Replaces
545192186 - 9/14/10
NOTE : Illustration may differ from actual model due to design changes.
545192186
5/15/12
Page:
PARTS LIST
R
128CD (US/CAN)
1
Parts List No.
Date
MODEL
1. Assy - Cable/Wire Harness
2. Housing - Throttle (RH)
3. Screw
4. Screw
5. 530016454 Spring - Trigger
6. Trigger
7. Lockout - Throttle
8. Housing - Throttle (LH)
9. Kit - Switch
10. 545042201 Handle - Assist
11. 530015820 Bolt
12. 575262501 Kit - Driveshaft Upper (Incl. 15, & Flex)
13. 530059185 Clamp - Assist Handle
14. 530016152 Wingnut
15. 575291801 Kit - Knob / Screw
16. 545180847 Kit - Lower Shaft (incl. flex, 22 & 23)
17. 545031101 Kit - Shield (Incl. 18,19,20,21)
18. 530052287 Limiter - Line
19. 530015814 Screw
WARNING
All repairs, adjustments and
maintenance not described in
the Operator’s Manual must be
performed by Qualified Service
Personnel.
Ref. Part No. Description
Ref. Part No. Description
= New Part Number For This IPL
= Refer to the Service Reference Indicated for more information.(Located at the END of the IPL)
Not Shown
20. 530015820 Bolt
21. 530016152 Wingnut
22. Dust Cup
23. Assy. - T25 Cutting Head
115374327 Manual
530031159 Wrench-Hex (5/32”)
4
1
3
2
5
6
13
14
10
11
15
15
12
20
21
22
23
16
7
8
9
17
19
18
545192186
5/15/12
Replaces
545192186 - 9/14/10
Page:
PARTS LIST
R
128CD (US/CAN)
2
Parts List No.
Date
MODEL
NOTE : Illustration may differ from actual model due to design changes.
1. 530150253 Filter
2. 530016101 Nut - Carb. Screw
3. 530057844 Lever - Choke
4. 530058709 Bulb - Purge
5. 545008086 Kit - Carb. Gasket (Incl. 7,62)
6. 530035596 Adaptor - Carb.
7. ----- Foam - Gasket (Ref.#5,68)
8. 530016400 Bolt
9. 952030201 Plug - Spark (RCJ-8Y)
10. ----- Seal - Cylinder (Ref.#68)
11. ----- Seal - Crankshaft (Ref.#68)
12. 503873305 Assy - Starter Pawl
13. 530095646 Assy - Fuel Filter
14. Kit - Fuel Line (Incl. 15)
15. 530023877 Fitting - Fuel line
16. Assy - Cap w/ret.(Incl. 17)
17. ----- O-ring (Ref.#16,19,68)
18. 530059780 Isolator - Fuel Tank
19. Kit - Fuel Tank Assy.
(Incl. 14,15,16,17)
20. 576153201 Shroud - Rear
21. 530016448 Screw
22. 545008079 Kit - Rope
23. 545043204 Handle - Starter
24. 530016426 Screw
25. 530016449 Screw
47. Screw
48. Screw
49. 530015768 Nut
50. 530016456 Screw
51. Assy - Fan Housing
52. Assy - Clutch Drum
53. 530055122 Assy - Clutch
54. 530057852 Spacer
55. 530039242 Flywheel
56. 545195601 Crankcase - Cast
57. 545013401 Bearing
58. 545195202 Assy - Crankshaft
59. 530015162 Retainer - Piston Pin
60. 530019283 Ring - Piston
61. 545008082 Kit - Piston/Cyl.(Incl. 59,60)
62. ----- Seal - adaptor (Ref.#68)
63. 530015897 Screw
64. 545081848 Kit - Carb. (Incl. 3,4,5)
65. 576459001 Airbox
66.
530057846 Cover - Air Box
67.
530059796 Assy - Knob
68. 545008084 Kit - Gasket
(Incl. 5,7,10,11,17,40,62)
69. 545180885 Kit - Decal
Ref. Part No. Description
Ref. Part No. Description
Ref. Part No. Description
WARNING
All repairs, adjustments and
maintenance not described in
the Operator’s Manual must be
performed by Qualified Service
Personnel.
= New Part Number For This IPL
= Refer to the Service Reference Indicated for more information.(Located at the END of the IPL)
26. 525455501 Hsg. - Starter
27. 545008087 Kit - Spring
28. 579066801 Kit - Starter Pulley
29. 578465101 Spring - Driver
30. 579366201 Pulley - Driver
31. 530016468 Screw
32. 579063101 Assy - Starter Hsg.
(Incl. 22,23,25 - 31)
33. 530058982 Bolt - Muffler
34. 530015241 Screw
35. 530150440 Shield - Heat
36. 530016449 Screw
37. 576215001 Kit - Muffler Guard
(Incl. Screws)
38. 545030501 Kit - Spark (Incl. 34)
39. 574031502 Kit - Muffler
(Incl. 33,34,38,40)
40. ----- Gasket (Ref.#39,68)
41. 530015897 Screw
42. 545046701 Module
43. 530039227 Assy - Leadwire
44. 530016456 Screw
45. 530016463 Washer
46. 530094189 Washer - Clutch
1
2
16
14
13
15
12
11
58
57
10
61
60
62
63
64
66
65
67
59
9
8
7
6
5
19
17
20
21
23
22
24
27
28
26
25
31
30
18
33
34
38
39
40
42
45
46
47
48
50
51
52
68
Gasket
Kit
53
54
55
56
49
43
44
41
35
36
37
32
69
Kit
Decal
4
3
29
Replaces
545192186 - 9/14/10
NOTE : Illustration may differ from actual model due to design changes.
545192186
5/15/12
Page:
PARTS LIST
R
128CD (US/CAN)
3
Parts List No.
Date
MODEL
Service Reference
Note : Due to product improvements, your unit may have a different starter housing assembly.
Please refer to the serial number on your unit and order the parts below.
Serial Number - 2009-212N and lower, please use the following parts:
Ref.# 23 - 537419303 - Housing
Ref.# 24 - 537419901 - Adapter
Ref.# 25 - 537338801 - Spring
Ref.# 26 - 545080801 - Assy - Wound Spool
Ref.# 27 - 545003365 - Kit - Cover and Eyelet
Ref.# 28 - 537419601 - Knob
Ref.# 29 - 537419214 - Assy - TNG7 Cutting Head
Serial Number - 2009-213N and higher, please use the following parts:
Page 1, Ref.# 22 - 545017403 - Dust Cup
Page 1, Ref.# 23 - 537338307 - Assembly - T25 Cutting Head
23
24
25
26
27
28
29
Service Reference
Note : Due to product improvements, your unit may have a different throttle housing assembly.
Please refer to the serial number on your unit and order the parts below.
Serial Number - 2010-72N and lower, please use the following parts:
Ref.# 1 - 545125301 - Assy-Cable/Wire Harness
Ref.# 2 - 545062001 - Housing-throttle (RH)
Ref.# 3 - 530016448 - Screw
Ref.# 4 - 530016449 - Screw
Ref.# 6 - 545066001 - Trigger
Ref.# 7 - 530059804 - Lockout - Throttle
Ref.# 8 - 545045601 - Spring - Lockout
Ref.# 9 - 545067001 - Housing-throttle (LH)
Ref.#10- 545030601 - Kit - Switch
Serial Number - 2010-73N and higher, please use the following parts:
Ref.# 1 - 576139401 - Assy. - Cable/Wire Harness
Ref.# 2 - 545223001 - Housing-throttle (RH)
Ref.# 3 - 530016449 - Screw
Ref.# 4 - 530015805 - Screw
Ref.# 6 - 574355301 - Trigger
Ref.# 7 - 574355401 - Lockout - Throttle
Ref.# 8 - 545223201 - Housing-throttle (LH)
Ref.# 9 - 545049309 - Switch
4
1
3
2
6
7
8
9
4
1
3
2
6
7
8
9
10
22
23
545192186
5/15/12
Replaces
545192186 - 9/14/10
Page:
PARTS LIST
R
128CD (US/CAN)
4
Parts List No.
Date
MODEL
NOTE : Illustration may differ from actual model due to design changes.
Service Reference
Note : Due to product improvements, your unit may have a different fan housing assembly.
Please refer to the serial number on your unit and order the parts below.
Serial Number - 2010-72N and lower, please use the following parts:
Ref.# 49 - 530016469 - Screw
Ref.# 50 - 530016470 - Screw
Ref.# 52 - 545017501 - Assy. - Fan Housing
Serial Number - 2010-73N and higher, please use the following parts:
Ref.# 49 - 530015805 - Screw
Ref.# 50 - 530015774 - Screw
Ref.# 53 - 545205201 - Assy. - Fan Housing
49
50
53
49
50
52
Service Reference
Note : Due to product improvements, your unit may have a different clutch drum assembly.
Please refer to the serial number on your unit and order the parts below.
Serial Number - 2012-090N and lower, please use the following parts:
Ref.# 1 - 545173401 - Thrust Bearing
Ref.# 2 - 530016420 - Thrust Washer
Ref.# 3 - 530150039 - Assy. - Clutch Drum
Serial Number - 2012-091N and higher, please use the following parts:
Ref.# 1 - Thrust Bearing is NOT REQUIRED
Ref.# 2 - Thrust Washer is NOT REQUIRED
Ref.# 3 - 580446601 - Kit - Clutch Drum
1
3
2
1
3
2
X
X
Replaces
545192186 - 9/14/10
NOTE : Illustration may differ from actual model due to design changes.
545192186
5/15/12
Page:
PARTS LIST
R
128CD (US/CAN)
5
Parts List No.
Date
MODEL
Service Reference
Note : Due to product improvements, your unit may have a different gas tank assembly and fuel cap.
Please refer to the serial number on your unit and order the parts below.
Serial Number - 2009-001N thru 2012-090N, please use the following parts:
Page 2, Ref.# 14 - 530069599 Kit - Fuel Line
Page 2, Ref.# 16 - 530150350 Cap - Fuel
Page 2, Ref.# 19 - 545180870 Kit - Fuel Tank Assembly
Serial Number - 2012-091N and higher, please use the following parts:
Page 2, Ref.# 14 - ----- (REF. # 19)
Page 2, Ref.# 16 - 578931501 Cap - Fuel
Page 2, Ref.# 19 - 578942901 Assembly - Fuel Tank
/
