Picnic Time 770-00-175 User manual



OperatingInstructionsfortheVulcan,770‐00‐175



1. RemoveBBQgrillandallcomponentsfromthestoragebag.Makesuretoremoveallcardboard

and/orplasticfromallpartsbeforeusingthegrill.

2. Unfoldthelegs(awayfromthecenter)andplacethegrillonasecuredandlevelsurface.Place

thegrateontopoftheBBQgrill.

3. LocatethelocknutonthesideoftheBBQgrill.AligntheBBQscrewpostoftheregulatorwith

thelocknutofthegrill.Turnthelocknutclo ckwiseuntilthepropaneregulatorissecured.Do

notovertightenasthismaycausedamagetothescrewpost.Asmallwrenchmaybeused,but

isnotnecessarytoformaproperconnection.(Wrenchnotincluded.)

4. Attachapropane(LP)gastanktothegrillaccordingtothemanufacturer’sdirectionsprintedon

thecanister.Besuretofollowmanufacturer’sdirectionsforusetoavoidinjury.Thegrillisnow

readytolight.

5. Howtolight–UsingaBBQlighterorfireplacematches,insertflamethroughanopenexterior

holeatthebottomofgrillsoflamereachesintothegrill’sinterior.Turnknobto“on”position;

BBQshouldigniteimmediately,atwhichpointoneshouldremovetheflamesource.IfBBQdoes

notignitewithin2seconds,turnknob“off”,wait20secondsand repeatprevioussteps.

ALWAYSBESURETOINTRODUCEFLAMESOURCE

BEFORETURNINGGASKNOBTO“ON”

POSITION.Turninggasknobonbeforelightingthegrillmaylikelyresultingasbuildingupinthe

gaslinewhichcouldcauseseriousinjurywhen BBQislit.



InstructionsforStoringtheVulcan

1. OncetheBBQgrillhasfullycooled,removethegratefromtheBBQandputaside.Unscrewthe

regulatorfromtheBBQgrill,andplaceitundertheheatplateatoneend.Invertthelidsothat

itrestsinsidethegrill,makingsurethehandlefitsintothecut‐outsectionoftheheatplate.

2. Foldthelegsofthegrillin(towardsthecenter),makingtheBBQgrillascompactaspossible.

PlacetheBBQgrillinthebottomofthestoragebag.PlacetheBBQgrillinthebagontopofthe

grate.Cinchthedrawstringtoclosethebag.Placethebaginthebottom‐mostzippered

compartmentoftheVulcan.

770‐00_Vulcan_OperatingInstructions.doc