Swisher LS722X User manual

ReadandfollowallSafety

PrecautionsandInstructions

beforeoperatingthis

equipment.

LOG

SPLITTER

OWNER’S

MANUAL

1602CORPORATEDRIVE,WARRENSBURG,MISSOURI64093PHONE660-747-8183

FAX660-747-8650

MODELNO.

LS722X

STARTINGSERIAL#:

L206-010001

Manufacturingqualitylawncareequipmentsince1945

Safety

Assembly

Operation

ServiceandAdjustment

RepairParts

MadeInThe

USA

IMPORTANT

swisherinc.com

11624

Rev.06-010

Intheeventyouhaveaclaimunderthiswarranty,youmustreturntheproducttoanauthorizedservicedealer.

Alltransportationcharges,damage,orlossincurredduringtransportationofpartssubmittedforreplacementor

repairunderthis warrantyshallbe bornebythe purchaser.Should youhaveany questions concerningthis

warranty,pleasecontactustoll-freeat1-800-222-8183.Themodelnumber,serialnumber,dateofpurchase,

andthenameoftheauthorizedSwisherdealerfromwhomyoupurchasedthesplitterwillbeneededbeforeany

warrantyclaimcanbeprocessed.

THIS WARRANTY DOES NOT APPLY TO ANY INCIDENTAL OR CONSEQUENTIAL

DAMAGESANDANYIMPLIEDWARRANTIESARELIMITEDTOTHESAMETIMEPERIODS

STATEDHEREINFORALLEXPRESSEDWARRANTIES.Somestatesdonotallowthelimitationof

consequentialdamagesorlimitationsonhowlonganimpliedwarrantymaylast,sotheabovelimitationsor

exclusionsmaynotapplytoyou.Thiswarrantygivesyouspecificlegalrightsandyoumayhaveotherrights,

whichvaryfromstate-to-state.ThisisalimitedwarrantyasdefinedbytheMagnuson-MossActof1975.

LIMITEDWARRANTY

Themanufacturer’swarrantytotheoriginalconsumerpurchaseris:Thisproductisfreefromdefectsin

materialsandworkmanshipforaperiodofONE(1)yearfromthe dateofpurchasebytheoriginalconsumer

purchaser.Wewillrepairorreplace,atourdiscretion,partsfoundtobedefectiveduetomaterialsor

workmanship.Thiswarrantyissubjecttothefollowinglimitationsandexclusions:

TABLEOFCONTENTS

WARRANTY………………....….2

SAFETYPERCAUTIONS………3-4

TOWING..….……..……………..5

OPERATION……………………5-8

MAINTENANCE.…………………….7-8

DECALS…..………….……………….9

PARTSBREAKDOWN………………10-13

SPECIFICATIONS..…………………..15

1) EngineWarranty Allenginesutilizedonourproductshaveaseparatewarrantyextended

tothembytheindividualenginemanufacturer.Anyengineservice

difficultyistheresponsibilityoftheenginemanufacturerandinno

wayisSwisherMowerCo.,Inc.oritsagentsresponsibleforthe engine

warranty.TheBriggs&StrattonEngineServiceHot-Lineis1-800-

233-3723.

2) CommercialUse Thewarrantyperiodforanyproductusedforcommercialorrentalis

limitedtoninety(90)daysfromthedateoforiginalpurchase.

3) Limitation Thiswarrantyappliesonlytoproductswhichhavebeenproperly

assembled,adjusted,andoperatedinaccordancewiththeinstructions

containedwithinthismanual.Thiswarrantydoesnotapplytoany

productofSwisherMowerCo.,Inc.,thathasbeensubjecttoalteration,

misuse,abuse,improperassemblyorinstallation,shippingdamage,or

tonormalwearofproduct.

4) Exclusions Excludedfromthiswarrantyarenormalwear,normaladjustments, and

normalmaintenance.Thepump,valve,andcylindereachcarryseparate

manufacture’swarranties.Thevalveandcylinderbothcarryaone(1)year

limitedwarranty.Thepumpcarriesatwo(2)yearlimitedwarranty.

SAFETYPRECAUTIONS



WARNING:

TheengineexhaustfromthisproductcontainschemicalsknowntothestateofCalifornia

tocausecancer,birthdefectsorotherreproductiveharm.



DANGER:

Yourlogsplitterwasbuilttobeoperatedaccordingtotherulesforsafeoperationinthis

manual.Aswithanytypeofpowerequipment,carelessnessorerroronthepartoftheoperatorcanresult

inseriousinjury.Ifyouviolateanyoftheserules,youmaycauseseriousinjurytoyourselforothers.



• Readandunderstandthemanual.Learntooperatethisequipmentinasafemanner.Familiarize

yourselfwithallofthecontrolsinasafeenvironmentbeforestartingtoworkwiththismachine.



• DONOTunderanycircumstancesalterthislogsplitter.Thisequipmentwasdesignedand

engineeredinaccordancewithoperatinginstructions.Alteringthisequipment,orusingthis

equipmentinsuchawayastocircumventitsdesigncapabilitiesandcapacities,couldresultin

seriousinjuryorfatalityandWILLVOIDTHEWARRANTY.



• AllowONLYresponsibleadultswhohavereadthismanualtooperatethismachine.NEVER

allowchildrentooperatethismachine.



• NEVERoperateorallowsomeonetooperatethisequipmentwhileundertheinfluenceof

alcohol,drugsormedication.Beingcoherentisessentialforsafety.



• ALWAYSuseoutdoorswithadequateventilation.DON’Truntheengineinanenclosedarea.

Exhaustgasescontaincarbonmonoxide.Thisodorlessgascanbedeadlywheninhaled.



• NEVERusesplitterforanyotherpurposethansplittingwood.Anyotherusecanresultin

injury.Yoursplitterisaprecisionpieceofpowerequipment,notatoy.Therefore,exercise

extremecautionatalltimes.



•

ONLYasingleoperatoristoloadandoperatethelogsplitter.KEEPallothers,includingpets

andchildren,aminimumof20feetawayfromyourworkarea.Moreaccidentsoccurwhen

morethanonepersonoperatesthelogsplitterthananyothertime.



• ALWAYSwearprotectivegearsuchassafetygoggles,protectivehearingdevice,steel-toed

shoes,andtight-fittinggloveswithoutdrawstringsorloosecuffs.



• NEVERwearlooseclothingorjewelrythatcanbecaughtbymovingpartsofthesplitterand

pullyouintoit.Keephairawayfrommovingparts.



• NEVERoperateyoursplitteronwet,muddy,oricysurfaces.KEEPworkareacleanofsplit

wood.Safefootingisessentialinpreventingaccidents.



•

ONLYoperatesplitteronlevelgroundwithwheelsblocked,notonthesideofahill.Itcould

tip,orrollinglogs,poorfooting,etc.couldcauseanaccident.



ThisSafetyAlertSymbolindicatesimportantmessagesinthismanual.

Whenyouseethissymbol,carefullyreadthemessagethatfollowsandbe

alerttothepossibilityofpersonalinjury.

Readthismanualcompletely.Thismachinecanamputatehands,feet,andthrowobjects.

Failuretoobservethefollowingsafetyinstructionscouldresultinseriousinjuryordeath.

•

NEVERoperateyoursplitternearaflameorspark.Hydraulicoilandgasolineareflammableandcan

explode.



• NEVERfillgastankwhiletheengineishotorrunning.Allowtheenginetocoolbeforerefueling.



• Thisunitisequippedwithaninternalcombustionengineandshouldnotbeusedonornearany

unimprovedforest-covered,brush-coveredorgrass-coveredlandunlesstheengine’sexhaustsystemis

equippedwithasparkarrestermeetingapplicablelocalorstatelaws(ifany).Ifasparkarresterisusedit

shouldbemaintainedineffectiveworkingorderbytheoperator.



-NOTE-



InthestateofCalifornia,theaboveisrequiredbylaw(Section442oftheCaliforniaPublicResourcesCode).

Otherstatesmayhavesimilarlaws.Federallawsapplyonfederallands.Asparkarrestermuffler(optionalby

manufacturer)isavailableatyournearestenginedealer.Checklegalrequirementsinyourarea.



• ONLYuseyourhandstooperatethecontrollever.NEVERusefoot,knee,ropeoranyextensiondevice.



• SplitONLYonelogatatime.NEVERattempttosplittwologsontopofeachother.



• NEVERplacehandsorfeetbetweenlogandsplittingwedgeorbetweenlogandramduringforwardor

reversestroke.ALWAYSkeepfingersclearofsplitsthatopeninlogduringsplittingoperation.



• DONOTstraddleorreachacrossthesplittingareawhileoperatingthesplitter.



• DONOTstepoversplitterwhentheengineisrunning.Youmaytriporaccidentallyactivatethesplitting

wedge.Walkaroundtogettotheotherside.



• NEVERattempttoloadsplitterwhilesplittingwedgeisinmotion.Whenloadinglogsplitter,placehands

onthesidesofthelog,nottheends.



• NEVERattempttosplitwoodsacrossthegrain.Woodmayburstorflyoutofyoursplitterandresultin

seriousinjury.



• NEVERleaveyoursplitterunattendedwiththeenginerunning.Shutofftheengineifyouareleaving

yoursplitter,evenforashortperiodoftime.Someonecouldaccidentallyactivatetheramandbeinjured.



• Bothendsofthelogshouldbecutassquarelyaspossibletopreventthelogfromslidingoutofthesplitter

duringoperation.Loglengthshouldbekeptto24”orless.



• NEVERoperateyoursplitterwhileitisattachedtothetowvehicle.



• BEFOREtowing,becertainthatthesplitterissecurelyattachedtothetowingvehicleandthatthesupport

leg,beamandcylinderaresecuredinthererespectivetowingpositions.



• NEVERallowpersonstorideonsplitter.DONOTcarryanycargoorwoodonyoursplitter.Itmayfall

offandcauseanaccident.



• DONOTloosenorremoveanyhydraulicfitting,lineorreservoircapwhileyoursplitterorengineis

running.



• Fluidescapingfromaverysmallholecanalmostbeinvisible.DONOTcheckforleakswithyourhand.

Seemaintenancesectionforinstructions.IFinjuredbyescapingfluid,seeadoctoratonce.Serious

infectionorreactioncandevelopifpropermedicaltreatmentisnotadministeredimmediately.



• DONOToperateyoursplitterinpoormechanicalconditionorwhenitisneedofrepair.



• ALWAYSdisconnectthesparkplugwireandplacethewirewhereitcannotcontactthesparkplug,to

preventaccidentalstartingtheenginewhensettingup,transporting,adjustingorrepairing.



ASSEMBLY



Thislogsplitterhasbeenpartiallyassembledatthefactory.Refertothedrawingsandpartlistsshoulditbecome

necessarytodisassembletheunitforrepairorreplacementofparts.



Inspectallcomponentsfordamage.Ifyoubelieveyouhaveadamagedpartpleasecontactcustomerservice

immediatelyat1-800-222-8183.



WARNING:



Exerciseextremecaution,aspartsareveryheavy.Sufficientpersonsormechanicalhandling

equipmentshouldbeused.



Refertouncratingandassemblyinstructionsforassemblyprocedures.



OPERATION



INTENDEDUSE:



Thislogsplitterisintendedanddesignedtoonlysplitwood.NEVERuseforanyother

purposes.DoingsocancauseinjuryorVOIDTHEWARRANTY.



IMPORTANT:

Thisunitisshippedwithoilbutwithoutgasolineintheengine.Afterassembly,seeseparate

EngineManualforproperfuelandoilrecommendations.



WARNING:DONOTSTARTORRUNTHELOGSPLITTERWITHOUTOILINTHEENGINE

ANDHYDRAULICRESERVOIR.



FILLINGTHEHYDRAULICRESERVOIR

Fillthehydraulicreservoirwithatleast12QuartsofDextronIIIAutomaticTransmissionfluidor10WAW

hydraulicfluid.Afterthehydraulicreservoirandtheenginecrankcasearefilledcorrectlywiththeirrespective

oils,starttheengine.Remembertosetthethrottleandturnonthefuelshut-offvalve.Thehydraulicpump

shouldprimeitself.Withtheenginerunning,movethehydraulicvalvelevertowardthewedge.Thiswillcause

thecylindertoextendandexpelair.Whenthecylinderisfullyextended,retrac

tit.Repeatthisprocedureseveral

times.(Anerraticmovementofthecylinderindicatesthatthereisairinthesystem).Oncethecylinderhasa

smoothandconstantspeedindicatingthatallairhasbeenexpelled,addanother4quartsofoil,thisshouldthen

bringthefluidleveluptoapproximately3”belowthefillhole.Thismodelrequiresapprox.16-17Quartsof

hydraulicfluid.



NOTE:

Ifthetankisoverfilled,itwilltendtoexpeloilfromthebreathercapwhenthecylinderisretracted.



STARTUP

WARNING:

DONOTSTARTORRUNTHELOGSPLITTERWITHOUTOILINTHEENGINE

ANDHYDRAULICRESERVOIR.



SeeseparateEngineManualforfuelandoilrecommendations.Ifapplicableyourlogsplitterhascomeequipped

withafuelshut-offvalvefortowingpurposes.

Beforestartingenginemakesurecrankcaseisfilledcorrectlywithoilandtheproperfuelhasbeenused.The

enginewillonlystartwhenthethrottleleverandfuelshut-offvalveifapplicableareturnedtotheirONpositions.



STARTINGINSTRUCTIONS



Briggs&Stratton7HPEngine



1. Movethrottlecontrolto“FAST.”

2. Pushprimerbulbthree(3)times.NOTE:

Donotuseprimertorestartawarmengineafterashort

shutdown.

3. Graspropehandleandpulloutslowlyuntilresistanceitfelt.Thenpullrapidlywithafullarmstroke.

NOTE:

Ifenginefailstostartafterthree(3)pulls,repeatsteps1and2.

4. WhenEnginestarts,leavethrottlecontrolat“FAST.”Thethrottlemustbesetinthefastpositionfor

maximumperformance.

5. Tostopengine,movethrottleleverto“SLOW”forafewsecondsthento“STOP.”



POSITIONINGTHECYLINDER

1. Removelockpinsfromthecylinderretentionclipsandrotateclipsdownexposingtheopenslotsonthe

cylinderretentionbracket(referenceFigure2).

2. SlidetheCylinderforwarduntilthereartrunnionscleartheslotsthenliftthebacksideofthecylinderuntil

thereartrunnionsclearthecylinderretentionbracketandslidecylinderbackuntilthefrontcylinder

trunnionsslideintotheopenslotsofthecylinderretentionbracket(referencearrowinFigure2).

3. Rotatethecylinderretentionclipsupwardaroundthecylindertrunnionsandlocktheminplaceusingthe

lockpins.

4. Nextyouneedtoremovethelockpinfromthebeampivotbracketandrotatethebeamcounterclockwise

90degreesuntilthepivotholesareinalignmentandreinstallballlockpin(referenceFigure4).Your

splitterisnowinthehorizontaloperatingposition.

5. Removethehitchpinfromthebeampivot(referenceFigure4).Pivotyourbeamintotheverticalposition

andreinstallthehitchpininthecenterhole(referenceFigure5).Yoursplitterisnowinthevertical

operatingposition.



Figure2Figure1

Figure3

Figure4 Figure5



WARNING:

NEVEROPERATETHESPLITTERWITHTHECYLINDERINTHESTORED

POSITION.



SPLITTEROPERATION

1. Setupthelogsplitterinaclear,levelareaandblockthewheels.Thesuctionportonthetankshould

alwaysbeonthelowersideofthelogsplitter.

2. Placealogonthebeam,againstthefootplate.Makesurethelogissecurelyonthefootplateandup

againstthebeam.

3. Depressthevalveleversothatthecylinderwilldrivethepushblockintothelog.Extendthecylinder

untilthelogsplitsortotheendofitsstroke.Iftheloghasnotcompletelysplitafterthecylinderhas

reachedtheendofitsextension,retractthecylinder.NOTE:

Leavingthevalveinthe“actuate”position

attheendofthestrokemaydamagethepump.Alwaysuseextracarewhensplittinglogswithendsthat

arenotsquare.



NOTE:

Toextendthelifeofthehydrauliccylinder,avoid“BOTTOMINGOUT”thecylinder.



TOWINGSAFETY

Thisunitshouldnotbetowedonanystreet,highway,orpublicroadwithoutcheckingtheexistingfederal,local,

andstatelaws.Anylicensingormodificationssuchastaillights,etc.,needtocomplywithexistingfederal,local,

orstatevehiclerequirementsisthesoleresponsibilityofthepurchaser.Obeyallregulationswhentowingon

publicroadsandhighways.Seealso

SAFETYPERCAUTIONS.



WARNING:

NEVERTOWTHESPLITTERWITHCYLINDERINTHEOPERATINGPOSITION.



Turnthefuelshut-offvalveifapplicableOFFtopreventfloodingoftheenginewhiletraveling.



Becarefulwhenbackingup.Youcaneasilyjack-knifeyoursplitter.



TOWINGATNIGHT

TherequirementsfortaillightsarebasedonStatesregulations.Somestatesallowtowingatnightas

longasthetowedequipmentdoesnotvisiblyimpairthetowvehicletaillights.Thisisbas

edonastate,

tostaterequirements.Thecustomerisresponsibleformeetingthestatesrequirements.



Ifa“StatementofOrigin”isrequiredinyourstate,seeyourlocaldealertoreceiveone.



HYDRAULICSAFETY

Thehydraulicsystemonyoursplitterrequirescarefulinspectionalongwiththemechanicalparts.Besureto

replaceanyfrayed,kinked,crackedorotherwisedamagedhydrauliccomponents.Justbecauseitisn’tleaking

todaydoesn’tmeanthatitwillnotfailtomorrow.



Fluidescapingfromaverysmallholecanalmostbeinvisible.Donotcheckforleakswithyourhand.Escaping

fluidunderpressurecanhavesufficientforcetopenetrateskincausingseriouspersonalinjuryorevendeath.

Leakscanbedetectedbypassingapieceofcardboardorwoodoverthesuspectedleakandlookingfor

discoloration.

IFinjuredbyescapingfluid,seeadoctoratonce.Seriousinfectionorreactioncandevelopif

propermedicaltreatmentisnotadministeredimmediately.



Shoulditbecomenecessarytoloosenorremoveanyhydraulicfittings,linesorreservoircap,besuretorelieveall

pressurebyshuttingoftheengineandmovingthecontrolhandlebackandforthseveraltimes.



NEVERremovethecapfromthehydraulictankorreservoirwhiletheunitisr

unning.Hotoilunderpressure

couldresultinseriousinjury.Seealso

SAFETYPERCAUTIONS.



Thepressurereliefvalveonyoursplitterispresetatthefactory.DONOTadjustthevalve.Onlyaqualified

technicianshouldperformthisadjustment.



MAINTENANCEANDSTORAGE

WARNING:



DISCONNECTTHESPARKPLUGBEFOREPERFORMINGANYMAINTENANCE.



Consulttheoperatingandmaintenanceinstructionsoftheenginemanufacturerforenginecare.



Alwayschecktheoillevelofthehydraulicreservoirbeforeoperation.Operatingwithoutanadequateoil

supplywillcauseseveredamagetothepump.



Periodicallycheckthatallnuts,bolts,screws,clampsandfittingsaretightandsecure.



Tokeepyoursplitterintopworkingconditionperformallrecommendedmaintenanceproceduresbeforeyouuse

yoursplitter.



Ifthewedgebecomesdullornickedagrinderorsharpeningtoolcanbeusedtosharpenit.



Completelydrainthefueltankpriortostorage.Alwaysstoregasolineinanapproved,tightlysealedcontainer.Store

containerinadry,coolplacewithadequateventilation.Keepfuelawayfromareaswherefumescouldcontactopen

flame,pilotlightorsparks.



Beawareoftheenvironmentwhendisposingofusedpetroleumproducts.Pleasedisposeofusedhydraulic

fluid,engineoilandanybyproductsfromthemaintenanceofyoursplitteratapprovedrecyclingcenters.



Shoulditbecomenecessarytodisassembletheunitforrepairorreplacementofparts,refertothedrawingsandparts

listonthefollowingpages.Exerciseextremecaution,assomepartsareveryheavyandwillrequiresufficient

personsormechanicalhandlingequipment.



YourSwisherLogSplitterhasbeenproducedwithcomponentsdesignedspecificallytothismachine.Although

standardsprings,hardwareandectmaylooksimilartopartsusedonothermachinery,theymayinsomecases

bemadeofadifferentconstructionand/ormaterials.Allreplacementpartsmustmeetmanufacturer’s

specifications.



Theoperationofanysplittercanproduceforeignobjectstobethrownintothe

eyes,resultinginsevereeyedamage.Alwayswearcertifiedsafetyglassesor

wide-visionsafetygogglesoverspectaclesbeforestaringanysplittingmachine

andwhileoperatingsuchamachine.

Theoperationofanysplitterproducessoundwavesthataredamagingtothe

humanear.Earprotectionisrecommended.



OD12– HYDRAULICFILLPLUG

DECAL

11427– LSDANGERDECAL

OD33– SPEEDDECAL

OD16– FUELSHUTOFFDECAL

(NOTALLMODELS)

OD07– COLDWEATHERDECAL

SAFETYDECALS

Replacedecalsimmediatelyifdamaged.

11794– CAUTIONDECAL

ASSEMBLYDETAIL

LS722XMODELS

SERVICEPARTS

PleasehaveModelandSerialNumbersreadywhenorderingparts.

Colorcannotbeguaranteeduponserviceparts.

ITEMNUMBER DESCRIPTION PARTNUMBER

1 54"ReturnHose 7290

2 48"PressureHose 7289

3 #12HoseClamp LS5001

4 ReturnLineFitting 7329

5 FilterHead LS1112

6 FilterElement LS1113

7 3/4"NPTFillerCapw/Hole 7379

8 HydraulicReservoir/Tank 11467TK

9 Bolt3/8-16X3/4SerrFlange NB780

10 Nut3/8-16SerrFlange NB779

11 Bolt5/16-18X3/4SerrFlange NB596

12 Nut5/16-18SerrFlange NB170

13 #16HoseClamp LS4999

14 20"SuctionHose 7346

15 HydraulicPump-LS722X LS2001H

16 PressureLineFitting 11248

17 MotorBaseWeldment 11207TK

18 TongueSupportWeldment 11373TK

19 3/8X21/2SafetyHitchPin H11

20 Bolt3/8-16X21/2GR5 NB619

21 Washer3/8SAE NB272

22 Nut3/8-16Nyloc NB182

23 TongueWeldment 11374TK

24A LegSupportBracket1 11372TK

24B LegSupportBracket2 11425TK

25 LegWeldment 11371TK

26 5/16-18SpecialHexFlangeShoulderBolt NB743

27 AdditionalSupportWeldment 11615TK

28 Washer5/16SAE NB275

29 Nut5/16-18Nyloc NB181

30 5/16X1BallLokPin-RingGrip 11619

30A PlasticLanyard NB652

30B Bolt1/4-20X1/2MSCZP NB114

30C Nut1/4-20SerratedFlange NB524

31 Bolt3/8-16X11/2GR5 NB107

32 1/8X1/2#3WoodruffKey 024002

33 PumpPulley 7306

34 5/16-18X1/2SetScreww/Loctite NB312

35 37"Belt 11399

36 IdlerBushing 6037

37 IdlerArm 6041TK

38 IdlerSpacer 6040

39 IdlerPulley B527

40 Nut3/8-162-WayLock NB280

41 ClutchLever 11226TK

42 HandleGrip 2077

43 ClutchSpring 682S

44 Bolt3/8-16X5TurnedEye 11223

45 TensionStrap 11376TK

46 AxleWeldment 11370TK

47 Tire&Wheel F4157WF

48 Washer3/4IDX11/4OD10GA NB184

49 CotterPin1/8"X1" NB126

ITEMNUMBER DESCRIPTION PARTNUMBER

1 BeamW eldment 11468TK

2 WedgeW eldment 11910TK

3 WedgeGIBAngle 11857TK

4 Bolt3/8-16X11/4Carriage 10501

5 Nut3/8-16Nyloc NB182

6 Nut1/2-13NylocJam NB121

7 1/2-13X31/2GR5ZP NB577

8 RamCylinder 11242TK

9 2-W ayPipeNipple 7292

10 HydraulicFitting 7291

11 StationaryLineAssembly 7288TK

12 ValveInletFitting 7387

13 ValveControl 7287TK

14 ReturnLineFitting 7329

15 MasterChainLink 7424

16 ValveControlHandle 7423

17 HandleGrip 7425

18 1/4X1ClevisPin NB522

19 CotterPin NB597

20 CylinderRetentionPlate 11393TK

21 3/8"X13/8"HitchPin NB632

22 Bolt5/16-18X11/4HCCGR5 NB504

23 W asher5/16"SAE NB275

24 LatchPinBushing 7839Z

25 Washer17/32X11/4X16GA NB217

26 Nut5/16-18NylocNut NB181

BEAMDETAIL

PIVOTDETAIL

ITEM# DESCRIPTION PART#

1 BeamPivotWeldment 11469TK

2 Bolt3/4-10X2GR8 11431

3 WasherBelleville1.50ODX.761IDX.098X.134 AS155

4 Washer3/4SAE NB146

5 Nut3/4-10Nyloc NB609

6 Bolt1/2-13X4GR5 NB132

7 Nut1/2-13Nyloc NB281

8 1/2X31/2HITCHPINW/HAIRPIN NB648

9 3/8X15/8BallLokPin 11397

10 PlasticLanyard NB652

11 1/4-20X3/4SerratedFlangeBoltGR5 NB690

ENGINEDETAIL

ITEM# DESCRIPTION PART#

1 Engine N/A

2 Bolt5/16-18X21/4Serr.Flange NB622

3 Bolt5/16-18X11/4Serr.Flange NB253

4 Nut5/16-18Serr.Flange NB170

5 3/16X1Keystock 9030

6 5/16-18X1/2SetScreww/Loctite NB312

7 EnginePulley7/8"ID 7323

8 WasherBelleville 699

9 Bolt3/8-24X1w/Loctite NB238N

NOTSHOWN FuelShutOffValve(Inline) 7414

NOTSHOWN FuelLineClamp 6FLC

HydraulicHosesNotShownforClarity

NOTES

______________________________________________________________________

Models

LS722X

Splitting

Force

22Tons

Engine

7HPBriggsand

StrattonIntek

Splitting

Positions

Horizontal/Vertical

Cylinder

Size

4"X24"

Pump

2StagewithHeavy

DutyBearings

Pump

Specs

11GallonsPer

Minute

Valve

AutoReturn

Drive

System

BeltDrivewith

ClutchforEasy

Starting

Hydraulic

Fluid

Capacity

16-17Quarts

Maximum

Loglength

25"

TireSpecs

13.00X5.00

Metal

Fenders

BallHitch

Unit

Weight

410Lbs

SPECIFICATIONS

OWNER’S

MANUAL

MODELNO.

LS722X

HOWTOORDER

REPAIRPARTS:

LOGSPLITTER

EachLogSplitterhasitsownserialnumber.Eachenginehas

itsownserialnumber.TheserialnumberfortheLogSplitter

willbefoundontherighthandsideofthehydraulicoil

reservoir.Theserialnumberfortheenginewillbefoundon

thetopoftheblowerfanhousing.

AllLogSplitterpartslistedhereinmaybeordereddirectly

fromSwisherMower&MachineCo.Inc.,yournearest

Swisherdealer,orfromourwebsite.

Allenginepartsmaybeorderedfromthenearestdealerofthe

enginesuppliedwithyourlogsplitter

.

Partssubjecttochange

withoutnotice.

WHENORDERINGPARTS,PLEASEHAVETHE

FOLLOWINGINFORMATIONAVAILABLE:

*PRODUCT– SWISHERLOGSPLITTER

*SERIALNUMBER- _______________

*MODELNUMBER- _______________

*ENGINEMODELNUMBER- _______________

TYPE- _______________

*PARTNUMBER

*PARTDESCRIPTION

www.swisherinc.com

TELEPHONE- 1-800-222-8183

FAX- 1-660-747-8650

SWISHERMOWER&MACHINECO.INC.

1602CORPORATEDRIVE

WARRENSBURG,MO64093

SWISHERMOWER&MACHINECO.INC.

Swisher LS722X User manual

Related papers

Other documents