COMPANION COMP200 Owner's manual

Brand: COMPANION

Model: COMP200

Type: Owner's manual

Part No. COMP200

AGA Logo created from high res .jpeg supplied by AGA

CERT: 4411

2 BURNER DELUXE LP Gas Stove

Instruction Manual

IMPORTANT

Read these instructions for use

carefully. Familiarise yourself with

the appliance before connecting

it to its gas container. Keep these

instructions for future reference.

www.companionleisure.com.au

GENERAL WARNINGS

• Thisapplianceshallonlybeconnectedtocylinderwith

a3/8”LHBSPgascylindervalvecertiedtoAS2469

standards.Thisapplianceisdesignedforoutdooruse

onlyandmustbeoperatedawayfromanyammable

materialorsurfacesandmaterials.

• Useonlywithpropanefuel.

• Thisapplianceistobestoredinadryandwellventilated

locationfreefromdirectsunlight.Donotstorewhenstill

connectedtothecylinder.Makesurethatthecylinderis

disconnectedandisstoredinawellventilatedarea,free

fromdirectsunlight,heatandignitionsources.Ifbeing

storedindoors,ensurethatthelocationcomplieswith

thestandardAS/NZS1596.

• Donotusethisapplianceifithaswornordamagedseals.

• Thisappliancemustonlybeservicedbyanauthorised

serviceagent,returntoyourplaceofpurchasefor

serviceandrepair.

DANGER!

• Duringoperationallsurfaceswillbeextremelyhotand

shouldnotbetouchedorhandled.

• Donotusetheapplianceifithasaleak,worn,

deterioratedordamagedseals.

• Handlewithcareevenafterbriefuse,alwayspickup

usingthehandlenotthecylinder.

• Itmaybehazardoustoattempttotothertypesofgas

containersorcartridges.

• Useonlyinwellventilatedareas.

• Alwaysoperateapplianceaminimumof800mmfrom

ammablematerials,wallsandceiling.

• Donotuseadaptorsormodifyappliancetotother

connectorsorcylinders.

• Donotusemultipleappliancestoheatasingleutensil.

• Childrenmustbesupervisedbyanadultatalltimes.

• Neverleaveapplianceunattendedwhenoperating.

• Useasacookingapplianceonly,isnottobeusedas

heaterormodifyforanyotherreason.

• Avoidboiloverandspillsontoburners.

CARBON MONOXIDE HAZARD

• Thisapplianceproducescarbonmonoxidewhichhas

noodour.Usingtheapplianceinenclosedspaces,for

example;caravan,car,boatormobilehomecould

cause DEATH.

IMPORTANT

• Keepawayfromchildrenatalltimes.

• Surfacesoftheappliancewillbecomehotduring

operationpleasetakecarewhenhandlingormoving

theappliance.

• Applianceistobeusedonastable,level,atnon-

ammablesurface,theapplianceshouldbeprotected

fromdirectdraftsandinawellventilatedplace.

• Onlycookingvesselswithamaximumdiameterof

220mmaretobeusedwiththisappliance.

• Takecarethattheprimaryairintakes,locatedonthe

burnertubeofthisappliancearenotobstructed,orthat

airowisrestrictedbyplacingitemsorotherappliances

closetooradjacenttotheinlets.

• Ifyousmellgasimmediatelyturnthegasoffatthe

cylinderandmovetheapplianceandcylindertoawell

ventilatedareaoutside,keepingwellawayfromsources

ofheatsuchasnakedamesandpilotlights.

• Donotattempttomoveorrelocatetheappliancewhen

itisoperating,extinguishtheburnerandallowtocool,

disengagethegascylinderthenmovetheappliance.

CHECKING FOR GAS LEAKS

• Checkthatallconnectionsaretightandthatthegas

cylinderconnectionhasbeentightenedbeforeyouturn

thecylindergasvalveon.

• NEVERcheckforleakswithaameorpilotlight.

• Usingsoapywatercoatallconnections,ifbubbles

appearturnthecylindergascontroloffandretightenthe

connectionbeforere-testing.

• Inspecttheapplianceregularlyforsignsofwear,leaks

orincorrectoperation.Ifsymptomssuchasaringof

theburners,issueswithlighting,damagestohoses

orconnectionsorleaksfromsealsorgascontrols

areidentieddonotattempttorepair,returntoyour

authorisedstockistforserviceandmaintenance.

• Tocheckifgasremainsinthecylinder,disconnectfrom

theapplianceandholdthecylinderinaverticalposition

thenshakefromsidetoside,ifthereisasoundorfeelof

liquidmovementinsidethecylindercontainsgas.

• Whenchanginggascylindersensurethisisconducted

outsideinawellventilatedlocationfreefrompeople,

animalsandignitionsourcessuchasnakedames,pilot

lightsandelectricalequipmentwithheatersorelements.

1.CONNECTION

Yourstoveisdesignedtoconnectdirectlyontoa3/8”LH

BSPcampinggascylinderusingthespeciallydesignedLP

Gashosesuppliedwiththeappliance.

1.Checkthatthe

gas controls

areinthe“Off”position

(turnedfullyclockwise).

2.Takethestoveconnector

headofthehoseand

attachtothegasinlet

ontheappliance,

tightenupusingngers.

3.Attachtheotherend

ofthehosetothegas

cylinder,tightening

usingaspanner.

4.Turnthecylindergas

valveoninananti-

clockwisedirection

foronefullturn

andthencheckthe

connectionsforleaks

withsoapywater,ifa

leakisdetectedturn

thecylindergasvalve

“Off”andretightenall

connectionsthenretest.

OPERATING THE APPLIANCE

1. Gas control

2. Burners

3.Cylinder

connection

4. Stove

connection

5.Hose

6.Windshield

7.Driptray

8. Trivet

2.LIGHTING BURNER

1. Checkthatthegas

controlisshutoff,then

turnthegascylinder

valveoninananti-

clockwisedirection

foronefullturn.

2. Takealitmatchor

lighterandposition

closetotheedgeof

theburnerthatisto

beignited,slowly

turnthegascontrol

inananti-clockwise

directionapproximately

¼ofaturn.

3. Iftheburnerdoes

notignite,turnthe

gascontrolinthe

clockwisedirection

tothe“Off”positionandallowthe

residualgastodispersebefore

attemptingtoreignitetheburner.

3.ADJUSTING FLAME

1. Turnthegascontrol

inananti-clockwise

directiontoachieve

ahigherameandin

theclockwisedirection

foralowerame.

4. TURNING THE APPLIANCE OFF

Iftheapplianceisnolongertobeusedandtoreducethe

riskofblockedgasjetscausedbyexcessgasbeingleftin

thehose,allremaining

gasmustbeexpelled

fromthehoseassembly.

1. Withtheamestill

operating,turn

thevalveonthe

gascylinderinthe

clockwisedirection

untilitis“Off”.Allow

theametoburn

downthenextinguish

onceallremaining

gasinthehosehas

beenused.

2. Turnthegascontrols

ontheappliance

clockwisetothe

“Off”position.

CARE INSTRUCTIONS

Yourapplianceismanufacturedwithahardwearingpowder

coatednishonthecabinet,chromeplatedburners,trivet

andstainlesssteeldriptray(iftted)andiseasytoclean.

Usingwarmsoapywaterwithamilddetergentwipedown

allsurfacesandareasoftheappliance,takingcarenot

toallowwatertoentertheburneroutletsoraerationholes

locatedintheburnertube.

DO NOTsubmergetheapplianceinasinkorbowl.

DO NOTuseabrasivecleanersorbleach.

SAFETY INSTRUCTIONS

Thisappliancemustonlybeusedinanabovegroundopenair

situationwithnaturalventilation,withoutstagnantareas,wheregas

leakageisrapidlydispersedbywindandnaturalconvection.

Anyenclosureinwhichtheapplianceisusedshouldcomplywithone

ofthefollowing:

(A)Anenclosurewithwallsonallsides,butwithnooverheadcover.

(B)Withinapartialenclosurethatincludesanoverheadcoverandno

morethantwowalls.

(C)Withinapartialenclosurethatincludesanoverheadcoverand

morethantwowalls,thefollowingmustapply:

(1)Atleast25%ofthetotalwallareaiscompletelyopen.

(2)30%ormoreintotaloftheremainingwallside,backandfront

wallareasisopenandunrestricted.

(3)Inthecaseofbalconies,20%ormoreofthetotalwallareamust

remainopenandunrestricted.

Code

COMP200

Description

2BurnerDeluxeLPGasStove

Size

464x289x82mm

Weight

4.3kg

Gas Jet

MediumBurner: 0.15mm

Large Burner: 0.18mm

Consumption

Inlet Pressure: CylinderPressure

MediumBurner: 136g/hr

6.8Mj/hr

Large Burner: 180g/hr

9.1Mj/hr

Aselectionofsparepartsand

componentsareavailableforyour

appliancetoensureyearsofoperation.

Spare Part List

1 PCS7034

Trivet

2 PCS7089

Driptray

3 PCS6023

Burner

4 PCS5023

Gasjetburner

5 PCS8951

“O”ringforspindle

6 PCS8950

Spindle

7 PCS8952

Locknut

8 PCS8949

Controlknob

9 PCS8414

“O”ringforgasconnector

10 HP1200F

1200mmgashose

Distributed by

PRIMUS AUSTRALIA Pty Ltd

Bundoora Victoria 3083

www.primusaustralia.com.au

WARRANTY

This appliance is covered

against faulty workmanship

and materials for a period of

12 months from the date of

original purchase.

The following items are not

covered by warranty:

• Blockedjetnipples

Each of these items are a

serviceable part and are

readily available from your

specialist outdoor retailer.

TECHNICAL DETAILS AND SPARE PARTS

COMPANION COMP200 Owner's manual

COMPANION COMP200 Owner's manual

COMPANION COMP200 Owner's manual

Related papers

Other documents