Comtech EF Data HPOD Operating instructions

Part Number MN/HPOD.IOM Revision 6

IMPORTANT NOTE: The information contained in this document supersedes all previously published

information regarding these products. Product specifications are subject to change without prior notice.

HPOD

C-, X-, Ku-Band High-Power Outdoor Amplifier

Installation and Operation Manual

ER-HPOD-EA6 THIS DOCUMENT IS NOT SUBJECT TO REVISION/UPDATE! PLM CO C-0025634 Page 1 of 2

Errata A

Comtech EF Data Documentation Update

Subject: HPODGainSpecification

OriginalManualPart

Number/Rev:



MN/HPOD.IOMRev6

ErrataNumber/

PLMDocumentID:



ER‐HPOD‐EA6

PLMCONumber: C‐0025634

Comments: Theupdatedinformationwillbeincorporatedintothenextformalrevision

ofthemanual.



• Sect.1.4Specifications(Pg.1‐7)–Gainspecification

istypicalfor

C‐Band,X‐Band,Ku‐Bandunits:



70dBmin,75dBtypical



Errata A for MN-HPOD Rev 6 Update HPOD Gain Specification

ER-HPOD-EA6 THIS DOCUMENT IS NOT SUBJECT TO REVISION/UPDATE! PLM CO C-0025634 Page 2 of 2

Thispageisintentionallyblank.

ER-HPOD-EB6 THIS DOCUMENT IS NOT SUBJECT TO REVISION/UPDATE! PLM CO C-0027014 Page 1 of 6

Errata B

Comtech EF Data Documentation Update

Subject: HPOD1:2Ku‐BandAssemblyFigures

OriginalManualPart

Number/Rev:



MN/HPOD.IOMRev6

ErrataNumber/

PLMDocumentID:



ER‐HPOD‐EB6

PLMCONumber: C‐0027014

Comments: Theupdatedinformationw ill beincorporatedintothenextformalrevision

ofthemanual:



AddFiguresA‐22throughA‐25

forHPODKu‐Band1:2RedundancySystem

(CEFDP/NKT‐0020685)toAppendixA.REDUNDANCYSYSTEMASSEMBL:Y

KITS

ErrataBforMN/HPOD.IOMRev6AddHPODKu‐Band1:2RedundancySystemFigures

ER-HPOD-EB6 THIS DOCUMENT IS NOT SUBJECT TO REVISION/UPDATE! PLM CO C-0027014 Page 2 of 6

Thispageisintentionallyblank.

HPOD C-, X-, Ku-Band High-Power Outdoor Amplifier Revision 6

Appendix A MN/HPOD.IOM

A–36

A.4.2 HPOD Ku-Band 1:2 Redundancy System (CEFD P/N KT-0020685)



Figure A-22. HPOD Ku-Band 1:2 Redundancy System – Exploded Isometric View (Front)

HPOD C-, X-, Ku-Band High-Power Outdoor Amplifier Revision 6

Appendix A MN/HPOD.IOM

A–37



Figure A-23. HPOD Ku-Band 1:2 Redundancy System – Assembled Isometric View (Back)

HPOD C-, X-, Ku-Band High-Power Outdoor Amplifier Revision 6

Appendix A MN/HPOD.IOM

A–38



Figure A-24. HPOD Ku-Band 1:2 Redundancy System – Front and Bottom Views

HPOD C-, X-, Ku-Band High-Power Outdoor Amplifier Revision 6

Appendix A MN/HPOD.IOM

A–39



Figure A-25. HPOD Ku-Band 1:2 Redundancy System – Assembled Switch Detail ‘A’ and Side View



SWITCHDETAIL‘A’

ASASSEMBLED,VIEWEDFROMBACK

Comtech EF Data, 2114 West 7th Street, Tempe, Arizona 85281 USA, 480.333.2200, FAX: 480.333.2161

HPOD

C, X-, Ku-Band High-Power Outdoor Amplifier

Installation and Operation Manual

Part Number MN/HPOD.IOM

Revision 6



ii



Thispageisintentionallyblank.

iii

TABLE OF CONTENTS

TABLE OF CONTENTS .............................................................................................................. III

TABLES ..................................................................................................................................... VII

FIGURES ................................................................................................................................... VII

PREFACE ................................................................................................................................... IX

AboutthisMa

nual..............................................................................................................................ix

Disclaimer.................................................................................................................................................ix

ConventionsandReferences...............................................................................................................ix

PatentsandTrademarks..........................................................................................................................ix

Warnings,Cautions,andNotes................................................................................................................ix

ExamplesofMulti‐Hazard Notices............................................................................................................x

RecommendedStandardDesignations.....................................................................................................x

MetricConversion.....................................................................................................................................x

ElectricalSafetyNotice.........................................................................................................................x

InstallationG

uidelinesRegardingPowerLineQuality.........................................................................xi

WarrantyPolicy.................................................................................................................................xii

LimitationsofWarranty..........................................................................................................................xii

ExclusiveRemedies.................................................................................................................................xiii

GettingHelp............................................................................................................................... .......xiv

ContactingComtechEFData..................................................................................................................xiv

ReturningaProductforUpgradeorRepair............................................................................................xv

CHAPTER 1. INTRODUCTION ............................................................................................. 1–1

1.1 Overview..............................................................................................................................1–1

1.1.1 Features....................................................................................................................................1–2

1.2 Functi

onalDescription..........................................................................................................1–2

1.2.1 DimensionalEnvelope ..............................................................................................................1–3

1.3 TheoryofOperation.............................................................................................................1–4

1.3.1 SSPAModule.............................................................................................................................1–5

1.3.2 PowerSupply............................................................................................................................1–5

1.3.3 CoolingSystem.........................................................................................................................1–5

1.3.4 MonitorandControl(M&C).....................................................................................................1–5

1.3.5 BlockUpConverterInputOption.............................................................................................1–6

HPOD C, X-, Ku-Band High-Power Outdoor Amplifier Revision 6

Table of Contents MN/HPOD.IOM

iv

1.4 Specifications.......................................................................................................................1–7

CHAPTER 2. EXTERNAL CONNECTORS AND PINOUTS ................................................. 2–1

2.1 CablingConnectionTypes.....................................................................................................2–1

2.1.1 CoaxialCableConnections........................................................................................................2–1

2.1.2 CircularCableConnections.......................................................................................................2–1

2.2 HPODSSPACablingConnections...........................................................................................2–2

2.3 RFSignalInterfaceConnectorGroup.....................................................................................2–4

2.3.1 J1|RFINConnector.................................................................................................................2–4

2.3.2 J2|RFOUTConnector.............................................................................................................2–4

2.4 GroundandPo

werConnectionGroup..................................................................................2–5

2.4.1 GroundConnection..................................................................................................................2–5

2.4.2 J3|ACINConnector(ACPowerMain)....................................................................................2–5

2.4.3 J10Connector:Optional‐48VDCPowerSupply......................................................................2–6

2.5 ElectricalControlInterfaceConnectionGroup......................................................................2–7

2.5.1 J4|REDUNDANTLOOPConnector...........................................................................................2–7

2.5.2 J6|COM1Connector...............................................................................................................2–8

2.5.3 J8|INP

UTSAMPLEConnector.................................................................................................2–8

2.5.4 J9|OUTPUTSAMPLEConnector..............................................................................................2–8

2.6 EnergizingtheHPODSSPA....................................................................................................2–9

CHAPTER 3. UPDATING FIRMWARE ................................................................................. 3–1

3.1 Introduction.........................................................................................................................3–1

3.2 GettingStarted:PreparingfortheFirmwareDownload........................................................3–2

3.3 DownloadingandExtracti

ngtheFirmwareUpdate...............................................................3–5

3.4 PerformingtheFTPUploadProcedures................................................................................3–8

3.4.1 PerformingtheAutomatedSerial‐basedFTPUpload Procedure.............................................3–8

3.4.2 PerformingtheEthernet‐basedFTPUploadProcedure.........................................................3–10

CHAPTER 4. ETHERNET-BASED REMOTE PRODUCT MANAGEMENT ......................... 4–1

4.1 Introduction.........................................................................................................................4–1

4.2 EthernetManagementInterfaceProtocols...........................................................................4–2

4.3 SNMPInterface....................................................................................................................4–2

4.3.1 Manage

mentInformationBase(MIB)Files..............................................................................4–2

4.3.2 SNMPCommunityStrings.........................................................................................................4–3

HPOD C, X-, Ku-Band High-Power Outdoor Amplifier Revision 6

Table of Contents MN/HPOD.IOM

v

4.3.3 SNMPTraps..............................................................................................................................4–3

4.4 TelnetInterface....................................................................................................................4–4

4.4.1 TelnetOperationviaHype rTerminal........................................................................................4–5

4.5 HPODWebServer(HTTP)Interface.......................................................................................4–6

4.5.1 EnablingtheWebServerInterface...........................................................................................4–6

4.5.2 UserLogin.................................................................................................................................4–8

4.5.3 WebServerInterface–OperationalFeatures..........................................................................4–9

4.5.3.1 Navigation.........................................................................................................................4–9

4.5.3.2 PageSections....................................................................................................................4–9

4.5.3.3 ActionButto

ns..................................................................................................................4–9

4.5.3.4 Drop‐downLists................................................................................................................4–9

4.5.3.5 TextorDataEntry...........................................................................................................4–10

4.5.4 WebServerInterface–MenuTree........................................................................................4–10

4.5.5 WebServerPageDescriptions...............................................................................................4–10

4.5.5.1 HomePages....................................................................................................................4–11

4.5.5.1.1 Home|HomePage..................................................................................................4–11

4.5.5.1.2 Home|ContactPage................................................................................................4–12

4.5.5.1.3 Home|Su

pportPage...............................................................................................4–13

4.5.5.2 AdminPages....................................................................................................................4–14

4.5.5.2.1 Admin|AccessPage.................................................................................................4–14

4.5.5.2.2 Admin|SNMPPage..................................................................................................4–16

4.5.5.3 ConfigPages....................................................................................................................4–17

4.5.5.3.1 Config|AmplifierPage.............................................................................................4–17

4.5.5.3.2 Config|UtilityPage..................................................................................................4–19

4.5.5.3.3 Config|Red

undancyPage........................................................................................4–20

4.5.5.4 StatusPages....................................................................................................................4–21

4.5.5.4.1 Status|MonitorPage...............................................................................................4–21

4.5.5.4.2 Status|AlarmsPage.................................................................................................4–22

4.5.5.4.3 Status|FETsPage.....................................................................................................4–23

CHAPTER 5. SERIAL-BASED REMOTE PRODUCT MANAGEMENT ................................ 5–1

5.1 Overview..............................................................................................................................5–1

5.2 KeyOperationalParameters.................................................................................................5–1

5.2.1 RFInputLe

vel...........................................................................................................................5–1

5.2.2 AttenuatorControl...................................................................................................................5–2

5.2.3 MuteControl............................................................................................................................5–2

5.2.4 Faults........................................................................................................................................5–2

5.2.5 PowerDetector.........................................................................................................................5–3

5.2.6 MostCommonRemoteQueries...............................................................................................5–3

5.3 SerialRemoteControlIntroduction......................................................................................5–3

5.3.1 EIA‐485......................................................................................................................................5–3

5.3.2 EIA‐232......................................................................................................................................5–4

HPOD C, X-, Ku-Band High-Power Outdoor Amplifier Revision 6

Table of Contents MN/HPOD.IOM

vi

5.3.3 BasicProtocol...........................................................................................................................5–4

5.3.4 PacketStructure.......................................................................................................................5–5

5.3.4.1 StartofPacket...................................................................................................................5–6

5.3.4.2 TargetAddress..................................................................................................................5–6

5.3.4.3 AddressDelimiter..............................................................................................................5–6

5.3.4.4 InstructionCode................................................................................................................5–6

5.3.4.5 InstructionCodeQualifier.................................................................................................5–6

5.3.4.6 OptionalMessageArguments...........................................................................................5–8

5.3.4.7 EndofPacket....................................................................................................................5–8

5.4 RemoteCom

mandsandQueries...........................................................................................5–9

APPENDIX A. REDUNDANCY SYSTEM ASSEMBLY KITS ............................................... A–1

A.1 Introduction.........................................................................................................................A–1

A.2 CommonMountingKits........................................................................................................A–4

A.3 1:1RedundancySystemMountingandSwitchKits.............................................................A–12

A.4 1:2RedundancySystemMountingandSwitchKitExamples...............................................A–32

APPENDIX B. 1:1 AND 1:2 REDUNDANCY OPERATION ................................................. B–1

B.1 Introduction.........................................................................................................................B–1

B.1.1 1:1RedundancyMode..............................................................................................................B–1

B.1.2 1:2Red

undancyMode..............................................................................................................B–3

B.2 RedundancyOperationUsingtheHPODWebServerInterface..............................................B–5

B.2.1 HPODWebServerInterfaceOverview.....................................................................................B–5

B.2.2 Config|RedundancyPage.......................................................................................................B–6

B.3 RedundancyOperationusingSerial‐basedRemoteCommandsandQueries.........................B–8

B.4 HPODSeries1:1Redundancy Test ......................................................................................B–10

B.4.1 Connection..............................................................................................................................B–10

B.4.2 Operation................................................................................................................................B–11

APPE

NDIX C. MAINTENANCE ............................................................................................ C–1

C.1 Introduction.........................................................................................................................C–1

C.2 ReplacingthePowerSupply..................................................................................................C–2

C.2.1 RemovingtheOldPowerSupply..............................................................................................C–2

C.2.2 InstallingtheNewPowerSupply..............................................................................................C–3

C.3 ReplacingtheFanAssembly..................................................................................................C–4

C.3.1 RemovingtheOldFanAssembly..............................................................................................C–4

HPOD C, X-, Ku-Band High-Power Outdoor Amplifier Revision 6

Table of Contents MN/HPOD.IOM

vii

C.3.2 InstallingtheNewFanAssembly..............................................................................................C–5

C.4 ScheduledMaintenance.......................................................................................................C–6

TABLES

Table2‐1.HPODSSPAExternalConnectors.............................................................................................2–3

Table2‐2.J2|RFOUTWaveguideOutputFlange...................................................................................2–4

Table2‐3.J3|ACINConnectorPinout....................................................................................................2–5

Table2‐4.J10ConnectorPinout...............................................................................................................2–6

Table2‐5.J4|REDUNDANTLOOPConnectorPinout..............................................................................2–7

Table2‐6.J6|COM1ConnectorPinout...................................................................................................2–8

TableA‐1.S

ummaryofAvailableRedundancySystemAssemblyKits.....................................................A–2

TableA‐2.UniversalPoleMountingKit(CEFDP/NPL/12319‐1)PartsList..............................................A–4

TableA‐3.HPODUnitMountingKit(CEFDP/NPL/12300‐1)PartsList....................................................A–6

TableA‐4.HP

OD1:1RedundancySystem–CommonUnistrutKit(CEFDP/NKT/12200‐1)PartsList....A–8

TableA‐5.HPOD1:2RedundancySystem–CommonUnistrutKit(CEFDP/NKT‐0000017)PartsList..A–10

TableA‐6.ODPAC‐Band1:1RedundancySwitch/WaveguideKit(CEFDP/NKT/1

1799)PartsList.......A–18

TableA‐7.ODPAX‐Band1:1RedundancySwitch/WaveguideKit(CEFDP/NKT/11387‐1)PartsList....A–20

TableA‐8.HPODC‐Band1:1RedundancySwitch/WaveguideKit(CEFDP/NKT/12201‐1)PartsList....A–23

TableA‐9.HPODC‐BandOfflineUnitTerminationBypassWavegui

deKit(CEFDP/NKT‐0020523)Parts

List...................................................................................................................................................A–25

TableA‐10.Ku‐Band1:1RedundancyAssemblyKit(CEFDP/NKT/11936‐1)PartsList.........................A–27

TableA‐11.HPODKu‐Band1:1RedundancySwitch/WaveguideKit(CEFDP/NKT/12337‐1)PartsList.......

........................................................................................................................................................A–29

FIGURES

Figure1‐1.ComtechEFDataHPODSSPA.................................................................................................1–1

Figure1‐2.HPODSSPADimensionalEnvelope.........................................................................................1–3

Figure1‐3.ComtechEFDataHPODSSPABlockDiagram.........................................................................1–4

Figure2‐1.CoaxialConnectorExample....................................................................................................2–1

Figure2‐2.CircularConnectorExample...................................................................................................2–2 

Figure2‐3.HPODEx

ternalConnectors.....................................................................................................2–3

Figure2‐4.HPODUnit...............................................................................................................................2–9

Figure4‐1.HPODHome|Homepage....................................................................................................4–11

Figure4‐2.Home|Contactpage............................................................................................................4–12

Figure4‐3.Home|Supportpage...........................................................................................................4–13

Figure4‐4.Admin|AccessPage.............................................................................................................4–14

Figure4‐5.Ad

min|SNMPpage.............................................................................................................4–16

Figure4‐6.Config|Amplifierpage.........................................................................................................4–17

Figure4‐7.Config|Utilitypage..............................................................................................................4–19

Figure4‐8.Config|Redundancypage....................................................................................................4–20

Figure4‐9.Status|Monitorpage ..........................................................................................................4–21

Figure4‐10.Status|Alarmspage...........................................................................................................4–22

Figure4‐11.St

atus|FETspage...............................................................................................................4–23

HPOD C, X-, Ku-Band High-Power Outdoor Amplifier Revision 6

Table of Contents MN/HPOD.IOM

viii

FigureA‐1.UniversalPoleMountingKit(CEFDP/NPL/12319‐1).............................................................A–5

FigureA‐2.HPODUnitMountingKit(CEFDP/NPL/12300‐1)..................................................................A–7

FigureA‐3.HPOD1:1RedundancySystem–CommonUnistrutKit(CEFDP/NKT/12200‐1)..................A–9

FigureA‐4.HPOD1:2RedundancySystem–Commo

nUnistrutKit(CEFDP/NKT‐0000017)................A–11

FigureA‐5.Typical1:1MountingandSwitchKitExample–ExplodedIsometricView..........................A–12

FigureA‐6.Typical1:1MountingandSwitchKitExample–AssembledIsometricView.......................A–13

FigureA‐7.Typical1:1MountingandSwitchKitExample–TopView...................................................A–14

FigureA‐8.Ty

pical1:1MountingandSwitchKitExample–FrontView................................................A–15

FigureA‐9.Typical1:1MountingandSwitchKitExample–SideView..................................................A–16

FigureA‐10.ODPAC‐Band1:1RedundancySwitch/WaveguideKit(CEFDP/NKT/11799)...................A–19

FigureA‐11.ODPAX‐Band1:1Redun

dancySwitch/W aveguideKit(CEFDP/NKT/11387‐1)................A–21

FigureA‐12.HPODC‐Band1:1RedundancySystem–SwitchandUnistrutAssembly(CEFDP/N

KT/12240‐1)....................................................................................................................................A–22

FigureA‐13.HPODC‐Band1:1RedundancySwitch/WaveguideKit(CEFDP/NKT/12201‐1)................A–24

FigureA‐14.HPODC‐BandOfflineUnit Termina

tionBypassWaveguideKit(CEFDP/NKT‐0020523)..A–26

FigureA‐15.Ku‐Band1:1RedundancyAssemblyKit(CEFDP/NKT/11936‐1).......................................A–28

FigureA‐16.HPODKu‐Band1:1RedundancySwitch/WaveguideKit(CEFDP/NKT/12337‐1)..............A–30

FigureA‐17.HPODC‐Band1:2Redun

dancySystem–Isometric View..................................................A–32

FigureA‐18.HPODC‐Band1:2RedundancySystem–TopView...........................................................A–33

FigureA‐19.HPODC‐Band1:2RedundancySystem–FrontView.........................................................A–33

FigureA‐20.HPODC‐Band1:2RedundancySys

tem–FrontViewSwitchDetail‘A’andSideView......A–34

FigureA‐21.HPODC‐Band1:2RedundancySystem–BackView..........................................................A–35

FigureB‐1.HPODC‐Band1:2RedundancySystemBlockDiagram..........................................................B–3

FigureB‐2.Config|Redundancypage.....................................................................................................B–6

FigureC‐1.HPO

DPowerSupplyReplacement.........................................................................................C–2

FigureC‐2.HPODFanAssemblyRemoval.................................................................................................C–4

FigureC‐3.HPODFanAssemblyReplacement.........................................................................................C–5



ix

PREFACE

About this Manual

This manual provides installation and operation information for the Comtech EF Data HPOD

family of High‐Power Outdoor Amplifiers. This manual is an informational document intended

for the persons responsible for the operation and maintenance of the HPOD C‐Band, X‐Band,

andKu‐Bandunits.

Disclaimer

ComtechEFDatahasreviewedthismanualthoroughlyinordertoprovideaneasy‐to‐useguideto

thisequipment.Allstatements,technicalinformation,andrecommendationsinthismanualandin

anyguidesorrelateddocumentsarebelievedreliable,buttheaccuracyandcompletenessthereof

arenotguaranteedorwarranted , and theyareno

tintendedtobe,norshouldtheybeunderstood

tobe,representationsorwarrantiesconcerningtheproductsdescribed.Further,ComtechEFData

reservestherighttomakechangesinthespecificationsoftheproductsdescribedinthismanualat

anytimewithoutnoticeandwithoutobligationtonotifyanype

rsonofsuc h changes.



If there are any questions regarding this equipment, or the content and design of this

manual, pleaseco nta cttheCo mtechEFDataCustomerSupportDepartment.

Conventions and References

Patents and Trademarks

SeeallofComtechEFData'sPatentsandPatentsPendingathttp://patents.comtechefdata.com.



ComtechEFDataacknowledgesthatalltrademarksarethepropertyofthetrademarkowners.

Warnings, Cautions, and Notes

A WARNING

gives information about a possible hazard that MAY CAUSE DEATH

or SERIOUS INJURY.

HPOD C-, X-, and Ku-Band High-Power Outdoor Amplifiers Revision 6

Preface MN/HPOD.IOM

x

A CAUTION

gives information about a possible hazard that MAY CAUSE INJURY

or PROPERTY DAMAGE.

A NOTE

gives important information about a task or the equipment.

A REFERENCE

directs you to additional information about a task or the

equipment.

Examples of Multi-Hazard Notices



Recommended Standard Designations

Recommended Standard(RS) Designationshavebeen supersededbythenew designation ofthe

ElectronicIndustriesAssociation(EIA).ReferencestotheoldRSDesign ation(e.g.,RS‐232)maybe

used when depicting actual text displayed on the unit’s Web Server pages, serial interface, or

physicallabeling.Allotherre f er encesinthemanualus

etheEIAdesignations.

Metric Conversion

Metric conversion information is located on the inside back cover of this manual. This

information is provided to assist the operator in cross‐referencing non‐Metric to Metric

conversions.





Carefully review the following information:

Electrical Safety Notice

Neutral Fusing – Double pole/neutral fusing is used on the prime power supply

input.

Thisequipmenthasbeen designed tominimize exposureofpersonnelto hazards.For further

Page is loading ...

Comtech EF Data HPOD Operating instructions

Comtech EF Data HPOD Operating instructions

Related papers

Other documents