Page is loading ...
1
P e d e s t a l M o u n t e d E m e r g e n c y
E y e w a s h S t a t i o n
Installation, Use and Maintenance Instructions
2
Brief Introduction
"Pedestal Mounted Emergency Eyewash Station" only has an eyewash system
without a sprinkler, applies to the accident emergency rescue, attached to the human
body quickly cleaning the poisonous and harmful material, through the use of large
amounts of water quickly rush drench, cleaning, achieve emergency treatment, so as
to reduce the damage degree. Decontamination method is one of the most
economically feasible.
Before using this product, the user should carefully read this manual. This
product is used for emergency temporarily slow down harmful substances to the body,
is not a medical device, further processing treatment, please listen to the doctor.
Main Performance Parameters
Installation
1、Before installation, please reinspect product model, certification, operation
instruction, packing list.
2、The installation position should be away from the accident prone to 15 meters,
with running speed can within 10 seconds to wash.
3、Threaded joints need winding ribbons.
Mpa
L/min
Media
Ps
Pm
P
Wash eye
Normal temperature
water in line with
hygiene standards
1.0
0.6
0.20--0.40
≥11.4
3
Installation Instruction
1. Bottom
2. Pedal (Optional)
3. 1-1/4 drain
4. Shim
7. The eye wash basin
8. Fixing piece
9. Eyewash Spray Heads
11. Spool cap
12. Nut
14. Water pipe
15. Eyewash Switch
4
Note: the spool has been successfully debugged and cannot be loosened or tightened.
The initial angle of the plug cover should be adjusted to 45 degrees during installation.
Overall dimensions
5
Use Reminder
1、Use this product over at 0 degrees environment, if 0 degrees Celsius environment
used for pipeline anti-freezing maintenance.
2、Before installation, please in advance keep suction culvert be rinsed clean;
Method of Use
1、Open the upper flip cover directly, the eye wash nozzle immediately drains the
water; Close the upper flap and the eye wash will close immediately.
2、When the accident occurred, the victim should undertake choosing according to
degree of harmful substances to Continuous flushing, (recommended more than 15
minutes) during preparing emergency rescue measures.
Maintenance
The device should be performed more than once every week, to test the
reliability,validity, to ensure the emergency effective use when the accident happened
and reliable to provide personal safety and health protection.
Common troubleshooting
NO
Common fault
Occurence reason
Troubleshooting
1
Small water
A: Eye nozzle inlet filter is clogging
B: Check whether the water pressure
is up to standard
A: Unscrew the filter,
and clean
B: Solve the problem of
water pressure
2
Eye wash basin of
many water
Wash basin drain plug or
water pipe blockage
Clear the blockage
3
Eye wash nozzle is
still in the water
After turned off
A: The eyewash switch is not closed.
B: Eye-washing valve spool is
damaged
A: Re-debugging the
eyewash switch position
B: Replace the spool
6
*Service Contact Information*
Amazon seller: CGOLDENWALL
Messeger / WhatsApp: +8613758246804
Facebook : CGOLDENWALL
/
