REV 0 - A - 2309271115 L-C2-710
1
INSTALLER: Leave these instructions with consumer.
CONSUMER: Retain for future reference.
ROBERT H. PETERSON CO. • 14724 East Proctor Avenue • City of Industry, CA 91746
Gas Connection Box
with Timer
Model # 5521-11T, 5521-12T
5521-13T, 5521-14T
AFTER EACH USE:
• MAKE CERTAIN THAT THE APPLIANCE CONTROL KNOBS ARE IN THE OFF POSITION
• IF TIMER IS ON, SLOWLY TURN IT TO THE OFF POSITION
• TURN OFF THE PRIMARY GAS SUPPLY SHUT-OFF VALVE TO COMPLETELY SHUT OFF THE GAS
TO THE APPLIANCE
This timer box can be installed in a Fire Magic GFRC island, or a custom-built enclosure.
INSTALLATION REQUIREMENTS
• Reference Fig. 2-1 on next page.
• Box MUST be installed in accordance with local codes or, in the absence of local codes, in accordance with
the National Fuel Gas Code ANSI Z223.1/NFPA54, or the Natural Gas & Propane Installation Code, CSA
B149.1, as applicable.
• Box MUST be installed in a grill enclosure in such a way that it is easily accessible to the rear of the box for
gas connection, maintenance, and service.
• Fire Magic GFRC islands meet all enclosure and ventilation requirements. For requirements regarding
custom-built enclosures, see the ENCLOSURE REQUIREMENTS section of your grill owner's manual.
Observe all codes.
• Box MUST be installed in-line between the required primary gas supply shut-o valve and the gas appliance.
• Timer MUST NOT be used as the primary gas supply shut-o valve.
• Box MUST be installed a minimum of 10" away from the appliance or it will overheat, causing damage to the
timer and may result in a leak.
• Box MUST be installed within 6 feet of the appliance.
• Use pipe joint compound resistant to all gasses on all NPT ttings except are ttings. Be sure to leak test
at all connections.
Specications
• 5521-11T and 5521-13T Box dimensions: 81/2" W x 73/4" H x 21/2" D
• 5521-12T and 5521-14T Box dimensions: 151/2" W x 73/4" H x 21/2" D
• 100,000 B.T.U., Natural Gas @ 0.6 SP. @ 7" w.c. (per valve)
• 100,000 B.T.U., Propane Gas @ 1.53 SP.@ 11" w.c. (per valve)
• Maximum working pressure not to exceed 1/2 P.S.I.G.
• Maximum ambient operating range: from 0° F (-18° C ) to 150° F (65.6° C).
The gas hoses should be exible/long enough to allow the box to be pulled out of the enclosure for leak
testing during installation.
Installation continued on next page
5521-13T model shown
REV 0 - A - 2309271115 L-C2-710
2
Fig. 2-1 Box installation overview
Gas supply
(NPT)
Required primary gas
supply shut-o valve
(shown in-line) must
be within 6 feet of the
appliance AND upstream
from the box
Gas
appliance
Flex
connector
Flare-to-NPT
adapter
Gas connection
box with timer
Flex
connector
ROBERT H. PETERSON CO. • 14724 East Proctor Avenue • City of Industry, CA 91746
INSTALLATION
In addition to following the CONNECT GAS SUPPLY
section of the gas appliance owner’s manual, install
the box in the gas supply line (between the shut-o
valve and the appliance).
Follow ALL information found in the
INSTALLATION REQUIREMENTS section,
the gas appliance owner’s manual, Fig. 2-1,
and Fig. 2-2.
1. Create box cutout in grill enclosure (see Fig.
2-3).
• 5521-11T and 5521-13T: 71/2" W x 61/2" H
• 5521-12T and 5521-14T: 141/2" W x 61/2" H
Note: For 5521-12T and 5521-14T models, repeat
steps 2 and 3 for the second appliance.
2. Using two wrenches, connect the ex connector
coming from the appliance to the 1/2" are
adapter labeled OUT. See Fig. 2-4, A. Ensure
the connection is tightened securely.
3. Using two wrenches, connect a ex connector
(not included) to the 1/2" are adapter labeled
IN. See Fig. 2-4, B. Ensure the connection is
tightened securely.
4. Carefully check all gas connections for leaks
with a brush and soapy water before lighting.
NEVER USE A MATCH OR OPEN FLAME TO
TEST FOR LEAKS.
5. Install box and secure to enclosure using
the appropriate mounting hardware for the
construction (not included).
Fig. 2-4 Install timer box
Fig. 2-3 Cut out dimensions
W
H
A
B
Gas source - IN
To grill - OUT
1/2" Flare adapters
(included)
Fig. 2-2 Box clearance
Gas
appliance
Box must be a
minimum of 10"
from the appliance
(max. 6 ft.)
Box
SIDE VIEW
5521-13T model
shown
5521-13T model shown
(Setup may vary)
REV 0 - A - 2309271115 L-C2-710
3
ROBERT H. PETERSON CO. • 14724 East Proctor Avenue • City of Industry, CA 91746
Timer setting
mark (shown
here in OFF)
Time settings:
20-60 minutes
Fig. 3-1 1-Hour timer operation
Turn past
20 minutes to
activate (see
Important
for 1-hr model)
Timer setting
mark (shown
here in OFF)
Time settings:
1-3 hours
Fig. 3-2 3-Hour timer operation
OPERATION (1-hour model)
To use, set the dial (turn clockwise) to the desired time to shut o.
The dial is marked in 3 twenty minute increments (any position in
between is an estimate of that set time). The timer dial will auto
rotate (counter-clockwise) and will shut o the gas supply when
the dial reaches OFF (i.e. the desired time is completed).
Important: When using the timer for periods of less than twenty
minutes, you must rst turn the dial past 20 minutes
(to activate), then return (counter-clockwise) to the
desired amount of time. This will ensure proper timer
operation. See Fig. 3-1.
OPERATION (3-hour model)
To use, set the dial (turn clockwise) to the desired time to shut
o. The dial is marked in 3 one hour increments (any position in
between is an estimate of that hour). The timer dial will auto rotate
(counter-clockwise) and will shut o the gas supply when the dial
reaches OFF (i.e. the desired time is completed).
Important: When using the timer for periods of less than one
hour, you must rst turn the dial past 1 hour (to
activate), then return (counter-clockwise) to the
desired amount of time. This will ensure proper timer
operation. See Fig. 3-2.
Turn past
1 hour to
activate (see
Important
for 3-hr model)
WARNING: AFTER EACH USE:
• MAKE CERTAIN THAT THE APPLIANCE CONTROL KNOBS
ARE IN THE OFF POSITION
• IF TIMER IS ON, SLOWLY TURN IT TO THE OFF POSITION
• TURN OFF THE PRIMARY GAS SUPPLY SHUT-OFF VALVE
TO COMPLETELY SHUT OFF THE GAS TO THE APPLIANCE
REV 0 - A - 2309271115 L-C2-710
4
NOTES PAGE
Please use this page to record any information that you may want to have at hand.
-
1
-
2
-
3
-
4
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
-
Fire Magic Gas Connection Box with Timer (5520-11T & 5520-13T) User manual
-
-
-
Fire Magic 3092B User manual
-
-
-
Fire Magic Island Enclosure User manual
-
-
Fire Magic Gourmet Single and Double Searing Station User manual
-
Other documents
-
-
Real Fyre G52 Vented Burner Owner's manual
-
-
-
-
-
-
-
-