GE PVB98STSS Operating instructions

GE
Brand
GE
Model
PVB98STSS
Type
Operating instructions

This manual is also suitable for




PVB94
PVB98
ZVB30
ZVB36
31-10728-3
07-11 GE




Use this unit only in the manner intended by
the manufacturer. If you have questions, contact
the manufacturer.
 Before service or cleaning unit, switch power
o at service panel and lock the service
disconnecting means to prevent power from
being switched on accidentally. When the
service disconnecting means cannot be locked,
securely fasten a prominent warning device,
such as a tag, to the service panel.
• Do not attempt to repair or replace any part
of the downdraft system unless it is specically
recommended in this book. All other servicing
should be performed by a qualied technician.
• For general ventilating use only. Do not use
to exhaust hazardous or explosive materials
and vapors.
• Installation work and electrical wiring must
be done by a qualied person(s), in accordance
with all applicable codes and standards including
re-rated construction.
To reduce the risk of re
and to properly exhaust air, be sure to duct air
outdoors. Do not vent exhaust air into spaces
within walls or ceilings or into attics, crawl spaces
or garages.


•
 – Save these instructions
for local inspector’s use.
•
 – Observe all governing
codes and ordinances.
•
 Be sure to leave these
instructions with the consumer.
•
 Keep these instructions
for future reference.
•
 Installation of these vents require
basic mechanical and electrical skills.
•
 
• Proper installation is the responsibility of the
installer. Product failure due to improper
installation is not covered under the warranty.
If you received a damaged vent, you should
immediately contact your dealer or builder.







This appliance must be properly grounded.






Product Dimensions ................................................................3
Accessories ..................................................................................3
Advance Planning ............................................................... 4, 5

Clearances ..............................................................................6, 7
Parts Supplied ............................................................................7
Tools and Materials Required .............................................7
Remove Packaging ..................................................................7
Power Supply ..............................................................................8
Venting Options .........................................................................9

Duct Fittings ............................................................................. 10

Step 1, Install Downdraft Vent ......................................... 11
Step 2, Install the Ductwork .............................................. 11
Step 3, Install Remote Switch ........................................... 12
Step 4, Connect Power ........................................................ 13
Step 5, Install Filters, Check Operation ........................ 13
Cleaning ..................................................................................... 13


30" Models 30" 28-5/16"
36" Models 36" 33-15/16"

 – Optional accessory for indoor remote
location of the blower/motor assembly. Use this kit
when the blower and motor assembly will be located
outside of the cabinet, such as below the cabinet oor.
'HVLJQ,QIRUPDWLRQ
$'9$1&(3/$11,1*
5HPRWH6ZLWFK
7KHDQG0RQRJUDPPRGHOVDQGWKH
DQG3UR¿OHPRGHOVKDYHDVHSDUDWHUDLVHORZHU
VZLWFK3ODQWRLQVWDOOWKHVZLWFKLQDFRQYHQLHQW
ORFDWLRQRXWVLGHRIWKHYHQWFRRNWRSFXWRXW
'RZQGUDIW9HQWDQG&RRNWRS&XWRXW
7KHLQVWDOODWLRQRIWKHVHGRZQGUDIWYHQWVZLWK
DQ\*(RU0RQRJUDPFRRNWRSUHTXLUHVFDUHIXO
FRQVLGHUDWLRQ%HIRUH\RXEHJLQUHYLHZWKH
FRPELQDWLRQFXWRXWLOOXVWUDWLRQVRQSDJH
&RXQWHUWRS5HTXLUHPHQWV
7KHFRXQWHUWRSPXVWKDYHDGHHSÀDWVXUIDFH
WRDFFRPPRGDWHWKHFRRNWRSDQGWKHYHQW
&RXQWHUWRSVZLWKDUROOHGIURQWHGJHDQGEDFNVSODVK
PD\QRWSURYLGHWKHÀDWVXUIDFHDUHDUHTXLUHG
%DVH&DELQHW5HTXLUHPHQWV
7KHEDVHFDELQHWPXVWEHGHHSHQRXJKWR
DFFRPPRGDWHWKHPLQLPXPFOHDUDQFHWRWKHIURQW
RIWKHFRXQWHUWRSWKHFRRNWRSEXUQHUER[
DQGWKHYHQW
%HIRUH\RXEHJLQ\RXPXVW
5HYLHZFRXQWHUWRSGLPHQVLRQLOOXVWUDWLRQVWR
EHVXUH\RXZLOOKDYHHQRXJKÀDWFRXQWHUWRS
VXUIDFH
&KHFNWREHVXUHWKDWWKHWRWDOFRXQWHUWRSGHSWK
UHTXLUHGLQFOXGLQJPLQLPXPFXWRXWWRIURQWHGJH
GHSWKDOORZVHQRXJKVSDFHIRUDEDFNVSODVK
5HYLHZWKHFDELQHWLOOXVWUDWLRQ&KHFNWREHVXUH
WKHLQWHULRUFDELQHWGHSWKZLOOKRXVHWKHFRRNWRS
EXUQHUER[WKHYHQWDQGWKHFXWRXWFOHDUDQFH
IURPWKHIURQW
:KHQFRXQWHUWRSDQGFDELQHWGHSWKSUHVHQW
DSUREOHPUHYLHZ&UHDWLYH6ROXWLRQV
5HDGWKLVERRNFRPSOHWHO\WRDFFXUDWHO\SODQ
WKHLQVWDOODWLRQORFDWLRQFOHDUDQFHVDQG
GXFWZRUNUHTXLUHPHQWV
:LWKFDUHIXOSODQQLQJ\RXFDQDFKLHYHDFXVWRP
ORRNZLWKPLQLPDODGMXVWPHQWV
&UHDWLYH6ROXWLRQV
:KHQWKHNLWFKHQGHVLJQFDOOVIRUDQDJDLQVW
WKHZDOOLQVWDOODWLRQPRYHWKHEDVHFDELQHW
IRUZDUGWR)LOOHUSDQHOVRUFRPSOHPHQWDU\
PROGLQJVFDQEHDGGHGWRH[SRVHGFDELQHWVLGHV
,QDQLVODQGRUSHQLQVXODXVHDQH[WUDGHHS
FRXQWHUWRS7KHFRXQWHUWRSRYHUKDQJDWWKH
IURQWFDQEHDGMXVWHGWRPHHWVHWEDFNWRFXWRXW
UHTXLUHPHQWV
:KHQWKHFXWRXWWRWKHIURQWHGJHRIWKH
FRXQWHUWRSUHTXLUHPHQWLVPRUHWKDQDGG
DEXOOQRVHWULPWRWKHIURQWHGJHRIWKH
FRXQWHUWRS,QFOXGHWKHWULPWKLFNQHVVZKHQ
PHDVXULQJWKHIURQWHGJHWRFXWRXWUHTXLUHPHQW
%\DGGLQJWKHWULPWKHFRRNWRSFDQEHPRYHG
IRUZDUGSURYLGLQJDGGLWLRQDOFRXQWHUWRSGHSWK
DQGLQWHULRUFDELQHWVSDFH
Cover Panel
End
Panel
Countertop
Overhang
per Cooktop
Clearances
Must be
Maintained
Base
Cabinet
Filler Panel
Base Sink
Filler Panel
Maintain Cutout Clearances
to Front Edge as Specified
'HVLJQ,QIRUPDWLRQ
&OHDUDQFHV
7KHGRZQGUDIWV\VWHPZLWKEORZHUPRWRU
DQGGXFWZRUNZLOORFFXS\WKHFDELQHWEHORZ
WKHFRXQWHUWRSDQGFRRNWRS
7KHEORZHUPRWRUDVVHPEO\FDQEHORFDWHG
EHORZWKHFDELQHWÀRRU7KHDVVHPEO\ZLOO¿W
EHWZHHQÀRRUMRLVWV2UGHU-;5%IRULQGRRU
UHPRWHORFDWLRQV
5HIHUWR\RXUVSHFL¿FFRRNWRSLQVWDOODWLRQ
LQVWUXFWLRQIRUDSSURSULDWHFOHDUDQFHV
,QVWDOODWLRQPXVWFRQIRUPZLWKORFDOFRGHV
'XFWZRUN
3UHSDUHGXFWZRUNWRYHQWWRWKHRXWGRRUV
8VHWKHVKRUWHVWDQGVWUDLJKWHVWGXFWUXQSRVVLEOH
7KHPD[LPXPSHUPLVVLEOHHTXLYDOHQWOHQJWKIRU
GXFWUXQLVIHHW
5HIHUWR´'XFW)LWWLQJVµFKDUWWRFDOFXODWH
HTXLYDOHQWOHQJWKIRUYDULRXVGXFWFRQ¿JXUDWLRQV
7KHGRZQGUDIWEORZHUV\VWHPLVGHVLJQHGWRXVH
[GXFWZRUN,WFDQEHWUDQVLWLRQHGWR
URXQG
'XFWZRUN0867EHYHQWHGWRWKHRXWVLGH²QHYHU
LQWRDFUDZOVSDFHDWWLFRURWKHUHQFORVHGVSDFH
'HWHUPLQHWKHQHHGIRUDZDOOFDSRUURRIFDS
2UGHUWKHFDSLQDGYDQFH
(OHFWULFDODQG*DV/RFDWLRQV
3ODQWKHSODFHPHQWRIWKHHOHFWULFDORXWOHWDQGJDV
FRQQHFWLRQVLIXVHGFDUHIXOO\(OHFWULFDORXWOHWVDQG
JDVFRQQHFWLRQVFDQQRWEHSODFHGRQWKHEDFNZDOO
RIWKHFDELQHWEHFDXVHLWPD\LQWHUIHUHZLWKWKH
GRZQGUDIWSOHQXP5HIHUWR32:(56833/<VHFWLRQ
IRULQIRUPDWLRQRQORFDWLRQRIHOHFWULFDODQGJDV
FRQQHFWLRQV
,QVWDOODVWDQGDUGHOHFWULFDORXWOHWZLWKLQUHDFKRI
WKHYHQW·VWZRIRRWORQJSRZHUFRUG
7KHYHQWDQGD*(RU0RQRJUDPJDVFRRNWRS
FRPELQDWLRQFDQRSHUDWHIURPWKHVDPHYROW
VWDQGDUGGXSOH[RXWOHW
(OHFWULFFRRNWRSVPXVWRSHUDWHIURPDVHSDUDWH
YROWMXQFWLRQER[
$HOERZQRWVXSSOLHGFDQEHLQVWDOOHGRQWRWKH
LQOHWRIWKHJDVFRRNWRSDQGURXWHWKHJDVFRQQHF
WLRQVWRDYRLGLQWHUIHUHQFHZKHQLQVWDOOHGZLWKD
GRZQGUDIWYHQWRURWKHUFDELQHWU\IHDWXUHV
,QVWDOODWLRQ3UHSDUDWLRQ
&872876$1'&/($5$1&(6
0HDVXUHFDUHIXOO\ZKHQFXWWLQJWKHFRXQWHUWRS
0DNHVXUHVLGHVRIWKHRSHQLQJDUHSDUDOOHODQG
UHDUDQGIURQWFXWVDUHH[DFWO\SHUSHQGLFXODU
ULJKWDQJOHVWRWKHVLGHV
0HDVXUHWREHVXUHWKHUHLVURRPIRUFOHDUDQFHV
WRWKHIURQWHGJHRIWKHFRXQWHUWRS
5HIHUWRFRRNWRSLQVWDOODWLRQLQVWUXFWLRQVWREH
VXUHWKDWPRGHOV¿WLQWRWKHEDVHFDELQHWVEHLQJ
XVHG
'UDZOLQHVRQWKHFRXQWHUWRSWRIROORZDVD
FXWWLQJJXLGH
0HDVXUHDQGPDUNFRRNWRSDQGYHQWRYHUODSVWR
EHVXUHWKHUHLVHQRXJKÀDWFRXQWHUWRSGHSWK
&22.723$1''2:1'5$)7
&20%,1$7,21
7KHFRRNWRSPXVWEHLQVWDOOHGSHUPDQXIDFWXUHU·V
LQVWDOODWLRQLQVWUXFWLRQV
,03257$177KHFRXQWHUWRSFXWRXWGHSWKUHTXLUHV
PLQLPXPÀDWFRXQWHUWRSVXUIDFHDQG
PLQLPXPWRWDOFRXQWHUWRSGHSWK
127(%HIRUH\RXEHJLQPHDVXUHDQGPDUNGHSWK
WRHQVXUHWKDWDGHTXDWHÀDWFRXQWHUWRSVXUIDFH
LVDYDLODEOH
)RUFRRNWRSDQGGRZQGUDIWFRPELQDWLRQGHSWK
)ROORZFRRNWRSLQVWDOODWLRQLQVWUXFWLRQVIRUFRRNWRS
DQGGRZQGUDIWFRPELQDWLRQLQVWDOODWLRQ
2WKHUZLVHDGGWRWKHFRRNWRSFXWRXWGHSWK
127($GGWRWKHFRRNWRSFXWRXWGHSWKIRU
-3DQG-3
5HTXLUHGWRPDLQWDLQ8/RU&6$DSSURYDOV


0LQLPXP

0LQLPXPÀDWFRXQWHU
WRSEHKLQGFXWRXWUHTXLUHG
&22.723$1''2:1'5$)7
&20%,1$7,21
,03257$177KHFRXQWHUWRSFXWRXWGHSWKUHTXLUHV
PLQLPXPÀDWFRXQWHUWRSVXUIDFHDQG
PLQLPXPWRWDOFRXQWHUWRSGHSWK
127(%HIRUH\RXEHJLQPHDVXUHDQGPDUNGHSWK
WRHQVXUHWKDWDGHTXDWHÀDWFRXQWHUWRSVXUIDFH
LVDYDLODEOH
)RUFRRNWRSDQGGRZQGUDIWFRPELQDWLRQGHSWK
)ROORZFRRNWRSLQVWDOODWLRQLQVWUXFWLRQVIRUFRRNWRS
DQGGRZQGUDIWFRPELQDWLRQLQVWDOODWLRQ
2WKHUZLVHDGGWRWKHFRRNWRSFXWRXWGHSWK
127($GGWRWKHFRRNWRSFXWRXWGHSWKIRU
-3DQG-3
5HTXLUHGWRPDLQWDLQ8/RU&6$DSSURYDOV


0LQLPXP

0LQLPXPÀDWFRXQWHU
WRSEHKLQGFXWRXWUHTXLUHG
,QVWDOODWLRQ3UHSDUDWLRQ
3$5766833/,('
2SHQWKHFDUWRQDQGUHPRYHSDUWVSDFNDJH
&KHFNFRQWHQWVWREHVXUHDOOSLHFHVDUHSUHVHQW
722/6$1'0$7(5,$/65(48,5('
/DUJHÀDWEODGHVFUHZGULYHU
-LJVDZ
&DUSHQWHU·VVTXDUH
'XFWZRUNWRVXLWWKHLQVWDOODWLRQ
/HYHO
5(029(3$&.$*,1*
5HPRYHWKHVKLSSLQJPDWHULDOVDQGWKHFDUWRQ
VHWFDUWRQDVLGH7KHFDUWRQFDQEHXVHGDVDSDG
ZKHQFKDQJLQJRUDGMXVWLQJYHQWGLUHFWLRQ
6WDELOL]LQJ%UDFNHWV
:LWK6FUHZV
5HPRWH6ZLWFK
)LOWHUV
:LUHDQG:KLWH
&RQQHFWRU
,QVWDOODWLRQ3UHSDUDWLRQ
,03257$17
3OHDVHUHDGFDUHIXOO\
7KHSRZHUFRUGRIWKLVDSSOLDQFHLVHTXLSSHG
ZLWKDWKUHHSURQJJURXQGLQJSOXJZKLFKPDWHV
ZLWKDVWDQGDUGWKUHHSURQJJURXQGLQJZDOO
UHFHSWDFOHWRPLQLPL]HWKHSRVVLELOLW\RIHOHFWULF
VKRFN7KHFXVWRPHUVKRXOGKDYHWKHZDOO
UHFHSWDFOHDQGFLUFXLWFKHFNHGE\DTXDOL¿HG
HOHFWULFLDQWRPDNHVXUHWKHUHFHSWDFOHLV
SURSHUO\JURXQGHGDQGKDVFRUUHFWSRODULW\
:KHUHDVWDQGDUGWZRSURQJZDOOUHFHSWDFOH
LVHQFRXQWHUHGLWLVWKHSHUVRQDOUHVSRQVLELOLW\
DQGREOLJDWLRQRIWKHFXVWRPHUWRKDYHLW
UHSODFHGZLWKDSURSHUO\JURXQGHGWKUHHSURQJ
ZDOOUHFHSWDFOH
'RQRWXQGHUDQ\FLUFXPVWDQFHVFXWRUUHPRYH
WKHWKLUGJURXQGSURQJIURPWKHSRZHUFRUG
'212786($1(;7(16,21&25'
:$51,1*6+2&.+$=$5'
)253(5621$/6$)(7<7+,6$33/,$1&(0867
%(3523(5/<*5281'('
5HPRYHKRXVHIXVHRURSHQFLUFXLWEUHDNHUEHIRUH
EHJLQQLQJLQVWDOODWLRQ
'RQRWXVHDQH[WHQVLRQFRUGRUDGDSWHUSOXJ
ZLWKWKLVDSSOLDQFH)ROORZ1DWLRQDO(OHFWULFDO&RGH
RUSUHYDLOLQJORFDOFRGHVDQGRUGLQDQFHV
7KLVGRZQGUDIWYHQWPXVWEHVXSSOLHGZLWK9
+]DQGFRQQHFWHGWRDQLQGLYLGXDOSURSHUO\
JURXQGHGEUDQFKFLUFXLWSURWHFWHGE\D
RUDPSHUHFLUFXLWEUHDNHURUWLPHGHOD\IXVH
$SURSHUO\JURXQGHGSURQJUHFHSWDFOHVKRXOG
EHORFDWHGZLWKLQUHDFKRIWKHYHQW·VWZRIRRWSRZHU
FRUG

*DV&RRNWRSV
,IWKLVYHQWLVLQVWDOOHGLQFRPELQDWLRQZLWKD*(
RU0RQRJUDPJDVFRRNWRSLWPD\RSHUDWHIURP
WKHVDPHGXSOH[RXWOHW

(OHFWULF&RRNWRSV
,IWKLVYHQWLVLQVWDOOHGLQFRPELQDWLRQZLWKD*(
RU0RQRJUDPHOHFWULFFRRNWRSWKHYHQWPXVW
RSHUDWHIURPDVHSDUDWH9RXWOHW
/RFDWHWKHUHFHSWDFOHLQVLGHWKHFDELQHWRQWKHULJKW
VLGHZDOOVHHLOOXVWUDWLRQ7KHUHFHSWDFOHFDQQRWEH
SODFHGRQWKHEDFNRIWKHFDELQHWZDOOZKHUHLWPD\
LQWHUIHUHZLWKWKHGRZQGUDIWSOHQXP
7KHGRZQGUDIWYHQWSRZHUFRUGLVWREHURXWHG
EHQHDWKWKHFRRNWRSDQGURXWHGDZD\IURPKHDW
JHQHUDWHGE\WKHFRRNWRS
(QVXUHWKDWWKHFRRNWRSLVLQVWDOOHGSHU
PDQXIDFWXUHU·VLQVWDOODWLRQLQVWUXFWLRQV
32:(56833/<
/RFDWHWKH*DVRU(OHFWULFDO
&RQQHFWLRQ2QO\:LWKLQWKH
6KDGHG$UHD
'2127/RFDWH
*DVRU(OHFWULFDO
&RQQHFWLRQVZLWKLQ
WKLV$UHD
IRU0RGHOV
IRU0RGHOV


(OHFWULFDO
2XWOHW
$ERYH
&DELQHW
)ORRU
,QVWDOODWLRQ3UHSDUDWLRQ
9(17,1*237,216
7KHGRZQGUDIWYHQWLVVKLSSHGZLWKWKH
GLVFKDUJHRXWOHWSRLQWLQJVWUDLJKWGRZQ
DQGFDQEHFKDQJHGWRWKHOHIWRUULJKW
VLGH
7KHEORZHURXWOHWLVVL]HGIRU[
DQGFDQEHWUDQVLWLRQHGWRURXQG
6LGHWR6LGH$GMXVWPHQWV
7KHHQWLUHEORZHUPRXQWLQJSODWHFDQEH
DGMXVWHGWRWKHOHIWRUULJKW7KLVZLOO
KHOSWRDOLJQYHQWGLVFKDUJHWRKRXVH
GXFWZRUN
'LVFKDUJH'LUHFWLRQ
7KHEORZHUDVVHPEO\PD\EHUHPRYHGDQGWXUQHG
IRUDOHIWRUULJKWVLGHGLVFKDUJH
$OHIWRUULJKWGLUHFWLRQDGMXVWPHQWVKRXOGEH
SHUIRUPHGEHIRUHGURSSLQJLQWRWKHFRXQWHUWRS
RSHQLQJ
)ODWWHQWKHVKLSSLQJER[WRXVHDVDSDG
/D\WKHYHQWRQLWVEDFNDQGRQWRWKHSDG
7RFKDQJHWRDOHIWRUULJKWGLVFKDUJH
5HPRYHWKHVFUHZVKROGLQJWKHEORZHUDQG
WKHPRXQWLQJSODWHDVVHPEO\WRWKHGRZQGUDIW
YHQW5HWDLQVFUHZV
5HPRYHEORZHUDVVHPEO\WXUQLWRYHUWRDFFHVV
WKHQXWVKROGLQJWKHEORZHUWRWKHPRXQWLQJ
SODWH5HPRYHWKHQXWV
,03257$17'RQRWOLIWPRWRUE\WKHSRZHUFDEOH
7XUQWKHEORZHUWRWKHOHIWRUULJKWGLVFKDUJH
GLUHFWLRQDQGUHLQVWDOOWKHQXWV
5HLQVWDOOEORZHUDQGPRXQWLQJSODWHZLWKRULJLQDO
VFUHZV
7RORFDWHWKHGXFWZRUNKROHVLQWKHFDELQHW
ÀRRURUVLGHZDOOV
7HPSRUDULO\SODFHYHQWLQWRWKHFRXQWHUWRS
RSHQLQJ
3XVKWKHYHQWDOOWKHZD\WRWKHEDFNRIWKH
RSHQLQJ
,I\RXDUHWUDQVLWLRQLQJWRURXQGREWDLQHG
ORFDOO\SODFHWUDQVLWLRQSLHFHRYHUWKHGLVFKDUJH
RXWOHW
0DUNWKHORFDWLRQDQGUHPRYHWKHDVVHPEO\
&XWKROHVDQGLQVWDOOGXFWZRUNFRQQHFWLRQV
2UGHU-;5%IRULQVWDOODWLRQRIWKHEORZHUDQG
PRWRUEHORZWKHÀRRU
'LVFKDUJH'RZQ
$V6XSSOLHG
/RRVHQ6FUHZV
WR$GMXVW
WR
/HIWRU5LJKW
'LVFKDUJH'RZQ
$V6XSSOLHG
'LVFKDUJH/HIW
'LVFKDUJH5LJKW

,QVWDOODWLRQ3UHSDUDWLRQ
'8&7
),77,1*6
8VH[
GXFW,WFDQ
WUDQVLWLRQWR
URXQG
7RWDO
(TXLYDOHQW 4XDQWLW\ (TXLYDOHQW
'XFW3LHFH 'LPHQVLRQV /HQJWK 8VHG /HQJWK
IW
URXQG SHUIRRW
VWUDLJKW OHQJWK
IW
ø[ SHUIRRW
VWUDLJKW OHQJWK

HOERZ IW

HOERZ IW
ø[
HOERZ IW
ø[
HOERZ IW
ø[
ÀDWHOERZ IW
URXQG
WRø[
WUDQVLWLRQ IW
ø[
URXQGWR
WUDQVLWLRQ IW
URXQGWR
ø[
WUDQVLWLRQ
HOERZ IW
ø[WR
URXQGWUDQVLWLRQ
HOERZ IW
URXQG
ZDOOFDS
ZLWKGDPSHU IW
ø[
ZDOOFDS
ZLWKGDPSHU IW
URXQG
URRIFDS IW
7RWDO'XFW5XQ
8VHWKLVFKDUWWR
FRPSXWHPD[LPXP
SHUPLVVLEOHOHQJWKV
IRUGXFWUXQVWR
RXWGRRUV
127('RQRWH[FHHG
PD[LPXPSHUPLVVLEOH
HTXLYDOHQWOHQJWKV
'RZQGUDIW9HQW
PD[LPXP
HTXLYDOHQWOHQJWK
)OH[LEOHGXFWLQJ
,IÀH[LEOHPHWDO
GXFWLQJLVXVHGDOOWKH
HTXLYDOHQWIHHWYDOXHV
LQWKHWDEOHVKRXOGEH
GRXEOHG7KHÀH[LEOH
PHWDOGXFWVKRXOGEH
VWUDLJKWDQGVPRRWK
DQGH[WHQGHGDVPXFK
DVSRVVLEOH
'2127XVHÀH[LEOH
SODVWLFGXFWLQJ
$FWXDOOHQJWKRIVWUDLJKWGXFWSOXVGXFW¿WWLQJ
HTXLYDOHQW(TXLYDOHQWOHQJWKRIGXFWSLHFHVLVEDVHG
RQDFWXDOWHVWVFRQGXFWHGE\*((YDOXDWLRQ(QJLQHHULQJ
DQGUHÀHFWUHTXLUHPHQWVIRUJRRGYHQWLQJSHUIRUPDQFH
ZLWKDQ\GRZQGUDIWFRRNWRS
127($Q\KRPH
YHQWLODWLRQV\VWHP
VXFKDVDFRRNWRSZLWK
DGRZQGUDIWH[KDXVW
PHFKDQLVPPD\
LQWHUUXSWWKHSURSHU
ÀRZRIFRPEXVWLRQDLU
DQGH[KDXVWUHTXLUHG
E\¿UHSODFHVJDV
IXUQDFHVJDVZDWHU
KHDWHUVDQGRWKHU
QDWXUDOO\YHQWHG
V\VWHPV7RPLQLPL]H
WKHFKDQFHRI
LQWHUUXSWLRQRIVXFK
QDWXUDOO\YHQWHG
V\VWHPVIROORZWKH
KHDWLQJHTXLSPHQW
PDQXIDFWXUHU·V
JXLGHOLQHVDQGVDIHW\
VWDQGDUGVVXFKDV
WKRVHSXEOLVKHGE\
1)3$DQG$6+5$(

,167$//'2:1'5$)79(17
$
2QHVWDELOL]LQJEUDFNHWPXVWEHLQVWDOOHGRQ
HDFKVLGHRIWKHGRZQGUDIWYHQW
)RUULJKWVLGHRUVWUDLJKWGRZQEORZHU
GLVFKDUJHIDVWHQWKHVWDELOL]LQJEUDFNHWVDW
ORFDWLRQV$DQG%
)RUOHIWVLGHEORZHUGLVFKDUJHIDVWHQWKH
VWDELOL]LQJEUDFNHWVDWORFDWLRQV%DQG&
%
3ODFHWKHGRZQGUDIWYHQWLQWRWKHFRXQWHUWRS
FXWRXWVRWKDWWKHEDFNÀDQJHRIWKHYHQWLV
VLWWLQJRQWRSRIWKHFRXQWHUWRS
1RWH7KHGRZQGUDIWYHQWPD\QHHGWREH
WXUQHGDWDQDQJOHWR¿WLQWRWKHFRXQWHUWRS
FXWRXW
&
6HFXUHWKHVFUHZVIRUWKHVWDELOL]LQJEUDFNHWVWR
WKHFDELQHWEDFNZDOO
'
:KHQLQVWDOOLQJWKHGRZQGUDIWYHQWLQDWLOH
FRXQWHUWRSVXUIDFHLWPD\EHQHFHVVDU\WRDSSO\
DORFDOO\DSSURYHGFDXONLQJWRFRYHUDQ\JDSV
(
&KHFNWKDWWKHGRZQGUDIWYHQWLVYHUWLFDOO\OHYHO
2SHUDWHWKHYHQWWRWLPHVWRHQVXUHSURSHU
LQVWDOODWLRQ
,QVWDOODWLRQ,QVWUXFWLRQV
,167$//'8&7:25.
7KHGRZQGUDIWEORZHUV\VWHPLVGHVLJQHGIRUXVH
ZLWK[GXFWZRUN,WFDQEHWUDQVLWLRQHG
WRURXQG
'XFWZRUN0867EHYHQWHGWRWKHRXWVLGH³QHYHU
LQDFUDZOVSDFHDWWLFRURWKHUHQFORVHGVSDFH
39&GXFWVKRXOGEHXVHGZKHQLQVWDOOLQJXQGHU
DFRQFUHWHVODE
127(/RFDOEXLOGLQJFRGHPXVWEHIROORZHG
IRULQVWDOODWLRQLQVSHFLI\LQJDSSURYHGW\SHDQG
VFKHGXOHRI39&GXFWXVHG
'212786(ÀH[LEOHSODVWLFGXFWLQJ
$OZD\VXVHDSSURSULDWHURRIRUZDOOFDSZLWK
GDPSHU/DXQGU\W\SHZDOOFDSVVKRXOGQHYHU
EHXVHG
8VHWKHVWUDLJKWHVWGXFWUXQSRVVLEOH
)RUVDWLVIDFWRU\SHUIRUPDQFHWKHGXFWUXQVKRXOG
QRWH[FHHGIWRULWVHTXLYDOHQWOHQJWKZKHQ
EHQGVRUYDULRXV¿WWLQJVDUHXVHG5HIHUWRWKH
WDEOHRIHTXLYDOHQWOHQJWKVWRFDOFXODWH\RXULQVWDO
ODWLRQ
,QVWDOOGXFWZRUNVRWKHSLHFHRIGXFWQHDUHVWWKH
GRZQGUDIWXQLWVORWV,172WKHQH[WSLHFHRIWKH
GXFW6HFXUHWKHMRLQWVZLWKVHOIWDSSLQJVFUHZV
DQGDSSO\GXFWWDSHDURXQGWKHMRLQWVWRHQVXUHDQ
DLUWLJKWVHDO
Duct Tape
Over Seam and Screw
Screw
Air
Flow
%UDFNHW
&DELQHW%DFN
:DOO
'RZQGUDIW9HQW
/RFDWLRQ$
7239,(:
$
&
%
$
&

,QVWDOODWLRQ,QVWUXFWLRQV
,167$//5(027(6:,7&+
&RQQHFW:LUH/HDGWR&RQWURO%R[
&RQQHFWWKHPDWLQJZLUHHQGV
3ODFHWKHDGKHVLYHZLUHFODPSVSURYLGHGQHDU
WKHPDWLQJFRQQHFWRU
.HHSDSSUR[LPDWHO\ORQJZLUHDQGDWWDFK
WKHZLUHWRWKHFODPSZLWKDZLUHWLH7KLVZLOODFW
DVDVWUDLQUHOLHI
 'ULOODGLDKROHLQWRWKHGHVLUHGORFDWLRQ8VH
WKHPRXQWLQJEUDFNHWDVDWHPSODWHWRORFDWHWKH
KROHDFFXUDWHO\&KHFNIRULQWHUIHUHQFHEHWZHHQ
WKHVZLWFKFRYHUDGMDFHQWREMHFWVDQGFRRNWRS
YHQWRYHUODSV
 ,IVZLWFKLVPRXQWHGLQWRDWLOHVXUIDFHGULOOWKH
KROHEHWZHHQWLOHV8VHORFDOO\DSSURYHGFDXONLQJ
WRFRYHUDQ\JDSV
 ,IWKHUHPRWHVZLWFKLVQRWLQVWDOOHGRQWKHFRXQ
WHUWRSHQVXUHWKDWLWLVLQVWDOOHGLQDORFDWLRQWKDW
PHHWVORFDOFRGHVDQGLVHDVLO\DFFHVVLEOH
&RQQHFW5HPRWH6ZLWFKWR5HPRWH+DUQHVV
7KUHDGWKHUHPRWHKDUQHVVWKURXJKWKHGLD
KROHDQGDWWDFKWKHKDUQHVVFRQQHFWRUWRWKH
UHPRWHFRQQHFWRU
5HPRYHWKHSDSHUEDFNLQJRQWKHUHPRWHVZLWFK
IRDPSLHFHDQGPRXQWWKHUHPRWHVZLWFKRQWKH
FRXQWHUWRSVXFKWKDWWKHVZLWFKFRQQHFWRUVVWD\
ORFDWHGLQWKHGLDKROH
6WLFNDGKHVLYHZLUHFODPSQHDUWKHGLDKROH
DQGDWWDFKWKHORRVHZLUHZLWKDZLUHWLH
:$51,1*6+2&.+$=$5'
'LVFRQQHFWHOHFWULFDOSRZHUIURPXQLWEHIRUH
EHJLQQLQJVZLWFKLQVWDOODWLRQ)DLOXUHWRGRVRFRXOG
UHVXOWLQSHUVRQDOLQMXU\RUGDPDJHWRWKHHOHFWULFDO
FRQWUROV
:$51,1*%851+$=$5'
7KHUHPRWHVZLWFKPXVWEHORFDWHGVRWKDWLWFDQEH
RSHUDWHGZLWKRXWUHDFKLQJRYHUWKHFRRNWRS)DLOXUH
WRGRVRPD\UHVXOWLQLJQLWLRQRIFORWKLQJZKLFKFRXOG
FDXVHVHULRXVLQMXU\RUGHDWK
'HWHUPLQHWKHORFDWLRQIRUWKHUHPRWHVZLWFK
 7KHUHPRWHVZLWFKVKRXOGEHORFDWHGVRWKDWWKH
YHUWLFDOGLVWDQFHIURPWKHÀRRUWRWKHUHPRWH
VZLWFKLVOHVVWKDQDQGPRUHWKDQ
 7KHUHPRWHVZLWFKKDUQHVVLVORQJDQGVKRXOG
EHLQVWDOOHGVRWKDWLWLVQRWSLQFKHGDQGLVDZD\
IURPPRYLQJSDUWV
Control
Box
'LD+ROH
'LD
+ROH
)RDP3LHFH:LWK
$GKHVLYH0RXQWLQJ
6XUIDFH
)RDP3LHFH:LWK$GKHVLYH
0RXQWLQJ6XUIDFH
5HPRWH6ZLWFK
5HPRWH
6ZLWFK
6WUDLQ5HOLHI
$GKHVLYHZLUHFODPS
ZLWKWLH
5HPRWH
+DUQHVV
5HPRWH+DUQHVV
0DWLQJ&RQQHFWRUV
6WUDLQ5HOLHI
$GKHVLYHZLUH
FODPSZLWKWLH

,QVWDOODWLRQ,QVWUXFWLRQV
&211(&732:(5
3OXJSRZHUFRUGLQWRSURSHUO\JURXQGHGUHFHSWDFOH

,167$//),/7(56&+(&.23(5$7,21
3UHVVWKH212))SDGRQWKHFRQWURO
WRUDLVHWKHYHQW
6OLS¿QJHUVLQWRWKHYHQWKROHV/LIWWKHYHQW
VWUDLJKWXSDQGSXOOIRUZDUG
6OLGH¿OWHULQWRWKHUHWDLQHUVDQGFORVHWKHYHQW
3UHVVWKH)DQ6SHHG+,*+(5SDGWRVWDUWWKH
EORZHU$GMXVWWKHEORZHUE\SUHVVLQJ+,*+(5RU
/2:(5
7RORZHUWKHYHQWSUHVVWKH212))SDG
127(,WLVQRWQHFHVVDU\WRWXUQWKHIDQ2))
EHIRUHORZHULQJWKHYHQW7KHIDQZLOODXWRPDWLFDOO\
WXUQRȺZKHQWKHYHQWLVORZHUHG:KHQWKHIDQ
LVQRWWXUQHGRȺEHIRUHORZHULQJWKHYHQWLWZLOO
DXWRPDWLFDOO\FRPHRQDWWKHSUHYLRXVO\VHWVSHHG
ZKHQWKHYHQWLVIXOO\UDLVHG
,03257$177KHYHQWFDQEHDFWLYDWHGE\SUHVVLQJ
WKHSDGVRQWKHVZLWFK'RQRWXVHH[FHVVLYHIRUFH
RUVKDUSREMHFWVWRDFWLYDWHWKHVZLWFK'DPDJH
FRXOGRFFXUDQGYRLGWKHZDUUDQW\
)LOWHU7DEV
5HWDLQHUV

1RWHV

1RWHV

127(:KLOHSHUIRUPLQJLQVWDOODWLRQVGHVFULEHGLQWKLVERRN
VDIHW\JODVVHVRUJRJJOHVVKRXOGEHZRUQ
127(3URGXFWLPSURYHPHQWLVDFRQWLQXLQJHQGHDYRU
DW*HQHUDO(OHFWULF7KHUHIRUHPDWHULDOVDSSHDUDQFH
DQGVSHFL¿FDWLRQVDUHVXEMHFWWRFKDQJHZLWKRXWQRWLFH

*(
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16

GE PVB98STSS Operating instructions

GE
Brand
GE
Model
PVB98STSS
Type
Operating instructions
This manual is also suitable for
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents