Sierra Wireless GL6110 User manual

WA_DEV_GL6100_PTS_001

002

May 24, 2010

AirLink GL Series

GL61x0 Product Technical

Specification and User Guide

WA_DEV_GL6100_PTS_001 Rev 002 May 24, 2010 2

GL61x0 Product Technical

Specification and User Guide

Important Notice

Due to the nature of wireless communications, transmission and reception of data can never be

guaranteed. Data may be delayed, corrupted (i.e., have errors) or be totally lost. Although significant

delays or losses of data are rare when wireless devices such as the Sierra Wireless modem are used

in a normal manner with a well-constructed network, the Sierra Wireless modem should not be used

in situations where failure to transmit or receive data could result in damage of any kind to the user or

any other party, including but not limited to personal injury, death, or loss of property. Sierra Wireless

accepts no responsibility for damages of any kind resulting from delays or errors in data transmitted or

received using the Sierra Wireless modem, or for failure of the Sierra Wireless modem to transmit or

receive such data.

Safety and Hazards

Do not operate the Sierra Wireless modem in areas where blasting is in progress, where explosive

atmospheres may be present, near medical equipment, near life support equipment, or any equipment

which may be susceptible to any form of radio interference. In such areas, the Sierra Wireless modem

MUST BE POWERED OFF. The Sierra Wireless modem can transmit signals that could interfere with

this equipment. Do not operate the Sierra Wireless modem in any aircraft, whether the aircraft is on

the ground or in flight. In aircraft, the Sierra Wireless modem MUST BE POWERED OFF. When

operating, the Sierra Wireless modem can transmit signals that could interfere with various onboard

systems.

Note: Some airlines may permit the use of cellular phones while the aircraft is on the ground and the door is

open. Sierra Wireless modems may be used at this time.

The driver or operator of any vehicle should not operate the Sierra Wireless modem while in control of

a vehicle. Doing so will detract from the driver or operator’s control and operation of that vehicle. In

some states and provinces, operating such communications devices while in control of a vehicle is an

offence.

Limitations of Liability

This manual is provided “as is”. Sierra Wireless makes no warranties of any kind, either expressed or

implied, including any implied warranties of merchantability, fitness for a particular purpose, or

noninfringement. The recipient of the manual shall endorse all risks arising from its use.

The information in this manual is subject to change without notice and does not represent a

commitment on the part of Sierra Wireless. SIERRA WIRELESS AND ITS AFFILIATES

SPECIFICALLY DISCLAIM LIABILITY FOR ANY AND ALL DIRECT, INDIRECT, SPECIAL,

GENERAL, INCIDENTAL, CONSEQUENTIAL, PUNITIVE OR EXEMPLARY DAMAGES INCLUDING,

BUT NOT LIMITED TO, LOSS OF PROFITS OR REVENUE OR ANTICIPATED PROFITS OR

REVENUE ARISING OUT OF THE USE OR INABILITY TO USE ANY SIERRA WIRELESS

PRODUCT, EVEN IF SIERRA WIRELESS AND/OR ITS AFFILIATES HAS BEEN ADVISED OF THE

POSSIBILITY OF SUCH DAMAGES OR THEY ARE FORESEEABLE OR FOR CLAIMS BY ANY

THIRD PARTY.

Notwithstanding the foregoing, in no event shall Sierra Wireless and/or its affiliates aggregate liability

arising under or in connection with the Sierra Wireless product, regardless of the number of events,

occurrences, or claims giving rise to liability, be in excess of the price paid by the purchaser for the

Sierra Wireless product.

WA_DEV_GL6100_PTS_001 Rev 002 May 24, 2010 3

GL61x0 Product Technical

Specification and User Guide

Patents

Portions of this product may be covered by some or all of the following US patents:

5,515,013

5,629,960

5,845,216

5,847,553

5,878,234

5,890,057

5,929,815

6,169,884

6,191,741

6,199,168

6,339,405

6,359,591

6,400,336

6,516,204

6,561,851

6,643,501

6,653,979

6,697,030

6,785,830

6,845,249

6,847,830

6,876,697

6,879,585

6,886,049

6,968,171

6,985,757

7,023,878

7,053,843

7,106,569

7,145,267

7,200,512

7,295,171

7,287,162

D442,170

D459,303

D599,256

D560,911

and other patents pending.

This product includes technology licensed from QUALCOMM

®

3G

Manufactured or sold by Sierra Wireless or its licensees under one or more patents licensed from

InterDigital Group.

Copyright

Trademarks

AirCard

®

and Watcher

®

are registered trademarks of Sierra Wireless. Sierra Wireless™, AirPrime™,

AirLink™, AirVantage™ and the Sierra Wireless logo are trademarks of Sierra Wireless.

, ,

®

, inSIM

®

, WAVECOM

®

, WISMO

®

, Wireless Microprocessor

®

,

Wireless CPU

®

, Open AT

®

are filed or registered trademarks of Sierra Wireless S.A. in France and/or

in other countries.

Windows

®

and Windows Vista

®

are registered trademarks of Microsoft Corporation.

Macintosh and Mac OS are registered trademarks of Apple Inc., registered in the U.S. and other

countries.

QUALCOMM

®

is a registered trademark of QUALCOMM Incorporated. Used under license.

Other trademarks are the property of the respective owners.

Contact Information

Sales Desk:

Phone:

1-604-232-1488

Hours:

8:00 AM to 5:00 PM Pacific Time

E-mail:

sales@sierrawireless.com

Post:

Sierra Wireless

13811 Wireless Way

Richmond, BC

Canada V6V 3A4

Fax:

1-604-231-1109

Web:

www.sierrawireless.com

Consult our website for up-to-date product descriptions, documentation, application notes, firmware

upgrades, troubleshooting tips, and press releases: www.sierrawireless.com

WA_DEV_GL6100_PTS_001 Rev 002 May 24, 2010 4

GL61x0 Product Technical

Specification and User Guide

Document History

Version

Date

Updates

001

March 15, 2010

Creation

002

May 24, 2010

Update power consumption values in sections 12.2 GL6100 Power

Consumption and 12.3 GL6110 Power Consumption.

Updated TBC items throughout the document.

Updated Appendix B: Product Labeling.

Updated Table 53: Operating Class Temperature Range.

Added section 13.4 Reliability Prediction Model.

Updated Figure 26 Serial Link Implementation for a 4-wire UART and Figure

27 Serial Link Implementation for a 2-wire UART.

Updated the description for entering Sleep Idle Mode and Serial Port Auto

Shut Down Feature.

Updated data feature from 14.400 bits/s to 14, 400 bits/s.

Updated document reference from Firmware 7.4a to Firmware 7.42.

Updated Table 62: Applicable Standards and Requirements for the GL61x0.

Removed document reference [9].

WA_DEV_GL6100_PTS_001 Rev 002 May 24, 2010 5

Contents

1. OVERVIEW......................................................................................................... 12

1.1. Variants ...................................................................................................................... 12

1.1.1. Ordering Information ............................................................................................ 12

1.1.2. Shipment Configuration........................................................................................ 12

1.2. Overall Dimensions ..................................................................................................... 13

1.3. GSM/GPRS Features ................................................................................................. 13

1.4. Connectors ................................................................................................................. 13

1.5. Interfaces ................................................................................................................... 14

1.6. Environmental Compliance ......................................................................................... 14

1.6.1. RoHS Compliance ............................................................................................... 14

1.6.2. Disposing of the Product ...................................................................................... 14

2. GL61X0 FEATURE SET ..................................................................................... 15

2.1. Supported Bands ........................................................................................................ 17

2.2. Protection ................................................................................................................... 17

2.2.1. Power Supply ...................................................................................................... 17

2.2.1.1. GL6100 – UART Version ......................................................................................... 17

2.2.1.2. GL6110 – USB Version............................................................................................ 17

2.2.2. Electrostatic Discharge ........................................................................................ 17

2.2.3. Main Serial Link and USB Connection .................................................................. 18

2.2.4. SIM Interfaces ..................................................................................................... 18

3. GL61X0 CABLES AND ACCESSORIES ........................................................... 19

3.1. Adaptive Cable (for the GL6100) ................................................................................. 19

3.1.1. 8-pin Micro-Fit Edge............................................................................................. 19

3.1.2. DB9 Edge ............................................................................................................ 20

3.1.3. 2-pin Micro-Fit Edge............................................................................................. 21

3.2. Standard DB9 Cable (for the GL6100) ........................................................................ 22

3.3. DC Cable (for the GL6100) ......................................................................................... 23

3.4. AC/DC Adaptor (for the GL6100) ................................................................................ 24

3.5. Micro-fit

®

USB Cable (for the GL6110) ........................................................................ 25

3.6. FME Antenna ............................................................................................................. 26

4. FUNCTIONAL SPECIFICATIONS ...................................................................... 27

4.1. Functional Architecture ............................................................................................... 27

4.1.1. GL6100 Functional Architecture ........................................................................... 27

4.1.2. GL6110 Functional Architecture ........................................................................... 28

4.2. RF Functionalities ....................................................................................................... 29

4.3. Operating System ....................................................................................................... 29

5. TECHNICAL SPECIFICATIONS ........................................................................ 30

5.1. Power Supply ............................................................................................................. 30

5.1.1. GL6100 – UART Version ..................................................................................... 30

WA_DEV_GL6100_PTS_001 Rev 002 May 24, 2010 6

GL61x0 Product Technical

Specification and User Guide

5.1.2. GL6110 – USB Version ........................................................................................ 30

5.2. Mechanical Specifications ........................................................................................... 31

5.2.1. Mechanical Drawing............................................................................................. 31

5.2.2. Mechanical Constraints ........................................................................................ 33

5.2.2.1. Micro-Fit Connector ................................................................................................. 33

5.2.2.2. FME Connector ....................................................................................................... 33

6. INTERFACES AND PERIPHERALS .................................................................. 34

6.1. Front Interface ............................................................................................................ 34

6.1.1. SIM Interface ....................................................................................................... 34

6.1.1.1. SIM Socket Pin Description ...................................................................................... 35

6.1.2. LED Status Indicator ............................................................................................ 36

6.2. Back Interface............................................................................................................. 37

6.2.1. 8-pin Micro-Fit Connector ..................................................................................... 37

6.2.1.1. Power Supply Connection ........................................................................................ 40

6.2.1.2. Setup Communications with the GL6100: Main Serial Link Connection (RS-232) ....... 40

6.2.1.3. Setup Communications with the GL6110: USB Connection ....................................... 44

6.2.2. RF Interface ......................................................................................................... 44

6.2.2.1. RF Performances .................................................................................................... 45

6.2.2.2. Antenna Specifications ............................................................................................ 45

7. USING THE GL61X0 .......................................................................................... 46

7.1. Getting Started ........................................................................................................... 46

7.1.1. Inserting the SIM Card ......................................................................................... 47

7.1.2. Extracting the SIM Card ....................................................................................... 48

7.2. Operational Status ...................................................................................................... 48

8. COMMUNICATING WITH THE GL61X0 ............................................................ 49

8.1. Communications Testing for the GL61x0..................................................................... 49

8.2. Verifying the Received Signal Strength ....................................................................... 50

8.3. Verifying the Network Registration .............................................................................. 50

8.4. Checking the Band Selection ...................................................................................... 51

8.5. Switching Bands ......................................................................................................... 51

8.6. Checking the PIN Code Status .................................................................................... 52

8.7. Main AT Commands for the GL6100 ........................................................................... 52

8.8. Echo Function............................................................................................................. 53

9. USING THE GL61X0 WITH EMBEDDED SIM ................................................... 54

9.1. Operation ................................................................................................................... 54

9.2. Switching Between Embedded SIM and an External SIM ............................................ 54

9.3. Software Configuration ............................................................................................... 55

10. GL61X0 MAINTENANCE ................................................................................... 56

10.1. Enabling/Disabling the Flash LED ............................................................................... 56

10.2. Resetting the GL61x0 ................................................................................................. 56

10.3. Operating System Upgrade Procedure ........................................................................ 56

11. TROUBLESHOOTING THE GL61X0 ................................................................. 57

WA_DEV_GL6100_PTS_001 Rev 002 May 24, 2010 7

GL61x0 Product Technical

Specification and User Guide

11.1. GL6100 – RS232 Version ........................................................................................... 57

11.1.1. No Communications with the GL6100 through the Serial Link ............................... 57

11.2. GL6110 – USB Version ............................................................................................... 58

11.2.1. No Communications with the GL6110 through the USB ........................................ 58

11.3. Receiving “ERROR” .................................................................................................... 58

11.4. Receiving “NO CARRRIER” ........................................................................................ 59

12. POWER CONSUMPTION .................................................................................. 61

12.1. Various Operating Modes ........................................................................................... 61

12.1.1. Entering Sleep Idle Mode (only available on GL6100) .......................................... 62

12.1.1.1. Using AT+W32K = 1 .............................................................................................. 62

12.1.1.2. Using AT+W32K = 1,0 ........................................................................................... 62

12.1.2. Entering Active/Sleep Mode ................................................................................. 62

12.2. GL6100 Power Consumption ...................................................................................... 63

12.2.1. Power Consumption without the Sierra Wireless Software Suite ........................... 63

12.3. GL6110 Power Consumption ...................................................................................... 65

12.3.1. Power Consumption without the Sierra Wireless Software Suite ........................... 65

12.4. Consumption Measurement Procedure ....................................................................... 66

12.4.1. Hardware Configuration ....................................................................................... 66

12.4.1.1. Equipment ............................................................................................................. 66

12.4.1.2. SIM Cards Used .................................................................................................... 67

12.4.2. Software Configuration ........................................................................................ 67

12.4.2.1. GL61x0 Configuration ............................................................................................ 67

12.4.2.2. Equipment Configuration........................................................................................ 68

13. RELIABILITY STANDARDS: COMPLIANCE AND RECOMMENDATIONS ..... 69

13.1. Reliability Compliance................................................................................................. 69

13.2. Applicable Standards Listing ....................................................................................... 69

13.3. Environmental Specifications ...................................................................................... 70

13.3.1. Function Status Classification .............................................................................. 71

13.4. Reliability Prediction Model ......................................................................................... 71

13.4.1. Life Stress Test .................................................................................................... 71

13.4.2. Environmental Resistance Stress Test ................................................................. 71

13.4.3. Corrosive Resistance Stress Test ........................................................................ 72

13.4.4. Thermal Resistance Cycle Stress Test ................................................................. 72

13.4.5. Mechanical Resistance Stress Tests .................................................................... 73

13.4.6. Handling Resistance Stress Tests ........................................................................ 74

14. RECOMMENDATIONS WHEN USING THE GL61X0 ON TRUCKS .................. 76

14.1. Recommended Power Supply Connection on Trucks .................................................. 76

14.2. Technical Constraints on Trucks ................................................................................. 77

15. CERTIFICATION COMPLIANCE AND RECOMMENDED STANDARDS ......... 78

15.1. Certification Compliance ............................................................................................. 78

15.2. Applicable Standards Listing ....................................................................................... 78

16. EMBEDDED PERIPHERALS ............................................................................. 80

16.1. I/O Connector ............................................................................................................. 80

WA_DEV_GL6100_PTS_001 Rev 002 May 24, 2010 8

GL61x0 Product Technical

Specification and User Guide

16.2. SIM Card Socket ........................................................................................................ 80

17. RECOMMENDED CONNECTORS ..................................................................... 81

17.1. GSM Antenna ............................................................................................................. 81

18. REFERENCE DOCUMENTS .............................................................................. 82

18.1. Sierra Wireless Software Documentation .................................................................... 82

18.2. Firmware Documentation ............................................................................................ 82

18.3. Other Related Documentation ..................................................................................... 83

18.4. General Reference Documentation ............................................................................. 83

19. LIST OF ABBREVIATIONS................................................................................ 84

20. APPENDIX A: PACKAGING .............................................................................. 87

20.1. GL6100 2-Cable Package (antenna not included) ....................................................... 87

20.2. GL6100 Complete Cable Package .............................................................................. 88

20.3. GL6110 Package ........................................................................................................ 90

21. APPENDIX B: PRODUCT LABELING ............................................................... 91

21.1. Model and MSN Label ................................................................................................ 91

21.2. IMEI and Approval Label ............................................................................................. 92

22. APPENDIX C: SAFETY RECOMMENDATIONS (FOR INFORMATION ONLY) 93

22.1. RF Safety ................................................................................................................... 93

22.1.1. General ............................................................................................................... 93

22.1.2. Exposure to RF Energy ........................................................................................ 93

22.1.3. Efficient Terminal Operation ................................................................................. 93

22.1.4. Antenna Care and Replacement .......................................................................... 93

22.2. General Safety............................................................................................................ 94

22.2.1. Driving ................................................................................................................. 94

22.2.2. Electronic Devices ............................................................................................... 94

22.2.3. Vehicle Electronic Equipment ............................................................................... 94

22.2.4. Medical Electronic Equipment .............................................................................. 94

22.2.5. Aircraft ................................................................................................................. 94

22.2.6. Children ............................................................................................................... 95

22.2.7. Blasting Areas ..................................................................................................... 95

22.2.8. Potentially Explosive Atmospheres....................................................................... 95

WA_DEV_GL6100_PTS_001 Rev 002 May 24, 2010 9

List of Figures

Figure 1. GL61x0 Plug & Play Modem ....................................................................................... 13

Figure 2. Adaptive Cable Fuse .................................................................................................. 17

Figure 3. Adaptive Cable for the GL6100 ................................................................................... 19

Figure 4. 8-pin Micro-Fit Edge of the Adaptive Cable ................................................................. 19

Figure 5. DB9 Edge of the Adaptation Cable .............................................................................. 20

Figure 6. 2-pin Micro-Fit Edge of the Adaptive Cable ................................................................. 21

Figure 7. Pin Assignment of the 2-pin Micro-Fit Edge ................................................................. 21

Figure 8. DB9 Cable .................................................................................................................. 22

Figure 9. Pin Assignment of the DB9 Cable ............................................................................... 22

Figure 10. DC Cable .................................................................................................................... 23

Figure 11. Pin Assignment of the DC Cable ................................................................................. 23

Figure 12. AC/DC Adaptor ........................................................................................................... 24

Figure 13. Micro-fit

®

USB Cable................................................................................................... 25

Figure 14. USB Connector on Micro-fit

®

USB Cable ..................................................................... 25

Figure 15. FME Antenna ............................................................................................................. 26

Figure 16. GL6100 Functional Architecture .................................................................................. 27

Figure 17. GL6110 Functional Architecture .................................................................................. 28

Figure 18. GL61x0 Mechanical Drawing ...................................................................................... 32

Figure 19. GL61x0 Front Interface ............................................................................................... 34

Figure 20. LED State During Reset and Initialization Time ........................................................... 36

Figure 21. GL61x0 Back Interface ............................................................................................... 37

Figure 22. 8-pin Micro-Fit Connector on Cable Side ..................................................................... 37

Figure 23. Pin Assignment of the 8-pin Micro-Fit Connector on GL61x0 ....................................... 38

Figure 24. RS-232 Serial Link Signals ......................................................................................... 40

Figure 25. Serial Link Implementation for a 5-wire UART ............................................................. 42

Figure 26. Serial Link Implementation for a 4-wire UART ............................................................. 42

Figure 27. Serial Link Implementation for a 2-wire UART ............................................................. 43

Figure 28. USB Signals on the USB Type A Connector................................................................ 44

Figure 29. Typical Hardware Configuration for Power Consumption Measurement ....................... 66

Figure 30. Recommended Power Supply Connection on Trucks .................................................. 76

Figure 31. Example of an Electrical Connection Which May Damage the GL61x0 ........................ 77

Figure 32. GL61x0 Model and MSN Label ................................................................................... 91

Figure 33. GL61x0 IMEI and Approval Label................................................................................ 92

WA_DEV_GL6100_PTS_001 Rev 002 May 24, 2010 10

List of Tables

Table 1: GL61x0 Variants with Corresponding PNMKT ............................................................. 12

Table 2: GL61x0 Shipment Configuration ................................................................................. 12

Table 3: GL61x0 Physical Dimensions...................................................................................... 13

Table 4: GL61x0 Feature Set ................................................................................................... 16

Table 5: 8-pin Micro-Fit Connector Pin Description ................................................................... 20

Table 6: DB9 Connector Pin Description ................................................................................... 20

Table 7: 2-pin Micro-Fit Connector Pin Description ................................................................... 21

Table 8: DC Cable Pin Description ........................................................................................... 23

Table 9: 8-pin Micro-Fit Connector Pin Assignment .................................................................. 25

Table 10: USB Pin Assignment .................................................................................................. 26

Table 11: FME Antenna Characteristics...................................................................................... 26

Table 12: Supported RF Frequencies ......................................................................................... 29

Table 13: Power Supply Electrical Characteristics ...................................................................... 30

Table 14: Effects of Power Supply Defect for the GL6100 ........................................................... 30

Table 15: Effects of Power Supply Defect for the GL6100 ........................................................... 31

Table 16: Micro-Fit Connector Mechanical Constraints ............................................................... 33

Table 17: FME RF Connector Mechanical Constraints ................................................................ 33

Table 18: SIM Interface Electrical Characteristics ....................................................................... 35

Table 19: SIM Interface Pin Description ...................................................................................... 35

Table 20: GL61x0 LED Status .................................................................................................... 36

Table 21: 8-pin Micro-Fit Connections ........................................................................................ 37

Table 22: 8-pin Micro-Fit Connector Pin Description for the GL61x0 ........................................... 39

Table 23: Power Supply Pin Description ..................................................................................... 40

Table 24: RS-232 Pin Description ............................................................................................... 40

Table 25: USB Pin Description on Micro-fit

®

Connector .............................................................. 44

Table 26: Main Receiver Parameters for the GL61x0 .................................................................. 45

Table 27: Main Transmitter Parameters for the GL61x0 .............................................................. 45

Table 28: GL61x0 Antenna Specifications .................................................................................. 45

Table 29: Basic AT Commands for the GL61x0 .......................................................................... 49

Table 30: <rssi> Value Description ............................................................................................. 50

Table 31: AT+CREG Main Reponses ......................................................................................... 50

Table 32: AT+WMBS Responses ............................................................................................... 51

Table 33: AT+WMBS Band Selection ......................................................................................... 51

Table 34: AT+CPIN Main Responses ......................................................................................... 52

Table 35: Main AT Commands used for the GL61x0 ................................................................... 52

Table 36: AT+CPIN Main Response ........................................................................................... 54

Table 37: AT+WHCNF SIM Selection ......................................................................................... 54

WA_DEV_GL6100_PTS_001 Rev 002 May 24, 2010 11

GL61x0 Product Technical

Specification and User Guide

Overview

Table 38: AT+WHCNF Main Responses..................................................................................... 55

Table 39: Requirement of X-modem Downloading for GL61x0 .................................................... 56

Table 40: No Communications with the GL6100 Through the Serial Link .................................... 57

Table 41: No Communications with the GL6110 Through the USB ............................................. 58

Table 42: Receiving a “NO CARRIER” Message ........................................................................ 59

Table 43: Extended Error Codes ................................................................................................ 60

Table 44: GL61x0 Operating Modes ........................................................................................... 61

Table 45: AT+WBHV Behavior Configuration.............................................................................. 62

Table 46: Power Consumption without the Sierra Wireless Software Suite (Serial Port Auto

Shutdown Mode Enabled); Typical Values ....................................................................................... 63

Table 47: Power Consumption without the Sierra Wireless Software Suite (Serial Port Auto

Shutdown Mode Disabled); Typical Values ...................................................................................... 64

Table 48: Power Consumption without the Sierra Wireless Software Suite; Typical Values ......... 65

Table 49: List of Recommended Equipments .............................................................................. 67

Table 50: Operating Mode Information ....................................................................................... 68

Table 51: Standards Conformity for the GL61x0 ......................................................................... 69

Table 52: Applicable Standards and Requirements for the GL61x0 ............................................. 69

Table 53: Operating Class Temperature Range .......................................................................... 70

Table 54: ISO Failure Mode Severity Classification..................................................................... 71

Table 55: Life Stress Test ........................................................................................................... 71

Table 56: Environmental Resistance Stress Test ........................................................................ 72

Table 57: Corrosive Resistance Stress Test ............................................................................... 72

Table 58: Thermal Resistance Cycle Stress Test ........................................................................ 72

Table 59: Mechanical Resistance Stress Tests ........................................................................... 73

Table 60: Handling Resistance Stress Tests ............................................................................... 74

Table 61: Standards Conformity for the GL61x0 ......................................................................... 78

Table 62: Applicable Standards and Requirements for the GL61x0 ............................................. 78

Table 63: 8-pin Micro-Fit Connector............................................................................................ 80

Table 64: Recommended SIM Card Socket ................................................................................ 80

WA_DEV_GL6100_PTS_001 Rev 002 May 24, 2010 12

1. Overview

The GL61x0 is a wireless modem that allows users to connect to a wireless network. It offers quad

band 850/900/1800/1900 MHz GPRS Class 10 capabilities and it supports the Sierra Wireless

Software Suite. The Sierra Wireless Software Suite is the world’s most comprehensive cellular

development environment, which allows embedded standard ANSI C applications to be natively

executed directly on the Embedded Module. For more information about the Sierra Wireless Software

Suite, refer to the documents listed in section 18.1 Sierra Wireless Software Documentation.

Note: This document does not cover the programmable capabilities available through the Sierra Wireless

Software Suite.

1.1. Variants

The GL61x0 comes in two variants:

 the GL6100 which has an RS-232 connection, and

 the GL6110 which has a USB connection.

Both GL61x0 variants may be used with either an external SIM or Embedded SIM.

1.1.1. Ordering Information

Refer to the following table for the product number marketing (PNMKT) of the GL61x0 series.

Table 1: GL61x0 Variants with Corresponding PNMKT

GL61x0 Variant

Description

PNMKT

GL6100

GL6100 – RS232 Version

GL6100

GL6100 Embedded SIM

GL6100 – RS232 Version with Embedded SIM

GL6100SM3

GL6110

GL6110 – USB Version

GL6110

GL6110 Embedded SIM

GL6110 – USB Version with Embedded SIM

GL6110SM3

1.1.2. Shipment Configuration

The GL61x0 comes in three shipment configurations. Refer to the following table for the inclusions in

each shipment package.

Table 2: GL61x0 Shipment Configuration

Shipment Configuration

Notes

GL6100 + Adaptive Cable + DC Cable

Refer to section 20.1 GL6100 2-Cable Package

(antenna not included) for more information.

GL6100 + Adaptive Cable + DB9 Cable + AC/DC

Adaptor + FME Antenna

Refer to section 20.2 GL6100 Complete Cable

Package for more information.

GL6110 + USB Cable + FME Antenna

Refer to section 20.3 GL6110 Package for more

information.

WA_DEV_GL6100_PTS_001 Rev 002 May 24, 2010 13

GL61x0 Product Technical

Specification and User Guide

Overview

1.2. Overall Dimensions

Figure 1. GL61x0 Plug & Play Modem

The following table lists the GL61x0’s physical characteristics.

Table 3: GL61x0 Physical Dimensions

Length

67mm

Width

51.5mm

Thickness

23.5mm

Weight

~60 g (GL61x0 only)

Volume

81.78 cm

3

Housing

Plastic

1.3. GSM/GPRS Features

 2 Watts EGSM 900/GSM 850 radio section running with 4.75 ~ 32 Volts DC input for the

GL6100; and USB Power, 5 Volts DC input for the GL6110

 1 Watt GSM1800/1900 radio section running with 4.75 ~ 32 Volts DC input for the GL6100;

and USB Power , 5 Volts DC input for the GL6110

 Hardware GPRS class 10 capable

1.4. Connectors

 One 8-pin Micro-Fit Connector

 RF Connector (FME type)

WA_DEV_GL6100_PTS_001 Rev 002 May 24, 2010 14

GL61x0 Product Technical

Specification and User Guide

Overview

1.5. Interfaces

GL6100 – UART Version

GL6110 – USB Version

Power Supply (4.75V to 32V DC input)

Power Supply (USB Power, 5V DC input)

Serial Link (RS-232)

USB connection

3V/1V8 SIM Interface

LED Status Indicator

Antenna Interface

1.6. Environmental Compliance

1.6.1. RoHS Compliance

The GL61x0 is compliant with RoHS Directive 2002/95/EC which sets limits for the

use of certain restricted hazardous substances. This directive states that “from 1st

July 2006, new electrical and electronic equipment put on the market does not

contain lead, mercury, cadmium, hexavalent chromium, polybrominated biphenyls

(PBB) or polybrominated diphenyl ethers (PBDE)”.

1.6.2. Disposing of the Product

This electronic product is subject to the EU Directive 2002/96/EC for Waste Electrical

and Electronic Equipment (WEEE). As such, this product must not be disposed off at

a municipal waste collection point. Please refer to local regulations for directions on

how to dispose of this product in an environmental friendly manner.

WA_DEV_GL6100_PTS_001 Rev 002 May 24, 2010 15

2. GL61x0 Feature Set

This section enumerates the feature set available on the GL61x0.

WA_DEV_GL6100_PTS_001 Rev 002 May 24, 2010 16

GL61x0 Product Technical

Specification and User Guide

GL61x0 Feature Set

Table 4: GL61x0 Feature Set

Features

Description

Sierra Wireless

Software Suite

Sierra Wireless Software Suite programmable:

 Native execution of embedded standard ANSI C applications

 Custom AT command creation

 Custom application library creation

 Standalone operation

Standard

 850 MHz / 900 MHz

 E-GSM compliant

 Output power: class 4 (2W)

 Fully compliant with ETSI

GSM phase 2 + small MS

 1800 MHz / 1900 MHz

 Output power: class 1 (1W)

 Fully compliant with ETSI

GSM phase 2 + small MS

GPRS

 Class 10

 PBCCH support

 Coding schemes: CS1 to CS4

 Compliant with SMG31bis

 Embedded TCP/IP stack

Interfaces

 RS-232 (V.24/V.28) Serial interface for GL6100 supporting:

 Baud rate (bits/s): 300, 600, 1200, 2400, 4800, 9600, 19200,

38400, 57600, 115200, 230400, 460800 and 921600

 Autobauding (bits/s): from 1200 to 921600

 USB 2.0 interface, Full speed, 12Mbit/s for GL6110

 1.8V/3V SIM interface

 AT command set based on V.25 ter and GSM 07.05 & 07.07

 Interface for embedded application

 Plug-In compatible

SMS

 Text & PDU

 Point to point (MT/MO)

 Cell broadcast

Data

 Data circuit asynchronous

 Transparent and Non Transparent modes

 Up to 14, 400 bits/s

 MNP Class 2 error correction

 V42.bis data compression

GSM Supplement

Services

 Call forwarding

 Call barring

 Multiparty

 Call waiting and call hold

 Calling line identity

 Advice of charge

 USSD

Others

 DC power supply

 Real Time Clock with calendar

WA_DEV_GL6100_PTS_001 Rev 002 May 24, 2010 17

GL61x0 Product Technical

Specification and User Guide

GL61x0 Feature Set

2.1. Supported Bands

The GL61x0 supports either EU bands (EGSM900/DCS1800) or US bands (GSM850/PCS1900).

Users may switch from one supported band to another using AT commands.

Refer to sections 8.4 Checking the Band Selection and 8.5 Switching Bands for more information

regarding switching bands.

2.2. Protection

2.2.1. Power Supply

2.2.1.1. GL6100 – UART Version

The GL6100 is protected against voltage over +32V. When the input voltage (Vin) exceeds the limit,

the supply voltage is disconnected to protect the internal electronic components from overvoltage.

Note: An 800mA/250V fuse is directly bonded on the Adaptive cable of GL6100. The fuse model is FSD

800mA/250V FAST-ACTING.

Figure 2. Adaptive Cable Fuse

2.2.1.2. GL6110 – USB Version

The GL6110 is protected against voltage over +5V. When the input voltage (Vin) exceeds the limit,

the supply voltage is disconnected to protect the internal electronic components from overvoltage.

2.2.2. Electrostatic Discharge

The GL61x0 withstands ESD according to IEC 1000-4-2 requirements for all accessible parts, except

for the RF connector which withstands ESD as follows:

 +/- 8kV of air discharge

 +/- 4kV of contact discharge

WA_DEV_GL6100_PTS_001 Rev 002 May 24, 2010 18

GL61x0 Product Technical

Specification and User Guide

GL61x0 Feature Set

2.2.3. Main Serial Link and USB Connection

Both GL6100 and GL6110 are internally protected against electrostatic surges on its lines by ESD

protection and it also has the following filtering guarantees:

 EMI/RFI protection on both input and output

 Signal smoothing

2.2.4. SIM Interfaces

The GL61x0’s SIM interface is ESD protected. Transient Voltage Suppressor (TVS) diodes are

internally added on the signals connected to the SIM interface in order to prevent any damage from

electrostatic discharge.

WA_DEV_GL6100_PTS_001 Rev 002 May 24, 2010 19

3. GL61x0 Cables and Accessories

3.1. Adaptive Cable (for the GL6100)

The adaptive cable provides the serial interface and is used as the power source of the GL6100. It

has three edges/plugs.

Figure 3. Adaptive Cable for the GL6100

3.1.1. 8-pin Micro-Fit Edge

Figure 4. 8-pin Micro-Fit Edge of the Adaptive Cable

Refer to the following table for the pin description of the 8-pin Micro-Fit Edge of the Adaptive cable.

8-pin Micro-Fit Edge

DB9 Edge

2-pin Micro-Fit Edge

1

2

3

4

5

7

8

6

WA_DEV_GL6100_PTS_001 Rev 002 May 24, 2010 20

GL61x0 Product Technical

Specification and User Guide

GL61x0 Cables and Accessories

Table 5: 8-pin Micro-Fit Connector Pin Description

Pin Number

Signal

Description

1

RS232-CTS

Main RS232 Clear To Send

2

RS232- RTS

Main RS232 Request To Send

3

RS232-RXD

Main RS232 Receive Serial Data

4

RS232-TXD

Main RS232 Transmit Serial Data

5

RS232-DTR

Main RS232 Data Terminal Ready

6

GND

Ground Connection

7

Vin

Power Supply with a 4.75 ~ 32V DC input

8

Adaptive Cable

Detect

Detection of the Adaptive Cable

Refer to Table 22: 8-pin Micro-Fit Connector Pin Description for more information about the pin

assignments and description.

3.1.2. DB9 Edge

Figure 5. DB9 Edge of the Adaptation Cable

Refer to the following table for the pin description of the DB9 Edge of the Adaptation Cable.

Table 6: DB9 Connector Pin Description

Pin Number

Signal

Description

1

Not Connected

2

RS232 – RXD

Output Data to DTE

3

RS232 – TXD

Input Date from DTE

4

RS232 – DTR

Input Signal from DTE

5

GND

Ground Connection

6

Not Connected

7

RS232 – RTS

Flow Control Signal from DTE

8

RS232 – CTS

Flow Control Signal to DTE

9

Not Connected

1

2

4

3

5

6

8

9

7

Page is loading ...

Sierra Wireless GL6110 User manual

This manual is also suitable for

Sierra Wireless GL6110 User manual

Related papers

Other documents