SAFETY DATA SHEET
DATE : 2016/08/30
Testing Period : 2016/08/30 TO 2016/09/07
1
、
IDENTIFICATION OF THE SUBSTANCE
PRODUCT NAME: BLACK FUSED ALUMINIUM OXIDE
CHEMICAL FORMULA: Al2O3
2
、
COMPOSITION/INFORMATION ON INGREDIENTS
SYNONYMS: FUSED ALUMINA
COMPONENT FORMULA TYPICAL
ALUMINUM OXIDE Al2O3 76.50%
TITANIUM OXIDE TiO2 1.55%
SILICON OXIDE SiO2 8.5%
IRON OXIDE Fe2O3 7.5%
3
、
HAZARDS IDENTIFICATION
HAZARD RATINGS: ( 0-NO HAZARD; 4-EXTREME HAZARD):
HEALTH -- 1 SLIGHT
FLAMMABILITY -- 0 NONE
REACTIVITY -- 0 NONE
CONTACT -- 1 SLIGHT
EFFECTS OF OVEREXPOSURE
DUST INHALATION MAY CAUSE TIGHTNESS AND PAIN IN CHEST,COUGHING,AND DIFFICULTY IN BREATHING.
EXCESSIVE INHALATION OF DUST MAY BE DAMAGING TO RESPIRATORY PASSAGES AND/OR LUNGS.
CONTACT WITH SKIN OR EYES MAY CAUSE IRRITATION.
4
、
FIRST AID MEASURES
INGESTION: IF SWALLOWD AND THE PERSON IS CONSCIOUS,IMMEDIATELY GIVE LARGE AMOUNTS
OF WATER. GET MEDICAL ATTENTION.
INHALATION: IF A PERSON BREATHES IN LARGE AMOUNTS,MOVE THE EXPOSED PERSON TO FRESH
AIR,GET MEDICAL ATTENTION.
EYE CONTACT: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.GET
MEDICAL ATTENTION.
SKIN CONTACT: IMMEDIATELY WASH WITH PLENTY OF SOAP AND WATER FOR AT LEASE 15 MINUTES.
5
、
FIRE-FIGHTING MEASURES
FLASH POINT: N/A (NON-FLAMMABLE)
FLAMMABLE LIMITS: N/A
FIRE EXTINGUISHING MEDIA: USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING FIRE
PAGE 1/3: MSDS
8529950
6
、
ACCIDENTAL RELEASE MEASURES
STEPS TO BE TAKEN IN THE EVENT OF A SPILL OR DISCHARGE:
WEAR SUITABLE PROTECTIVE CLOTHING, CAREFULLY SWEEP UP AND REMOVE.
7
、
HANDLING AND STORAGE
PRECAUTIONS IN STORAGE AND HANDLING
USE HANDLING PROCEDURES WHICH WILL LIMIT EXPOSURE TO EXCESSIVE AIRBORNE DUST..
SPECIAL PRECAUTIONS
KEEP BAGS OR DRUMS TIGHTLY CLOSED.KEEP IN SUITABLE FOR ANY GENERAL CHEMICAL STORAGE AREA.
8
、
EXPOSURE CONTROLS/PERSONAL PROTECTION
VENTILATION: USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS.
RESPIRATORY PROTECTION: NONE REQUIRED WHERE ADEQUATE VENTILATION CONDITIONS EXIST.
IF AIRBORNE CONCENTRATION EXCEEDS TLV, A DUST/MIST RESPIRATOR
IS RECOMMENDED. IF CONCENTRATION EXCEEDS CAPACITY OF RESPIRATOR,
A SELF-CONTAINED BREATHING APPARATUS IS ADVISED.
EYE/SKIN PROTECTION: SAFETY GLASSES WITH SIDESHIELDS, PROPER GLOVES ARE RECOMMENDED.
9
、
PHYSICAL AND CHEMICAL PROPERTIES
BOILING POINT: N/A VAPOR PRESSURE: N/A
MELTING POINT: 1240C VAPOR DENSITY: N/A
SPECIFIC GRAVITY: >3.96G/CM3 EVAPORATION RATE: N/A
SOLUBILITY IN WATER: INSOLUBLE
APPEARANCE&ORDOR: LIGHT/DARK BROWN GRAINS/POWDER &ORDORLESS
10
、
STABILITY AND REACTIVITY
STABILITY: STABLE
CONDITIONS TO AVOID: NONE DOCUMENTED
HAZARDOUS POLYMERIZATION: N/A
HAZARDOUS DECOMPOSITION PRODUCTS: N/A
11
、
TOXICOLOGICAL INFORMATION
EXCESSIVE INHALATION OF DUST MAY BE DAMAGING TO RESPIRATORY PASSAGES AND/OR LUNGS.
CONTACT WITH SKIN OR EYES MAY CAUSE IRRITATION.
12
、
ECOLOGICAL INFORMATION
NATURAL CORUNDUM IS BELIEVED NOT TO BE DANGEROUS TO THE ENVIRONMENT WITH RESPECT TO MOBILITY ,
PERSISTENCY AND DEGRADABILITY , BIO ACCUMULATIVE POTENTIAL , AQUATIC TOXICITY AND OTHER DATA
RELATING TO ECOTOXICITY .
13
、
DISPOSAL CONSIDERATIONS
DISPOSE IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE, AND LOCAL ENVIRONMENTAL
REGULATIONS.
PAGE 2/3: MSDS
14
、
TRANSPORT INFORMATION
SEA,ROAD/RAIL,AIR ALL APPLICABLE
15
、
REGULATORY INFORMATION
R42 : MAY CAUSE SENSITIZATION BY INHALATION .
S22 : DO NOT BREATHE DUST .
S24 : AVOID CONTACT WITH SKIN .
S36/37: WEAR SUITABLE PROTECTIVE CLOTHING AND GLOVES.
16
、
OTHER INFORMATION
THE INFORMATION CONTAINED IN THIS MATERIAL SAFETY DATA SHEET, AS OF THE ISSUE DATE,IS BELIEVED TO BE
TRUE AND CORRECT. HOWEVER, THE ACCURACY OR COMPLETENESS OF THIS INFORMATION AND ANY
RECOMMENDATIONS OR SUGGESTIONS ARE MADE WITHOUT WARRANTY OR GUARANTEE . SINCE THE CONDITIONS
OF USE ARE BEYOND THE CONTROL OF OUR COMPANY, IT IS THE RESPONSIBILITY OF THE USER TO DETERMINE THE
CONDITION OF SAFE USE OF THIS PRODUCT.
PAGE 3/3: MSDS
/
