Burley Jogger Owner's manual

Brand: Burley

Model: Jogger

Category: Strollers

Type: Owner's manual

This manual is also suitable for

Jogger 2007

Burley Jogger 2007 is a durable and versatile stroller designed for jogging, strolling, and everyday use. With a weight capacity of up to 80 pounds and a spacious storage basket, it's perfect for carrying your child and all their essentials. The adjustable canopy and seat recline allow you to customize the stroller to your child's comfort, while the hand and foot brakes provide added safety and control. Whether you're running errands, exploring the neighborhood, or hitting the trails, the Burley Jogger 2007 is the perfect companion for your active family.

BURLEY

JOGGER

Owner’s Instruction and Safety Manual

Burley Jogger Limited Warranty

Burley will repair or replace parts it determines to be defective as follows: fabric parts for one year and durable

parts for ﬁve years. The owner of a Burley Jogger must present the Jogger for repair at an Authorized Burley Dealer,

together with an original sales receipt or similar proof of purchase. This warranty applies only to the original

owner and is nontransferable. Burley can not be responsible for failure due to improper assembly, modiﬁcation of

parts or instructions, neglect, abuse, accident, and/or normal wear. The warranty does not cover any Jogger used

for rental, competition, or commercial use.

Burley neither assumes nor authorizes any person to assume any other liability in connection with a Burley

product, and there are no oral agreements or warranties collateral to or affecting this agreement.

This warranty gives you speciﬁc legal rights and you may also have other rights which vary from state to state.

“Burley” is a registered trademark of Burley Design LLC

Burley Design, LLC

•

4020 Stewart Rd

•

Eugene, OR 97402

541.687.1644

•

Fax 541.687.0436

•

www.burley.com

170003 jogger manual r1 rev. 02/07

I. Assembly Instructions Pg. 3– 5

II. Location and Use of Brakes Pg. 5– 6

III. Canopy Adjustment and Cleaning Pg. 6

IV. Seat Adjustment and Cleaning Pg. 7

V. Seat Harness Securing and Adjustment Pg. 8

VI. Storage Pockets Location and Use Pg. 8

VII. Handle Adjustment Pg. 8

VIII. Cover and Folding Information Pg. 9

IX. Aligning the Jogger’s Tracking Pg. 9

X. Annual Maintenance Checklist Pg. 10

XI. Adjusting the Brakes Pg. 10

XII. Frequently Asked Questions Pg. 11

XIII. Speciﬁcations Pg. 11

XIV. Warranty Pg. 12

Congratulations!

You’ve just purchased a Burley

Jogger. Every effort has been made to

ensure your purchase is of top quality and proven design, ready to provide

you with many years and miles of happy, safe use.

Table of Contents

Because some of the features and guidelines for using the

Burley

Jogger merit close attention, it is very important that you familiarize

yourself with the Jogger by reading this entire manual before use. If you have

any questions, we encourage you to contact your Authorized Burley Dealer.

IMPORTANT:

Assembly

1. Turn the stroller over so that the foot plate is down.

2. Lift the stroller by the handle until it clicks.

3. Make sure the foot brake is in the unlocked, up, position.

4. Remove and discard the foam protectors on the wheel axles.

5. To put the rear wheels on, push the button on the wheel while pushing the

wheel axle into the stroller frame. Push wheels all the way in until they lock.

2 B U R L E Y J O G G E R O W N E R ’ S I N S T R U C T I O N A N D S A F E T Y M A N U A L

B U R L E Y J O G G E R O W N E R ’ S I N S T R U C T I O N A N D S A F E T Y M A N U A L 3

6. Tip the stroller back so it is resting on its handle and rear wheels to put the

front wheel on.

7. Remove the fork tip protectors.

8. Make sure the front brake release lever is pointed out, away from

the stroller.

9. Starting at the bottom of the brake pads, push the wheel up and in between

the brake pads.

10. Rotate the tire upwards. Find the ﬂat sides on the round axle and slide all

the way to the back of the forks, on BOTH SIDES.

11. Set the quick release lever so it is straight out. While holding the lever,

tighten the thumb nut until it is snug. The axle should not move side to

side. Close the lever. With proper closing resistance the lever will leave an

imprint in your palm. When closed the lever should be ﬂush with the fork.

12. Give the wheel a tug to make sure it is secure.

Make sure wheels are held

securely. You should not be

able to rock or shift wheels.

Improperly installed wheels

can fall off causing accident

and serious injury.

WARNING

13. Be sure to close the brake calipers by pushing the lever forward all the way.

Check to make sure the brake caliper is locked before each use.

IMPORTANT:

14. Make sure the seat straps, located on the bottom of the seat, are snapped

around the frame on both sides, by the basket.

Brakes

Your stroller comes with two parking brakes: a foot brake and a hand brake.

The hand brake, located on the handle, locks the front wheel. The foot brake is

located near the basket, on the rear axel. It locks the rear wheels.

You should always use both brakes when the stroller is not

being pushed.

IMPORTANT:

To lock the hand brake, pull the lever in and hold it while you push the button

down. As you hold the button, release the brake lever.

To release the hand brake, pull the lever in until the button pops up.

To lock the foot brake, simply push it down with your foot. Try to push the

stroller to make sure the brake is secure.

4 B U R L E Y J O G G E R O W N E R ’ S I N S T R U C T I O N A N D S A F E T Y M A N U A L

B U R L E Y J O G G E R O W N E R ’ S I N S T R U C T I O N A N D S A F E T Y M A N U A L 5

Pull the foot brake up with your foot to release it.

NEVER trust your brakes 100%. Always keep an eye on your

stroller. Always use your safety wrist strap any time a child is in the stroller.

WARNING:

Never leave your child unattended.

WARNING

Canopy

Your canopy has multiple adjustments. It also has a side ventilation system,

with ﬂaps that roll up and velcro into place. Use the canopy at its fully extended

postion during midday sun to provide your child with the most amount of shade.

When the canopy is not needed, pull it all the way back. To shade your child

during early morning or late evening sun, unsnap the strap at the back of the

canopy and pull it forward for best positioning. To view your child through the

top window, simply roll back the sun cover and velcro into place. To clean the

canopy window use a damp cloth. To remove the sun canopy completely, you

will need a Phillips screwdriver to remove the screws from both sides of the

canopy. Unsnap the canopy from the back and lift it out. Before washing the

canopy, remove the frame. The canopy may be washed in cold water with mild

detergent. Place the canopy back on the jogger to dry. When the canopy is wet,

extend it fully until completely dry to prevent any mildew from forming.

6 B U R L E Y J O G G E R O W N E R ’ S I N S T R U C T I O N A N D S A F E T Y M A N U A L

B U R L E Y J O G G E R O W N E R ’ S I N S T R U C T I O N A N D S A F E T Y M A N U A L 7

Seat

The amount of recline on the seat is adjusted by holding the buckle behind the

seat and pulling the strap to make the seat more upright.

To make the seat recline more, hold the strap and pull the buckle.

The seat is fully reclined by unbuckling the strap behind the seat.

The seat is removed by undoing the velcro and the straps from the foot plate

and the frame. The seat also needs to be unsnapped from the frame.

To wash the seat, take out the ﬁrmness panels by unzipping the pouch at the

top and underneath the seat.

The seat may be washed in cold water with mild detergent. Snap the seat back

on the frame to dry to prevent mildewing.

Do not use your jogger with the back ﬁrmness panels removed. Removing

the panels could cause suffocation.

WARNING

Foot brake

Buckles here adjust

amount of seat recline.

Seat Harness

1. Undo both buckles from the padded center strap.

2. Place the child in the seat.

3. Adjust the padded center strap forward or backward to ﬁt your child.

4. Adjust the padded shoulder seat harness up or down on the velcro strips to

ﬁt your child.

5. Connect the two buckles to the padded center strap.

6. Pull the adjustment strap until the padded center strap and the padded

shoulder seat harness are both snug.

Always use seat harness to avoid serious injury from falling or sliding out.

WARNING

Storage

Your jogger has many places to store your belongings. There is a pocket located

on the back of the seat, as well as pockets for keys or a cell phone on both sides.

There is a basket under the seat and there is a key leash and two water bottle

holders located on the back of the jogger.

Do not store more than 12 pounds between the pockets and basket.

Overloading the jogger may cause it to become unstable and tip over.

WARNING

Height Adjustable Handle

Your jogger is equipped with a height adjustable handle.

To adjust the handle, push the buttons on the inside of both handles.

While holding the buttons, rotate the handle to the desired height.

Folding

Pull the latches on both sides of the frame and push down on the handle until

the forks and handle meet.

Latch located on both sides of Jogger frame. Pull here.

If you would like the jogger to fold more compactly, simply take the wheels off.

Tracking

If your jogger is pulling to the left or right, check to see if it is one of the

following things:

Check to make sure the tire pressure in all the wheels is equal.

Correct tire pressure is printed on the side of the tires.

If that does not work and it continures to pull to the right, unscrew the front

wheel thumb nut and shift the wheel to the left. Tighten the wheel again and

push the jogger to see if it rolls straight. If it pulls to the left, shift the wheel to

the right.

These adjustments should be done in small increments.

Only a small amount of adjustment is necessary.

IMPORTANT:

8 B U R L E Y J O G G E R O W N E R ’ S I N S T R U C T I O N A N D S A F E T Y M A N U A L

B U R L E Y J O G G E R O W N E R ’ S I N S T R U C T I O N A N D S A F E T Y M A N U A L 9

Maintenance

We recommend that you have an experienced dealer perform these maintenance

checks once a year. Lubrication of the following items is necessary:

1. Pivot point and cable of hand brake

2. Hand brake cable by caliper lever

3. Front wheel axle

4. Quick release lever

5. Insert in frame for rear wheels

6. Wheel nub and ball bearings of rear wheel

7. Locking bars of folding mechanism

8. All pivot locations of shocks on both sides

Replace the brake pads when the grooves become worn away. Check to ensure

all bolts are tight and springs are secure for rear foot brake.

Check fabric seams and straps for fraying or tearing. Keep it out of the sun and

in a dry place when not in use to prevent fading and mildew. Check the frame

for loose rivets, cracks and wear. Check to make sure that all nuts and bolts are

tight on the frame.

To adjust the hand brake if it becomes loose, turn the barrel towards you, away

from the locking ring. Tighten the locking ring to make a gap no more than a

1/4” wide. If it is still too loose, adjust the barrel down by the brake calipers.

These adjustments should be done in small increments.

Only a small amount of adjustment is necessary.

IMPORTANT:

Frequently Asked Questions

When can I start using my jogger?

You should wait until your child is about 6-8 weeks old before using your jogger.

Limit your use to ﬂat, smooth terrain. Use neck support until your child has

adequate neck strength. As every child develops differently, you may want to

consult your pediatrician.

How much weight will my jogger hold?

The jogger is designed to carry one child up to 80 pounds. You may also put up

to 12 pounds in the lower storage area.

How safe is my jogger?

Very safe. It is equipped with safety features to protect your child including a

wrist strap, 5-point harness, and locking hand and foot brakes.

Is it safe to hang anything on my jogger?

Absolutely not. Never hang bags or other items from any part of your jogger. The

jogger could tip, which could cause injury to your child.

What if I am 6’4” and my wife is 5’2”?

The jogger’s handle can be set at any height between 35 1/2” and 43”.

Can I use a car seat with my jogger?

Items such as car seats or child carriers from other manufacturers may cause

your jogger to become unstable. We do not recommend this; it is not safe.

Can I roller blade with my jogger?

We do not recommend this; it is too easy to lose control and possibly harm

your child.

Reminders:

Always use your safety wrist strap any

time a child is in the jogger.

Never leave your child unattended.

Never overload the jogger. Overloading it

may cause the jogger to become unstable

and tip over.

Do not allow your child to stand in the

jogger. This may cause the jogger to tip

and cause injury to your child.

10 B U R L E Y J O G G E R O W N E R ’ S I N S T R U C T I O N A N D S A F E T Y M A N U A L

B U R L E Y J O G G E R O W N E R ’ S I N S T R U C T I O N A N D S A F E T Y M A N U A L 11

S P E C I F I C A T I O N S

weight (with wheels)

27 lbs. (12.2 kg)

length

60 in. (152 cm)

width (overall)

25.5 in. (65 cm)

maximum interior width

10 in. (25 cm)

inside height

20 in. (51 cm)

height (from ground)

38 in. (97 cm)

folded dimension, in

37 x 19.5 x 11

folded dimension, cm

94 x 50 x 28

capacity

75 lbs. (34 kg)

wheels

16 in. spoked alloy qr.

Burley Jogger Owner's manual

Brand: Burley

Model: Jogger

Category: Strollers

Type: Owner's manual

This manual is also suitable for

Jogger 2007

Download PDF

report

Burley Jogger Owner's manual

This manual is also suitable for

Burley Jogger Owner's manual

Related papers

Other documents