2. Home
  3. Domestic appliances
  4. Climate control
  5. Fireplaces
  6. American Hearth
  7. Madison Premium Clean-Face Contemporary Fireplace Intermittent Pilot (DVCC_BP) Home

American Hearth Madison Premium Clean-Face Contemporary Fireplace Intermittent Pilot (DVCC_BP) Home, DVCC_BP, Tahoe Premium Clean-Face Contemporary Fireplace Intermittent Pilot Home (DVCC_BP) Owner's manual

  • Hello! I am an AI chatbot trained to assist you with the American Hearth Madison Premium Clean-Face Contemporary Fireplace Intermittent Pilot (DVCC_BP) Home Owner's manual. I’ve already reviewed the document and can help you find the information you need or explain it in simple terms. Just ask your questions, and providing more details will help me assist you more effectively!
Page 1
WARNING
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly
could result in serious injury, death or
property damage.
— Do not store or use gasoline or other
ammable vapors and liquids in the
vicinity of this or any other appliance.
— WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch;
do not use any phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier
from a neighbor’s phone. Follow
the gas supplier’s instructions.
• If you cannot reach your gas
supplier, call the re department.
— Installation and service must be
performed by a qualied installer,
service agency or the gas supplier.
INSTALLER:
Leave this manual with the appliance.
CONSUMER:
Retain this manual for future reference.
This appliance may be installed in
an aftermarket, permanently located,
manufactured home (USA only) or mobile
home, where not prohibited by state or local
codes.
This appliance is only for use with the type of
gas indicated on the rating plate. This appliance
is not convertible for use with other gases,
unless a certied kit is used.
DIRECT VENT ZERO
CLEARANCE GAS FIREPLACE
HEATER SERIES MODELS:
INTERMITTENT PILOT (IP)
DVCC(32,36,42)BP7(0,2)K(N,P)-4
DVCP42BP70K(N,P)-4
HOT GLASS
DO NOT TOUCH
NEVER
WILL
CAUSE BURNS.
GLASS
UNTIL COOLED.
ALLOW CHILDREN
TO TOUCH GLASS.
WARNING
A barrier designed to reduce the risk of burns from the
hot viewing glass is provided with this appliance and shall
be installed for the protection of children and other at-risk
individuals.











GAS-FIRED

HOMEOWNER’S MANUAL
41362-0-0120
TABLE OF CONTENTS
SECTION PAGE

 4
 5
6-7

 9
 
 11
 
41362-0-0120 
WARNING





Figure 1

COMBUSTIBLE MATERIAL
41362-0-0120Page 4
LIGHTING INSTRUCTIONS
Figure 2
TO TURN OFF GAS TO FIREPLACE
 
 
 
       

 



 
 
          

 
        





 



 
           
          

FOR YOUR SAFETY READ BEFORE LIGHTING
INTERMITTENT PILOT LIGHTING INSTRUCTIONS (BP7 SERIES)
 



 



 
 
 
       

 

 

-


 



 

 

 

 
WARNING
If you do not follow these instructions exactly, a re or explosion may result causing property damage,
personal injury or loss of life.
41362-0-0120 Page 5
IPI ELECTRONIC SYSTEM OPERATING INSTRUCTIONS (BP7 SERIES)
ELECTRONIC CONTROL VALVE


 IPI Mode



 CPI Mode



NOTICE: 
 
 See Figure 3.
NOTICE: 
 
 See Figure
3.
 
 
OPTIONAL REMOTE CONTROLS


MANUAL
HI/LO
REGULATOR
GAS VALVE
MANUAL ON/OFF SWITCH
PILOT SELECTOR SWITCH
IPI-INTERMITANT PILOT (LEFT)
CPI-CONTINUOUS PILOT (RIGHT)
AA (4)
BATTERY
BACKUP
Figure 3
41362-0-0120Page 6
MAINTENANCE AND SERVICE
NOTICE:










IMPORTANT: 








WARNING
H
andle the glass with care to avoid
breaking it. Never strike
the glass. To prevent etching or discoloring, clean the glass
with Fireplace Glass Cleaner (available from your dealer).
Never use cleaners that contain ammonia or abrasives. Never
clean the glass while it is hot or even warm. Touching hot glass
can cause severe burns. Using liquids or aerosols on hot glass
will cause it to shatter. Never operate the replace with the
glass removed or cracked. Have your dealer replace damaged
glass only with glass and gasket material from Empire Comfort
Systems. Using substitute glass will void the warranty.
Glass Cleaning Procedure

Wear clean protective gloves when handling the glass door
to prevent injury to your hands and avoid leaving smudges.
 
 
See Figure 2.
 


 

 

 
 (Do not use glass cleaner that
contains ammonia.)
 

See Figure 6.
 

 (Heat from
the replace can cause residue on the frame to discolor
the nish.)
 (See Lighting Instructions on page 4.)
 


 

Glass Cleaning









General Glass Information
WARNING
Do not operate appliance with the glass front removed,
cracked or broken.





CAUTION
The use of substitute glass will void all product warranties.
Care must be taken to avoid breakage of the glass. Under no
circumstances should this appliance be operated without
the glass front or with a broken glass front. Replacement
of the glass (with gasket) as supplied by the manufacturer
should be done by a qualied service person.
CAUTION
Do not use Ammonia based or abrasive cleaners on
glass. Do not attempt to clean glass when glass is hot.
41362-0-0120 Page 7
MAINTENANCE AND SERVICE
Glass Door & Barrier Screen Removal
NOTE: Do not handle barrier screen or door with your bare
hands! (Always Wear Gloves)
 
Figure 4
Figure 5
 


 


Install Glass Door and Barrier Screen
 

Figure 6.
Important: Do not allow the gasket across the top of the
door to roll up on top of the rebox ange as shown in
“Incorrect” view in Figure 6.
 




 


 

FIREBOX
TOP
CORRECT
FIREBOX
TOP
GASKET
INCORRECT
Figure 6
41362-0-0120
IMPORTANT SAFETY INFORMATION
For the Homeowner
• 



• 



• 



• 


• 


• 




• 






• 



• 






• 

Annual Inspection
• 
• 


During the annual checkup, the technician will:
 

 
 

 


 
See Figure 4.
 

See Figure 6.
 

 
 

 

• Inaddition,cleanandinspectthereplacefollowingany
remodelingworkinyourhome.
41362-0-0120 Page 9
APPLIANCE SERVICE HISTORY
Date Dealer Name Service Technician Name Service Performed/Notes
41362-0-0120
SAFETY INFORMATION FOR USERS OF PROPANE GAS
Propane is a ammable gas which can cause res and
explosions. In its natural state, propane is odorless and
colorless. You may not know all the following safety
precautions which can protect both you and your family
from an accident. Read them carefully now, then review
them point by point with the members of your house-
hold. Someday when there may not be a minute to lose,
everyone’s safety will depend on knowing exactly what
to do. If, after reading the following information, you feel
you still need more information, please contact your gas
supplier.
PROPANE GAS WARNING ODOR
If a gas leak happens, you should be able to smell the
gas because of the odorant put in the Propane Gas.
That’s your signal to go into immediate action!
 

 

 


        


   



 Finally,-



NO ODOR DETECTED - ODOR FADE
Some people cannot smell well. Some people cannot
smell the odor of the chemical put into the gas. You
must nd out if you can smell the odorant in propane.






The odorant in Propane Gas is colorless, and it can fade
under some circumstances.      








-




SOME POINTS TO REMEMBER
 Learn to recognize the odor of Propane Gas.




 
-









 




        
          


If you have any question
about the gas odor, call your Propane Gas Dealer.
A periodic sniff test of the Propane Gas is a good
safety measure under any condition.





 
-








41362-0-0120 Page 11
REQUIREMENTS FOR THE COMMONWEALTH OF MASSACHUSETTS

        
        
   
   



    

      
        
       
         
   
       
      
         
        
       
        


       




 
         

      



    
      
      
         

 


       


“GAS VENT DIRECTLY BELOW. KEEP CLEAR OF
ALL OBSTRUCTIONS”.
     

      

 

 

       



 
       



    
   
  
  




     


 
      
        

 
  
      
      
      

41362-0-0120
WARRANTY




Limited Lifetime Parts Warranty – Combustion Chamber, Heat Exchanger, and Factory-Installed Glass
 

Limited Three-Year Parts Warranty – All Other Components
(Except Remote Controls, Thermostats, Accessories and Replacement Parts)


Limited One-Year Parts Warranty – Remote Controls, Thermostats, Accessories, and Parts


Duties Of The Owner



What Is Not Covered






How To Get Service







Your Rights Under State Law

www.empirecomfort.com
Empire Comfort Systems Inc.
Belleville, IL





/