Marcy MKM-1101 Owner's manual

NOTE:

Please read all instructions

carefully before using this

product

Table of Contents

Safety Notice

Important Assembly

Information

Care and Maintenance

Parts List

Warranty

Ordering Parts

Model

MKM-1101

Retain This

Manual for

Reference

120601

OWNER'S

MANUAL

MARCY

®

CLUB HOME GYM

MKM-1101

IMPORTANT: Please read this manual before commencing

assembly of this product.

IMPEX

®

INC.

2801 S. Towne Ave, Pomona, CA 91766

Tel: (800) 999-8899

www.impex-fitness.com

[email protected]

©IMPEX INC. www.impex-fitness.com

1

TABLE OF CONTENTS

BEFORE YOU BEGIN....................................................................................………… 1

IMPORTANT SAFETY NOTICES...................................................................……….. 2

EXERCISE GUIDELINES…………………………………………………………………. 3

WARNING LABEL PLACEMENT.....….....................................................................… 5

IMPORTANT ASSEMBLY INFORMATION.................................................................. 6

OPERATING NOTES……………………………………………………………………….. 7

CARE AND MAINTANENCE, WEIGHT CAPACITY, OPERATING NOTES ………… 8

PARTS LIST…………………………………………………………………………………. 9

EXPLODED DIAGRAM………………………………………………………………………11

WEIGHT RESISTNACE CHART………………………………………………………….. 12

WARRANTY.................................................................................................…………. 13

ORDERING PARTS.......................................................................................………… 13

BEFORE YOU BEGIN

Thank you for selecting the MARCY CLUB HOME GYM MKM-1101 by

IMPEX

®

INC. For your safety and benefit, read this manual carefully before

using the equipment. As a manufacturer, we are committed to provide you

complete customer satisfaction. If you have any questions, or find there are

missing or damaged parts, we guarantee you complete satisfaction through

direct assistance from our factory. To avoid unnecessary delays, please call

our TOLL-FREE customer service number. Our Customer Service Agents

will provide immediate assistance to you.

Toll-Free Customer Service Number

1-800-999-8899

Mon. – Fri. 9 a.m. – 5 p.m. PST

www.impex-fitness.com

[email protected]

©IMPEX INC. www.impex-fitness.com

2

IMPORTANT SAFETY NOTICE

This exercise equipment is built for optimum safety. However, certain precautions apply

whenever you operate a piece of exercise equipment. Be sure to read the entire manual

before you assemble or operate your equipment. In particular, note the following safety

precautions:

1. Keep children and pets away from the equipment at all times. DO NOT

leave children unattended in the same room with the equipment.

2. Only one person at a time should use the equipment.

3. If the user experiences dizziness, nausea, chest pain, or any other abnormal

symptoms, STOP the workout at once. CONSULT A PHYSICIAN

IMMEDIATELY.

4. Position the equipment on a clear, leveled surface. DO NOT use the equipment

near water or outdoors.

5. Keep hands away from all moving parts.

6. Always wear appropriate workout clothing when exercising. DO NOT wear

robes or other clothing that could become caught in the equipment. Running

or aerobic shoes are also required when using the equipment.

7. Use the equipment only for its intended use as described in this manual. DO

NOT use attachments not recommended by the manufacturer.

8. Do not place any sharp object around the equipment.

9. Disabled person should not use the equipment.

10. Before using the equipment to exercise, always do stretching exercises to

properly warm up.

11. Never operate the equipment if the equipment is not functioning properly.

12. A spotter is recommended during exercise.

13. This equipment is designed and intended for home and consumer use only, not for

commercial use.

WARNING: BEFORE BEGINNING ANY EXERCISE PROGRAM, CONSULT YOUR

PHYSICIAN. THIS IS ESPECIALLY IMPORTANT FOR INDIVIDUALS OVER THE AGE

OF 35 OR PERSONS WITH PRE-EXISTING HEALTH PROBLEMS. READ ALL

INSTRUCTIONS BEFORE USING ANY FITNESS EQUIPMENT. IMPEX INC. ASSUMES

NO RESPONSIBILITY FOR PERSONAL INJURY OR PROPERTY DAMAGE

SUSTAINED BY OR THROUGH THE USE OF THIS PRODUCT.

SAVE THESE INSTRUCTIONS.

©IMPEX INC. www.impex-fitness.com

3

EXECISE GUIDELINES

Building Muscle and Gaining Weight

Unlike aerobic exercise, which emphasizes endurance training, anaerobic exercise focuses on

strength training. A gradual weight gain can occur while building the size and strength of muscles.

While developing muscle mass, your body adapts to the stress placed upon it. You can modify your

diet to include foods such as meat, fish and vegetables. These foods help muscles recover and

replenish important nutrients after a strenuous workout.

Muscle Strength and Endurance

To achieve the greatest benefit from exercise, it is important to develop an exercise program that

allows you to work all of the major muscle groups equally.

To increase muscles strength; follow this principle:

Increasing resistance and maintaining the number of repetitions of an exercise results in increased

muscle strength.

To tone your body, follow the principle: Decreasing resistance plus increasing the number of

repetitions of an exercise results in increased body tone.

Once you feel comfortable with an exercise, you can change the resistance, the number of

repetitions, or the speed at which you do the exercise. It is not necessary to change all three

variables. For example, let’s say that you are training at 50 lbs and performing the exercise 10 times

in 3 minutes. When this becomes too easy, you may decide to move up lifting 60 lbs for the same

number of repetitions in the same amount of time. Lifting more weights fewer times most often

develops muscle strength. To gain both muscle strength and endurance, it is recommended that you

perform each exercise 15 to 20 reps per set.

Training Intensity

How hard you begin to train depends on your overall level of fitness. The soreness you experienced

can be lessened by decreasing the load you place on your muscles and by performing fewer sets. To

avoid injury, you should gradually work into an exercise program and set the load to your individual

fitness level. The load should increase as your fitness level increases.

Muscle soreness is common, especially when you first start exercising. If you are painfully sore for a

long time, it may be time to change your program. Eventually, your muscle system will become

accustomed to the stress and strain placed on it.

©IMPEX INC. www.impex-fitness.com

4

Beginning a Strength Building Program

Warming Up

To begin strength training, it is important to stretch and perform light exercise for 5 to 10 minutes.

This helps prepare the body for more strenuous exercise by increasing circulation, raising your body

temperature and developing more oxygen to your muscles.

Workout

Each workout to keep in mind that muscle soreness that lasts for a long period in not desirable and

may mean that injury has occurred.

Cool Down

At the end of each workout, perform slow stretching exercises for 5 to 10 minutes. Ease into each

stretch only going as far as you can. This stage allows your muscles wind down after training.

To provide a total workout program it is also recommended that 2 to 3 days of aerobic exercise is

performed in addition to the strength training.

Drinking Water

For the body to function properly, it must be properly hydrated. If you are exercising, you should

increase your fluid intake. The reason for this is that the water you take in will leave your system

through the sweating mechanism that cools your body during exercise. The water you lose through

exercise must be replaced so that the muscles can recover properly.

Rest Day

Although you may not feel like doing it, taking a rest day at least once a week is important because it

gives you body a chance to heal it self. Continuously working your muscle will result in over training

which will not benefit in the long run.

WARNING LABEL PLACEMENT

©IMPEX INC. www.im

pex-fitness.com

5

The warning labels shown here have been placed on the Rear Base and Upper Frame. If the labels are missing or

illegible, please call customer service at 1-800-888-8899 for replacements. Apply the labels in the location

shown.

IMPORTANT ASSEMBLY INFORMATION

 Tools Required for Assembling the Bench: Two Adjustable Wrenches and Allen

Wrenches.

 NOTE: It is strongly recommended that this equipment is assembled by two or more

people to avoid possible injury.

 Ensure Carriage Bolts are inserted through the SQUARE holes on components that need to

be assembled. Attach washer only to end of the Carriage Bolt.

 Use Allen Bolts or Hex Bolts inserted through the ROUND hole on components that need to

be assembled.

 Always wait until all bolts are assembled onto the bench before tightening the bolts. Do not

tighten each bolt right after it is installed

Fasten Nuts and Bolts

Securely tighten all Nuts and Bolts after all

components have been assembled in current and

previous steps.

NOTE: Do not over tighten any component with

pivoting function.

Make sure all pivoting components are able to move

freely.

Do not tighten all Nuts and Bolts in this step.

Weight Plate Installation

©IMPEX INC. www.im

pex-fitness.com

6

Slide weight plates onto Guide Rod from top to bottom.

The deep groove on each weight plate needs to face

backwards and downwards.

Deep Groove

OPERATION NOTES

Weight Plate Selection

1. Use the Weight Selector Pin to select the number of weight plates to exercise.

2. Do not insert weight selector pin while the weight stack or top plate is in elevated position.

3. Be certain the weight Selector Pin is completely inserted.

4. Each Weight Plate weights approximately 15lbs.

5. Please refer to Weight Resistance Chart page.

6. Never use dumbbells or other means to increase the weight resistance. Use only weight plates

provided by manufacturer.

Front Press and Butterfly Exercises

1. Insert the Butterfly Lock Pin through the holes on

Front Press Base and Butterfly to lock the

Butterfly in position when doing Front Press

exercises.

2. Pull out the Butterfly Lock Pin when doing

Butterfly exercises.

Cable Tension Adjustment

Adjust the tension of the Cable System by moving the lower Pulley position on the

Double Floating Pulley Brackets.

If the tension is too loose, move the lower pulley up by one hole.

If the tension is too tight, move the lower pulley down by one hole.

©IMPEX INC. www.impex-fitness.com

7

©IMPEX INC. www.impex-fitness.com

8

Lower Pulley

CARE AND MAINTENANCE

1. Lubricate moving parts with WD-40 or light oil periodically.

2. Inspect and tighten all parts before using the equipment.

3. The equipment can be cleaned using a damp cloth and mild non-abrasive detergent.

DO NOT use solvents.

4. Examine the equipment regularly for signs of damages or wear.

5. Replace any defective components immediately and/or keep the equipment out of use until

repair.

6. Failure to examine regularly may affect the safety level of the equipment.

WEIGHT CAPACITY AND DIMENSION

1. Maximum user weight: 300 lbs.

2. Assembled Dimension: 61” x 37” x 79”

©IMPEX INC. www.impex-fitness.com

9

MKM-1101 PARTS LIST

PART NO DESCRIPTION

SIZE

QUANTITY

1 Rear Base 1

2 Base Frame 1

3 Vertical Frame 1

4 Seat Support 1

5 Leg Developer 1

6 Upper Frame 1

7 Front Press Base 1

8 Right Butterfly 1

9 Left Butterfly 1

10 Guide Rod 2

11 Front Press Handle 2

12 Swivel Pulley Bracket 2

13 Double Floating Pulley Bracket 2

14 Angled Floating Pulley Bracket 1

15 Bracket 4 ¾” x 1 ¾” 3

16 Foam Tube 2

17 Selector Rod 1

18 Lat Bar 1

19 Shiver Bar 1

20 Shiver Bar Handle 1

21 Bracket 7” x 2 3/8” 1

22 Front Press Axle 4” 1

23 Seat Pad 1

24 Backrest Board 1

25 Foam Roll 4

26 Butterfly Large Foam Roll 2

27 Grip 5 3/8” 6

28 Rubber Bumper Ø2 ½” x 1” 2

29 Rubber Bumper Ø 1 ½” x 5/8” 1

30 Rubber End Cap 1 7/8” x 1 7/8” 1

31 Cone-shaped End Cap Ø 1” 1

32 End Cap Ø2” 6

33 End Cap Ø 1” 4

34 End Cap 2” x 2” 6

35 Front Press Base End Cap 2” x 2” 2

36 Rear Base End Cap 2” x 2” 2

37 Cable Retainer 4

38 Pulley Bushing Ø 1” x 5/8” 10

10

39 Bushing Ø 1 ½” 2

40 Upper Cable 144” 1

41 Butterfly Cable 119” 1

42 Lower Cable 122” 1

43 Butterfly Lock Pin 2

44 Metal Bushing Ø 1” x Ø 7/8” x 3/8” 2

45 Metal Bushing Ø 1” x Ø 7/8” x ½” 2

46 Selector Stem 5lb 1

47 Weight Plate 15lb 8

48 Weight Plate Selector Lock Pin 1

49 Pulley 14

50 Chain 15-link 1

51 Hook 2

52 Ankle Strap 1

53 Single Handle 1

54 Philips Screw M6 x 5/8” 1

55 Self Tapping Philips Screw ST4.8 2

56 Allen Bolt M10 x 1” 7

57 Allen Bolt M10 x 1 ¾” 7

58 Allen Bolt M10 x 2” 2

59 Allen Bolt M12 x 3 1/8” 1

60 Allen Bolt M10 x 2 5/8” 7

61 Allen Bolt M8 x 2 ½” 4

62 Carriage Bolt M10 x 2 ¾” 6

63 Carriage Bolt M10 x 2 7/8” 2

64 Washer Ø 5/8” 4

65 Washer Ø ¾” 37

66 Washer Ø 1” 2

67 Large Washer Ø 1” x Ø 3/8” 4

68 Aircraft Nut M10 29

69 Aircraft Nut M12 1

Allen Wrench (Tool) 5# 1

Allen Wrench (Tool) 6# 1

Allen Wrench (Tool) 8# 1

EXPLODED DIAGRAM

pex-fitness.com

11

12

MKM-1101 WEIGHT RESISTANCE CHART

WEIGHT PLATE

Station 1 2 3 4 5 6 7 8

Front Press 40 57 74 91 108 125 142 159

Lat Pull 40 55 70 85 100 115 130 145

Butterfly 20 27.5 35 42.5 50 57.5 65 72.5

Low Pulley 40 55 70 85 100 115 130 145

Leg Developer 40 55 70 85 100 115 130 145

Note: Each plate weights 15 lbs.

Numbers are approximate. Actual weights may vary.

Values for Butterfly are for each arm.

13

IMPEX

®

INC.

LIMITED WARRANTY

IMPEX Inc. ("IMPEX

®

") warrants this product to be free from defects in workmanship and material, under

normal use and service conditions, for a period of two years on the Frame from the date of purchase. This

warranty extends only to the original purchaser. IMPEX's obligation under this Warranty is limited to

replacing or repairing, at IMPEX's option.

All returns must be pre-authorized by IMPEX. Pre-authorization may be obtained by calling IMPEX

Customer Service Department at 1-800-999-8899. All freights on products returned to IMPEX must be

prepaid by the customer. This warranty does not extend to any product or damage to a product caused by

or attributable to freight damage, abuse, misuse, improper or abnormal usage or repairs not provided by an

IMPEX authorized service center or for products used for commercial or rental purposes. No other

warranty beyond that specifically set forth above is authorized by IMPEX.

IMPEX is not responsible or liable for indirect, special or consequential damages arising out of or in

connection with the use or performance of the product or other damages with respect to any economic loss,

loss of property, loss of revenues or profits, loss of enjoyments or use, costs of removal, installation or other

consequential damages or whatsoever natures. Some states do not allow the exclusion or limitation of

incidental or consequential damages. Accordingly, the above limitation may not apply to you.

The warranty extended hereunder is in lieu of any and all other warranties and any implied warranties of

merchantability or fitness for a particular purpose is limited in its scope and duration to the terms set forth

herein. Some states do not allow limitations on how long an implied warranty lasts. Accordingly, the

above limitation may not apply to you.

This warranty gives you specific legal right. You may also have other rights which vary from state to state.

Register on-line at www.impex-fitness.com

IMPEX

®

INC.

2801 S. Towne Ave.

Pomona, CA 91766

ORDERING REPLACEMENT PARTS

Replacement parts can be ordered by calling our Customer Service Department toll-free at 1-800-999-8899

during our regular business hours: Monday through Friday, 9 am until 5 pm Pacific standard time.

[email protected]

When ordering replacement parts, always give the following information.

1. Model

2. Description of Parts

3. Part Number

4. Date of Purchase

Marcy MKM-1101 Owner's manual

Marcy MKM-1101 Owner's manual

Related papers

Other documents