1. Top Case Removal
1) Remove 4 screws holding the top case.
2. Panel Front Removal (see Fig. 1)
1) Release 7 tabs, and then remove the panel front.
Fig. 1
3. Front-1 C.B. and Front-2 C.B. Removal (see Fig. 2)
1) Release 2 tabs, and then remove front-1 C.B. from the
connector (PKM02) in the direction of arrow (1).
2) Release the tab, and then remove front-2 C.B. from the
connector (PKM01) in the direction of arrow (2).
Fig. 2
4. Mechanism Removal (see Fig. 3)
1) Disconnect the drum FF cable from the connector
(PMD01) on the Main C.B.
2) Disconnect the ACE head FF cable from the connector
(P3D02) on the Main C.B.
3) Remove 6 screws (A).
Fig. 3
5. Main C.B. Removal (see Fig. 4)
1) Remove 2 screws (B) holding the panel assy, distri-butor.
2) Release 5 tabs, and then simultaneously lift the panel as-
sembly, distributor and Main C.B. to remove them.
Fig. 4
TAB
PANEL
FRONT
PANEL ASSY,
DISTRIBUTOR
MAIN C,B
TAB
TAB
TAB
TAB
TAB
B
PKM02
TAB
TAB
TAB
(1)
(2)
PKM01
Front-1 C,B
Front-2 C,B
MAIN C,B
FF CABLE
FF CABLE
PMD01
P3D02
A
A
A
5
SERVICE POSITION
To set the mechanism to the service position in active status:
Insert a spacer as shown below: The service position can be set in the stable status without any defective contact.
Location
Install spacers at locations (A) and (B).
MAIN C.B
D33 MECHANISM
SPACER
60mm
MAIN C.B
D33
MECHA
SPACER
REAR PANEL
Use a spacer with a diameter of 10-15 mm,
and of any shape (round, square, etc.).
Caution: The spacer must be of insulated
material, of a size that does not hinder
the mechanism loading.
Side view
A
B
CYLINDER
HEAD CLEANER
D33 Mechanism Top View
6
VCR TEST TAPE INTERCHANGEABILITY TABLE
There are two types of the new allgnment tape CH-1B (for NTSC) and CH-2 (for PAL). On each tape four signals (1)-(4)
are recorded for the times and in the order shown below.
(1) : 8min. → (2) : 2min. → (3) : 5min. → (4) : 5min.
The TTV-MP1 (for M-PAL), TTV-MS1 (for MESECAM) and TTV-S1 (for SECAM) allgnment tapes have the same
contents as the previous tapes.
Method
Now in use TYPE
Model Contents *1
New TYPE
Model Contents *1
Application
NTSC
PAL
TTV-N1
NTSC, Color bar,
1 kHz, SP
TTV-NS1
NTSC, Color bar,
1 kHz, SP
TTV-N1E
NTSC, Color bar,
1 kHz, EP
TTV-NS6E
NTSC, Color bar,
No sound, EP
TTV-N2
NTSC, Stairsteps,
7 kHz, SP
TTV-N12
(SCV-1998)
NTSC, Color bar,
1 kHz, SP
NTSC, Mono scope,
7 kHz, SP
TTV-N7A
NTSC, Stairsteps,
1 kHz, SP, HiFi 400 Hz
TTV-N6
(TTV-N06T)
TTV-P1
PAL, Color bar,
1 kHz, SP
TTV-P1L
PAL, Color bar,
1 kHz, LP
TTV-P2
PAL, Stairsteps,
6 kHz, SP
PAL, Monoscope,
6 kHz, SP
TTV-P6
(TTV-N06T)
TTV-P7
PAL, Stairsteps,
1 kHz, SP,
HiFi 1 kHz
TTV-P16
PAL, Color bar,
400 Hz,
SP, HiFi 1 kHz
CH-1B(2)
NTSC, Stairsteps,
1 kHz, SP
No Changed.
NTSC, Color bar,
1 kHz, EP
CH-1B(4)
*2
No Changed.
CH-1B(1)
NTSC, Stairsteps,
7 kHz, SP
CH-1B(4)
NTSC, Color bar,
1 kHz, EP
No Changed.
CH-1B(3)
NTSC, Color bar,
No sound SP,
HiFi 400 Hz
PAL, Stairsteps,
1 kHz, SP
CH-2 (2)
* 3
CH-2 (4)
PAL, Color bar,
1 kHz, LP
CH-2 (1)
PAL, Stairsteps,
6 kHz, SP
No Changed.
CH-2 (3)
PAL, Color bar,
No sound
SP, HiFi400 Hz
No Changed.
PB-Y Level/General electrical ADJ.
Head ACE Height/Tilt ADJ.
For S-VHS (SQPB) check
Switching position ADJ.
For S-VHS (SQPB) check
Head ACE Azimuth ADJ.
FM Envelope ADJ.
X-Value ADJ.
For total picture quality check (resolution, etc)
HiFi Audio PB Level ADJ.
Switching position ADJ.
PB-Y Level/General electrical ADJ.
Head ACE Height/Tilt ADJ.
Switching position. (LP Model)
FM Envelope ADJ. (LP Model)
X-Value ADJ. (LP Model)
HEAD ACE Azimuth ADJ.
FM Envelope ADJ. (SP Model)
X-Value ADJ. (SP Model)
For total picture quality check (resolution, etc)
FM Filter ADJ.
HiFi Audio PB Level ADJ.
* 1. Described in the order of color format. video signal. linear audio. tape speed and Hi-Fi audio.
* 2. Use CH-1B (1)-(3) with models used exclusively in the SP mode.
* 3. Use CH-2 (3) and (4) when it is necessary to observe the chroma signal.
7
REF. NO PART NO. KANRI DESCRIPTION
NO.
REF. NO PART NO. KANRI DESCRIPTION
NO.
ELECTRICAL MAIN PARTS LIST
IC
SI-SS4-310-00A IC,KA431AZ
SI-SK6-153-00A IC,STR-G6153T 5P
! S2-309-024-040 SENSOR LTV-817B PHOTO COU
! S6-570-62B-000 SENSOR PC123Y
SI-KE4-310-00A IC,KIA431 3P
SI-TO1-238-00A IC,TA1238N
SI-SA7-159-10A IC,LA71591M
SI-GS3-977-57B IC,GMS3977RAA57F
SI-HI3-977-17A IC,HD3977RC17F
SI-SS3-082-00A IC,KA3082
SI-AL2-416-00B IC,AT24C16-10PC
SI-SS7-531-00A IC,KA7531Z
SI-KE7-031-00A IC,KIA7031P
SI-SS7-542-00A IC,KA7542Z
87-001-196-010 IC,KIA7042P
87-A20-281-010 IC,MN12510
87-A21-261-010 IC,MSP3417D
SI-SA7-479-30A IC,LC74793
SI-PH9-605-00A IC,TDA9605H
SI-RH7-635-00A IC,BH7635S
TRANSISTOR
ST-R31-990-9AF TR,KTC3199-BL
ST-R10-300-9AE TR,KRC103M
ST-R32-030-9AA TR,KTC3203-Y
S7-A30-293-010 TR,KTC2804-Y
ST-R31-980-9AC TR,KTC3198-TP-BL
S3-1KR-A10-3M0 TR,KRA103M-TP
ST-R70-900-9AE TR,KSA709C-Y
ST-R12-680-9BA TR,KTA1268-BL
ST-R12-730-9AA TR,KTA1273-TP-Y
SK-RC1-01M-000 TR,KRC101M
ST-R12-670-9AC TR,KTA1267-GR
DIODE
SD-D01-000-9AC DIODE,EU01W
87-020-465-080 DIODE,1SS133
87-017-011-080 DIODE,IN4003A
83-NEG-677-080 DIODE,MTZ5.6B
87-070-173-010 DIODE,S1WBA60
SD-D01-000-9CA DIODE,EG01CW
87-A40-284-080 DIODE,ERA22-10
87-020-215-010 DIODE,ERC81-004L22
SD-R18-020-9AA DIODE,ERA18-02KFRB
87-070-112-060 DIODE,RU4YX-LF
87-A40-345-080 ZENER,MTZ10-C
SM-TZ6-8CT-000 ZENER,MTZ6.8C
83-NEG-678-080 ZENER,MTZ6.2B
87-002-743-080 ZENER,MTZ33B
SD-Z51-000-9HA ZENER,MTZ5.1B 0.5W
SD-Z13-000-9AA ZENER,MTZ13A
MAIN C.B
!C101 S6-240-88F-000 CAP,0.1UF-275V
!C102 S6-240-88F-000 CAP,0.1UF-275V
C103 S0-2TF-H68-0M0 CAP,E 68U-400V
!C105 87-016-375-010 CAP,0.01UF-630V
!C106 S6-240-87B-000 CAP,100P-1KV
C109 87-010-982-040 CAP,E 33UF-25V
!C112 87-012-379-010 CAP,3300PF-400V
!C113 SA-1B3-0KH-2M0 CAP,220PF-400V
C115 87-010-408-040 CAP,E 47UF-50V
C116 87-010-237-910 CAP,E 1000UF-16V
C117 87-016-577-080 CAP,E 470UF-16V
C118 87-010-248-080 CAP,E 220-10V
C119 87-010-408-040 CAP,E 47UF-50V
C120 87-010-387-010 CAP,E 470UF-25V KME
C121 87-010-387-080 CAP,E 470UF-25V
C123 87-010-078-080 CAP,E 47M-6.3V
C124 87-010-552-040 CAP,E 22-16V
C151 87-015-698-080 CAP,E 4.7-50V
C152 87-015-698-080 CAP,E 4.7-50V
C153 87-015-698-080 CAP,E 4.7-50V
C156 87-015-681-080 CAP,E 10-16V
C157 87-015-681-080 CAP,E 10-16V
C159 87-015-681-080 CAP,E 10-16V
C201 87-010-402-040 CAP,E 2.2-50V
C203 87-010-400-080 CAP,E 0.47-50V
C206 87-010-400-080 CAP,E 0.47-50V
C208 87-015-681-080 CAP,E 10-16V
C210 87-010-078-080 CAP,E 47M-6.3V
C213 87-010-402-040 CAP,E 2.2-50V
C303 87-015-695-080 CAP,E 1.0-50V
C304 87-016-088-040 CAP,E 220-6.3V
C310 87-015-698-080 CAP,E 4.7-50V
C315 87-015-681-080 CAP,E 10-16V
C316 87-015-681-080 CAP,E 10-16V
C318 87-010-402-040 CAP,E 2.2-50V
C320 SC-N10-50K-948 CAP,1UF-50V
C322 87-010-078-080 CAP,E 47M-6.3V
C323 87-010-078-080 CAP,E 47M-6.3V
C325 SC-N10-50K-948 CAP,1UF-50V
C326 87-015-681-080 CAP,E 10-16V
C327 SC-N10-50K-948 CAP,1UF-50V
C331 87-016-088-040 CAP,E 220-6.3V
C334 87-016-088-040 CAP,E 220-6.3V
C337 87-015-698-080 CAP,E 4.7-50V
C339 87-015-698-080 CAP,E 4.7-50V
C346 87-016-088-040 CAP,E 220-6.3V
C348 87-015-695-080 CAP,E 1.0-50V
C354 87-016-088-040 CAP,E 220-6.3V
C358 87-015-695-080 CAP,E 1.0-50V
C401 87-010-078-080 CAP,E 47M-6.3V
C405 87-015-681-080 CAP,E 10-16V
C406 87-015-681-080 CAP,E 10-16V
C415 87-010-552-040 CAP,E 22-16V
C420 87-010-408-040 CAP,E 47UF-50V
C423 87-015-698-080 CAP,E 4.7-50V
C466 87-010-403-040 CAP,E 3.3-50V
C4A1 87-010-552-040 CAP,E 22-16V
C500 87-016-455-080 CAP,E 470UF-6.3V
C502 87-010-078-080 CAP,E 47M-6.3V
C504 87-016-088-040 CAP,E 220-6.3V
C505 87-010-078-080 CAP,E 47M-6.3V
C524 87-010-265-080 CAP,E 33-16V
C525 87-015-684-080 CAP,E 47-16V
C526 87-016-130-080 CAP,47-25V
C530 87-015-681-080 CAP,E 10-16V
C534 87-015-698-080 CAP,E 4.7-50V
C535 87-015-698-080 CAP,E 4.7-50V
C541 87-015-698-080 CAP,E 4.7-50V
C546 87-015-684-080 CAP,E 47-16V
C561 87-010-078-080 CAP,E 47M-6.3V
C588 87-015-698-080 CAP,E 4.7-50V
C5F7 87-010-078-080 CAP,E 47M-6.3V
C5F8 87-010-078-080 CAP,E 47M-6.3V
C701 87-015-698-080 CAP,E 4.7-50V
C702 87-015-681-080 CAP,E 10-16V
C703 87-015-681-080 CAP,E 10-16V
C704 87-010-078-080 CAP,E 47M-6.3V
C706 87-016-577-080 CAP,E 470UF-16V
C7S1 87-010-265-080 CAP,E 33-16V
C7V1 87-015-684-080 CAP,E 47-16V
C7V2 SC-N10-50K-948 CAP,1UF-50V
C7V6 87-015-698-080 CAP,E 4.7-50V
8
REF. NO PART NO. KANRI DESCRIPTION
NO.
REF. NO PART NO. KANRI DESCRIPTION
NO.
C7V7 87-015-695-080 CAP,E 1.0-50V
C7V8 87-015-695-080 CAP,E 1.0-50V
C806 87-015-698-080 CAP,E 4.7-50V
C807 87-015-698-080 CAP,E 4.7-50V
C810 87-015-681-080 CAP,E 10-16V
C811 87-015-681-080 CAP,E 10-16V
C813 87-015-681-080 CAP,E 10-16V
C814 87-015-681-080 CAP,E 10-16V
C815 87-015-681-080 CAP,E 10-16V
C816 87-015-681-080 CAP,E 10-16V
C817 87-015-681-080 CAP,E 10-16V
C818 87-015-698-080 CAP,E 4.7-50V
C819 87-015-681-080 CAP,E 10-16V
C821 87-015-684-080 CAP,E 47-16V
C822 87-015-681-080 CAP,E 10-16V
C823 87-015-681-080 CAP,E 10-16V
C824 87-015-681-080 CAP,E 10-16V
C825 87-015-684-080 CAP,E 47-16V
C827 87-015-681-080 CAP,E 10-16V
C828 87-015-684-080 CAP,E 47-16V
C832 87-010-078-080 CAP,E 47M-6.3V
C835 87-010-400-080 CAP,E 0.47-50V
C902 87-016-577-080 CAP,E 470UF-16V
C912 87-016-577-080 CAP,E 470UF-16V
C941 87-015-681-080 CAP,E 10-16V
C942 87-010-132-080 CAP,E 1.0-50V
C948 87-015-681-080 CAP,E 10-16V
C950 87-015-681-080 CAP,E 10-16V
C951 87-015-684-080 CAP,E 47-16V
CS501 S6-00R-DB0-04B SW SPPB62042 5V
CS501 S6-00R-DB0-04C SW,MPU10252MLB4 MIC
DIG5F1 S3-02R-1N0-03A DH 9MT168GK
DIG5F1 S3-02R-2N0-03A DH SVV09MM14
ES501 S9-31R-001-6A0 SENSOR END
ES502 S9-31R-001-6A0 SENSOR END
!F101 S5-850-11T-000 FUSE,1600MA 250V
!F101 S5-850-11C-000 FUSE,T 1.6A 250V
!F103 87-001-196-010 ICP-N10 T104
!FH01 S5-860-08B-000 FUSE CLUMP
!FH02 S5-860-08B-000 FUSE CLUMP
JK901 S6-20R-M00-02A JACK 42P
JK902 S5-720-36H-000 JK BJP
!L102 S6-161-45H-000 FILTER SHT LFS2020V4-04350
!L102 S6-161-45J-000 FL BUJEON V-04350
L103 S6-330-88G-000 COIL,CHOCK TP 5MM
L104 S6-330-88G-000 COIL,CHOCK TP 5MM
L105 87-003-152-080 INDUCTOR,100M 2.3-3.4-5
L201 87-003-282-080 COIL,12 2.3-3.4-5
L301 87-005-196-080 COIL,10UH
L302 87-003-286-080 COIL,56 2.3-3.4-5
L303 87-003-148-080 INDUCTOR,33
L304 87-005-696-080 COIL,100UH
L307 87-005-696-080 COIL,100UH
L309 87-005-696-080 COIL,100UH
L401 87-003-145-080 INDUCTOR,8.2
L402 87-003-129-080 INDUCTOR,6800
L405 87-005-196-080 COIL,10UH
L502 87-005-696-080 COIL,100UH
L505 87-005-696-080 COIL,100UH
L506 87-005-686-080 COIL,15UH
L507 87-003-152-080 INDUCTOR,100M 2.3-3.4-5
L5S1 87-003-148-080 INDUCTOR,33
L701 87-005-696-080 COIL,100UH
L702 87-005-196-080 COIL,10UH
L703 87-005-196-080 COIL,10UH
L704 87-003-145-080 INDUCTOR,8.2
L7V1 87-005-696-080 COIL,100UH
L801 87-005-696-080 COIL,100UH
L802 87-005-696-080 COIL,100UH
L901 87-003-152-080 INDUCTOR,100M 2.3-3.4-5
L902 87-003-152-080 INDUCTOR,100M 2.3-3.4-5
L904 87-003-152-080 INDUCTOR,100M 2.3-3.4-5
L905 S6-360-04C-000 COIL,BFS3550R2FD8
L906 87-003-152-080 INDUCTOR,100M 2.3-3.4-5
L907 S6-360-04C-000 COIL,BFS3550R2FD8
L911 87-003-152-080 INDUCTOR,100M 2.3-3.4-5
L912 87-003-152-080 INDUCTOR,100M 2.3-3.4-5
L914 87-003-152-080 INDUCTOR,100M 2.3-3.4-5
L916 87-003-152-080 INDUCTOR,100M 2.3-3.4-5
L924 87-003-152-080 INDUCTOR,100M 2.3-3.4-5
L926 87-003-152-080 INDUCTOR,100M 2.3-3.4-5
L941 87-005-696-080 COIL,100UH
LD501 S9-31R-001-7A0 LED
MS501 S6-00R-PY0-01B SW,MMS00420ZMBO MIC
P3D01 S5-612-34Y-000 CONN,6P
P3D02 S6-30R-5S0-08E CONN,6P
P3D03 S5-612-51B-000 CONN,2P
PM701 S6-724-43B-000 CONN,6P
PM702 S5-618-43J-000 CONN,9P
PMC01 S6-30R-2P0-05C CONN,8P
PMD01 S5-612-34V-000 CONN,7P
PMK01 S6-724-34B-000 CONN,5P
PMK02 S5-618-43J-000 CONN,10P
PML01 S6-30R-2S0-11A CONN,2P
PML01 S6-30R-2S0-11A CONN,2P
!PW101 S5-612-92B-000 CONN,2P
R101 S6-140-07R-000 RES,2.7-2W
R102 SR-S10-03K-619 RES,100K-2W
R109 SR-S03-50K-619 RES,0.35-2W
R/C5F1 S7-12R-293-8GA REMOCON RECEIVER
RS501 S5-00R-AB0-02A SENSOR GP1S566
RS502 S5-00R-AB0-02A SENSOR GP1S566
!T101 S6-420-23M-000 TRANS EER2828
TL401 S6-330-32K-000 COIL,OSC BIAS 1CHIP 5V
TU701 S7-00R-P3L-02A TUNER TADC-S003D LGC&N BG SECA
VR501 S6-130-32W-000 SFR,RH0638CJ5R(220K)
X201 S2-02R-142-8BE X’TAL,4.286230MHZ
X201 S2-02R-142-8AC X’TAL,4.286M 16PF
X301 S2-02R-144-3AD X’TAL,4.433709M
X301 S2-02R-144-3AC X’TAL,4.433709M
X301 S2-02R-144-3AE X’TAL,4.433709MHZ 15PPM
X501 S2-02R-310-01F X’TAL,10.0000
X501 S2-02R-310-01E X’TAL,10.0000MHZ
X502 S5-290-01B-000 X’TAL,32.768KHZ
X502 S5-290-01K-000 X’TAL,32.768KHZ
X503 S2-02R-317-71F X’TAL,17.7344
X503 S2-02R-317-71E X’TAL,17.734476MHZ
X5F1 S6-180-10B-000 X’TAL,4MHZ
X7V1 S2-02R-317-71F X’TAL,17.7344
X7V1 S2-02R-317-71E X’TAL,17.734476MHZ
NICAM C.B
C752 87-015-684-080 CAP,E 47-16V
C753 87-015-684-080 CAP,E 47-16V
C760 87-015-684-080 CAP,E 47-16V
C761 87-010-403-040 CAP,E 3.3-50V
C763 87-015-681-080 CAP,E 10-16V
C765 87-015-684-080 CAP,E 47-16V
C773 87-015-681-080 CAP,E 10-16V
C774 87-015-681-080 CAP,E 10-16V
C775 87-015-681-080 CAP,E 10-16V
C776 87-015-681-080 CAP,E 10-16V
L752 87-005-696-080 COIL,100UH
L753 87-005-696-080 COIL,100UH
L754 87-003-129-080 INDUCTOR,6800
L755 87-003-129-080 INDUCTOR,6800
P7M51 S5-618-48D-000 CONN,6P
P7M52 S5-618-48F-000 CONN,9P
X751 S5-290-219-000 X’TAL 18.432MHZ
9
FRONT-1 C.B
PMK02 S5-618-44J-000 CONN,10P
SW5A1 S5-562-82C-000 SW,SKQNQED ALPS 5MM
SW5A2 S5-562-82C-000 SW,SKQNQED ALPS 5MM
SW5A3 S5-562-82C-000 SW,SKQNQED ALPS 5MM
SW5A4 S5-562-82C-000 SW,SKQNQED ALPS 5MM
SW5A5 S5-562-82C-000 SW,SKQNQED ALPS 5MM
SW5A6 S5-562-82C-000 SW,SKQNQED ALPS 5MM
FRONT-2 C.B
LD5A1 SD-L53-110-0AA LED,SG5311(GRN)
PMK01 S5-610-36D-000 CONN,5P
SW5A0 S5-562-82C-000 SW,SKQNQED ALPS 5MM
SW5A7 S5-562-82C-000 SW,SKQNQED ALPS 5MM
SW5A8 S5-562-82C-000 SW,SKQNQED ALPS 5MM
SW5A9 S5-562-82C-000 SW,SKQNQED ALPS 5MM
REF. NO PART NO. KANRI DESCRIPTION
NO.
TRANSISTOR ILLUSTRATION
KRA103M
KRC101M
KRC103M
KTA1267
KTC3198
KTC3199
KSA709
KTA1268
KTC3203
KTA1273 KTC2804
E C B
E C B
E C B
E C B
10
WIRE HARNESS DIAGRAM
1
2
3
4
5
GND
OTB "H"
5.3VA
GND
KEY RTN1
1
2
3
4
5
1
2
3
4
5
6
7
D.CTL
M.GND
DFG
12V
PG
GND
5.3V
1
2
3
4
5
6
7
1
2
3
4
5
6
7
8
GND
MOTOR GND
I-LIMIT
CAP CTL
12V
CFG
CAP REV "L"
5.3V
1
2
3
4
5
6
7
8
1
2
3
4
5
6
CTL(+)
CTL(-)
A/E(-)
A/E(+)
A.REC
A.PB
1
2
3
4
5
6
1
2
3
4
5
6
7
8
9
10
1
2
3
4
5
6
7
8
9
10
SP A PB
SP REC
SP B PB
LP A PB
LP REC
LP B PB
Hi-Fi A PB
Hi-Fi REC
Hi-Fi B PB
1
2
3
4
5
GND
MODE S1
MODE S2
MODE S3
MODE S4
1
2
3
4
5
1
2
GND
FULLERASE
1
2
LOWER
DRUM
CAPSTAN
MOTOR
MS501
MODE SW
FULL ERASE
HEAD
CYL.
HEADS
A MAIN C.B
D FRONT2 C.B
ACE
HEAD
PMD01 PMD01
PMC01 PCM01
P3D02 P3D02
MS501
P3D03 PD303
1
2
LD(+)
LD(-)
1
2
LOADING
MOTOR
PML01 PML01
P3D01 P3D01
PKM01 PMK01
1
2
3
4
5
6
7
8
9
10
GND
KEY RTN0
1
2
3
4
5
6
7
8
9
10
C FRONT1 C.B
B NICAM C.B
PKM02 PMK02
P7M51 PM701
1
2
3
4
5
6
5V
MONO AUDIO
GND
SIF
GND
GND
P7M52 PM702
1
2
3
4
5
6
7
8
9
1
2
3
4
5
6
7
8
9
GND
GND
GND
TU AUDIO (R)
GND
TU AUDIO (L)
9V
IIC CLOCK
IIC DATA
11
BLOCK DIAGRAM-1 (POWER SECTION)
5.3VA
5VG
BD101
R101
R102
C103
C113
C112
HOT GND
F101
WH
(BL)
BK
(BR)
PW101
6
9
10
11
8
7
12
2
1
4
3
13
13
1
2
IC102
IC103
4
T101
TRANSFORMER
4
2
3
1
RECTIFIER
& SMOOTHING
9V REG.
BLOCK
(Q152,R152,
Q165,C153,
ZD152)
RECTIFIER
& SMOOTHING
RECTIFIER
& SMOOTHING
DRIVE & S/W BLOCK
OVER CURRENT LIMIT
BLOCK
+
12.5VA
-27VA
STAND-BY "H"
FD(-)
FD(+)
33V
12VA
9V
12V(DRUM)
5VT
5V
D152 D154 D155
SNUBBER
BLOCK
(IC101,R109,C111,
D104,R103,C109)
(D102,R104,
C105,C106)
(D107, F103,
C118)
(D109, C120,
L104,C121)
(D106, C116,
L103,C117)
NOTES: Symbol denotes AC ground.
Symbol denotes DC chassis ground.
FROM µ-COM
P.CTL"H"
LINE FILTER
BLOCK
(C101,L102,
C102)
RECTIFIER
& SMOOTHING
(D105, C115)
-27VG S/W BLK
(Q154,R164,R165,Q155)
(Q156,Q157,R166,R167)
RECTIFIER
& SMOOTHING
(D108, C119)
36V S/W
BLOCK
(Q158,R154,
R155)
12VT REG.
BLOCK
(Q153,C152
R171, ZD153)
5VT SW
BLOCK
(Q162, R161,
R162)
5V S/W
BLOCK
PWR CTL
BLOCK
Q160
(Q159, R158,
R159)
(Q161)
FEED-BACK
BLOCK
(R116,R117,R118
R119,R120,R121
C114)
12VA REG.
BLOCK
(Q151,R151, ZD151, C151)
FD(+) REG BLK
(Q164,R169,R170)
5VG SW BLK
FROM/TO
SYSCON/SERVO
SECTION
TO
SYSCON/SERVO
SECTION
TO
SYSCON/SERVO,
TUNER/IF SECTION
TO
SYSCON/SERVO,
TUNER/IF,AUDIO/VIDEO
SECTION
TO
SYSCON/SERVO,
TUNER/IF,AUDIO/VIDEO,
Hi-Fi SECTION
FROM
SYSCON/SERVO
SECTION
TO
Hi-Fi SECTION
TO
TUNER/IF
SECTION
Hot Circuit
12
ACC
C. COMB LPF
Y
DELAY
MAIN
CONV
C LPF
PB EQ
LPF
YNR
NL
DE EMP
Y/C
MIX
60dB AMP
CLAMP
DOUBLE
LIMIT
PB
PEAKING
MAIN
DE-EMPH
V.H S/W
CLOCK DATA C SYNC
Y/C
VIDEO
V. OUT
VPS
PB FM
AGC
FM
DEM
ENV.
DET
SUB
LPF
SP 'B' PB
SP 'A' PB
FROM
CYL.HEADS
V. ENV
TO
SYSCON/SERVO
SECTION
FROM
SYSCON/SERVO
SECTION
FROM/TO
SYSCON/SERVO
SECTION
COLOR
ROTARY
88
5974 57 54 52 51 61 72 71
15 21
46
45
43
41
91
93
10 18 17 21 20 23 24 28 29
11
LP 'A' PB
LP 'B' PB
82
85
IC301
LA71591M
VIDEO/AUDIO
PROCESSOR
PB MODE
REC MODE
IC201 TA1238N
SP REC
IC 301
LA71591M
VIDEO/AODIO
PROCESSOR
COLOR
ROTARY
V. H S/W
CLOCK
DATA
C. SYNC
REC 'H'
90
LP REC
84
71 72 61 51 52 54 57 59
46
45
43
41
38
32
31
3028242319181110
+
REC FM
EQ
FM
MOD
W/D
CLIP
MAIN
EMPH
AGC
FBC
NL EMPH
DETAIL
ENH
Y-LPF
YNR
BPF1
C. COMB
BPF
Y
DELAY
COMB
AMP
CCD
LPF
S/W
V. IN 1
24
12
IC201
TA1238N
Q301
Q302
Q304
Q303
Q303
Q304
Q201
:PB Y SIGNAL
:PB CHROMA SIGNAL
:REC Y SIGNAL
:REC CHROMA SIGNAL
Q305
FROM
SYSCON/SERVO
SECTION
FROM/TO
SYSCON/SERVO
SECTION
TO
CYL.HEADS
MAIN
DE-EMPH
2120
Q302
R308,R309,
C309,C363
FROM
Hi-Fi
SECTION
BLOCK DIAGRAM-2 (VIDEO SECTION)
1413
BLOCK DIAGRAM-3 (TUNER/IF, NICAM, A2 SECTION)
4
6
7
8
9
4
6
7
8
9
TU AUDIO(R)
TU AUDIO(L)
9V
IIC CLOCK
IIC DATA
1
2
4
1
2
4
5V
MONO AUDIO
SIF
123456789101112
24 23 22 21 20 19 18 17 16 15 14 13
1
25
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
BB
NC
AUDIO
SDA
4MB
SCL
VIDEO
MD TU
RF AGC
NC
AS
SCL
SDA
B+
B+
NC
TU
TP
IF
SW 1
SW 2
AUDIO
SIF
AFT
VIDEO
1B
2B
3B
4B
5B
1E
2E
4E
5E
1H
2H
3H
4H
5H
6H
7H
8H
5.3VA
9V
5VT
33VT
5V
TU AUDIO(L)
TU AUDIO(R)
VIDEO
TU VIDEO
OSD VIDEO
IIC CLOCK
IIC DATA
TU SECVL "H"
IIC CLOCK
AFT
VIDEO(VPS)
TU SEC "H"
To
POWER
SECTION
To
Hi_Fi
SECTION
To
SYSCON/
SERVO
SECTION
PM701P7M51
PM702P7M52
C7V3 C7V4
X7V1
17.734476MHz
IC7V1
LC74793
VPS
Timing
Generator
V.Sync
Sep.
Sync
Detect
Sync Sep/
Data
Sucer
IIC BUS
Interface
AFC
(VCO)
Data
Latch
Data
Acousition
VDD2
VDD1 RST
VSS1
NC VSS2
A MAIN(TUNER/IF SECTION)C.B
:REC AUDIO SIGNAL
:PB AUDIO SIGNAL
:REC VIDEO SIGNAL
:PB VIDEO SIGNAL
TU701
ANTENA IN
ANTENA OUT
SECAM AGC
CONTROL
Q7S1
SECAM AGC
CONTROL
Q701
52 51 50 49 48 47 46 45 44 43 42 41 39 38 37 36 35 34 33 32 31 30 29 272840
1
NC
AUD CLK
C CTL 1
C CTL 0
ADR SEL
STANDBYQ
IIC CLK
IIC DATA
IIS CL
IIS WS
IIS DA OUT
IIS DA IN
ADR DA
ADR WS
ADR CLK
DVSSUP
DGND
IIS DA IN2
NC
RESETQ
DACA R
DACA L
VREF2
DACM R
DACM L
DACM SUB
SC2 OUT R
SC2 OUT L
VREF1
SC1 OUT R
SC1 OUT L
CAPL A
A8VSUP
CAPL M
AGND
AGNDC
SC3 IN L
SC3 IN R
SC2 IN L
SC2 IN R
SC1 IN L
SC1 IN R
VREF TOP
MONO IN
AGND
AVSUP
ANA IN1
ANA IN-
ANA IN2
TESTEN
IN
OUT
2 3 4 5 6 7 8 9 101112 1415161718192021222324 262513
PILOT
DET
FM
BLOCK
IIC BUS
INTERFACE
DEINTERLEAVING
NICAM DECODING
FRAME
SYNC
DQPSK
DECODER
PD
IIS1 BUS
INTERFACE
IIS2 BUS
INTERFACE
DECIMATION SHAPING
FILTER
GEN2
MIXER
GEN1
A/D
LEVEL
CTL
TIMING
RECOVERY
AUDIO
PLL
INPUT
SELECT
A/D
7-LINE
I/P
SELECT
DEEMPHASIS
S-BUS
INTERFACE
MATRIX
DAC
VOL
DAC
VOL
DAC
VOL
OVERSAM
FILTER
DAC
VOL
OVERSAM
FILTER
DAC
DAC
OUTPUT SELECT
D751
X751
18.432MHz
IC751IC751
MSP3415DMSP3415D
NICAM,A2NICAM,A2
B NAICAM C.B
:REC AUDIO SIGNAL
FILTER
FILTER
1615
BLOCK DIAGRAM-4 (Hi-Fi/SCART SECTION)
1
11
10
9
8
7
6
5
4
3
2
33
23
24
25
26
27
28
29
GND
Lref
Vref
30
31
32
44 34
VCC
43 42 41
A.H/SW VCCH GNDH
40 39 38 37 36 35
12 2213 14
13 24
15 16 17 18 19 20 21
LINE
SELECT
OUTPUT
SELECT
DEC.
SELECT
NORMAL
SELECT
NOISE
REDUCTION
INPUT
SELECT
PEAK
HOLD
DCL
DCR
DCL
DCR
NOISE
REDUCTION
HF
AGC
HF
LPF
LEVEL DET.
HF LIMITER
HF
LPF
PLL 1.3M
CCO
I C
PLL 1.7M
CCO
AUDIO
CLIPPER
NOISE
SUPPR.
1.3M
BPF
1.7M
BPF
LEVEL DET.
HF LIMITER
AUDIO
CLIPPER
NOISE
SUPPR.
DOC
2
14 15 16 17 18 19
VCC
20 22 2321
12 1
22
42
40
38
36
34
32
30
28
26
24
23
41
39
37
35
33
31
29
27
25
11109876
GND
532
GND
4
VCC
5V
REG
IC-BUS
CONT.
CLAMP CLAMP CLAMP
CLAMP
1
21
19
17
15
13
11
9
7
5
3
2
20
18
16
14
12
10
8
6
4
4J
1E
2E
4E
5E
TU AUDIO(R)
VIDEO
TU VIDEO
4G
5G
6G
MONO AUDIO
AUDIO IN 1
VIDEO IN 1
3J
2J
1J
3G
2G
1G
2A
1A
A.ENV.
TU AUDIO(L)
IIC CLOCK
IIC DATA
A.H/SW
HF B PB
HF REC
HF A PB
5V
12VA
9J
8J
7J
LV MT "R"
LV MT "L"
C+ DET "H"
C801
ZD801
ZD802
IC801
TDA9605H
VHS Hi-Fi AUDIOVHS Hi-Fi AUDIO
PROCESSORPROCESSOR
C827
10/16
C826
6800P
R822
33K
R821
2.7K
C825
47/16
C824
10/16
C823
10/16
R820
39K
C822
10/16
C821
47/16
R819
2.7K
C820
6800P
R818
33K
C819
10/16
ZD805
ZD806
L905
BEAD
JK902
JK901
SCART2
AUDIO
OUT(R)
AUDIO
OUT(L)
L907
BEAD
IC901
BH7635S
JK901
SCART1
A MAIN(Hi-Fi SECTION)C.B
To
POWER
SECTION
To
A/V
SECTION
To
SYSCON/
SERVO
SECTION
To
TUNER/IF
SECTION
To
A/V
SECTION
To
SYSCON/
SERVO
SECTION
AV2 IN (DECODER)
AV1 IN/OUT (TV)
:REC AUDIO SIGNAL
:PB AUDIO SIGNAL
:REC VIDEO SIGNAL
: VIDEO SIGNAL
:PB VIDEO SIGNAL
1817
BLOCK DIAGRAM-5 (Hi-Fi PB SECTION)
BLOCK DIAGRAM-6 (Hi-Fi REC SECTION)
AMP
HI-FI B
HI-FI A
FROM
CYL.HEADS
HI-FI S/W 25
AMP
SERIAL
DECOEDR
AMP
37
35
41
44 40 34
16
17
19
20
434222
961
4
5
23
24
100
HF
AGC
BPF
(L,R)
PLL
HP
LIMITER
SWITCH
NOISE
AUDIO
LPF
DATA
LP/EP
REC"H"
Q402
Q403
Q404
AUDIO
REC/PB
HEAD
I C
2
CLOCK
DATA
SERIAL
DECODER
LINE
AMP
MUTE
IC301
LA71591M
VIDEO/AUDIO
PROCESSOR
CLK
EU1 A.OUT L
A.OUT L
A.OUT R
JK902
EU2 A.OUT L
EU1 A.OUT R
EU2 A.OUT R
OUT SELECT
NOISE
REDUCTION
LEVEL
DET
IC801
TDA9605H
VHS Hi-Fi AUDIO
PROCESSOR
A.ENV
5V 12VA
FROM
TUNER/IF
SECTION
FROM
SCART 1,
SCART 2
FROM/TO
SYSCON/SERVO
SECTION
FROM
SYSCON/SERVO
SECTION
FROM
POWER
SECTION
FROM
POWER
SECTION
TO
SCART 1,
SCART 2
FROM
SYSCON/SERVO
SECTION
TO
CYL.HEAD
FROM
SYSCON/SERVO
SECTION
:PB AUDIO SIGNAL
:PB AUDIO SIGNAL
1
40 34
99
36
6
796
76
98
434221
2
3
6
7
8
9
EE
VOLUME
TU A.IN L
TU A.IN R
EU1A.IN L
EU1A.IN R
EU2A.IN L
EU2A.IN R
AUIDO
LPF
AUIDO
CLIPPER
HF
LPF
CCO MIX
NOISE
REDUCTION
INPUT SELECT
AUTO
BIAS
REC
AMP
LINE
AMP
ALC
MUTE
CONTROL
Q401
CURRENT
AMP
BIAS
OSC
TL401
Q405
NOMAL
SELECT
5V 12VA
IC801
TDA9605H
VHS Hi-Fi AUDIO
PROCESSOR
IC301
LA71591M
VIDEO/AUDIO
PROCESSOR
DATA
I C
2
CLOCK
AUDIO
REC,PB
HEAD
HF REC
2019
BLOCK DIAGRAM-6 (SYSTEM CONTROL SECTION)
IC505
KIA7042P
FROM
POWER
SECTION
IC504
KIA703P
IC503
FROM/TO
POWER
SECTION
FROM/TO
AUDIO/
VIDEO
SECTION
FROM/TO
Hi-Fi
SECTION
FROM/TO
TUNER/IF
SECTION
FROM/TO DECK
AT24C16
EEPROM
IC502
L/D MOTOR
MODE SW
MS501
PML01
12V
(DRUM)
KA3082
1
2
3
VCC
GND
OUT
RESET
VCC
GND
OUT
RESET
VCC
GND
V OUT
5V
-27VG
5VG
5.3VA
5V
OSC
OSC
OSC
OSC
RC5F1
REMOCON
SENSOR
CS501
CST&REC SW
REC P/STILL REW
FF PLAY STOP
CH-UP CH DOWN
ONE-TOUCH POWER
PLAYBACK
Q501
Q503
1
1234
5678
23
321
12
3
45
67
89
10
GND
ZD501
C529
C528
GND
MODE S1
MODE S2
MODE S3
MODE S4
OUT 1
OUT 2
R526
R555
R553
R550
R559
R560
R556
R558
Q515
Q514
RS502
SUP.REEL
RS501
T-UP REEL
LD501
DECK IR LED
C501C506 C521C503
C500C505
L502
L505
R503
C561C554
R525
ES502
END
X501
10MHZ
X503
17.734MHz
L506
R518
C518
C519
VR501
PG ADJ
X502
32.768KHZ
ES501
T-UP END
LD(-)
CTL+
CTL-
CAP REV "H"
I - LIMIT
DRUM PWM
CAP PWM
DFG
DPG
CFG
CAP ADJ
DRUM ADJ
LEVEL METER 'L'
LEVEL METER 'R'
A.ENV
A. H/SW
C+ DET 'H'
IIC CLK
IIC DATA
IIC CLK
IIC DATA
V.ENV
V. H/SW
PWR CTL 'H'
REC 'H'
DV.SYNC
SECAM DET "H"
TIMER "H"
C.ROTARY
H AMP SW
COMP. IN
CVin
CVout
STAND-BY 'H'
AFT
C.SYNC(INV)
IIC DATA
IIC CLK
IIC DATA
IIC CLK
S7/ FLD ENV
A.MUTE "H"
C.SYNC(NOR)
LD(+)
MODE SW1
MODE SW2
MODE SW3
MODE SW4
OSC1
OSC2
X-TAL1
X-TAL2
END SENSOR
PG ADJ
T-UP SENSOR
SUPPLY REEL
T-UP REEL
DOSC OUT
DOSC IN
R/C
CST SW 'H'
KEY RTN 1
KEY RTN 0
CTL.GAIN ADJ
CTL1
CTL2
CTL3
CTL CONT.
Vcc(OSD)
Vcc(SERVO)
Vcc(SYS)
Vcc(A/D)
4fsc out
4fsc in
P 1
P 2
V ret
IN 1
IN 2
VCC 1
VCC 2
3
78
5
4
19
31 32 61 78 26 25 38 39 40 80 81 11 23 21 90 91
90
91
12
24
62
54
60
79
27
6
66
28
29
30
43
45
88
9
87
81
TU SEC "H"
63
TU SEC VL "H"
18
90
91
90
94
S4/ FLD DATA OUT
97
S5/ FLD DATA IN
S6/ FLD CLK
RESE
PWR FA
96
95
16
89
20
77
76
75
74
72
73
70
69
10
1
52
53
51
50
82 57 14 13 55 35 36 37 42 41 22
15
34
IC501
HD3977
SYSCON/SERVO
PROCESS
5VT
1
2
3
4
5
1LD +
2LD -
R
R
D FRONT 2 C.B C FRONT 1 C.B
5.3VA
CTL.
GAIN
ADJ
Q5A1
1
P15
P16
NC
NC
G1
G2
G3
G4
G5
P3
P2
P1
POWER LED
SHUTTLE4
SHUTTLE3
SHUTTLE2
SHUTTLE1
DATA OUT
DATA IN
CLK
234567891011
33 32 31 30 29 28 27 26 25 24 23
44
43
42
41
40
39
38
37
36
35
34 P4
P5
P6
P7
P8
P9
P10
P11
P12
P13
P14
12
13
14
15
16
17
18
19
20
21
22
G6
G7
G8
G9
VPP
IC5F1
MN12510
LED DRIVE
VDD
OSC1
OSC2
VSS
ENA
OSC
X5F1 4MHz
2221
SCHEMATIC DIAGRAM-1(POWER SECTION)
R
R
R
R
2B
3C
4C
5C
6C
7C
8C
9C
10C
11C
12C
2C
1C
1D
2D
3D
13C
3B
4B
5B
6B
1A
1B
1B 6B
2A
3A
5.3VA
9V
5VT
33VT
5V
GND
12VA
5V
GND
12.3V(CAP)
12V(DRUM)
-27VG
-21VG(F-)
-15VG(F+)
STAND-BY "H"
5VG
TIMER "H"
5VT
5V
PWR CTL "H"
5.3VA
GND
5VT
5V
GND
POWER CORD
PW101
F101
T1.6A/250V
C101
0.1
FH02
FH01
L102
33m
C102
0.1
BC101
BEAD CORE
BD101
S1WBA60
R102
100K 2W
R101
2.7 2W
C103
68/400
C122
0.022
R104
56K
2W
C105
0.01/630
C106
100P/1K
BC102
BEAD
D102
ERA22-10
EG01CW
5
4
3
2
41
23
1
DROIN
OCP
GND
FB
VCC
Slort
OVP
Reg1(9.4V)
Reg2(7.2V)
Reg3(7.2V)
TSD
Latch
Drive
Buffer
Amp.
Mirror
FB Curent
Detector
Counter
FB OCP
OSC
S
RQ
IC101
G-6153T
R109
0.35 2W
C109
33/25
C111
0.022
C112
3300P
C113
220P
IC103
KA431AZ
or
KIA431
IC102
PC123Y
or
LTB-8178
R103
8.2
D104
EU01W
1
2
15
13
12
7
8
11
10
96
4
T101
EER2828
D109
RU4YXLF
D108
EU01W
ZD151
MTZ13A
R151
1.2K
ZD153
MTZ13A
C152
4.7/50
R171
3.9K
R165
12K
L105
100M
R164
12K
R166
2.2K
R167
2.2K
R155
27K
R154
1K
R161
270
R162
330
R158
270
R159
330
C123
47/6.3
Q161
KTC3199BL
C124
22/16
R172
12K
D151
1SS133
R156
10K
R157
1K
R169
1K
R170
1K
D153
T/W
R152
1.2K
C153
4.7/50
ZD152
MTZ10C
ZD104
MTZ5.6B
C155
0.1
Q165
KRC101M
Q155
KRA103M
Q157
KRA103M
C156
10/16
D155
1N4003A
D154
1N4003A
D152
1N4003A
C159
10/16
C120
470/25
C151
4.7/50
C157
10/16
Q151
KTC3203Y
Q154
KTC3198BL
Q156
KTC3203Y
Q158
KTA1268BL or KSA709CY
Q164
KTA1273Y
Q162
KTA1273Y
Q159
KTA1273Y
Q160
KRC101M
Q152
KTC3203Y
Q153
KTC2804Y
L104
22MH
C121
470/25
C119
47/50
FR02
4.7 1/4W
F103
ICP-N10
D107
ERA18
C118
220/10
C117
470/16
R114
100K
L103
22MH
C116
1000/16
C115
47/50
D106
ERC81-004L
D105
EU01W
R116
330
R117
2.2K
R118
1K
C114
0.047
R119
3.3K
1%
R120
2.7K
1%
R121
180
To
TUNER/IF
SECTION
1A 3A
To
Hi-Fi
SECTION
1C 13C
To
SYSCON/
SERVO
SECTION
1D 3D
To
A/V
SECTION
HOT CIRCUIT
A MAIN(POWER SECTION)C.B
2423
SCHEMATIC DIAGRAM-2 (AUDIO/VIDEO SECTION)
1 30
31
50
2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29
80 5179 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
100
81
99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
ALC
Vref
2.3V
ENV
DET
MUTE
Vref
LINE
AMP
ALC
DET
Vref
2.3V
EQ
AMP
EQ
AMP
COMP
OUT
REC
FM
AGC2
PB FM
AGC
REC FM
AGC1
REC
FM EQ
DOUBLE
LIM
SERIAL
DECODER
NL
EMPHA
CLAMP
CLAMP
H-PLL
FBC
CLAMP
1/2
DETAIL
ENH
FM
DEM
SUB
LPF
Chara
INS
60dB
AMP
SYNC
SEP
Y/C
MIX
N.C1
N.C2
PIC-CTL
ANR
SYNC
DET
EE
AGC
PB FM
EQ
AUDIO
SIGNAL
PROCESSING
HEAD AMP
RF
PROCESSING
FM
PROCESSING
W/D
CLIP
FM
MOD
Y. N .R
BPF1
Y.LPF
AFC
1.1M BPF
V/I
CON
MAIN
CONV
SUB
CONV
BALANCE
BPF2
C-LPF
ACC
AGC
DET
B-UP
AMP
REC
BGA
BPF
D.E.
D.E.
D.E.
SLD
C COMB
CCD
LC89981/82
DELAY
PROCESSING
Y DELAY
VXO2 VXO1
NAP
KIL
KIL
B.D.
KIL
DET
PILOT
BG
320FH
VXO
COMB
AMP
PHASE
ALT
SECAM DET
PAL M DET
REC
APC
REC
APC
REC
APC
DET
REC
AFC
ID DET
CCD
LPF
PB BGA
AFTER
PB BGA
BEFORE
NL
DEEMP
A.GND
PB/EE
PB EQ
THROUGH
S-VHS:OPEN
320/321FH
VCO
VXO
XO
PB/EE
REC:EP/LP
PB:EP
REC
FM AGC2
DET
H.A
GND
H.A
GND
H.A
GND
A-VCC
C-GND
SP
LP/EP
A-MUTE/
C+ROT
RFSW/
HASW IN
REC
S-FM IN
FM AGC
DET
ACC DET
BAL/TCI
Y-VCC
Y-GND
R
R
P
P
P
P
P
R
AFC
DET
DET
SYNC
REG
ALWAYS
5V
DELAYED
SIGNAL
VCA
DET
R
R
R
R
R
R
R
R
RR
RR
B.B
R
R
P
R
R
NTSC-M
P
P
P
P
P
PB-Y
PB-C
P
P
P
PB
CTL
EQ
TC1
AGC
TC2
P
P
COMP
IN
Y/C SEP
IN
P
P
R
BEFORE
NON CORR
MES
CORRE
AFTER
C-MAIN
C-DELAY
Cn-CTL
Cn-CTL
C-VCC
NTSC:H
CCD
VCC
CCD
GND
To
SEC
DET
P
1 12234567891011
24 1323 22 21 20 19 18 17 16 15 14
PHASE
ADJ
MAIN
ID-DET
IDENT
IIC BUS
SYSTEM
SW
4.3M
BPF
ACC1
ACC
BPF
ACC
DET
BELL
ADJ
1.1M
PRE-BPF
Anti Bell
ADJ
SYSTEM
SW
1/4
C/D
X 2 X 2
1.1/4.3
Anti Ball
L/M 1/4
ATT
SYNC
GATE
SYNC
COMORESS
ACC2
LIMITER
2.2M BPF
V C/D
V SEP
SLICER
V C/D
VCO
AFC
LP
XVCO
QUAD DET
TRICK
ID-DET
EP
ADJ
4.3/1.1
BELL
DAC
TRICK
SW8
REC
REC
REC
REC
REC
PB
PB
PB
PB
PB
PAL/NTSC
SECAM
SW5
SW4
SW2
SW3
SW6
SW7
1
2
3
4
5
6
7
8
9
10
Hi-Fi A PB
Hi-Fi REC
Hi-Fi B PB
SP A PB
SP REC
SP B PB
LP A PB
LP REC
LP B PB
2
1
F/E
GND
3G
2G
1G
4G
5G
6G
6G1G
13F
14F
15F
16F
16F3F
11F
12F
8F
9F
10F
6F
7F
3F
4F
5F
1F
2F
1
2
3
6
5
4
2D
3D
3D1D
1D
5VT
5V
GND
REC "H"
H.AMP SW
C.ROTARY
79
29
28
62
24
91
90
27
6
54
30
12
A.MUTE "H"
V.H/SW
IIC DATA
IIC CLOCK
DV.SYNC
VIDEO(VPS)
VIDEO(Y/C)
SEC DET "H"
C.SYNC
COMP OUT
V.ENV
To
SYSCON/
SERVO
SECTION
To
CYL.HEADS
To
Hi-Fi
SECTION
2F1F
To
SYSCON/
SERVO
SECTION
P3D01
HF B PB
HF REC
HF A PB
MONO A.OUT
AUDIO IN1
VIDEO IN1
CTL(-)
CTL(+)
6
5
4
3
2
1
AUDIO PB
AUDIO REC
A/E (+)
A/E (-)
CTL (-)
CTL (+)
P3D02
P3D03
To
POWER
SECTION
,
A MAIN(AUDIO/VIDEO SECTION)C.B
C367
0.022
R337
18K
C3A1
0.022
R3A1
2.2K
C320
1
C373
0.1
C346
220/6.3
IC301
LA71591M
VIDEO/AUDIO
PROCESSOR
IC201
TA1238N
L-SECAM
CHRONA
PROCESSOR
L307
100uH
R350
470
C350
0.1
C348
1/50
C466
3.3/50
C302
0.1
R3A2
47K
R3B1
4.7K
R431
4.7K
R3A3
1K
C375
0.1
L402
6800u
R406
2.7K
C410
0.1
C412
0.1
C413
0.01
R412
1.8K
R413
8.2K
R415
330K
R414
12K
C414
0.01
R416
150
C415
22/16
C423
4.7/50
TL401
BIAS COIL
C421
0.022
R422
560
R418
27K
C417
1200P
C416
2200P
R417
1K
C368
1000P
C371
0.022
Q301
KTC3199
BL
Q302
KTC3199BL
C309
330P
C363
39P
R308
2.7K
R306
330
R341
2.7K
R307
330
R310
1K
C304
220/6.3
C305
0.1
L301
10uH
R312
1.8K
C311
180P
R335
18K
C369
0.022
C370
180P
C314
0.1
R317
82K
R325
1K
C323
47/6.3
C315
10/16
C316
10/16
C317
0.01
C318
2.2/50
R318
4.7K
C319
0.1
C322
47/6.3
C324
0.1
L304
100UH
R319
1K
C325
0.1
C326
10/16
C327
1
C313
100P
Q303
KTA1267GR
C328
0.047
C329
0.01
C330
0.01
C210
47/6.3
L201
12M
C209
0.022
R213
100
C203
0.47/50
R209
100
X201
4.286MHz
C214
15P
C215
0.1
C216
0.1
C217 0.1
R206
100
R210
1K
R205
1K
R204
1K
C213
2.2/50
C212
0.033
Q201
KTA1267GR
C201
22/50
R211
1.5K
C211
0.022
R212
100
C208
10/16
C207
0.047
C206
0.47
C205
0.01
C204
0.047
Q304
KTC3199BL
Q202
KTC3199BL
C335
0.1
C354
220/6.3
L309
100uH
C334
220/6.3
C218
0.1
C220
0.022
C405
10/16
C406
10/16
C355
0.01
RF TP
C401
47/6.3
C402
0.022
R430
3.9K
R201
470
R222
1K
R322
8.2K
C358
1/50
C341
0.022
C340
0.033
C339
4.7/50
R321
1.5K
C338
0.022
R326
2.7K
C337
4.7/50
C342
0.01
C343
0.047
C344
0.022
R323
5.6K
C403
0.1
R425
47K
L401
8.2M
X301
4.43MHz
C331
220/6.3
D301
1SS131
Q305
KTA1267
GR
R316
150
R311
4.7K
C312
22P
R313
470
L303
33M
C3B1
0.033
C303
1/50
C301
0.1
R349
5.6K
C353
22P
C307
27P
R309
820
C310
4.7/50
C306
0.01
R490
47K
R491
12K
V.H/SW TP
L405
10uH
R419
47
C420
47/50
C424
0.1
R420
1K
C418
0.015
C419
0.01
R421
2.2
R410
10K
R411
22K
R409
4.7K
C4A1
22/16
R408
2.2K
R407
22K
R404
270
R403
6.8K
C408
0.015
Q3A1
KTC3199BL
Q404
KTC3199BL
Q405
KTC3203Y
Q403
KTC3199BL
Q401
KTA1267GR
Q402
KTA1267GR
Q3A2
KTC3199BL
C431
0.01
R333 560
R424 270
30
79
79
REC "H"
REC "H"
12 V.ENV
COMP.OUT
R302 10K
R303 18K
R304 10K
R340 18K
R305 1.2K
L302 56M
62 A.MUTE
28 C.ROTARY
24 V.H/SW
29 H.AMP SW
90 IIC CLOCK
91 IIC DATA
27 DV.SYNC
54 C.SYNC
79 REC "H"
C336 0.01
C332 0.01
79
REC "H"
R301
R402 2.2M
R324 10K
91 IIC DATA
6 SECAM DET "H"
90 IIC CLOCK
54 C.SYNC
27 DV.SYNC
To
CTL/AUDIO
HEADS
To
FULL
ERASE
HEAD
5VT
5V
5V
5VT
ONE VOLTAGE:PB OR REC MODE
TWO VOLTAGES:PB AND (REC) MODE
:REC AUDIO SIGNAL
:PB AUDIO SIGNAL
:PB CHROMA SIGNAL
:PB VIDEO SIGNAL
:PB Y SIGNAL
:REC CHROMA SIGNAL
:REC VIDEO SIGNAL
:REC Y SIGNAL
*
: WAVEFORMS No.
2.4 2.4 2.5 2.4 0.1
(2.4)
2.4 2.4 0 0 1.0 1.7
5.1
(2.7)
1.5
1.9
(1.5)
2.3 5.1
3.0
(0.2)
1.9
(2.5)
1.1
(2.5)
3.0
2.2
(2.5)
0
1.8(2.3)
4.3(3.8)
1.2
(1.7)
1.3
(1.9)
5.1
2.2
(2.5)
4.9 4.9 0
0
2.4
1.7(0.6)
0.1 0.3 0.3
2.9
1.5(2.3)
1.9(1.3)
2.2
4.1
5.1
3.0
2.8(3.1)
2.1
0
1.5
(2.3)
1.6
1.6
0
2.6
(2.2)
9.5
2.2
0.9
0
1.9
1.9
1.3
5.0
2.602.65.1
3.4
0.2
(0.5)
5.03.33.43.43.55.05.0
2.1
(1.4)
2.73.800.6
2.0
(2.9)
2.53.23.4
1.8
(0)
5.02.402.42.5
0
0
0
0.7
0.7
0
5.0
1.9(4.8)
0
1.9(0)
1.9(4.8)
0.2
4.2(0)
0(0.3)
0
2.3
0
2.4(1.6)
4.9
(4.1)
2.4(3.3)
2.4
(1.9)
1.8
(3.3)
1.3
(3.4)
1.8
(3.3)
1.6
(4.7)
1.7
(2)
1.1
(4.4)
5
4 15 14
1
9
2
2
2
7
16
1212
12
13
8
11
3 610
25
WAVEFORM-1 (VIDEO SECTION)
IC301 Pin
20
PBmode
500mvp-p
IC301 Pin
38 , 32 , 31
Video in
1Vp-p
IC301 Pin
28
PB/REC mode
4.2Vp-p
IC301 Pin
7
REC mode
1.4Vp-p
IC301 Pin
6
REC mode
2.2Vp-p
IC301 Pin
29
PB mode
2.1 Vp-p
IC301 Pin
41
PB mode
400mVp-p
IC301 Pin
64
PB mode
600mVp-p
IC301 Pin
51 ,
52 , 54
PB mode
300mVp-p
IC301 Pin
71, 72
REC mode
340mVp-p
IC301 Pin
24
PB/REC mode
5Vp-p
IC301 Pin
23
PB/REC mode
5Vp-p
IC301 Pin
63
PB mode
600mVp-p
IC301 Pin
71
PB mode
3.2Vp-p
IC301 Pin
10
PB mode
1.8Vp-p
IC301 Pin
43
PB mode
400mVp-p
1
2
5
6
3
7
4
8
12
9
10
11
16
15
14
13
26
WAVEFORM-2 (SERVO/OSD SECTION)
IC501 Pin
24
1V/5mS
REC/PB mdes
(V.H/SW)
IC501 Pin
27
1V/2mS
QUE/REV modes
(D.V-SYNC)
IC501 Pin
31
1V/10mS
REC mode
(CTL+)
IC501Pin
32
1V/10mS
REC mode
(CTL–)
IC501 Pin
38
1V/1mS
REC/PB mode
(DFG)
IC501 Pin
39
1V/10µS
REC/PB modes
(DPG)
IC501 Pin
45
500mV/10µS
EE/PB modes
(V-OUT)
IC501 Pin
40
1V/1mS
REC/PB modes
(CFG)
IC501 Pin
43
100mV/10µS
EE/PB modes
(V-IN)
IC501Pin
54
1V/20µS
EE/PB modes
(C-SYNC)
1 2
3
4
87
6
5
9
10
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16
  • Page 17 17
  • Page 18 18
  • Page 19 19
  • Page 20 20
  • Page 21 21
  • Page 22 22
  • Page 23 23
  • Page 24 24
  • Page 25 25
  • Page 26 26
  • Page 27 27
  • Page 28 28
  • Page 29 29
  • Page 30 30
  • Page 31 31
  • Page 32 32
  • Page 33 33
  • Page 34 34
  • Page 35 35
  • Page 36 36
  • Page 37 37
  • Page 38 38
  • Page 39 39
  • Page 40 40
  • Page 41 41
  • Page 42 42
  • Page 43 43
  • Page 44 44
  • Page 45 45
  • Page 46 46
  • Page 47 47
  • Page 48 48
  • Page 49 49
  • Page 50 50
  • Page 51 51
  • Page 52 52
  • Page 53 53
  • Page 54 54
  • Page 55 55
  • Page 56 56
  • Page 57 57
  • Page 58 58
  • Page 59 59
  • Page 60 60
  • Page 61 61
  • Page 62 62
  • Page 63 63
  • Page 64 64
  • Page 65 65
  • Page 66 66
  • Page 67 67
  • Page 68 68
  • Page 69 69
  • Page 70 70
  • Page 71 71

Aiwa HV-FX5200 User manual

Aiwa
Brand
Aiwa
Model
HV-FX5200
Category
Cassette players
Type
User manual
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents