Faber MAES3618SS1200B Installation guide

MAES3018SS600-B

MAES3618SS600-B

Installation Instructions

Use and Care Information

Instructions d'installation

Utilisez et d'entretien

MAESTRALE 18"

MAES3618SS1200-B

MAES4218SS1200-B

MAES4818SS1200-B

2

READ AND SAVE THESE INSTRUCTIONS BEFORE YOU START

INSTALLING THIS RANGEHOOD

WARNING: - TO REDUCE THE RISK OF A RANGE TOP GREASE FIRE:

a) Never leave surface units unattended at high settings. Boilovers cause smoking and

greasy spillovers that may ignite. Heat oils slowly on low or medium setting.

A KV@XRSTQMGNNC.-VGDMBNNJHMF@SGHFGGD@SNQVGDMl@LADHMFENNCHD"QDODR

Suzette, Cherries Jubilee, Peppercorn Beef Flambé).

c) Clean ventilating fans frequently. Grease should not be allowed to accumulate on fan

NQkKSDQ

d) Use proper pan size. Always use cookware appropriate for the size of the surface element.

WARNING: - TO REDUCE THE RISK OF INJURY TO PERSONS IN THE EVENT OF A

RANGE TOP GREASE FIRE, OBSERVE THE FOLLOWING*:

@2,.3'$1%+ ,$2VHSG@BKNRDkSSHMFKHCBNNJHDRGDDSNQLDS@KSQ@XSGDMSTQMNEESGDATQMDQ

!$" 1$%4+3./1$5$-3!41-2(ESGDl@LDRCNMNSFNNTSHLLDCH@SDKX$5 "4 3$

AND CALL THE FIRE DEPARTMENT.

b) NEVER PICK UP A FLAMING PAN - You may be burned.

c) DO NOT USE WATER, including wet dishcloths or towels - a violent steam explosion will

result.

d) Use an extinguisher ONLY if:

1. You know you have a Class ABC extinguisher, and you already know how to operate it.

 3GDkQDHRRL@KK@MCBNMS@HMDCHMSGD@QD@VGDQDHSRS@QSDC

 3GDkQDCDO@QSLDMSHRADHMFB@KKDC

 8NTB@MkFGSSGDkQDVHSGXNTQA@BJSN@MDWHS

* Based on "Kitchen Firesafety Tips" published by NFPA

WARNING - TO REDUCE THE RISK OF FIRE OR ELECTRIC SHOCK, do not use this

fan with any solid-state speed control device.

WARNING - TO REDUCE THE RISK OF FIRE, ELECTRICAL SHOCK, OR INJURY TO

PERSONS, OBSERVE THE FOLLOWING:

1. Use this unit only in the manner intended by the manufacturer. If you have any

questions, contact the manufacturer.

2. Before servicing or cleaning unit, switch power off at service panel and lock the

service disconnecting means to prevent power from being switched on acciden-

tally. When the service disconnecting means cannot be locked, securely fasten a

prominent warning device, such as a tag, to the service panel.

CAUTION: For General Ventilating Use Only. Do Not Use To Exhaust Hazardous or

Explosive Materials and Vapors.

WARNING - TO REDUCE THE RISK OF FIRE, ELECTRICAL SHOCK, OR INJURY TO

PERSONS, OBSERVE THE FOLLOWING:

1. (MRS@KK@SHNM6NQJ MC$KDBSQHB@K6HQHMF,TRS!D#NMD!X0T@KHkDC/DQRNMR(M BBNQ-

dance With All Applicable Codes And Standards, Including Fire-Rated Construction.

2. 2TEkBHDMS@HQHRMDDCDCENQOQNODQBNLATRSHNM@MCDWG@TRSHMFNEF@RDRSGQNTFG

SGDlTDBGHLMDXNEETDKATQMHMFDPTHOLDMSSNOQDUDMSA@BJCQ@ESHMF%NKKNVSGD

heating equipment manufacturer's guideline and safety standards such as those

OTAKHRGDCAXSGD-@SHNM@K%HQD/QNSDBSHNM RRNBH@SHNM-%/ @MCSGD LDQHB@M

2NBHDSXENQ'D@SHMF1DEQHFDQ@SHNM@MC HQ"NMCHSHNMHMF$MFHMDDQR 2'1 $@MC

the local code authorities.

3

ALL WALL AND FLOOR OPENINGS WHERE THE RANGEHOOD IS INSTALLED MUST

BE SEALED.

This rangehood requires at least 24" of clearance between the bottom of the rangehood and

the cooking surface or countertop. This hood has been approved by UL at this distance from

the cooktop. Overhead cabinets on both sides of this unit must be a minimum of 18" above the

cooking surface or countertop. Consult the cooktop or range installation instructions given by

the manufacturer before making any cutouts. MOBILE HOME INSTALLATION The installation

of this rangehood must conform to the Manufactured Home Construction and Safety Standards,

Title 24 CFR, Part 3280 (formerly Federal Standard for Mobile Home Construction and Safety,

Title 24, HUD, Part 280). See Electrical Requirements.

• Venting system MUST terminate outside the home.

• DO NOT terminate the ductwork in an attic or other enclosed space.

• DO NOT use 4" laundry-type wall caps.

• Flexible-type ductwork is not recommended.

• DO NOTNARSQTBSSGDkNVNEBNLATRSHNM@MCUDMSHK@SHNM@HQ

q%@HKTQDSNENKKNVUDMSHMFQDPTHQDLDMSRL@XQDRTKSHM@jQD

WARNING

!

Cold Weather installations

M@CCHSHNM@KA@BJCQ@ESC@LODQRGNTKCADHMRS@KKDCSNLHMHLHYDA@BJV@QCBNKC@HQkNV@MC@

nonmetallic thermal break should be installed to minimize conduction of outside temperatures as

part of the vent system. The damper should be on the cold air side of the thermal break. The break

should be as close as possible to where the vent system enters the heated portion of the house.

VENTING REQUIREMENTS

Determine which venting method is best for your application. Ductwork can extend either through the

wall or the roof.

3GDKDMFSGNESGDCTBSVNQJ@MCSGDMTLADQNEDKANVRRGNTKCADJDOSSN@LHMHLTLSNOQNUHCDDEjBHDMS

performance. The size of the ductwork should be uniform. Do not install two elbows together. Use

CTBSS@ODSNRD@K@KKINHMSRHMSGDCTBSVNQJRXRSDL4RDB@TKJHMFSNRD@KDWSDQHNQV@KKNQkNNQNODMHMF

around the cap.

Flexible ductwork is not recommended. Flexible ductwork creates back pressure and air turbulence

that greatly reduces performance.

,@JDRTQDSGDQDHROQNODQBKD@Q@MBDVHSGHMSGDV@KKNQkNNQENQDWG@TRSCTBSADENQDL@JHMFBTSNTSR

Do not cut a joist or stud unless absolutely necessary. If a joist or stud must be cut, then a supporting

frame must be constructed.

WARNING - To Reduce The Risk Of Fire, Use Only Metal Ductwork.

" 43(.-3NQDCTBDQHRJNEkQD@MCSNOQNODQKXDWG@TRS@HQADRTQDSNCTBS@HQNTSRHCDm#N

not vent exhaust air into spaces within walls or ceilings or into attics, crawl spaces, or garages.

3. When cutting or drilling into wall or ceiling, do not damage electrical wiring and

other hidden utilities.

4. Ducted fans must always be vented to the outdoors.

4

• Electrical ground is required on this rangehood.

• If cold water pipe is interrupted by plastic, nonmetallic gaskets or other materials, DO

NOT use for grounding.

• DO NOT ground to a gas pipe.

• DO NOT have a fuse in the neutral or grounding circuit. A fuse in the neutral or

grounding circuit could result in electrical shock.

q"GDBJVHSG@PT@KHjDCDKDBSQHBH@MHEXNT@QDHMCNTAS@RSNVGDSGDQSGDQ@MFDGNNCHR

properly grounded.

q%@HKTQDSNENKKNVDKDBSQHB@KQDPTHQDLDMSRL@XQDRTKSHM@jQD

WARNING

5

1 MOTOR - RANGEHOOD DIMENSIONS

1 MOTOR - RANGEHOOD DIMENSIONS WITH OPTIONAL FULL CHIMNEY

1 MOTOR - RANGEHOOD DIMENSIONS WITH OPTIONAL TELESCOPIC CHIMNEY

6

2 MOTOR - RANGEHOOD DIMENSIONS

2 MOTOR - RANGEHOOD DIMENSIONS WITH OPTIONAL FULL CHIMNEY

2 MOTOR - RANGEHOOD DIMENSIONS WITH OPTIONAL TELESCOPIC CHIMNEY

7

2 MOTOR RANGEHOOD REAR INFORMATION

1 MOTOR RANGEHOOD REAR INFORMATION

8

MAIN PARTS 1 MOTOR RANGEHOOD

Components

Ref. Qty. Product Components

1 1 Hood Body, complete with: Con-

trols, Light, Filters, Blower.

10 1 Damper ø 5 7/8"

Ref. Qty. Installation Components

12a 2 Wall plug

14 6 Screws 3/16" x 1 15/16"

Qty. Documentation

1 Instruction Manual

10

1

12a

14

MAIN PARTS 2 MOTOR RANGEHOOD

Components

Ref. Qty. Product Components

1 1 Hood Body, complete with: Con-

trols, Light, Filters, Blower.

10 2 Damper ø 5 7/8"

Ref. Qty. Installation Components

12a 2 Wall plug

14 6 Screws 3/16" x 1 15/16"

Qty. Documentation

1 Instruction Manual

10

1

12a

14

9

Available Accessories

Parts needed

- 6" Round Metal ductwork .

Direct Connect Wiring Box sku # number: WIREBOX

30" Full Width Chimney Duct Cover - sku#FULL30

36" Full Width Chimney Duct Cover - sku#FULL36

42" Full Width Chimney Duct Cover - sku#FULL42

48" Full Width Chimney Duct Cover - sku#FULL48

Telescopic Chimney Duct Cover - TELEMAES

CFM Reducer Accessory Kit - CFMRED

Vent Grate Kit 30" - DUCTGRT30

Vent Grate Kit 36" - DUCTGRT36

6" Make-Up Air Damper - MUDAMPER6

8" Make-Up Air Damper - MUDAMPER8

Activated Charcoal Filter sku #; FILTER1

Min. 24"

10

Install Damper that is included with the

Hood before connecting to the ductwork.

One for 1 motor model.

Two for 2 motor model.

8VHKDQGVWRUHPRYH¿OWHUV7XUQWKHNQREWRWKHOHIWFRXQWHUFORFNZLVHWR

UHOHDVH¿OWHU5HSHDWZLWKRWKHU¿OWHU5HLQVWDOOWKH¿OWHUE\SODFLQJWKHEDFNHGJH

LQWKHFKDQQHODWUHDURIKRRG3XVK¿OWHULQWRSODFHWXUQWKHNQREWRWKHULJKW

FORFNZLVHWRDWWDFKWRUDQJHKRRG5HSHDWZLWKRWKHU¿OWHU

!@ElD%HKSDQ1DLNU@K

Removal / Déplacement

Removal







H

I









H

I









H

I



11

Ducted Venting Options Installation

Horizontal

Vertical

6"

Rear

6"

Ducting Methods

12

Rear Ducted Installation for 1 motor Rangehood





The Electrical Connector must be

UHPRYHG¿UVWEHIRUHFRQYHUWLQJWKH

hood to Rear Ducting mode.

For a rear ducting installation the

PRWRUQHHGVWREHXQVHFXUHGE\¿UVW

removing the 12 screws as shown.

2QFHWKHVFUHZVDUHUHPRYHG

extract the blower from the body

of the Hood and position it so the

transition opening is facing to the

UHDUZDOOIURPWKHEDFNUHPRYHDQG

URWDWHGHJUHHVWRWKHOHIWDQG

WKHQÀLSLWEDFNGHJUHHVDVVKRZQ

LQWKHGLDJUDP

Once the blower is in place re-install

the 12 screws to fasten the motor to

the Hood body.

Disconnect the Electrical Connector

by depressing the tabs with your

hand and also using light force on

RQHWDEZLWKDÀDWKHDGVFUHZGULYHU

Reconnect the Connector to the

blower.

13

Rear Ducted Installation for 2 motor Rangehood





The Electrical Connector must be

UHPRYHG¿UVWEHIRUHFRQYHUWLQJWKH

hood to Rear Ducting mode.

The Electrical Connector is always

on the left of left Motor Group.

For a rear ducting installation the

PRWRUQHHGVWREHXQVHFXUHGE\¿UVW

removing the 16 screws as shown.

2QFHWKHVFUHZVDUHUHPRYHG

extract the blower from the body

of the Hood and position it so the

transition opening is facing to the

UHDUZDOOIURPWKHEDFNUHPRYHDQG

URWDWHGHJUHHVWRWKHOHIWDQG

WKHQÀLSLWEDFNGHJUHHVDVVKRZQ

LQWKHGLDJUDP

Once the blower is in place re-install

the 16 screws to fasten the motor to

the Hood body.

'LVFRQQHFWWKH(OHFWULFDO&RQQHFWRU

one from the left motor goup and

RQHIURPWKHULJKWPRWRU*USRXSE\

depressing the tabs with your hand and

also using light force on one tab with a

ÀDWKHDGVFUHZGULYHU

Reconnect the Connector to the

blower.

Attention: The longhest cable with

connector is always for Left motor

*URXSDQGWKHVKRUWHVWFDEOHZLWK

connector is always for Right motor

Group.

Reconnect the Electrical Connector

on the left of left Motor Group.

14

RECIRCULATION INSTRUCTIONS

Note: It is recommended that pro-

fessional style cooking always be

vented to the outside; for recirculat-

ing Installations, some duct work is

required to exhaust the unit out of

the cabinet.

RECIRCULATING INSTALLATIONS

)RUUHFLUFXODWLQJLQVWDOODWLRQV&KDUFRDO)LOWHUVDUHQHFHVVDU\5HPRYHDOOJUHDVH¿OWHUV

DQGVHWDVLGH$WWDFKRQHFKDUFRDO¿OWHUWRHDFKHQGRIWKHEORZHU(DFKFKDUFRDO¿OWHU

DWWDFKHVWRWKHJULGRQWKHVLGHRIWKHEORZHU5RWDWHWKH¿OWHUFORFNZLVHWRLQVWDOODQG

FRXQWHUFORFNZLVHWRUHPRYH),*85(&5HSODFHDOOJUHDVH¿OWHUV

There are 2 ways to recirculate the Maestrale:

8VHWKH'XFWOHVV5HFLUFXODWLQJ.LW(sold separately)UHIHUWRLQVWDOODWLRQLQVWUXFWLRQV

LQVLGHWKH5HFLUFXODWLQJ.LWZKLFKLQFOXGHVFKDUFRDO¿OWHUV

'8&7*57

'8&7*57

6RPHGXFWZRUNPXVWEHLQVWDOOHGWRH[KDXVWWKHUDQJHKRRGEDFNLQWRWKHNLWFKHQ

HLWKHUDWWKHWRSRIWKHFDELQHW),*85($RUDWWKHIDFHRUVLGHRIWKHVRI¿W),*85(

%,QVWDOODWOHDVWRIPHWDOGXFW¿J$DQG%DWWKHDLUH[LW5XQWKHGXFWYHUWLFDOO\

DQGVHFXUHLWDWWKHRSHQLQJFXWRXWDWWKHWRSRUVLGHRIWKHFDELQHWRUVRI¿W,QVWDOODWLRQ

of metal grill is recommended. This duct work must not terminate into a dead air space.

FILTER1 must be purchased to complete this type of installation.

upper

cabinet

upper

cabinet

rangehood rangehood

open space

HQFORVHGVRI¿W

cooking surface cooking surface

15

Installation for Mounting on the Wall

==

Min. 24"

Installation Instruction for mounting on the Wall

Draw a vertical line on the supporting wall

DVKLJKDVSUDFWLFDODWWKHFHQWHURIWKH

area in which the hood will be installed.

Draw a horizontal line at where the bottom

edge of the hood will be located as indicated

LQWKH¿JXUHWKDWLVDPLQLPXPRIDERYH

cooking surface

1

16

2

´

[

24”

L

/ ´´

´´

16 13/16”

0DUNWKHZDOOZKHUHLQGLFDWHG13/16" above the horizontal line and at L distance on the left and

right of vertical line. The distance L change for all dimension of Hood.

,QVHUWWKHWZRZDOOSOXJVLQWKHKROHVDVVKRZQDQG¿[

Installation for 1 Motor Rangehood

Installation for 2 Motor Rangehood

´

[

24”

L

/ ´´´

´´´

16 13/16”

0DUNWKHZDOOZKHUHLQGLFDWHG13/16" above the horizontal line and at L distance on the left and

right of vertical line. The distance L change for all dimension of Hood.

,QVHUWWKHWZRZDOOSOXJVLQWKHKROHVDVVKRZQDQG¿[

17

3

4

E

Hook the hood body onto the wall plugs. Use a level to insure that Fixing Bracket is

level and then fully secure the two screws.

5

´

[

Mark the wall where indicated.

'ULOOGLUHFWO\LQWR¡KROHVDWDOOWKHFHQWHUSRLQWVPDUNHG

Insert the purchased wall plugs in the holes.

Using thhe remaining screws to anchor the hood in holes.

,I\RXULQVWDOODWLRQXVHVWKHRSWLRQDOGXFWFRYHU¿WWKHFRYHUÀDQJHVRYHUWKHEUDFNHWV,I

LQVWDOODWLRQXVHVWKHWHOHVFRSLFFKLPQH\H[WHQVLRQ¿WWKHH[WHQVLRQRYHUWKHEUDFNHWV,QVWDOOWKH

XSSHUVHFWLRQ¿UVWWKHQ¿WWKHORZHUVHFWLRQRYHUWKHXSSHUVHFWLRQ6HDOH[WHQVLRQWRKRRGZLWK

clamps.

18

Installation Instruction for Mounting Under the Cabinet

[

Lift the hood to the cabinet.

[

Fix the Hood Body with 4 screws from the bottom.

´

[

Mark the wall where indicated.

'ULOOGLUHFWO\LQWR¡KROHVDWDOOWKHFHQWHU

points marked.

Insert the purchased wall plugs in the

holes.

Using two remaining screws to anchor

the hood in holes.

1

2

3

19

A: Distance from center of mounting bracket to centerline:

INSTALLATION CONTINUED

1. Attach the full-width duct cover to the top of the range hood with the screws provided. The duct

cover must be attached to the top of the range hood before mounting the range hood to the wall.

A: Distance from center of mounting bracket to centerline:

KRRG

KRRG

KRRG

KRRG

B: Mounting brackets

C: Top of hood

2. Install each bracket on the wall as shown. Make sure the screws and brackets are securely

fastened to the wall. IMPORTANT: Install only the brackets. Do not install the hood.

Optional Duct Cover Installation

A: Ceiling

B: Brackets

Optional Telescopic Chimney Extension Installation

,IDFKLPQH\H[WHQVLRQLVXVHGDWWDFKWKHH[WHQVLRQEUDFNHWVDVVKRZQ0DNHVXUHWKDWWKH

screws are securely fastened to the wall.

A: Ceiling

B: Brackets

C: Top of hood

20

Direct Connect Wiring Box

Accessory sku # WIREBOX

SXUFKDVHGVHSDUDWHO\

ELECTRICAL INSTALLATION WITH CONNECTION CABLE

ELECTRICAL INSTALLATION WITH

OPTIONAL WIRING BOX

For Permanent wiring Installation-Use only

with Listed rangehood Wiring Box kit

VNX:,5(%2;PDQXIDFWXUHGE\)DEHU

Max. 33 7/16”

GROUNDING INSTRUCTIONS This appliance must

EHJURXQGHG,Q WKH HYHQW RI DQHOHFWULFDOVKRUWFLUFXLW

grounding reduces the risk of electric shock by providing

an escape wire for the electric current. This appliance

is equipped with a cord having a grounding wire with a

grounding plug. The plug must be plugged into an outlet

that is properly installed and grounded.

WARNING - Improper grounding can result in a risk of

electric shock.

&RQVXOWDTXDOL¿HGHOHFWULFLDQLIWKHJURXQGLQJLQVWUXFWLRQV

DUHQRW FRPSOHWHO\ XQGHUVWRRGRU LI GRXEW H[LVWVDV WR

whether the appliance is properly grounded.

Do not use an extension cord. If the power supply cord

LVWRRVKRUWKDYHDTXDOL¿HGHOHFWULFLDQLQVWDOODQRXWOHW

near the appliance.

5HSODFHWKH¿OWHUVUHPRYHGSUHYLRXVO\

Page is loading ...

Faber MAES3618SS1200B Installation guide

This manual is also suitable for

Faber MAES3618SS1200B Installation guide

in other languages

Related papers

Other documents