JumpSport 550F User manual
- Type
- User manual
1
User’s Manual - Fitness Trampoline Half-Fold Models:
230F, 350F, and Pro Series 550F, 550Fi
Assembly, Installation, Care, Maintenance, and Use Instructions.
Read these materials prior to assembling and using this trampoline
1. Do not attempt to open/unfold or close/fold
frame without using The 2-Person Method (see
below).
2. DO NOT attempt or allow somersaults. Land-
ing on the head or neck can cause serious in-
jury, paralysis, or death even when landing in
the middle of the bed.
3. Do not allow more than one person on the
trampoline.
4. Use trampoline only with mature knowledgea-
ble supervision.
5. Exercise can present a health risk. Consult a
physician before beginning any exercise pro-
gram with this equipment.
6. If you feel faint or dizzy, immediately discon-
tinue use of this equipment.
7. Keep others and pets away from equipment
when in use.
8. Always make sure all parts are securely tight-
ened prior to each use.
9. This trampoline is not recommended for chil-
dren.
10. This product is intended for indoor use only.
Serious bodily injury or death can occur if the
above warnings are not followed or if this equip-
ment is not assembled and used according to all
instructions.
This Product is Distributed Exclusively by
Patent info at: www.jumpsport.com/patents
Instruction Manual P/N: INS-P-21808-01A
Copyright © 2003-2018, by JumpSport, Inc. All rights reserved.
JumpSport, Inc.
1680 Dell Ave. 1.408.886.6036
Campbell, CA 95008 U.S.A. www.JumpSportFitness.com
(Product shown: 550Fi)
Models 230F, 350F, 550F
handle sold separately
Max Weight Allowed:
Model 230F : 225lb (102kg)
Model 350F : 275lb (125kg)
Model 550F Pro : 325lb (147.7kg)
Model 550Fi Pro : 325lb (147.7kg)
All units designed for indoor use only.
Pro Series –Commercial use allowed.
WARNING
WARNING
Use trampoline only with mature, knowledgeable supervision.
Read these materials prior to assembling
and using this rebounder trampoline
DO NOT attempt or allow
somersaults. Landing on the
head or neck can cause
serious injury, paralysis or
death, even when landing in
the middle of the bed.
DO NOT allow more than one
person on the trampoline.
Use by more than one person
at the same time can result in
serious injury.
WARNING
2
Safety Instructions
Consult your physician before starting this or any exercise program. This is especially important if you are over the age
of 35, have never exercised before, are pregnant, or suffer from any health problem. To reduce the risk of serious injury,
read the following Safety Instructions before using the JumpSport Folding Trampoline.
1. Save these instructions and ensure that other exercisers read this manual prior to using the JumpSport Folding
Trampoline for the first time.
2. Misuse and abuse of this trampoline is dangerous and can cause serious injuries.
3. Trampolines, being rebounding devices, propel the performer to unaccustomed heights and into a variety of body
movements.
4. When unfolding or folding the trampoline, the rails will try to spring into the folded position.
5. Always use two strong people to unfold or fold the trampoline frame. Failure to use two strong people may
allow the frame rail to spring back and strike someone, which can cause serious bodily injury or death.
6. Unless designated, the JumpSport Folding Trampoline is for home use only. Do not use in institutional or commer-
cial applications. Failure to follow this warning could result in minor or moderate injury.
7. All purchasers and all persons using the JumpSport Folding Trampoline must become familiar with the manufactur-
er’s recommendations for proper assembly, use and care of the JumpSport Folding Trampoline, as well as being
alert to the performer’s own limitations in the execution of trampoline skills. Assembly Instructions, Safety Instruc-
tions, Trampoline Fundamentals, and Warning Labels are included to promote safe, enjoyable use of the JumpSport
Folding Trampoline. Make sure that it is properly assembled and tightened before use.
8. The owner and supervisors of the trampoline are responsible to make all users aware of the Safety Instructions and
practices in the use instructions.
9. Place the JumpSport Folding Trampoline on a level surface before use.
10. Use the JumpSport Folding Trampoline in a well lighted area. THIS PRODUCT IS INTENDED FOR INDOOR USE
ONLY.
11. Do not place the JumpSport Folding Trampoline on an elevated surface. The JumpSport Folding Trampoline should
be at floor level or ground level.
12. Inspect your JumpSport Folding Trampoline before each use.
13. Make sure the floor or ground around the JumpSport Folding Trampoline is clear of all objects that may cause injury
if you step on them when dismounting.
14. Do not allow children to use the JumpSport Folding Trampoline. The JumpSport Folding Trampoline is not a toy, it is
for use by adults only. Use the trampoline only with mature knowledgeable supervision.
15. Keep small children and pets away from the JumpSport Folding Trampoline at all times including use and assembly
of the JumpSport Folding Trampoline.
16. Do not use the JumpSport Folding Trampoline with socks only. Good traction is very important when mounting, us-
ing, and dismounting the JumpSport Folding Trampoline. Bare feet are acceptable but we recommend good foot-
wear with rubber non-skid soles such as walking, running or cross-training shoes.
17. Wear appropriate clothing when exercising; do not wear loose clothing that could become caught in the JumpSport
Folding Trampoline.
18. The JumpSport Folding Trampoline should be used by only one person at a time.
19. Remove any obstructions from beneath the JumpSport Folding Trampoline.
20. The surface of the bed should be dry.
21. Be careful to maintain your balance when mounting, using, dismounting, or assembling the JumpSport Folding
Trampoline. Loss of balance may result in a fall and serious bodily injury.
22. Do not attempt any gymnastic or acrobatic maneuvers on the JumpSport Folding Trampoline.
23. Stop exercising before attempting to dismount the JumpSport Folding Trampoline. To avoid sprains and broken
bones, come to a complete stop before dismounting.
24. Use the JumpSport Folding Trampoline only as described in this manual.
25. Always store the JumpSport Folding Trampoline indoors in a dry place.
26. Secure the JumpSport Folding Trampoline against unauthorized and unsupervised use.
WARNING
WARNING
3
ASSEMBLY INSTRUCTIONS
Place all parts from the box in a clear/clean area and position them on the floor in front of you.
Remove all packing materials from your area and place them back into the box. Do not dispose of
the packing materials until assembly is completed.
1. The JFT can suddenly snap closed/fold up -- serious injury can occur. Keep head/face away from
JFT until hinge locks are properly in place and closed. Keep fingers/hands away from the hinge
area when unfolding/opening or folding/closing the JFT, serious injury can occur. FOLLOW THE
RECOMMENDED METHOD FOR OPENING OR CLOSING SET FORTH BELOW. SEE ALSO
JUMPSPORT’S VIDEOS ON ITS WEBSITE FOR THESE STEPS AT:
www.jumpsport.com/fitness-install
2. Always use two strong people to unfold or fold the trampoline frame. Failure to use two
strong people may allow the frame rail to spring back and strike someone, which can
cause serious bodily injury or death.
3. Keep children away from the JumpSport Folding Trampoline during assembly.
Read this manual carefully before using the JumpSport Folding Trampoline.
Although JumpSport constructs its products with the finest materials and uses the highest standards
of manufacturing and quality control, there can sometimes be missing parts or incorrectly sized
parts. If you have any questions or problems with the parts included with your JumpSport Folding
Trampoline, please do not return the product. Contact us FIRST!
If a part is missing or defective, please go to www.JumpSportFitness.com
and order the part needed, or call us toll free at 1-888-567-5867 (in the US) or 1-408-866-6036.
WARNING
4
Opening and Closing the Frame — The Two Person Method
Step 1: Make sure both hinge wire locks are in the fully open/unlocked position (Figure 1) if
wire locks get pinched between the hinges, (see Figure 2), the frame can suddenly
snap closed, - serious injury can occur.
Step 2: One person should firmly grab the frame and hold it to the floor at all times during the
opening process, as shown below. Keep head clear of frame. The second person
firmly grabs the other half of frame, as shown, and pulls frame until it pops open.
Never relax grip on frame until it is fully open, or serious injury can
occur. Keep head/ face clear of opening frame, and hands/ finger clear of hinges
during the opening/ unfolding process.
Step 3: Flip both hinge wire locks to the fully closed/locked position.
Opening/Unfolding The Frame
Always use two strong people to unfold or fold the trampoline frame. Failure to use two
strong people may allow the frame rail to spring back and strike someone, which can cause
serious bodily injury or death.
Only open on a clean surface. Do not open/unfold on a plush carpeted surface. Carpet
strands may get pinched in the hinge during the opening process.
Locked
Position
WARNING
Person 1
Person 2
Person 1
Person 2
Figure 2
Figure 1
Correct
Pinch Point.
Keep hands away
from the hinges to
avoid getting
pinched.
WARNING
Unlocked Unsafe
WARNING
5
Step 1: Uninstall/remove all legs and place them to the side.
Step 2: When ready to close the frame, switch the hinge wire locks to the fully open/unlocked
position.
Step 3: One person should stand with both feet on one side of the frame as shown, so the
frame is pinned to the ground, with hands/arms outstretched to catch the frame as it
pivots. When both individuals are ready, the second person should strongly grip the
frame and then lift up to fold the frame as shown.
Never relax grip on frame until it is fully closed, or serious injury can
occur. Keep head/ face clear of closing frame, and hands/ finger clear of hinges
during the closing / folding process.
Closing/Folding The Frame
Opening and Closing the Frame — The Two Person Method
Fully Open/
unlocked
Person 2 Person 2
Always use two strong people to unfold or fold the trampoline frame. Failure to use two
strong people may allow the frame rail to spring back and strike someone, which can cause
serious bodily injury or death.
WARNING
WARNING
6
Straight leg with spring
SPR-A-20847-00
How to install folding legs found on the model 230f:
1) Pull a leg rotating up and away from the frame.
2) Align the leg with the frame stud, then gently guide it
into place over the socket until the leg rests against
frame.
3) The leg should now be secure in this new position. Re-
peat until you have unfolded all 6 legs. Make sure
each leg is seated tightly against the frame. Then turn
the trampoline over. Kneel on the ground, put your
hands on the center of the trampoline and shake it to
make sure it is stable. If the legs feel loose, tighten
them. If the trampoline rocks, rotate it until all legs sit
on the ground and it feels stable.
To fold the legs, follow the instructions in reverse order.
Note: If installing a handle, refer to handle instructions that
came with your handle kit.
Leg Installation (Model 230F)
Pinch Point.
Keep hands away
from the end of the
leg that contacts the
frame to avoid get-
ting pinched as it
pulls tight.
WARNING
7
IMPORTANT: Be sure leg caps are installed securely over bottom of legs, as shown above.
Notch in leg socket
Pin on stud
1) With trampoline upside-down, fit leg sockets over stud on trampoline
frame. Notch in leg socket lines up with pin on stud.
2) Securely tighten the leg to the frame by turning the Leg screw clock-
wise. The supplied 6mm Allen wrench can also be used by inserting
the short end of the wrench into the hole of the leg screw to tighten se-
curely. The legs should feel tight with no wobble.
3) When all legs are installed, turn your rebounder over. Kneel on the
ground, put your hands on the center of the trampoline and shake it to
make sure it is stable. If the legs feel loose, tighten them. If the tram-
poline rocks, rotate it until all legs sit on the ground and it feels stable.
The JumpSport Fitness Trampoline is now ready for use!
IMPORTANT: Bolts
may offer resistance
when tightening. No
threads of the bolt
should be exposed
when bolt is properly in-
stalled. Use leverage
with the provided 6mm
Allen wrench or use a
power drill with a suita-
ble 6mm bit (not sup-
plied) to ensure safe
and proper installation.
Leg socket
Leg cap
CAP-P-11678-02
Leg
LEG-A-20159-02
6mm Allen wrench
6mm Hex drill bit
(not shown)
Note: Keep Allen wrench to remove or re-tighten legs, as needed.
Leg screw
SCR-P-20456-01
Leg Installation (300 and 500 series)
Periodically check all leg screws and retighten if necessary. All
leg screws should be tight prior to using the fitness trampoline,
or serious injury can occur.
WARNING
550Fi series note: If you are going to install an exercise handle,
refer to next page for installation.
8
1) The 2 handle legs will be installed in place of the normal legs at the 2 locations shown above. Turn trampoline upside-down, fit leg
socket over stud on trampoline frame, and tighten bolts using a 6mm Allen wrench. Be sure that a hinge is between the side handles.
Do not use rebounder until the handle bar is fully in-
stalled or serious injury or death can occur.
Hinge must be between the handlebar assembly, or
serious injury can occur.
2) Connect side handles to top handle, and secure with small
thumb screws to create a “top assembly”.
3) Lower top assembly into handle legs. You may have to
rotate entire top assembly 180 degrees for holes to line up.
Adjust height as necessary, before securing with large thumb
screws.
Your exercise handle bar
is now installed!
To remove the handle, follow the installation
instructions in reverse order.
Large thumb screws
SCR-P-11707A
Top handle
HAN-A-20164-02
Right side handle
HAN-P-20169-00
Handle Leg
LEG-A-20324-02
Exercise Handle Bar Installation for Model 550Fi, only
WARNING
Avoid Serious Injury.
Exercise handle bar
(when attached to the
rebounder) is not de-
signed to support your
entire weight. It is to aid
with balance and pro-
vide exercise versatility.
WARNING
WARNING
Left side handle
HAN-P-20170-00
Small thumb screws
SCR-P-11706A
9
Inspect the JumpSport Folding Trampoline before each use and replace any worn, defective, or
missing parts. The following conditions could represent potential hazards:
1. Punctures, frays, tears, or holes in the bed or elastic bands.
2. Deterioration in the stitching or fabric of the bed.
3. Ruptured or damaged elastic bands.
4. A bent or broken frame.
5. A sagging bed.
6. Sharp protrusions on the frame or suspension system.
Care, Maintenance and Storage
Stacking: Use 2 people when stacking or unstacking units. Stack 8 units max, with feet down.
WARNING
10
Making Replacements and Adjustments
FlexBounce III
Configurations FlexBounce VII Configurations
Softer Soft Setting on all
FlexBounce connectors Soft Setting on all FlexBounce
connectors
Medium Setting on every
other connector Medium Setting on every other
connector
Soft / Medium / Medium Settings
(repeat pattern)
Medium Setting on every
connector Medium Setting on every
connector
Firm Setting on every other
connector
Medium / Firm / Firm Settings
(repeat pattern)
Firmer Firm Setting on every connector
If you wish to change the firmness of your
rebounder, turn it upside down. Pull cord
tighter to different knot, according to chart.
How to Adjust FlexBounce™ Cords
Soft Setting
(factory setting) Medium
Setting Firm
Setting
FlexBounce
connector
FlexBounce VII
shown here
Expected Cord Life
Elastic cords are wear items that need
to be replaced from time to time. Their
life expectancy is determined by:
The way the trampoline is being used
(jumping for height vs. controlled,
fitness-style bouncing vs. jogging)
The user weight and height
Frequency of bouncing
The type of cords used (standard or
extra-firm)
We are often asked how long your
cords will last. The answer is, it de-
pends. Some of our customers use a
set for 9 months, while most will use a
set for many years. Similar to running
shoes or car tires, the more you use
them and the harder you use them, the
faster they need to be replaced.
Replacing Endurolast Cords
Replace your elastic cords with genuine JumpSport® parts whenever there is visible damage or when the cords
feel too soft.
1) Remove existing cord. Take the new cord and first secure each knot into the respective openings, as shown
at location 1 in the diagram, below.
2) Pull the loop end out and over the frame, securing it in the top slot, U-shaped slot, shown at location 2 in
the diagram, below.
3) Be sure the end of the cord loop is centered in the U-shaped slot so the cord tension is equal on both sides
of the mat connector.
TIP: If you have an adjustable FlexBounce system (see photo and diagram on page 11) and the cords are not
visibly damaged, try a firmer tension setting to improve performance and extend the life of your cords.
1
2
(300 and 500 Series)
11
Limited Warranty
What is covered by this warranty? This warranty covers any defects in materials or workmanship on all of the compo-
nents of a new JumpSport Fitness Trampoline system, and is extended exclusively to the original retail purchaser.
How long does this coverage last? Warranty coverage for each component of a new JumpSport® Fitness Trampoline
begins from the original date of purchase and lasts as follows
What will JumpSport do? If you return the defective part to JumpSport, as instructed below, JumpSport will either repair
or replace such part, at JumpSport’s discretion, and return it to you.
What is not covered by this warranty? This warranty covers new products purchased as a complete system; it does not
cover replacement parts. This warranty also does not cover expenses of on-site labor, shipping costs, travel, assembly or disas-
sembly, or other charges associated with the repair or replacement of covered components. Further, this warranty does not cover
any problem that is caused by abuse, misuse, commercial or public use of 200 Series models, ordinary wear and tear, outdoor
use, weathering, acts of God (such as wind and lightning), failure to follow directions, improper installation, improper maintenance,
or any silk screened graphics. Rust is a natural occurrence with any steel product and is likewise not covered by this warranty, to
the extent that it does not affect the structural integrity of the part.
JUMPSPORT IS NOT RESPONSIBLE OR LIABLE FOR INDIRECT, SPECIAL, OR CONSEQUENTIAL DAMAGES ARISING
OUT OF OR IN CONNECTION WITH THE USE OR PERFORMANCE OF THE PRODUCT OR OTHER DAMAGES WITH RE-
SPECT TO ANY LOSS, INCLUDING BUT NOT LIMITED TO ECONOMIC LOSS, LOSS OF PROPERTY, LOSS OF REVENUE
OR PROFITS, LOSS OF ENJOYMENT OR USE, COST OF REMOVAL, INSTALLATION OR OTHER CONSEQUENTIAL DAM-
AGES. SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAG-
ES. ACCORDINGLY, THE ABOVE LIMITATION MAY NOT APPLY TO YOU.
THE WARRANTY EXTENDED HEREUNDER IS IN LIEU OF ALL OTHER WARRANTIES AND ANY IMPLIED WARRANTY OF
MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE IS LIMITED IN ITS SCOPE AND DURATION TO THE
TERMS SET FORTH HEREIN. SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY
LASTS. ACCORDINGLY, THE ABOVE LIMITATION MAY NOT APPLY TO YOU.
How to get a defective part replaced:
1) Call the JumpSport Customer Service department at 1-877-507-1399 to obtain a Return Authorization number. All returns must
be pre-authorized.
2) Send the part(s) to the designated Service Center, along with a copy of your original sales receipt and a brief written descript
tion of the problem, including how it occurred. You must pay freight and insurance to return the part to JumpSport. At Jump
Sport’s sole discretion, we may ask you to send photographs in addition to or in lieu of returning the part.
3) After inspecting the returned part(s), JumpSport will make a final determination whether the part is covered by this warranty.
We reserve the right to examine photographs or physical evidence concerning parts claimed to be defective prior to making a
final determination concerning the claim. A repaired or replacement part will be returned to you. (Shipping charges may apply.)
Please allow 3 to 4 weeks for delivery."
This warranty gives you specific legal rights. You may also have other rights which vary from state to state.
*Only the models in our 300 and 500 Series of Fitness Trampolines are approved for commercial use. When used
in a commercial setting, the commercial warranty applies.
Private Use Commercial Use
(Series 300/500 Only)
Steel Frame & Legs Lifetime 5 years
Series 200 Jumping Surface and EnduroLast Cords* 2 years* n/a
Series 300 Jumping Surface and EnduroLast Cords* 3 years* 12 months* (Except the 370)
Series 300 PRO Jumping Surface and EnduroLast Cords* 4 years* 18 months* (Plus the 370) / 1 year on Jumping
Surface
Series 500 PRO Jumping Surface and EnduroLast Cords* 5 years* 18 months* / 1 year on Jumping Surface
All other components (including hinges) 1 year 1 year
*Mat and cord warranty are limited to only one (1) usage replacement during applicable period.
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
JumpSport 550F User manual
- Type
- User manual
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
Other documents
-
Stamina inTONE Plus 35-1632 Owner's manual
-
-
Aqua Creek F-WXTPRD User manual
-
Aqua Creek F-WXTPHX User manual
-
Stamina Products INMOTION 35-1625DW User manual
-
Stamina Products 35-1650F User manual
-
-
Avari A350-001 Owner's manual
-
SereneLife SLSPT438 Owner's manual
-
