Sunjoy A106005500 Installation guide

Brand: Sunjoy

Model: A106005500

Type: Installation guide

This manual is also suitable for

8 ft. x 9 ft. Black Steel Classic Pergola

Country of Origin: China Production Number: xxxxxxxxxx



WE HAVE YOU IN MIND, LET US SERVE YOU!

Questions? Issues?

24 hours / 7 days a week

www.sunjoyonline.com 

1-(866)-578-6569

[email protected]

ITEM NO.：A106005500

2 / 8

Country of Origin: China

Topbeam1

P000601290 4

Topbeam2

P000601291 4

Longsidebeam1

P000400852 2

Longsidebeam2

P000400853 2

Shortsidebeam

P000400854 2

B5

Shortsidebeam

2

P000400855 2

Conner

P000300083 4

Decoratetube

P005600295 4

Post1

P000200445 2

Post2

P000200446 2

Stake

P000100313 4

Stakecover

P006100161

Arcsupport

P005000392

Railconnector

P005700630 8

Railbeam

P000501118 4

Canopyrod1

P005700631 4

Canopyrod2

P005700632 4

Parts List

3 / 8

Country of Origin: China

Canopy

P001100520 1

AA H010110016 M6 * 15 Bolt

16PCS

BB H050010023 M6 Flat Washer

52PCS

CC H010020012 M6 * 20 Bolt

36PCS

Z H090010009 M6 Wrench 1 PCS

Fig.1

Fig.3

Fig.2

Fig.4

Hardware Pack 1

Step.1

4 / 8

Country of Origin: China

Fig.1‐1:Putthestakecover（H1）throughthepost(E1/E2),upthestakecover(H1),thenattachstake(G1)

topost（E1/E2） bottom，fastenbyusingbolt（AA）andwasher（BB）.

Fig.2:Attachlongsidebeam1（B2）tolongsidebeam2（B3）,Byusingbolt（CC）andwasher（BB）. 

Fig.3:Attachshortsidebeam1（B4）toshortsidebeam2（B5）,byusingbolt（CC）andwasher（BB）.



Fig.4‐1:  Attachcorner（C1）totopofpost （E1/E2）.

Fig.4‐2:Attached

Shortsidebeam（B4/B5）tolongsidebeam（B2/B3），thenfixbyusingbolt（CC）and

washer（BB）.

Fig.4‐3:Install the nitrate of decorative pipe(D) onto the hoist hole of crossbeam(B2/B3) and fix it

with bolt (CC) through gasket(BB)

BB H050010023 M6 Flat Washer

48 PCS

CC H010020012 M6 * 20 Bolt 8 PCS

DD H010020022 M6 * 40 Bolt 40 PCS

Fig.4-1

Fig.4-2

B2/B3

E1/E2

Fig.1

Hardware Pack 2

E1/E2

B4/B5

Step.2

Fig.5

Fig.6

Fig.2

Fig.3

Fig.4-3

B2/B3

5 /8

Country of Origin: China

Hardware Pack 3

Fig.5:Attachtopbeam1（A1）totopbeam2（A2）,fixbyusingbolt（CC）andwasher（BB）.

Fig.6:Fixassembledtopbeam1/beam2(A1/A2)toassembledlongsidebeam1/longsidebeam1（B2/B3）,by

usingbolt（DD）andwasher(BB).

Fig.7:Attachtopbeam1/topbeam1（A1/A2）toshortsidebeam1/shortsidebeam2（B4/B5）,byusingbolt

（DD）andwasher（BB）.

H010020011

M6 * 75 Bolt

8 PCS

H070010008

Φ6*230 floor stake

8 PCS

H010020014

M6 * 10 Bolt 4 PCS

Step.3

Fig.8

Fig.10-1

Fig.10-2

Fig.9

Fig.11

Fig.5

Fig.6

Fig.7

B4/B5

A1/A2

B2/B3

H050010023

M6 Flat Washer

4 PCS

Fig.12

6 / 8

Country of Origin: China

Fig.8:Attachcanopyrod1（M1）totcanopyrod2（M2）,fixb

yusingbolt（GG）andwasher（BB）.

Fig.9:Laythecanopy（O1）onthetentandpassthecanopyrod1/canopyrod1（M1/M2）throughthecanopy

（O1）asshowm.

Fig.10‐1:First,insertthecanopyrod1/canopyrod1（M1/M2）intotherailbeam（N1）,theninserttherailbeam

（N1）intotherailconnector（L1）,finallylockrailbeam（N1）、connector（L1）andpost（E1/E2）,byusing

bolt（EE）.

Fig.10‐2:lockrailbeam（N1）、connector（L1）andpost（E1/E2）byusingbolt（EE）.

Fig.11:Fixtheassembledgazeboongroundbyusingfloorstake(FF).

Fig.8 Fig.9

Fig.10-1

Fig.11

M1/M2

E1/E2

7 / 8

Fig.12

M1/M2

Fig.12:Push the spring buckle on the Rail beam (N1) and

pull the hole of Canopy rod 1(M1) and Canopy rod 2 (M2)

underneath the spring buckle. So the fabric tubes will not

move up.

Country of Origin: China

8 / 8

Country of Origin: China



 Oursteelcomponentsforgardenaccessoriesandfurniturearetreatedwithrustinhibitingpaintthatprotectsitfrom

rusting.However,duetothenatureofsteel,surfaceoxidation(rusting)willoccuroncetheseprotectivecoatingsare

scratched.Thisisnotadefectandthusnotcoveredbythewarranty.

 Tominimizethiscondition,werecommendcarewhenassembling&handlingtheproducttopreventscratchingthe

paint.Shouldanyscratchingordamageoccur,werecommendimmediatetouch‐upwithrustinhibitingpaint.

 Surfacerustcanalsobeeasilyremovedwithaverylightapplicationofcommoncookingoil.Ifsurfaceoxidation

(rusting)occursandifnomeasureistakentopreventthis,theoxidationmaystartdrippingontodeckorpatioand

causeddamagingstains,whichmaybedifficulttoremove.Thiscanbepreventediftheabove‐mentionedmeasures

aretakentokeeptheproductfromoxidizing.

 Usedampclothtowipeoffthestainsasquicklyaspossible.

 Ifnecessary,washwithamildsolutionofsoapandwater;rinsethoroughlyanddrycompletely.

 Periodicallycheckandensurethatallboltsarewell‐tightenduringuse

Sunj

oyGroupwarrantstotheoriginalpurchaserthatthisitemisfreefromdefectsinworkmanshipandmaterialsfora

periodof  1yearfromthedateofpurchase,providedtheitemwasfactory‐sealedatthetimeofpurchaseandis

maintainedwithcareandusedonlyforpersonal,residentialpurposes.Shouldanymanufacturingdefectarisewithinthis

warrantyperiod,SunjoyGroupwillreplace(atouroption)anydefectivemerchandiseorpartsuponproofofpurchase;

however,transportationanddeliverycosts,aswellaspaymentstoathirdpartyforassemblyordisassemblyoftheitem,

remaintheresponsibilityofthepurchaser.Apurchaserofan"openbox,"previously‐returned,or"clearance"item,aswell

asoriginalpurchasersoutsideofthewarrantyperiod,mayobtainreplacementpartsfromSunjoyGroupforproductsin

currentproduction,atnominalcost.

Itemsusedforcommercial,contract,orothernon‐residentialpurposes,oritemsdamagedduetoactsofnature,

vandalism,misuse,orimproperassemblyarenotcovered.Corrosionorrustingofhardwareisnotcovered.Proofof

purchase(datedregisterreceipt)isrequiredforwarrantyclaims.Warrantyistotheoriginalpurchaserandis

non‐transferable.Anyreplacementofwarranteditemswillbeintheoriginalstyleandcolor,orasimilarstyleand

coloriftheoriginalisunavailableorhasbeendiscontinued.Assomestatesdonotallowexclusionsorlimitationsonan

impliedwarranty,theaboveexclusionsandlimitationsmaynotapply.Thiswarrantygivesyouspecificrights,andyoumay

alsohaveotherrights,whichvaryfromstatetostate. 

Care and Maintenance

Limited Manufacturer’s Warranty

Exclusions:

Sunjoy A106005500 Installation guide

Brand: Sunjoy

Model: A106005500

Type: Installation guide

This manual is also suitable for

8 ft. x 9 ft. Black Steel Classic Pergola

Download PDF

report

Sunjoy A106005500 Installation guide

This manual is also suitable for

Sunjoy A106005500 Installation guide

Related papers

Other documents