Zibro RS50 Owner's manual

Brand: Zibro

Model: RS50

Category: Motorcycles

Type: Owner's manual

This manual is also suitable for

8202412

use and maintenance RS 50

First edition: january 2004

Reprint:

Producido e impreso por:

DECA s.r.l.

Via Risorgimento, 23/1 - Lugo (RA) - Italia

Tel. +39 - 0545 35235

Fax +39 - 0545 32844

E-mail: deca@decaweb.it

www.decaweb.it

por cuenta de:

aprilia s.p.a.

via G. Galilei, 1 - 30033 Noale (VE) - Italy

Tel. +39 - (0)41 58 29 111

Fax +39 - (0)41 44 10 54

www.aprilia.com

SAFETY WARNINGS

The following precautionary warnings are

used throughout this manual in order to

convey the following messages:

Safety warning. When you find this

symbol on the vehicle or in the

manual, be careful to the potential risk

of personal injury. Non-compliance with

the indications given in the messages

preceded by this symbol may result in

grave risks for your and other people's

safety and for the vehicle!

WARNING

Indicates a potential hazard which may

result in serious injury or even death.

CAUTION

Indicates a potential hazard which may

result in minor personal injury or dam-

age to the vehicle.

NOTE The word ≈NOTE∆ in this manual

precedes important information or instruc-

tions.

INFORMATION

The operations preceded by this

symbol must be repeated on the

opposite side of the vehicle.

If not expressly indicated otherwise, for the

reassembly of the units repeat the disas-

sembly operations in reverse order.

The terms ≈right∆ and ≈left∆ are referred to

the rider seated on the vehicle in the nor-

mal riding position.

Any mention to the use of the vehicle with

passenger is to be intended as referred

only to the countries where this is allowed.

WARNINGS - PRECAUTIONS -

GENERAL ADVICE

Before starting the engine, carefully read

this manual and in particular the chapters

≈WARNINGS - PRECAUTIONS - GENER-

AL ADVICE∆ and ≈SAFE DRIVE∆.

Your and other people»s safety depends

not only on your quickness of reflexes and

on your agility, but also on what you know

about the vehicle, on its efficiency and on

your knowledge of the basic information for

RIDING SAFELY. Therefore, get a thor-

ough knowledge of the vehicle, in such a

way as to be able to drive in the traffic safe-

ly.



★

use and maintenance RS 50

NOTE This manual must be considered

as an integral part of the vehicle and must

always accompany it, even in case of re-

sale.

aprilia has carried out this manual with the

maximum attention, in order to supply the

user with correct and updated information.

However, since aprilia constantly im-

proves the design of its products, there

may be slight discrepancies between the

characteristics of your vehicle and those

described in this manual.

For any clarification concerning the infor-

mation contained in this manual, do not

hesitate to contact your aprilia Official

Dealer.

For control and repair operations not ex-

pressly described in this publication, for the

purchase of aprilia genuine spare parts,

accessories and other products, as well as

for specific advice, contact exclusively

aprilia Official Dealers and Service Cent-

ers, which guarantee prompt and accurate

assistance.

Thank you for choosing aprilia. We wish

you a nice ride.

All rights as to electronic storage, repro-

duction and total or partial adaptation, with

any means, are reserved for all Countries.

NOTE In some countries the antipollu-

tion and noise regulations in force require

periodical inspections.

The user of the vehicle in these countries

must:

√ contact an aprilia Official Dealer to have

the non-homologated components re-

placed with others homologated for use in

the country in question;

√ carry out the required periodical inspec-

tions.

NOTE Soon after purchasing the vehi-

cle, write down the identification data indi-

cated on the SPARE PARTS IDENTIFICA-

TION LABEL in the table here below. The

label is positioned under the rider saddle;

to read it, it is necessary to remove the rid-

er saddle, see p. 52 (REMOVING THE

RIDER SADDLE).

These data indicate:

√ YEAR = year of manufacture (Y, 1, 2, ...);

√ I.M. = modification code (A, B, C, ...);

√ COUNTRY CODES = homologation

country (I, UK, A, ...).

and are to be supplied to the aprilia Offi-

cial Dealer as reference data for the pur-

chase of spare parts or specific accesso-

ries of the model you have acquired.

In this manual the various versions are in-

dicated by the following symbols:

optional

catalytic version

VERSION:

Italy

Singapore

United Kingdom

Slovenia

Austria

Israel

Portugal

South Korea

(

Finland

Malaysia

Belgium

Chile

Germany

Croatia

France

Australia

Spain

United States

of America

)

Greece

Brazil

Holland

South Africa

Switzerland

New Zealand

Denmark

Canada

Japan

use and maintenance RS 50

TABLE OF CONTENTS

SAFE DRIVE .........................................................5

BASIC SAFETY RULES ................................. 6

CLOTHING ..................................................... 9

ACCESSORIES............................................ 10

LOAD ............................................................ 10

ARRANGEMENT OF THE MAIN ELEMENTS ...12

ARRANGEMENT

OF THE INSTRUMENTS/CONTROLS ...............14

INSTRUMENTS AND INDICATORS ..................14

INSTRUMENTS

AND INDICATORS TABLE........................... 15

MAIN INDEPENDENT CONTROLS ...................16

CONTROLS ON THE LEFT PART

OF THE HANDLEBAR.................................. 16

CONTROLS ON THE RIGHT PART

OF THE HANDLEBAR.................................. 17

IGNITION SWITCH....................................... 18

STEERING LOCK......................................... 18

AUXILIARY EQUIPMENT...................................19

GLOVE/TOOL KIT COMPARTMENT........... 19

REAR MUDGUARD EXTENSION

(in the countries where required).................. 19

SPECIAL TOOLS

.................................. 20

MAIN COMPONENTS.........................................21

FUEL............................................................. 21

TRANSMISSION OIL.................................... 21

BRAKE FLUID-recommendations ................ 22

DISC BRAKES.............................................. 22

FRONT BRAKE ............................................ 23

REAR BRAKE............................................... 24

2 STROKE OIL TANK................................... 25

ADJUSTING THE SHIFTING LEVER........... 25

ADJUSTING THE REAR BRAKE ................. 26

ADJUSTING THE CLUTCH.......................... 27

COOLANT ....................................................28

TYRES.......................................................... 29

CATALYTIC SILENCER



;

........ 30

EXHAUST SILENCER

;

.......................... 30

INSTRUCTIONS FOR USE ................................ 31

PRELIMINARY

CHECKING OPERATIONS...........................31

STARTING ....................................................32

DEPARTURE AND DRIVE............................34

RUNNING-IN.................................................37

STOPPING....................................................37

PARKING ......................................................37

SUGGESTIONS TO PREVENT THEFT .......38

MAINTENANCE.................................................. 39

REGULAR SERVICE INTERVALS CHART..40

IDENTIFICATION DATA ...............................42

POSITIONING THE VEHICLE ON THE

FRONT SUPPORT STAND

...................42

POSITIONING THE VEHICLE

ON THE REAR SUPPORT STAND

.......43

CHECKING THE TRANSMISSION

OIL LEVEL AND TOPPING UP.....................44

CHANGING THE TRANSMISSION OIL........45

FRONT WHEEL ............................................46

REAR WHEEL...............................................48

DRIVE CHAIN ...............................................50

REMOVING THE RIDER SADDLE...............52

REMOVING THE SIDE FAIRINGS ...............52

LIFTING THE FUEL TANK............................53

AIR CLEANER ..............................................54

REMOVING THE EXHAUST SILENCER......54

INSPECTING THE FRONT

AND REAR SUSPENSIONS.........................55

CHECKING THE BRAKE PAD WEAR..........56

IDLING ADJUSTMENT .................................57

ADJUSTING

THE ACCELERATOR CONTROL.................57

SPARK PLUG ...............................................58

BATTERY ..................................................... 59

LONG INACTIVITY OF THE BATTERY ....... 59

CHECKING AND CLEANING

THE TERMINALS ......................................... 60

REMOVING THE BATTERY.........................60

CHECKING

THE ELECTROLYTE LEVEL........................61

RECHARGING THE BATTERY....................61

INSTALLING THE BATTERY .......................61

CHANGING THE FUSE................................ 62

CLEANING THE EXHAUST SILENCER

AND THE EXHAUST TERMINAL.................62

CHECKING THE SIDE STAND ................... 64

CHECKING THE SWITCHES.......................64

ADJUSTING THE VERTICAL

HEADLIGHT BEAM ......................................65

BULBS ..........................................................65

CHANGING THE HEADLIGHT BULBS........ 66

CHANGING THE FRONT AND REAR

DIRECTION INDICATOR BULBS.................67

CHANGING

THE REAR LIGHT BULB.............................. 68

TRANSPORT ......................................................68

DRAINING THE FUEL TANK ....................... 69

CLEANING ..........................................................70

LONG PERIODS OF INACTIVITY................ 71

TECHNICAL DATA .............................................72

LUBRICANT CHART .................................... 75

Importers.......................................................77

Importers.......................................................78

Importers.......................................................79

Importers.......................................................80

WIRING DIAGRAM - RS 50.......................... 81

WIRING DIAGRAM KEY - RS 50 ................. 82

safe drive

use and maintenance RS 50

BASIC SAFETY RULES

To drive the vehicle it is necessary to be in

possession of all the requirements pre-

scribed by law (driving licence, minimum

age, psychophysical ability, insurance,

state taxes, vehicle registration, number

plate, etc.).

Gradually get to know the vehicle by driv-

ing it first in areas with low traffic and/or pri-

vate areas.

The use of medicins, alcohol and drugs or

psychotropic substances notably increases

the risk of accidents.

Be sure that you are in good psychophysi-

cal conditions and fit for driving and pay

particular attention to physical weariness

and drowsiness.

Most road accidents are caused by the

driver»s lack of experience.

NEVER lend the vehicle to beginners and,

in any case, make sure that the driver has

all the requirements for driving.

use and maintenance RS 50

Rigorously observe all road signs and na-

tional and local road regulations.

Avoid abrupt movements that can be dan-

gerous for yourself and other people (for

example: rearing up on the back wheel,

speeding, etc.), and give due consideration

to the road surface, visibility and other driv-

ing conditions.

Avoid obstacles that could damage the ve-

hicle or make you lose control.

Avoid riding in the slipstream created by

preceding vehicles in order to increase

your speed.

WARNING

Always drive with both hands on the

handlebars and both feet on the foot-

rests (or on the rider’s footboards), in

the correct driving posture.

Avoid standing up or stretching your

limbs while driving.

use and maintenance RS 50

COOLER

OIL

The driver should pay attention and avoid

distractions caused by people, things and

movements (never smoke, eat, drink, read,

etc.) while driving.

Use only the vehicle»s specific fuels and lu-

bricants indicated in the ≈LUBRICANT

CHART∆; check the oil, fuel and coolant

levels regularly.

If the vehicle has been involved in an acci-

dent, make sure that no damage has oc-

curred to the control levers, pipes, wires,

braking system and vital parts.

If necessary, have the vehicle inspected by

an aprilia Official Dealer, who should care-

fully check the frame, handlebars, suspen-

sions, safety parts and all the devices that

you cannot check by yourself.

Always remember to report any malfunc-

tion to the technicians to help them in their

work.

Never use the vehicle when the amount of

damage it has suffered endangers your

safety.

use and maintenance RS 50

ONLY ORIGINALS

Never change the position, inclination or

colour of: number plate, direction indica-

tors, lights and horns.

Any modification of the vehicle will result

in the invalidity of the guarantee.

Any modification of the engine or of other

members which is aimed at increasing the

speed or the power of the vehicle is prohib-

ited by the law; in fact, any modification re-

sulting in an increase of the maximum

speed or of the engine displacement would

change the scooter into a motorcycle,

which implies the following obligations for

the owner:

√ new homologation;

√ new registration;

√ appropriate driving license.

Further, said modifications cause the loss

of the insurance cover, since insurance

policies expressly prohibit to make techni-

cal changes aimed at increasing the vehi-

cle performance levels.

For the reasons stated above, the failure to

comply with the tampering prohibition is

punished by law with apposite sanctions

(including the confiscation of the vehicle),

which, according to the case, can be com-

bined with the sanctions provided for not

using the crash helmet and/or the number

plate, for the violation of fiscal obligations

(ownership tax) and with penal sanctions

provided for using the vehicle without driv-

ing license.

Never race with other vehicles.

Avoid off-road driving.

CLOTHING

Before starting, always wear a correctly

fastened crash helmet. Make sure that it is

homologated, in good shape, of the right

size and that the visor is clean.

Wear protective clothing, preferably in light

and/or reflecting colours. In this way you

will make yourself more visible to the other

drivers, thus notably reducing the risk of

being knocked down, and you will be more

protected in case of fall.

This clothing should be very tight-fitting

and fastened at the wrists and ankles.

Strings, belts and ties should not be hang-

ing loose; prevent these and other objects

from interfering with driving by getting en-

tangled with moving parts or driving mech-

anisms.

A12

345

use and maintenance RS 50

Do not keep objects that can be dangerous

in case of fall, for example pointed objects

like keys, pens, glass vials etc. in your

pockets (the same recommendations also

apply to passengers).

ACCESSORIES

The owner of the vehicle is responsible for

the choice, installation and use of any ac-

cessory.

Avoid installing accessories that cover

horns or lights or that could impair their

functions, limit the suspension stroke and

the steering angle, hamper the operation of

the controls and reduce the distance from

the ground and the angle of inclination in

turns.

Avoid using accessories that hamper ac-

cess to the controls, since this can prolong

reaction times during an emergency.

Large fairings and windscreens assembled

on the vehicle can produce aerodynamic

forces capable of compromising the stabili-

ty of the vehicle while driving.

Make sure that the equipment is well fas-

tened to the vehicle and not dangerous

during driving. Do not install electrical de-

vices and do not modify those already ex-

isting to avoid electrical overloads, be-

cause the vehicle could suddenly stop or

there could be a dangerous current short-

age in the horn and in the lights. aprilia

recommends the use of genuine accesso-

ries (aprilia genuine accessories).

LOAD

Be careful and moderate when loading

your luggage. Keep any luggage loaded as

close as possible to the centre of the vehi-

cle and distribute the load uniformly on

both sides, in order to reduce imbalance to

the minimum. Furthermore, make sure that

the load is firmly secured to the vehicle, es-

pecially during long trips.

use and maintenance RS 50

KG!

Avoid hanging bulky, heavy and/or danger-

ous objects on the handlebars, mudguards

and forks, because the vehicle might re-

spond more slowly in turns and its ma-

noeuvrability could be unavoidably im-

paired.

Do not place bags that are too bulky on the

vehicle sides and do not ride with the crash

helmet hanging from its string, because it

could hit people or obstacles making you

lose control of the vehicle.

Do not carry any bag if it is not tightly se-

cured to the vehicle.

Do not carry bags which protrude too much

from the luggage rack or which cover the

lights, horn or indicators.

Do not carry animals or children on the

glove compartment or on the luggage rack.

Do not exceed the maximum load allowed

for each side-bag.

When the vehicle is overloaded, its stability

and its manoeuvrability can be compro-

mised.

use and maintenance RS 50

ARRANGEMENT OF THE MAIN ELEMENTS

KEY

1) Left rear-view mirror

2) Radiator cap

3) Radiator

4) Fuel tank plug

5) Spark plug

6) Fuel tap

7) Battery

8) Fuse carrier

9) Passenger left footrest

(snapping, closed/open)

(in the countries where required)

10) Drive chain

11) Side stand (with automatic return)

12) Rider left footrest

(with spring, always open)

13) Shifting lever

14) Left fairing

15) Horn

use and maintenance RS 50

KEY

1) Glove/tool kit compartment

2) 2 stroke oil tank

3) 2 stroke oil tank plug

4) Rider saddle

5) Saddle lock

6) Air cleaner

7) Ignition switch/steering lock

8) Right rear-view mirror

9) Front brake fluid tank

10) Dashboard

11) Cold start lever

12) Rear brake fluid tank

13) Rear brake pump

14) Rear brake control lever

15) Rider right footrest

(with spring, always open)

16) Passenger right footrest

(snapping, closed/open)

(in the countries where required)

use and maintenance RS 50

ARRANGEMENT OF THE INSTRUMENTS/CONTROLS

KEY

1) Ignition switch/steering lock (

 -  - + )

2) Direction indicator switch (

( )

3) Horn push button (

 )

4) Dimmer switch (

 -  )

5) High beam signalling push button (

 )

6) Clutch lever

7) Instruments and indicators

8) Front brake lever

9) Throttle grip

10) Start push button (

)

11) Engine stop switch (

 - )

(in the countries where required)

12) Cold start lever (

)

INSTRUMENTS AND INDICATORS

KEY

1) Revolution counter

2) Coolant temperature indicator ()

3) Green right direction indicator warning light (

* )

4) Green neutral indicator warning light (

)

5) Red 2 stroke oil reserve warning light (

 )

6) Blue high beam warning light (

 )

7) Green low beam warning light (

)

8) Green left direction indicator warning light (

) )

9) Partial kilometres odometer

10) Odometer trip control

11) Total kilometres odometer

12) Speedometer

12) Speedometer - only km/h scale

;

use and maintenance RS 50

INSTRUMENTS AND INDICATORS TABLE

Description Function

Right direction indicator warning light (

Blinks when the right direction indicator is on.

Left direction indicator warning light (

))

Blinks when the left direction indicator is on.

High beam warning light (

)

Comes on when the headlight is in ≈high beam∆ position or when the high beam signalling is operated.

Low beam warning light (

)

It comes on when the headlight is in low beam position.

Revolution counter (rpm) Indicates the number of revolutions of the engine per minute.

Coolant temperature indicator (

)

It indicates the approximate temperature of the coolant in the engine.

When the pointer starts moving beyond the ≈min∆ level, the temperature is sufficient for driving the

vehicle.

The normal running temperature range is indicated by the central area of the scale.

If the pointer reaches the red area, stop the engine and check the coolant level, see p. 28 (COOLANT).

If the maximum allowed temperature is exceeded (red area “max” of the

scale), the engine may be seriously damaged.

2 stroke oil reserve

warning light (

)

It comes on when the quantity of 2 stroke oil left in the tank is equal to 0.35

If the warning light comes on, this means that the 2 stroke oil reserve is

being used; in this case, provide for topping up, see p. 25 (2 STROKE

OIL TANK).

Neutral indicator warning light (

) Comes on when the gear is in neutral.

Partial kilometres odometer

It indicates the partial number of kilometres covered. To set it to zero, use the odometer trip control.

Odometer trip control

Rotate it anticlockwise to set the partial kilometres odometer to zero.

Total kilometres odometer

It indicates the total number of kilometres covered.

Speedometer

It indicates the driving speed.

CAUTION

use and maintenance RS 50

MAIN INDEPENDENT CONTROLS

NOTE The electrical parts work only when the ignition switch

is in position ≈

∆.

The lighting system works only when the engine is running.

CONTROLS ON THE LEFT PART

OF THE HANDLEBAR

1) HORN PUSH BUTTON (

 )

The horn is activated when the push button is pressed.

2) DIRECTION INDICATOR SWITCH ( ( )

To indicate the turn to the left, move the switch to the left; to

indicate the turn to the right, move the switch to the right.

To turn off the direction indicator, press the switch.

3) DIMMER SWITCH (  -  )

When it is in position ≈

∆ the parking lights, the dashboard

light and the low beam are always on.

When it is in position ≈∆, the high beam comes on.

NOTE The lights can be switched off only by stopping the

engine.

4) HIGH BEAM SIGNALLING PUSH BUTTON ()

It makes it possible to use the high beam for signalling to

forthcoming vehicles while overtaking and in case of peril

and/or emergency.

5) COLD START LEVER ()

The starter for the cold start of the engine is operated by rotat-

ing the lever "

" downwards. To disconnect the starter, move

the lever "

" to its initial position.

use and maintenance RS 50

CONTROLS ON THE RIGHT PART

OF THE HANDLEBAR

1) ENGINE STOP SWITCH (

 - )

(in the countries where required)

CAUTION

Do not operate the engine stop switch “- ” in running

conditions.

This is a safety or emergency switch. With the switch in posi-

tion ≈

∆, it is possible to start the engine; the engine can be

stopped by moving the switch to position ≈

∆.

CAUTION

With stopped engine and ignition switch in position “”,

the battery may discharge.

When the vehicle has come to rest, after stopping the en-

gine, move the ignition switch to position “

”.

2) START PUSH BUTTON (

)

When the start push button ≈

∆ is pressed, the starter makes

the engine run. For the starting, see p. 32 (STARTING).

use and maintenance RS 50

IGNITION SWITCH

The ignition switch (1) is positioned on the

upper plate of the steering column.

NOTE The key operates the ignition

switch/steering lock, the saddle lock and

the fuel tank lock.

Two keys are supplied together with the

vehicle (one spare key).

STEERING LOCK

WARNING

Never turn the key to position “+” in

running conditions, in order to avoid

losing control of the vehicle.

OPERATION

To lock the steering:

◆

Turn the handlebar completely leftwards

(or rightwards).

◆

Turn the key to position ≈∆.

◆

Press the key and rotate it to position ≈+∆.

◆

Extract the key.

Position Function

Key

removal

Steering

lock

The steer-

ing is

locked.

It is neither

possible to

start the

engine, nor

to switch on

the lights.

It is possi-

ble to

remove the

key.



Neither the

engine, nor

the lights

can be

switched on.

It is possi-

ble to

remove the

key.



The engine

and the

lights can be

switched on.

It is not pos-

sible to

remove the

key.

use and maintenance RS 50

AUXILIARY EQUIPMENT

GLOVE/TOOL KIT COMPARTMENT

The glove/tool kit compartment is posi-

tioned under the rider saddle; to reach it:

◆

Remove the rider saddle, see p. 52 (RE-

MOVING THE RIDER SADDLE).

The tool kit (1) includes:

√ 3 mm, 4 mm, , 5 mm allen spanners

√ 10-11 mm double fork spanner

√ 21-22 mm spark plug socket spanner

√ Double-ended, cross-/cut headedscrew-

driver

√ Bent pin for socket spanner

√ Tool case

Max. allowed weight: 1.5 kg

REAR MUDGUARD EXTENSION

(in the countries where required)

The extension of the rear mudguard (2) is

extremely useful when the road surface is

wet, in fact it reduces the reach of the wa-

ter spray caused by the rear wheel.

NOTE The rear mudguard extension (2)

is supplied as standard component in the

countries where this is required for the ho-

mologation.

use and maintenance RS 50

SPECIAL TOOLS -

To perform some specific operations, it is

advisable to use the following special

tools (to be requested to an aprilia Official

Dealer):

Tool Operations Page

Support pins

(1) for the rear

support stand.

Positioning of the vehicle

on the rear stand.

Rear support

stand (2)

Rear wheel disassembly.

Drive chain adjustment.

Front support

stand (3)

Front wheel disassembly.

Page is loading ...

Zibro RS50 Owner's manual

Brand: Zibro

Model: RS50

Category: Motorcycles

Type: Owner's manual

This manual is also suitable for

Download PDF

report

Zibro RS50 Owner's manual

This manual is also suitable for

Zibro RS50 Owner's manual

Related papers

Other documents