ADLY MOTO GTA 50 Owner's manual

1

E x c l u s i v e l y D i s t r i b u t e d b y B i n t e l l i S c o o t e r s

Owner’s

Manual

GTA 50

Bullseye 50

2

PREFACE

We would like to take this opportunity to thank you for choosing ADLY.

The purpose of this owner’s manual is to prepare you for the safe operation and

maintenance necessary of your new scooter. It is highly recommended you read

over the entire manual prior to driving.

Should you have any problems, please contact your local dealer and they will

assist you.

Enjoy your new scooter and ride safe.

Note: The information and specifications stated in this manual are for reference

purpose only and are subject to change without notice.

3

CONTENTS

Page

Welcome ………………………………………………………………………..……. 2

Operation Warnings...……………..………………………………….……….……. 4

Safety Information ………………………..…………………………….…….....….. 5

Warranty Information ……………………………………………………….………. 6

Specifications ………………………………………………………………………... 7

Periodic Checks and Services ……………………………………….……………. 12

Pre Operating Inspection …………………………………………………..………. 12

Operation …………………………………………………………………….………. 17

Maintenance ……………………………………………………………….…....…… 28

Proper Driving Technique ………………………………………………......……… 35

Troubleshooting …………………….. ……………………………………………… 39

Vehicle Identification Number ……………………………………………………… 41

Pre-Delivery Inspection (PDI) ……………………………………….……...……… 42

Maintenance & Service Records …………………………………………………... 43

Abnormalities Service Records……………………………………………………... 44

4

OPERATION WARNINGS

THIS VEHICLE IS NOT A TOY AND CAN BE HAZARDOUS TO OPERATE.

NEVER OPERATE THIS VEHICLE WITHOUT PROPER INSTRUCTION.

THIS VEHICLE IS NOT INTENDED FOR CHILDREN.

ALWAYS WEAR A HELMET WHEN OPERATING THE VEHICLE.

READ ENTIRE OWNER’S MANUAL CAREFULLY BEFORE USE.

THIS VEHICLE IS DESIGNED FOR ON-ROAD USE ONLY.

USE EXTRA CARE WHEN DRIVING AT NIGHT OR POOR CONDITIONS.

DO NOT USE VEHICLE IF UNDER THE INFLUENCE OF DRUGS.

DO NOT USE THIS VEHICLE ON HILLS TOO STEEP FOR SAFE DRIVING.

ALWAYS INSPECT YOUR VEHICLE PRIOR TO USING IT.

5

SAFETY INFORMATION

Don’t allow your child to ride.

Read all warning stickers on vehicle and follow the instructions.

Always maintain a safe distance between your vehicle and other vehicles.

If you are new to scooters, we recommend enrolling in a safety training

course.

This vehicle is designed to be operated only on level, paved road surfaces,

free of obstacles and debris. Always exercise caution and follow the rules of

the road.

6

WARRANTY INFORMATION

Regular servicing and maintenance must be performed on your

vehicle. Please read the following carefully to insure your vehicle

remains covered under warranty:

Vehicle MUST BE INSPECTED by an authorized Adly dealership

within 500 miles or 90 days from the date of purchase,

whichever comes first. Failure to do so will render the limited

warranty null and void. The end user is required to maintain a

dealer inspection record, which will be requested for any

warranty coverage.

**Oil changes for 150cc 4 stroke units are to be completed at a

minimum of every six (6) months or fifteen hundred (1,500) miles,

whichever comes first.**

7

SPECIFICATIONS

MODEL

AS

-

50

AS

-

50LC

LENGTH

7 6 . 7 i n c h e s

WIDTH

2 7 . 9 i n c h e s

HEIGHT

4 4 . 5 i n c h e s

WHEEL BASE

5 0 . 8 i n c h e s

NET WEIGHT

1 9 1 . 8 l b s

ENGINE TYPE

2

-

STROKE, Single Cyli

nder

COOLED

FORCE

AIR COOLED

LIQUID COOLED

DISPLACEMENT

49

CC

BORE × STROKE

40.0 X 39.2 mm

COMPRESSION RATIO

7.0 : 1

IGNITION

C.D.I

STARTER

ELECTRIC/KICK

FRONT SUPENSION

TELESCOPE TYPE

REAR SUPENSION

HYDRAULIC SHOCK ABSORBER

TRANSMISSION

C.V.T.

T

IRE

F:1

3

0/70

-

12, R:1

3

0/70

-

12

FRONT BRAKE

DISC

REAR BRAKE

(B/D)

DRUM

8

SPECIFICATIONS

MODEL

GTA

-

50

GTA

-

50

LC

LENG

TH

7 6 . 7 i n c h e s

WIDTH

2 7 . 9 i n c h e s

HEIGHT

4 4 . 5 i n c h e s

WHEEL BASE

5 0 . 8 i n c h e s

NET WEIGHT

1 9 1 . 8 l b s

ENGINE TYPE

2

-

STROKE, Single Cylinder

CO

OLED

FORCE

AIR COOLED

LIQUID COOLED

DISPLACEMENT

49

CC

BORE × STROKE

40.0 X 39.2 mm

COMPRESSION RATIO

7.0 : 1

IGNITION

C.D.I

STARTER

ELECTRIC/KICK

FRONT SUPENSION

TELESCOPE TYPE

REAR SUPENSION

HYDRAULIC SHOCK ABSORBER

TRANSMISSION

C.V.T.

TIRE

F:1

3

0/70

-

12, R:1

3

0/70

-

12

FRONT BRAKE

DISC

REAR BRAKE

(B/D)

DRUM

9

SPECIFICATIONS

MODEL

GT

C

-

50

BULLSEYE

LENGTH

6 8 . 9 i n c h e s

WIDTH

2 7 i n c h e s

HEIGHT

4 4 . 9 i n c h e s

WHEEL BASE

4 8 i n c h e s

NET WEIGHT

1 7 8 . 6 l b s

ENGINE TYPE

2

-

STROKE, Single Cylinder

COOLED

FORCE

AIR COOLED

DISPLACEMENT

49

CC

BORE × STROKE

40.0 X 39.2 mm

COMPRESSION RATIO

7.0 : 1

IGNITION

C.D.I

STARTER

ELECTRIC/KICK

FRONT SUPENSION

TELESCOPE TYPE

REAR SUPENSION

HYDRAULIC SHOCK ABSORBER

TRANSMISSION

C.V.T.

TIRE

F:1

3

0/70

-

12, R:1

3

0/70

-

12

FRO

NT BRAKE

DISC

REAR BRAKE

(B/D)

DRUM

1 0

SPECIFICATIONS

AS-50 GTA-50

Headlight 12V 35W/35W 12V 35W/35W

Position light 12V LED 12V LED

Rear / Brake light 12V LED

12V LED

Signal light 12V LED

12V LED

Speedometer indicator

12V 3.4W

Signal indicator 12V 1.7W

High beam indicator 12V 1.7W

Safety fuse 10A

Battery 12V 5A

Engine oil capacity 2 Stroke Synthetic Only (SAE20W)

Fuel tank capacity 1.59 Gallons

Gear oil capacity 3.4 fluid ounces, SAE 90W

Disc brake fluid DOT 4 OR 3 BRAKE FLUID

1 1

SPECIFICATIONS

GTC-50

EC US

Headlight

12V 35W/35W 12V 35W/35W

Position light

12V 5W

Rear / Brake light

12V 21/5W 12V 21/5W

Signal light

12V 10W 12V 21W

Speedometer indicator 12V 3.4W

Signal indicator 12V 1.7W

High beam indicator 12V 1.7W

Safety fuse 10A

Battery 12V 4A

Engine oil capacity 2 Stroke Synthetic Only (SAE20W)

Fuel tank capacity 1.59 Gallons

Gear oil capacity 3.4 fluid ounces, SAE 90W

Disc brake fluid DOT 4 OR 3 BRAKE FLUID

1 2

PERIODIC CHECKS & SERVICES

ITEM

Regular Service Mileag

e

300 500 1000

2000

3000

4000

5000

6000

7000

8000

9000

Fuel Filter R R

Brake System I I I I I I I I I I I

Drive Belt Check every 3000 miles, replace if showing signs of wear or cracking

Air Filter Replace air filter every 3000 miles or as needed

Nuts, Bolts T T T

Gear Oil R R R

Carburetor I I

Spark Plug Clean at every 1500 miles or as necessary

Tire I I I I I I I I I I I

Battery I I I I I I I I I I

Pulse Air Filter I R R

Muffler I I I

Fuel Line I I I

Coolant Check every ride, replace every 6000 miles

Notes: 1. R: Replace, A: Adjust, C: Clean, T: Tighten, I: Inspect and clean

2. When listed mileage is exceeded,, perform maintenance according to the listed

intervals.

1 3

PRE OPERATING INSPECTION

CHECK STEERING HANDLE

1. Check ease of turning to the left and right.

2. Check brake cables.

3. Check for abnormalities, if there is damage please contact your local dealer for

inspection and adjustment.

4. Check brake lever for normal operation. Braking free play should be between 1-2 cm

after brake adjustment.

CAUTION

Screw groove must be aligned with lock position after adjustment, any

deviation may result in brake free play change causing unsafe riding conditions.

1 4

PRE OPERATING INSPECTION

Brake cable inspection: Verify brake cable functioning and engaging properly prior to use

CHECK BRAKE LIGHT

1. Turn main switch to “ ON ” position.

2. Apply left and right brake lever separately to

see if brake light functions normally.

3. Check brake light for visibility. Clean lens if

necessary.

Adjusting Adjust screw

1 5

PRE OPERATING INSPECTION

CHECK TURN SIGNAL LIGHTS

1. Turn ignition switch to “ON” position.

2. Turn on signal lights, check to ensure all are functioning.

CHECK TIRE PRESSURE.

STANDARD TIRE PRESSURE

One passenger Two passenger

Front ………………………… 18 psi 25 psi

Rear ………………………… 25 psi 32 psi

Fill or remove air as necessary to reach recommended tire pressure.

1 6

PRE OPERATING INSPECTION

Check for gravel and other debris in the tread grooves, along with signs of punctures.

Remove debris as needed. If the tire is punctured or losing air DO NOT DRIVE. Contact

your local dealer to arrange for servicing.

Check for any signs of cracking or heavy wear. If the wear indicator is visible the tire

must be replaced. Do not drive with cracked or worn tires.

CHECK FRONT & REAR SHOCK ABSORBERS

Apply downward pressure on both front steering handle and seat to check the function of

front and rear absorbers. Shocks should return to normal position after applying

downward pressure.

1 7

OPERATION

Ignition Switch (GTA)

At this position, the power is off and the engine is not running.

The key can be removed from this position.

At this position, power is on and the engine can be started.

The key cannot be removed from this position.

At this position, handlebar is locked to prevent theft.

The key can be removed from this position.

1 8

OPERATION

Ignition Switch (GTC)

OFF

＊ To turn off the engine.

＊ The Key can be removed.

ON

To start the engine.

The Key can be taken out.

CAUTION

IF OIL INDICATOR LIGHT IS ON, OIL LEVEL IS INSUFFICIENT AND SHOULD BE

REFILLED IMMEDIATELY. USE ONLY 2 STROKE SAE20W OIL. DO NOT DRIVE THE

VEHICLE WITH LOW OIL LEVELS AS THIS CAN CAUSE ENGINE DAMAGE

IF THE LIGHT GLOWS WHILE DRIVING, THIS INDICATES OIL IS LOW AND

NEEDS TO BE ADDED.

1 9

OPERATION

STEERING LOCK

Turn handlebar to the left, then press and turn the key from “OFF” to “LOCK”.

Handlebars will lock and the key can be removed.

Handlebars will be unlocked immediately when the key is returned to “OFF” position.

CAUTION

1. After locking, turn the handlebar gently to ensure lock is engaged.

2. During riding, never turn the main switch to “LOCK” position.

2 0

OPERATION

ELECTRIC STARTER

With the ignition in the “ON” position, hold a brake

lever and press the red starter button to start the

engine. Once the engine turns on, immediately stop

pressing the ignition button.

STARTING TIPS

1. Ensure brake lever is fully engaged while pressing the electric start button.

2. Never press the starter button as engine is running.

3. In cold weather, twisting the throttle grip slightly will help with starting.

Page is loading ...

ADLY MOTO GTA 50 Owner's manual

ADLY MOTO GTA 50 Owner's manual

Related papers

Other documents