DROPSA Mk 150 Owner's manual

 

MK150

Safetydatasheet

Pag. 1/1

C2131IEWK20/09

SafetydatasheetinaccordancewithEUorderNo.1907/2006

MK150

MQLoilusedinminimalsystemsforallthealloysofgood

toughability



Safetydatasheet

Dateofprinting:08/05/2009

Revisedon:03/02/2009

Version1.0E



1Designationofthesubstance/preparationandcompany



Designationofthesubstanceorpreparation

MK150

Partnumber3226664



Useofthesubstance/preparation

Preparationforindustrialandcommercialuse

Non‐water‐misciblemetalworkinglubricant



DesignationofthecompanyDropsaS.p.A.–ViaB.Croce,1Vimodrone(MI)

Tel.02/250791–Fax.02/25079767

 



2Possiblehazards



Classification

Maycauselong‐termadverseeffectsintheaquaticenvironment.



Additionalnotesonhazardsforpersonsandtheenvironment

Nofurtherrisksknown



3 Composition/statementsontheconstituentparts



Generaldescriptionoftheconstituentparts

Preparationofiso‐paraffinhydrocarbonsandsyntheticesters



Hazardouscomponents

Designation CAS‐No. Concentration Classification R‐phrases*

Alkanes(C9‐C12),Iso‐ 90622‐57‐4 25‐50% Xn 53‐65‐66



*Thetextofthenotesonhazards(R‐phrases)listedisgiveninsection16.



 

MK150

Safetydatasheet

Pag. 2/2

C2131IEWK20/09

4 First‐aidmeasures



Followinginhalation

Bringtheaffectedpersonintofreshairandlayhim/herdownquietly..



Followingcontactwiththeskin

Removecontaminatedclothingimmediatelyandwashtheaffectedpartsoftheskinwithsoap

andwater



Followingcontactwiththeeyes

Inthecaseofcontactwiththeeyes,rinseouttheeyesimmediatelyandthoroughlywithalotof

waterandconsultaphysician.



Followingswallowing

Donotinducevomiting.Washoutthemouthanddrinkalotofwater.Getmedicalattendance.



5 Fire‐fightingmeasures



Suitableextinguishingagents

Foam,CO2,dryextinguishingagent



Unsuitableasanextinguishingagentforsafetyreasons

Waterjet



Particularhazardsfromthesubstanceortheproductitself,itscombustionproductsorthegases

arisingtherefrom

COx



Specialprotectiveequipmentwhenfightingfires

Inthecaseofafireuseself‐containedbreathingapparatus



Furtherstatements

Conflagrationresiduesandcontaminatedextinguishingwatermustbedisposedofin

accordancewiththeofficialprescriptions.



6 Measuresinthecaseofunintendedrelease



Precautionarymeasuresinrelationtopersons

Removesourcesofignition.Avoidcontactoftheproductwiththeskinandeyes.Usepersonal

protectiveclothing.Takecar–thereisanincreaseddangerofslippingfromtheproductthathas

runout.



Environmentalprotectionmeasures

Donotallowtheproducttogetintosurfacebodiesofwater,sewersystemsortheearth.Inform

theresponsibleauthoritiesiftheproductescapesintosurfacebodiesofwater,sewersystemsor

theground.



Methodsforcleaningup/disposal

Absorbliquidwithanoilbinderoruniversalbinderanddisposeofthisinaccordancewiththe

regulations.



 

MK150

Safetydatasheet

Pag. 3/3

C2131IEWK20/09

7 Handlingandstorage



Handling

Notesonsafehandling

Avoidallowingtheproducttocomeintocontactwithunprotectedpartsoftheskin;usesuitable

glovesifnecessary(e.g.ofnitrilerubber).Preventtheformationofvapoursandaerosols.Ensure

adequateventilation,ifnecessarywiththeaidoflocalexractionsystems.



Storage

Requirementsinrespectofstoragerooms/conditions

Storeprotectedagainstfrostandheat.Storeinclosedvessels.Takeprecautionstopreventthe

buildingupofelectrostaticcharges.

Containersandfillingequipmentaretobestored/handledinsuchawaythatthepossibilityof

waterandthegroundbeingendangerediftheproductescapesisexcluded.



Notesonstoringtheproductwithotherproducts

Storageclass3B,flammableliquids(VCI–AssociationoftheGermanChemicalIndustry)



Intendedformsofuse

Preparationforindustrialandcommercialuse.

Non‐water‐misciblecoolantlubricant

Workers’compensationinsurancecarrierrule143–“Workingwithcoolantlubricants”istobe

observed.



8 Limitingandmonitoringofexposure/personalprotectiveequipment



Exposurelimitvalues



Workplacelimitvalues



Designationofthesubstance  Workplacelimitvalue   Comment.

Theproductdoesnotcontainrelevantquantitiesofindividualsubstanceswithworkplacerelated

limitvaluesrequiringtobemonitored.



Limitingandmonitoringofexposureattheworkplace



Protectionandhygienemeasures

Keeptheproductawayfromfoodandbeverages.Donotcarrycleaningclothsthataresaturated

intheproductinclothes.Thehandsshouldbewashedbeforebreaksanmeals.Applyaskin‐care

creamafterworktoreturngreasetotheskin.Observetheskinprotectionplanrelatingtothe

workplace.



Personalprotectiveequipment

Breathingprotection

Thisisnotnecessarywhentheventilationisadequate.



Protectionofthehands

Whenworkingwiththeproductwearprotectiveglovesofasuitablematerial(e.g.nitrilerubber,

permeationtime>480minutes)whichhavebeentestedinaccordancewithEN374.

Useaskinprotectingcreamthatisinsolubleinoilifglovesmaynotbeworn.Observetheskin

protectionplan.

 

MK150

Safetydatasheet

Pag. 4/4

C2131IEWK20/09

Protectionoftheeyes

Weargogglesprovidingprotectionatthesidesifthereisariskofsquirting/splashing.



Protectionofthebody

Wearprotectiveworkclothing.



Limitingandmonitoringinrespectoftheexposureoftheenvironment

Seethestatementsinsection6onthis.



9 PhysicalandChemicalproperties

Appearance



Formliquid



Colouryellow



Odourweaklycharacteristic



Importantstatementsonprotectionofhealthandtheenvironmentaswellasonsafety



Basicparametersrelevantforsafety



pH  (g/lwater,20°C)  notapplicable



Meltingrangenotdetermined °C



Boilingpoint/rangenotdetermined °C



Flashpoint70°C



Ignitiontemperature240   °C



Explosivelimits lower   0,6   Vol%

upper   6,5Vol%



Vapourpressure (20°C)   <1hPa



Specificgravity (20°C)   860  kg/m³



Solubilityinwater (20°C)   insolubleinpracticalg/l

terms



Distributioncoefficient

n‐octanol/water(logPow)  notdetermined



Viscosity,kinematic (40°C)   13   mm²/s



 

MK150

Safetydatasheet

Pag. 5/5

C2131IEWK20/09

10 Stabilityandreactivity



Conditionstobeavoided

Theproductisstableundertheconditionsofuseusualforthepurposeforwhichtheproductis

intended.Observethestatementsonstorage.



Substancestobeavoided

Strongoxidizingagents



Hazardousdecompositionproducts

IncaseoffireCOx



11 Toxicologicalstatements



Generalcomments

Acutetoxicity,irritationoftheskin,irritationofthemucousmembranes,mutagenicpotential

andallergizationoftheskinwereevaluatedonthebasisofthedataavailableonthe

components.Gapsinthedataexistinpartontheindividualcomponents



Practicalexperience

Ourexperiencetodatehasshownthatnoharmtohealthistobeexpectedwhentheproductis

usedforthepurposeforwhichitisintendedinthepropermannerandwhenthebasicrulesof

safetyatworkandindustrialhygieneareobserved.Splashes/squirtsintotheeyesand

continuouscontactwiththeskincantobeavoided.



FurtherstatementsClassificationiscarriedoutinaccordancewithguide‐line1999/45/EC.

12 Environment‐relatedstatements



Ecotoxicity

Theproductisaliquidthatisahazardforwater;itshouldnotbeallowedtogetintotheearth,

sewersorsurfacebodiesofwater.



Mobility

Notstatementsavailable



Persistenceanddegradability

Nostatementsavailable



Bioaccumulationpotential

Nostatementsavailable



Otherharmfuleffects

Theproductcontainsnoorganicallyboundhalogens.ItdoesnotcontributetotheAOXvalue.



 

MK150

Safetydatasheet

Pag. 6/6

C2131IEWK20/09

13 Notesondisposal



Disposal/waste(product)

Wasteistobehandedovertoalicensedwastedisposalcompanyinaccordancewiththelocal

officialregulations.



EuropeanWaseCataloguekey

120110syntheticmachiningoils



Packing

Emptycontainerscompletely.Handthemovertoalicensedwastedisposalcompany.Drumsand

containerscanbereconditioned.Cleaningtobecarriedoutbythefurtheruser.



14 Statementsontransport



TheproductisnotahazardousmaterialinaccordancewithADR,RID,IMDG,ADNR,ICAO/IATA



15 Legalprescriptions



Labelling



Hazardsymbol(s)andhazarddesignation(s)

Notapplicable

R‐phrases

R53 Maycauselong‐termadverseeffectsintheaquaticenvironment.



S‐phrases

S61 Avoidreleasetotheenvironment.Refertospecialinstructions/safetydatasheets.



OtherEUprescriptions

Statementsrelatingtodirective1999/13/EUonthelimitingofemissionsofvolatileorganic

compounds(VOCdirective):nostatements

Theproductcontains“volatileorganiccompounds”.

Content:30%



Nationalprescriptions(Germany)

31.BlmSchV

Theproductcontains“volatileorganiccompounds”.

Content:30%



Germanwater‐hazardingclass

WGK1(aweakhazardforwater,VwVwSAppendix4)



 

MK150

Safetydatasheet

Pag. 7/7

C2131IEWK20/09

16 Otherstatements



TextoftheR‐phrasesundersection3

R53  Maycauselong‐termadverseeffectsintheaquaticenvironment.

R65  Harmful:maycauselungdamageifswallowed

R66  Repeatedexposuremaycauseskindrynessorcracking



Alterationservice

Sectionswhichhavebeenchangedaremarkedwitha*.



Thestatementsinthissafetydatasheetarebasedonthepresentstateofourknowledge.Theyare

intendedtodescribeourproductsinrespectoftherelevantsafetyrequirementsandaccordinglyarenot

intendedtoguaranteeparticularproperties.



DROPSA Mk 150 Owner's manual

Other documents