MyBinding FastBack Model 11 User manual

Brand: MyBinding

Model: FastBack Model 11

Category: Binding machines

Type: User manual

This manual is also suitable for

Powis Parker Fastback S52

Instruction Manual

Provided By

http://www.MyBinding.com

http://www.MyBindingBlog.com

Powis Parker

Fastback S52

Stitchin Machine

POWIS S52 STITCHER USER’S MANUAL 1

I SAFETY & COMFORT ......................2

II INTRODUCTION ...........................4

III FIRST TIME SETUP .........................5

IV STITCHING THE BOOK BLOCK ............6

V LOADING STAPLES. . . . . . . . . . . . . . . . . . . . . . . . .7

VI TIPS FOR BETTER BINDING ...............8

VII TROUBLESHOOTING .......................9

VIII SPECIFICATIONS ..........................10

IX FCC NOTICE ..............................11

WARRANTY .....................................12

Information for Your Reference:

Serial Number:

Purchase Date:

C O N T E N T S

2 POWIS S52 STITCHER USER’S MANUAL

SAFETY & COMFORT

Please read through this manual before setting up and using

your binder.

• Connectallequipmenttoproperlygroundedpower

outlets.

• Donotallowanythingtorestonthepowercord.Donot

locatetheStitcherwherepersonswillsteponthecord.

• PlacetheStitcheronaatsurface.TheStitchermaynot

operate properly if it is tilted or at an angle.

• Useonlythetypeofpowersourceindicatedonthe

Stitcher’s label on the rear of the machine.

• Donotuseadamagedorfrayedpowercord.

• Unplugthisproductfromthewalloutletbeforecleaning.

Donotuseliquidcleanersoraerosolcleaners.Useadamp

cloth for cleaning.

• DonotspillfoodorliquidontheStitcher.

• Keepyourngersawayfromthestaplingarea.

• Exceptasspecicallyexplainedinthisguide,donot

attempt to service the Stitcher yourself. Opening or

removingcoversmayexposeyoutodangerousvoltage

points or other risks. Refer all servicing to service

personnel.

• Useofanextensioncordwiththismachineisnot

recommended or authorized. Users should check building

codesandinsurancerequirementsifanextensioncordis

to be used. Make sure that the total of the ampere ratings

oftheproductspluggedintotheextensioncorddoesnot

exceedtheextensioncordampererating,andthatthe

totalamperageofallproductspluggedintothewalloutlet

doesnotexceedtheoutletrating.

• Donotallowchildrentousethisproduct,unlessunder

supervision of a responsible adult.

C A U T I O N : Do not insert ﬁngers or anything other than

the documents to be stapled into the stapling area.

FASTBACKPOWISS52STITCHERUSER’SMANUAL3

SAFETY & COMFORT (continued)

Inrecentyears,medicalattentiononoccupationalinjurieshasidentied

common,seeminglyharmlessactivitiesaspotentialcausesofawide

rangeofproblemscollectivelyknownasRepetitiveStressInjuriesor

CumulativeTraumaDisorders.Itisnowrecognizedthatanyrepetitive

motionmaycontributetothesehealthproblems.Dependingonhowitis

used,theprolongedorrepetitiveuseofalmostanymachinemighthavea

potentialfordiscomfortorinjury.AsauserofthisStitcher,youmightalso

be at risk.

The most commonly accepted causes of this type of disorder are

repeated,forcefulactions,usuallyinanawkwardpositionorposture,

withoutsufcientresttoallowthebodytorecover.Theserepetitive

actionsmaycausenerves,tendons,ligaments,andothersoftbodyparts

tobecomeirritatedandinamed.

Bypayingattentiontothewayyouperformyourwork,anddoother

activities,youcanidentifythebehaviorsthatcouldputyouatrisk.The

precautionsoutlinedbelowareexamplesyoucantaketohelpreduce

thelikelihoodofdevelopingtheseproblemsandworkmorecomfortably

withyournewStitcher.Keepinmind,however,thattheseareonly

suggestions.Comfortispersonalandonlyyoumaybeabletojudgewhat

worksbestforyou.

• Youmayndthatyourbodywillbemostcomfortableandrelaxed

withtheStitcherplaceddirectlyinfrontofyou.TheStitcher

andyoursuppliesshouldbewithineasyreach—avoidexcessive

stretching.

• TheStitchermaybeusedineitherastandingorseatedposition.

Ifyouarestanding,makesurethattheworksurfaceheightthat

theStitcherisondoesnotrequireyoutobendoverinawaythat

wouldstrainyourbackorarms.

• Ifyouareseated,adjusttheheightofyourchairtoyourtableso

yourbodyisnaturallyalignedandmakesureyouhaveadequate

legroom.Stayrelaxedandrelativelyupright.Don’tforceyourself

into an uncomfortable position.

• Donotbendyourwristsunnaturallyduringuse.

• Don’tstayinonepositionfortoolong.Trychanginghandsand

varying your posture.

• Takebreaks.Frequentshortbreaksareprobablybetterthanafew

long ones.

Manyfactorsgointocreatingacomfortableworkspace,includingproper

placementandadjustmentoffurnitureandequipment.Athoroughwork

siteanalysisbyaqualiedexpertisimportantinordertoreducetherisk

ofrepetitivemotioninjuries.Ifyouexperiencepain,throbbing,aching,

tingling,stiffness,aburningsensation,swelling,numbness,orweaknessin

yourwrists,hands,armsorlegs,seeyourphysicianimmediately.

DO NOT IGNORE THESE WARNING SIGNS. Even if symptoms occur

whenyouarenotusingtheStitcher,theycanbeassociatedwithpainful

andsometimespermanentlydisablinginjuriesordisordersofthenerves,

muscles,tendons,orotherpartsofthebody.Thesesymptomscould

meanthatyouaredevelopingarepetitivestressinjurythatrequires

promptmedicalattention.Formoredetailedinformation,consultyour

doctor.

4 POWIS S52 STITCHER USER’S MANUAL

INTRODUCTION

CongratulationsonthepurchaseofyournewPowisS52

Stitcher.Likeallourequipment,thismachinewascarefully

assembledandtestedpriortopacking.Youwillnditfastand

easytouse.ThePowisS52Stitcherwasdesignedtoworkwith

theFastback8xbinderandtheFastbackHardcoverGuide.It

isanimportantcomponentofthePowisStudioPhotobook

System.

Powis S51 Stitcher

Figure 1

Stitching Table

Figure 3

Staple Loading Mechanism

Figure 2

A B C D E F

A Power Light

B Cover Release Button

C Cover

D Back Stop

E Stapling Points

F Stitching Table

G Foot Pedal Plug

H Power Plug

FASTBACKPOWISS52STITCHERUSER’SMANUAL5

FIRST TIME SETUP

III

A. What’s Included Inside the Box

• ThePowisS52Stitcher

• AccessoryBox,whichcontains:

- 2 User Manuals

- Foot Pedal

- I Staple Cassette

-Powersupplyadapter

Ifanyitemsaredamagedormissing,contactPowisParkerdealer

immediately.

B. Set Up and Plug in Foot Pedal

PlacethePowisStitcheronaat,unobstructedworksurface.Plugthe

Foot Pedal into the socket at the rear of the Stitcher (see Figure 4).

IMPORTANT: Foot pedal must be plugged in beforethepower

Adapter.

C. Plug In Power Adapter

Plugtheadapterintothewallsocketintothewallsocket,thenplugthe

poweradapterintotheStitcher(SeeFigure5).TheLEDontopofthe

Stitcherwilllightupgreen,indicatingthatittheStitcherison.

F I G U R E 4

F I G U R E 5

6 POWIS S52 STITCHER USER’S MANUAL

STITCHING THE BOOK BLOCK

Stapling Points

Starting Point for 8½” book

F I G U R E 6

BeforeusingtheStitcher,bindthebookblockwiththeFastback

8x.FormoreinformationonbindingseetheFastback9manual

ortheStudioBindingSystemQuickStartGuide.

Using the Stitcher

The stitching table is designed to make binding book blocks fast

andeasytodo.StaplingpointsforA4,A5,11”and8½”spine

lengths are indicated on the stitching table (Figure 6).

1. Placethebookblockonthestitchingtablewiththespine

edge pressed against the back stop (Figure 7).

2. Press the foot pedal (Figure 8).

3. Startingfromtheleftandmovingright,linetheboundedge

ofthebookblockupwiththerststaplingpointonthe

stitching table (Figures 6).

4. Movethebookblocktothenextstaplingpointandpress

the foot pedal again. Continue this process until the book

blockiscompletelystapledacrossthebindingedge(gure

9).

Thebookblockisnowreadytoaddthecover.

HINT: Togiveyourbookamorepolishednalappearance,

you may also add headbands. See the Fastback Hardcover

Guidemanualformoreinformation.

CAUTION: Donotactivatethefootpedalwithoutpaper—

jammingwilloccur.IftheStitcherdoesjam,pleaserefertothe

Troubleshooting section for assistance.

F I G U R E 7

F I G U R E 8

F I G U R E 9

FASTBACKPOWISS52STITCHERUSER’SMANUAL7

Staple Cassette

LOADING STAPLES

ThepowerlightonthetopoftheSticher(seeFigure1)turnsfrom

greentoredwhenthestaplecassetteisdownto19remainingstaples.

IMPORTANT: UseonlyoriginalRapid5080staplecassettes.Thewrong

typeofstaplescandamagetheunitormayresultinjammingandbadly

stapled book blocks.

1. Press Release Button on top of the unit to remove the Cover

(Figure 10).

InsideyouwillseetheStapleCassette(Figure11).

2. Graspthecassetteonbothsideandpullstraightouthorizontally

(Figure 12).

3. Replacethecassettebyinsertingthenewcassettestraightintothe

Stitcher until the cassette clamps in place (Figure 13).

4. SnaptheCoverbackintoplace.ThePowerLightonthetopofthe

Stichershouldnowappeargreen.

F I G U R E 11

F I G U R E 12

F I G U R E 13

F I G U R E 10

8 POWIS S52 STITCHER USER’S MANUAL

TIPS FOR BETTER BINDING

• Allpaperhasagrain—itisaresultofthebersthatmake

up the paper. The grain of the paper should run parallel to

the binding edge of the document. If the grain runs parallel

tothelongsideofthesheet,thepaperis“grainlong”.

Whenthegrainrunsparalleltotheshortsideofthepaper,

itis“grainshort”.

 Asheetofpaperwillnaturallyexmoreeasilyalongthe

directionofitsgrain.Mostcopypapersaregrainlong,so

youshouldnothaveanyproblemswiththebind.Grain

longpaperwillgiveyouthebestbind.Occasionallyyou

mayndpapersthataregrainshort,sowerecommend

you test unfamiliar papers before binding large numbers of

documents.

• HowmanysheetsofpaperthePowisStitchercanbind

dependsontheweightandthesurfacedensityofthe

paper.Alwaysrunatestsamplebeforeproceeding.

• HowmanysheetsofpaperthePowisStitchercanbind

dependsontheweightandthesurfacedensityofthe

paper.Alwaysrunatestsamplebeforeproceeding.

FASTBACKPOWISS52STITCHERUSER’SMANUAL9

Removing jammed staples

1. Remove Cover and cassette (see page 7).

2. Removejammedstaple(s)fromthecassette.Difcultjamsmay

requireneedle-nosedplierstoremove.Becarefulnottodamage

thecassettewhenremovingjamswithpliersorsimilartools.

3. Depress the magazine release on the front of the insert stapler and

pull out the magazine.

IMPORTANT: Make sure that the stapler die has been returned to the

downpositionbeforeusingthestapler(Fig.14).

Stitcher will not operate

Check that:

1. The unit is receiving current (the light on the top of the Stitcher

should be green).

2. Thecoverisrmlysnappedinplace.

3. The foot control is properly plugged in.

Forfurtherinformationandtroubleshooting,pleaseconsulttheRapid

5050/508emanualincludedwiththisunit.

Iftheproblemsremain,returntheunittoyoursupplierortoPowisTech

Support.Donotuseamachinewithafaultyconnectingcableorplug.

TROUBLESHOOTING

VII

BAD

GOOD

F I G U R E 14

10 POWIS S52 STITCHER USER’S MANUAL

SPECIFICATIONS

VIII

Power Requirements: S52:120V~50-60Hz,0.5Amps

Recommended Operating

Temperature and

Humidity:

15to35degrees(C),59to95degrees(F)

Humidity Range: 5 to 80% RH noncondensing

Weight: 12.5 lbs

Dimensions: 23.5”Wx6.75”Hx17.5”D

Bind Capacity: Dependent on paper thickness and density.

POWIS S52 STITCHER USER’S MANUAL 11

FCC NOTICE

• Modificationsmadetotheproduct,unlessexpresslyapprovedbyPowisParker,couldvoidthe

user’sauthoritytooperatetheequipment.

Note:ThisequipmenthasbeentestedandfoundtocomplywiththelimitsforaClassBdigital

device,pursuanttoPar t15oftheFCCRules.Theselimitsaredesignedtoprovidereasonable

protectionagainstharmfulinterferenceinaresidentialinstallation.Thisequipmentgenerates,

uses,andcanradiateradiofrequencyenergyand,ifnotinstalledandusedinaccordancewith

theinstruction,maycauseharmfulinterferencetoradiocommunications.However,thereisno

guaranteethatinterferencewillnotoccurinapar ticularinstallation.Ifthisequipmentdoescause

harmfulinterferencetoradioortelevisionreception,whichcanbedeterminedbyturningthe

equipmentoffandon,theuserisencouragedtotr yandcorrecttheinterferencebyoneormoreof

thefollowingmeasures:

• Reorient or locate the receiving antenna.

• Increasetheseparationbetweentheequipmentandreceiver.

• Connecttheequipmentintoanoutletonacircuitfromthattowhichthereceiverisconnected.

• Consultthedealeroranexperiencedradio/TVtechnicianforhelp.

• Binderdoesnotcontainanyuserser viceablepar ts.ReturnunittoanauthorizedPowisParker

representative for repair or service.

204988 POWIS S51 STITCHER USER’S MANUAL

204986 FOOT PEDAL

204984 CRIMPINGTOOL

204982 STAPLES

204985 TORX SCREWDRIVER

POWISPARKERPARTNUMBERSFORYOURREFERENCE:

DECLARATION OF CONFORMITY

We,PowisParker,Incorporated

775 Heinz Avenue

Berkeley,CA94710U.S.A

1-800-321-2463

declare under our sole responsibility that the product

PowisS51Stitcher

complieswithPart15ofFCCRules.

Operationissubjecttothefollowingtwoconditions:(1)thisdevicemaynotcauseharmful

interference,and(2)thisdevicemustacceptanyinterferencereceived,includinginterferencethat

may cause undesired operation.

12 POWIS S52 STITCHER USER’S MANUAL

ThisdocumentcontainsproprietaryandconfidentialinformationofPowisParkerIncorporated(PPI).

Nopar tofthisdocumentmaybephotocopied,reproducedinanyform,ortranslatedintoanother

languagewithoutpriorwrittenconsentofPPI,exceptasallowedunderthecopyrightlaws.

WARRANTY

One (1) Year from date of purchase.

Theinformationcontainedinthisdocumentissubjecttochangewithoutnotice.

PPImakesnowarrantyofanykindwithrespecttothisinformation.PPIspecificallydisclaimstheimplied

warrantyofmerchantabilityandfitnessforaparticularpurpose.

PPIshallnotbeliableforanydirect,indirect,incidental,consequential,orotherdamageallegedin

connectionwiththefurnishingoruseofthisinformation.

NOTICE

Changesareperiodicallymadetothisdocument.Revisions,changes,anytechnicalinaccuracies,and

typographicalerrorswillbecorrectedinanysubsequenteditions.

MyBinding FastBack Model 11 User manual

Brand: MyBinding

Model: FastBack Model 11

Category: Binding machines

Type: User manual

This manual is also suitable for

Powis Parker Fastback S52

Download PDF

report

MyBinding FastBack Model 11 User manual

This manual is also suitable for

MyBinding FastBack Model 11 User manual

Related papers

Other documents