Pleasant Hearth GLF-5002-75 Installation guide

Pleasant Hearth
Brand
Pleasant Hearth
Model
GLF-5002-75
Category
Fireplaces
Type
Installation guide

This manual is also suitable for

1
COMPACT MOBILE FIREPLACE
MODEL #GLF-5002-50 / GLF-5002-68
GLF-5002-75 / GLF-5002-205
ATTACH YOUR RECEIPT HERE
Serial Number ________________________________ Purchase Date _________________________________
IMPORTANT INSTRUCTIONS
PLEASE READ THIS MANUAL BEFORE INSTALLING AND USING APPLIANCE
WARNING!
IF THE INFORMATION IN THIS MANUALS IS NOT FOLLOWED EXACTLY,
AN ELECTRICAL SHOCK OR FIRE MAY RESULT
CAUSING PROPERTY DMAGE, PERSONAL INJURY OR LOSS OF LIFE.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
20-10-251 Rev. 03/15/17
Questions, problems, missing parts?
Before returning to your retailer, call our customer service department at 1-877-447-4768,
8:30 a.m. – 8:00 p.m. CST, Monday – Friday.
Español p. 17
Français p. 33
C US
2
TABLE OF CONTENTS
Safety Information .................................................................................................3
Package Contents ................................................................................................6
Hardware Contents ...............................................................................................6
Fireplace Dimensions .............................................................................................7
Safety Information .................................................................................................8
Preparation .........................................................................................................8
Assembly Instructions ............................................................................................8
Operating Instructions ........................................................................................... 10
Care and Maintenance ...........................................................................................12
Electric Wiring Diagram ..........................................................................................13
Troubleshooting ...................................................................................................14
Warranty ............................................................................................................15
Replacement Parts ................................................................................................16
IMPORTANT: Read all instructions and warnings carefully before starting installation.
Failure to follow these instructions may result in a possible electric shock, injury to
persons, re hazard and will void the warranty.
Please read the Installation & Operating Instructions before using this appliance.
PRODUCT DAMAGE MAY OCCUR.
Never attempt to disassemble or alter the product in any way not instructed by this manual.
CAUTION
3
SAFETY INFORMATION SAVE THESE INSTRUCTIONS
Please read and understand this entire manual before attempting to assemble, operate or install the product.
1. Read all instructions before using this appliance.
2. This appliance is hot when in use. To avoid burns, do not let bare skin touch hot surfaces. If provided, use
handles when moving this appliance. Keep combustible materials, such as furniture, pillows, bedding,
papers, clothes and curtains at least 3 ft. (914 mm) from the front of this appliance and keep them away
from the sides and rear.
3. CAUTION: Extreme caution is necessary when any heater is used by or near
children or invalids and whenever the heater is left operating unattended.
4. If possible always unplug this appliance when not in use.
5. Do not operate any heater with a damaged cord or plug or after the appliance malfunctions, has been
dropped or damaged in any manner.
6. Anyrepairstothisapplianceshouldbecarriedoutbyaqualiedserviceperson.
7. Undernocircumstancesshouldthisappliancebemodied.Partshavingtoberemovedforservicingmust
be replaced prior to operating this appliance again.
8. Do not use outdoors.
9. This heater is not intended for use in bathrooms, laundry areas and similar indoor locations. Never place
this appliance where it may fall into a bathtub or other water container.
10. Do not use this heater in elevated locations, such as on shelves, raised platforms, etc.
11. Do not run cord under carpeting. Do not cover cord with throw rugs, runners or the like. Arrange cord away
fromtrafcareasandwhereitwillnotbetrippedover.
12. To disconnect this appliance, turn controls to the off position, then remove plug from outlet.
13. Connect to properly grounded outlets only.
14. This appliance, when installed, must be electrically grounded in accordance with local codes, with the
current CSA C22.1 Canadian Electrical codes or for USA installations, follow local codes and the National
Electric Code, ANSI/NFPA No. 70.
15. Do not insert or allow foreign objects to enter any ventilation or exhaust opening as this may cause an
electricshock,reordamagetotheappliance.
16.Topreventpossiblere,donotblockairintakesorexhaustinanymanner.Donotuseonsoftsurfaces,like
a bed, where openings may become blocked.
17. This appliance has hot and arcing or sparking parts inside. Do not use it in areas where gasoline, paint or
ammableliquidsareusedorstored.Thisapplianceshouldnotbeusedasadryingrackforclothing,nor
should Christmas stockings or decorations be hung on or near it.
18. Use this appliance only as described in this manual. Any other use not recommended by the manufacturer
maycausere,electricshockorinjurytopersons.
19. Always plug heaters directly into a wall outlet/receptacle. Never use with an extension cord or relocatable
powertap(outlet/powerstrip)becauseoftheriskofoverheatingthecordandtheriskofre.Extension
cordsarefortemporaryuseonly.Ifanextensioncordmustbeused,itmustbeUL/CSAcertied,
rated at 15A (1,875W), 125V maximum with 14 AWG minimum and constructed of two current carrying
conductors with ground. A heavy duty extension cord with the shortest length possible for the connection is
recommended and must not be longer than 50 ft. (15.2 m). Do not coil or cover the extension cord.
20. Do not use this heater with missing, damaged, or broken wheels.
21. “SAVE THESE INSTRUCTIONS”
4
SAFETY INFORMATION
DANGER
Electrical Connection
A 15 Amp, 120 Volt, 60 Hz circuit with a properly grounded outlet is required.
Preferably, the item will be on a dedicated circuit as other appliances on the same
circuit may cause the circuit breaker to trip or the fuse to blow when the heater is
in operation. The unit comes standard with a 6 ft. (1.8 m) long, three-wire cord,
exiting the right side of the item. Always plug the unit into a wall outlet/receptacle. An
extension cord or re-locatable power tap, (outlet/power strip), should never be used.
Grounding Instructions
Thisheaterisforuseon120volts.Thecordhasaplugasshownat(A)ingure1.
An adaptor as shown at (C) is available for connecting three-blade grounding-type
plugs to two-slot receptacles. The green grounding lug extending from the adaptor
must be connected to a permanent ground such as a properly grounded outlet box.
The adaptor should not be used if a three-slot grounded receptacle is available
NOTE: Adaptors are NOT
for use in Canada.
Electrical outlet wiring must comply with local building codes and other
applicableregulationstoreducetheriskofre,electricalshockand
injury to persons.
Do not use this item if any part of it has been under water. Immediately
callaqualiedservicetechniciantoinspecttheitemandreplaceany
part of the electrical system which has been under water.
Figure 1
GROUNDING
PIN
METAL SCREW
GROUNDING
MEANS
COVER OF GROUNDED
OUTLET BOX
ADAPTER
GROUNDING
PIN
(A)
(B)
(D)
(C)
1
5
SAFETY INFORMATION
REMOTE CONTROL
This Class (B) device complies with Part 15 of the FCC Rules and Canadian ICES-003.
Operation is subject to the following two conditions:
(1) This device may not cause harmful interference, and (2) this device must accept any
interference received, including interference that may cause undesired operation. There is no
guarantee that interference will not occur in a particular installation. If this equipment does cause
harmful interference to radio or television reception, which can be determined by turning the
equipment o and on, the user is encouraged to try to correct the interference by one or more of
the following measures:
• Reorient or relocate the receiving antenna.
• Increase the separation between the equipment and receiver.
• Connect the equipment into an outlet on a circuit dierent from that to which the receiver is
connected.
• Consult the dealer or an experienced radio/TV technician for help.
This remote control requires 1 Lithium Coin Cell Battery (size CR2025), which is included.
CAUTION: Changes or modications to this unit not expressly approved by the party responsible
forcompliancecouldvoidtheuser’sauthoritytooperatetheequipment.
WARNING
DO NOT mix old and new batteries.
DO NOT use rechargeable silver oxide cell batteries with remote control unit.
DO NOT mix alkaline, standard (Carbon-Zinc), or rechargeable (Nickel-Cadmium) batteries.
DONOTdisposeofbatteriesinre.Improperdisposalmaycausebatteriestoleakorexplode.
6
PACKAGE CONTENTS
HARDWARE CONTENTS
FFEE
DDCCBB
AA
Mounting
Bracket
Qty. 2
1-3/8”
Screw
Qty. 2
5/8”
Screw
Qty. 2
Wall
Anchor
Qty. 2
Nylon
Strap
Qty. 1
Remote
Control
Qty. 1
A
PART DESCRIPTION Quantity
A Mantel (with replace insert) 1
Page is loading ...
8
SAFETY INFORMATION
Warning: Do not install unit on shelves, raised platforms, beds, blankets, pillows
etc. Keep combustible materials such as furniture, bedding, papers, clothes and curtains at
least 3 feet (914 mm) from the stove.
Please read and understand this entire manual before attempting to assemble, operate or install the
product. If you have any questions regarding the product, please call customer service at
1-877-447-4768, 8:30 a.m. - 4:30 p.m., CST, Monday - Friday.
Before beginning assembly of product, make sure all parts are present. Compare parts with package
contents list and hardware contents above. If any part is missing or damaged, do not attempt to
assemble the product. Contact customer service for replacement parts.
Estimated Assembly Time: 20 minutes
Tools Required for Assembly (not included): Phillips screwdriver
Carefully remove all pieces from carton and make
sure that you have all parts listed (refer to parts list
on page 5). If you are missing parts, please call
customer service at 1-877-447-4768
NOTE:Toavoidscratchingthenish,assemble
the product on a soft, non-abrasive surface, such
as carpet or cardboard.
1. Attach a mounting bracket (AA) to the top edge
of the back of the mantel (A) by inserting two
screws (EE) through the mounting bracket (AA)
and into the pre-drilled holes in the mantel (A).
Tighten with a screwdriver.
CLEARANCE TO COMBUSTIBLES
Sides 2 27/64 (61.5 mm)
Floor 0 in. (0 mm)
Top 20 in. (508 mm)
Front 36 in. (914 mm)
Rear 0 in. (0 mm)
PREPARATION
ASSEMBLY INSTRUCTIONS
1
EE
EE
A
AA
AA
9
CC
EE
AA
AA
BB
2. Attach a mounting bracket (AA) to the
wall in the location you have selected
to put the mantel (A) by positioning the
mounting bracket AA) at approximately the
same height as the mounting bracket (AA)
previously attached to the mantel (A). Insert
screws (BB) through the mounting bracket
(AA) and into a wall stud. If there is no stud
present, insert wall anchors (DD) before
inserting the screws (BB). Tighten with a
screwdriver.
3. Set the mantel (A) 2-3 inches from the wall
with both mounting brackets (AA) aligned.
Slip the nylon strap (CC) through the
openings in each of the mounting brackets
(AA) and secure the nylon strap (CC). This
will help prevent the mantel from tipping.
DANGER: This product is only a deterrent. It
is not a substitute for proper adult supervision.
ASSEMBLY INSTRUCTIONS
2
3
DD
BB
AA
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
22
CONTENIDO DEL PAQUETE
ADITAMENTOS
FFEE
DDCCBB
AA
Soporte de
Montaje
Qty. 2
Tornillo
(1-3/8 pulg.)
Qty. 2
Tornillo
(5/8 pulg.)
Qty. 2
Ancla de
Pared
Qty. 2
Correa de
Nylon
Qty.1
Control
remoto
Qty. 1
A
PART DESCRIPTION Quantity
A
Marco de la chimenea (con inserto de chimenea)
1
23
CHIMENEA DIMENSIONES
A
B
C
Ref.
GLF-5002-68/GLF-5002-50
GLF-5002-75/GLF-5002-205
A 31.75 pulg. (806 mm)
B 12.375 pulg. (313 mm)
C 27.25 pulg. (792 mm)
ESPECIFICACIONES TÉCNICAS
VOLTAJE 120V AC
FRECUENCIA 60HZ
AMPERAJE 12.5A
POTENCIA DE SERVICIO
DEL CALENTADOR
1350W
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
39
DIMENSIONS DU FOYER
A
B
C
Réf.
GLF-5002-68/GLF-5002-50
GLF-5002-75/GLF-5002-205
A 806 mm (31,75 po)
B 313 mm (12,375 po)
C 792 mm (27.25 po)
CARACTÉRISTIQUES TECHNIQUES
TENSION 120V C.A.
FRÉQUENCE 60HZ
AMPÉRAGE 12,5 A
PUISSANCE DU GÉNÉ-
RATEUR D’AIR CHAUD
1350W
Page is loading ...
Page is loading ...
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16
  • Page 17 17
  • Page 18 18
  • Page 19 19
  • Page 20 20
  • Page 21 21
  • Page 22 22
  • Page 23 23
  • Page 24 24
  • Page 25 25
  • Page 26 26
  • Page 27 27

Pleasant Hearth GLF-5002-75 Installation guide

Pleasant Hearth
Brand
Pleasant Hearth
Model
GLF-5002-75
Category
Fireplaces
Type
Installation guide
This manual is also suitable for
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

in other languages

Related papers

Other documents