Husqvarna 952711939 Installation guide

Replaces

545192186 - 9/14/10

NOTE : Illustration may differ from actual model due to design changes.

545192186

5/15/12

Page:

PARTS LIST

R

128CD (US/CAN)

1

Parts List No.

Date

MODEL

1. Assy - Cable/Wire Harness

2. Housing - Throttle (RH)

3. Screw

4. Screw

5. 530016454 Spring - Trigger

6. Trigger

7. Lockout - Throttle

8. Housing - Throttle (LH)

9. Kit - Switch

10. 545042201 Handle - Assist

11. 530015820 Bolt

12. 575262501 Kit - Driveshaft Upper (Incl. 15, & Flex)

13. 530059185 Clamp - Assist Handle

14. 530016152 Wingnut

15. 575291801 Kit - Knob / Screw

16. 545180847 Kit - Lower Shaft (incl. flex, 22 & 23)

17. 545031101 Kit - Shield (Incl. 18,19,20,21)

18. 530052287 Limiter - Line

19. 530015814 Screw

WARNING

All repairs, adjustments and

maintenance not described in

the Operator’s Manual must be

performed by Qualified Service

Personnel.

Ref. Part No. Description

= New Part Number For This IPL

= Refer to the Service Reference Indicated for more information.(Located at the END of the IPL)

Not Shown

20. 530015820 Bolt

21. 530016152 Wingnut

22. Dust Cup

23. Assy. - T25 Cutting Head

115374327 Manual

530031159 Wrench-Hex (5/32”)

4

1

3

2

5

6

13

14

10

11

15

12

20

21

22

23

16

7

8

9

17

19

18

545192186

5/15/12

Replaces

545192186 - 9/14/10

Page:

PARTS LIST

R

128CD (US/CAN)

2

Parts List No.

Date

MODEL

NOTE : Illustration may differ from actual model due to design changes.

1. 530150253 Filter

2. 530016101 Nut - Carb. Screw

3. 530057844 Lever - Choke

4. 530058709 Bulb - Purge

5. 545008086 Kit - Carb. Gasket (Incl. 7,62)

6. 530035596 Adaptor - Carb.

7. ----- Foam - Gasket (Ref.#5,68)

8. 530016400 Bolt

9. 952030201 Plug - Spark (RCJ-8Y)

10. ----- Seal - Cylinder (Ref.#68)

11. ----- Seal - Crankshaft (Ref.#68)

12. 503873305 Assy - Starter Pawl

13. 530095646 Assy - Fuel Filter

14. Kit - Fuel Line (Incl. 15)

15. 530023877 Fitting - Fuel line

16. Assy - Cap w/ret.(Incl. 17)

17. ----- O-ring (Ref.#16,19,68)

18. 530059780 Isolator - Fuel Tank

19. Kit - Fuel Tank Assy.

(Incl. 14,15,16,17)

20. 576153201 Shroud - Rear

21. 530016448 Screw

22. 545008079 Kit - Rope

23. 545043204 Handle - Starter

24. 530016426 Screw

25. 530016449 Screw

47. Screw

48. Screw

49. 530015768 Nut

50. 530016456 Screw

51. Assy - Fan Housing

52. Assy - Clutch Drum

53. 530055122 Assy - Clutch

54. 530057852 Spacer

55. 530039242 Flywheel

56. 545195601 Crankcase - Cast

57. 545013401 Bearing

58. 545195202 Assy - Crankshaft

59. 530015162 Retainer - Piston Pin

60. 530019283 Ring - Piston

61. 545008082 Kit - Piston/Cyl.(Incl. 59,60)

62. ----- Seal - adaptor (Ref.#68)

63. 530015897 Screw

64. 545081848 Kit - Carb. (Incl. 3,4,5)

65. 576459001 Airbox

66.

530057846 Cover - Air Box

67.

530059796 Assy - Knob

68. 545008084 Kit - Gasket

(Incl. 5,7,10,11,17,40,62)

69. 545180885 Kit - Decal

Ref. Part No. Description

WARNING

All repairs, adjustments and

maintenance not described in

the Operator’s Manual must be

performed by Qualified Service

Personnel.

= New Part Number For This IPL

= Refer to the Service Reference Indicated for more information.(Located at the END of the IPL)

26. 525455501 Hsg. - Starter

27. 545008087 Kit - Spring

28. 579066801 Kit - Starter Pulley

29. 578465101 Spring - Driver

30. 579366201 Pulley - Driver

31. 530016468 Screw

32. 579063101 Assy - Starter Hsg.

(Incl. 22,23,25 - 31)

33. 530058982 Bolt - Muffler

34. 530015241 Screw

35. 530150440 Shield - Heat

36. 530016449 Screw

37. 576215001 Kit - Muffler Guard

(Incl. Screws)

38. 545030501 Kit - Spark (Incl. 34)

39. 574031502 Kit - Muffler

(Incl. 33,34,38,40)

40. ----- Gasket (Ref.#39,68)

41. 530015897 Screw

42. 545046701 Module

43. 530039227 Assy - Leadwire

44. 530016456 Screw

45. 530016463 Washer

46. 530094189 Washer - Clutch

1

2

16

14

13

15

12

11

58

57

10

61

60

62

63

64

66

65

67

59

9

8

7

6

5

19

17

20

21

23

22

24

27

28

26

25

31

30

18

33

34

38

39

40

42

45

46

47

48

50

51

52

68

Gasket

Kit

53

54

55

56

49

43

44

41

35

36

37

32

69

Kit

Decal

4

3

29

Replaces

545192186 - 9/14/10

NOTE : Illustration may differ from actual model due to design changes.

545192186

5/15/12

Page:

PARTS LIST

R

128CD (US/CAN)

3

Parts List No.

Date

MODEL

Service Reference

Note : Due to product improvements, your unit may have a different starter housing assembly.

Please refer to the serial number on your unit and order the parts below.

Serial Number - 2009-212N and lower, please use the following parts:

Ref.# 23 - 537419303 - Housing

Ref.# 24 - 537419901 - Adapter

Ref.# 25 - 537338801 - Spring

Ref.# 26 - 545080801 - Assy - Wound Spool

Ref.# 27 - 545003365 - Kit - Cover and Eyelet

Ref.# 28 - 537419601 - Knob

Ref.# 29 - 537419214 - Assy - TNG7 Cutting Head

Serial Number - 2009-213N and higher, please use the following parts:

Page 1, Ref.# 22 - 545017403 - Dust Cup

Page 1, Ref.# 23 - 537338307 - Assembly - T25 Cutting Head

23

24

25

26

27

28

29

Service Reference

Note : Due to product improvements, your unit may have a different throttle housing assembly.

Please refer to the serial number on your unit and order the parts below.

Serial Number - 2010-72N and lower, please use the following parts:

Ref.# 1 - 545125301 - Assy-Cable/Wire Harness

Ref.# 2 - 545062001 - Housing-throttle (RH)

Ref.# 3 - 530016448 - Screw

Ref.# 4 - 530016449 - Screw

Ref.# 6 - 545066001 - Trigger

Ref.# 7 - 530059804 - Lockout - Throttle

Ref.# 8 - 545045601 - Spring - Lockout

Ref.# 9 - 545067001 - Housing-throttle (LH)

Ref.#10- 545030601 - Kit - Switch

Serial Number - 2010-73N and higher, please use the following parts:

Ref.# 1 - 576139401 - Assy. - Cable/Wire Harness

Ref.# 2 - 545223001 - Housing-throttle (RH)

Ref.# 3 - 530016449 - Screw

Ref.# 4 - 530015805 - Screw

Ref.# 6 - 574355301 - Trigger

Ref.# 7 - 574355401 - Lockout - Throttle

Ref.# 8 - 545223201 - Housing-throttle (LH)

Ref.# 9 - 545049309 - Switch

4

1

3

2

6

7

8

9

4

1

3

2

6

7

8

9

10

22

23

545192186

5/15/12

Replaces

545192186 - 9/14/10

Page:

PARTS LIST

R

128CD (US/CAN)

4

Parts List No.

Date

MODEL

NOTE : Illustration may differ from actual model due to design changes.

Service Reference

Note : Due to product improvements, your unit may have a different fan housing assembly.

Please refer to the serial number on your unit and order the parts below.

Serial Number - 2010-72N and lower, please use the following parts:

Ref.# 49 - 530016469 - Screw

Ref.# 50 - 530016470 - Screw

Ref.# 52 - 545017501 - Assy. - Fan Housing

Serial Number - 2010-73N and higher, please use the following parts:

Ref.# 49 - 530015805 - Screw

Ref.# 50 - 530015774 - Screw

Ref.# 53 - 545205201 - Assy. - Fan Housing

49

50

53

49

50

52

Service Reference

Note : Due to product improvements, your unit may have a different clutch drum assembly.

Please refer to the serial number on your unit and order the parts below.

Serial Number - 2012-090N and lower, please use the following parts:

Ref.# 1 - 545173401 - Thrust Bearing

Ref.# 2 - 530016420 - Thrust Washer

Ref.# 3 - 530150039 - Assy. - Clutch Drum

Serial Number - 2012-091N and higher, please use the following parts:

Ref.# 1 - Thrust Bearing is NOT REQUIRED

Ref.# 2 - Thrust Washer is NOT REQUIRED

Ref.# 3 - 580446601 - Kit - Clutch Drum

1

3

2

1

3

2

X

Replaces

545192186 - 9/14/10

NOTE : Illustration may differ from actual model due to design changes.

545192186

5/15/12

Page:

PARTS LIST

R

128CD (US/CAN)

5

Parts List No.

Date

MODEL

Service Reference

Note : Due to product improvements, your unit may have a different gas tank assembly and fuel cap.

Please refer to the serial number on your unit and order the parts below.

Serial Number - 2009-001N thru 2012-090N, please use the following parts:

Page 2, Ref.# 14 - 530069599 Kit - Fuel Line

Page 2, Ref.# 16 - 530150350 Cap - Fuel

Page 2, Ref.# 19 - 545180870 Kit - Fuel Tank Assembly

Serial Number - 2012-091N and higher, please use the following parts:

Page 2, Ref.# 14 - ----- (REF. # 19)

Page 2, Ref.# 16 - 578931501 Cap - Fuel

Page 2, Ref.# 19 - 578942901 Assembly - Fuel Tank

Husqvarna 952711939 Installation guide

Husqvarna 952711939 Installation guide

Related papers

Other documents