GE PVB94DTBB Operating instructions









PVB94

PVB98

ZVB30

ZVB36

31-10728-3

07-11 GE











 Use this unit only in the manner intended by

the manufacturer. If you have questions, contact

the manufacturer.

 Before service or cleaning unit, switch power

o at service panel and lock the service

disconnecting means to prevent power from

being switched on accidentally. When the

service disconnecting means cannot be locked,

securely fasten a prominent warning device,

such as a tag, to the service panel.

• Do not attempt to repair or replace any part

of the downdraft system unless it is specically

recommended in this book. All other servicing

should be performed by a qualied technician.

• For general ventilating use only. Do not use

to exhaust hazardous or explosive materials

and vapors.

• Installation work and electrical wiring must

be done by a qualied person(s), in accordance

with all applicable codes and standards including

re-rated construction.

To reduce the risk of re

and to properly exhaust air, be sure to duct air

outdoors. Do not vent exhaust air into spaces

within walls or ceilings or into attics, crawl spaces

or garages.





•

 – Save these instructions

for local inspector’s use.

•

 – Observe all governing

codes and ordinances.

•

 Be sure to leave these

instructions with the consumer.

•

 Keep these instructions

for future reference.

•

 Installation of these vents require

basic mechanical and electrical skills.

•

 

• Proper installation is the responsibility of the

installer. Product failure due to improper

installation is not covered under the warranty.

If you received a damaged vent, you should

immediately contact your dealer or builder.















This appliance must be properly grounded.















Product Dimensions ................................................................3

Accessories ..................................................................................3

Advance Planning ............................................................... 4, 5



Clearances ..............................................................................6, 7

Parts Supplied ............................................................................7

Tools and Materials Required .............................................7

Remove Packaging ..................................................................7

Power Supply ..............................................................................8

Venting Options .........................................................................9



Duct Fittings ............................................................................. 10



Step 1, Install Downdraft Vent ......................................... 11

Step 2, Install the Ductwork .............................................. 11

Step 3, Install Remote Switch ........................................... 12

Step 4, Connect Power ........................................................ 13

Step 5, Install Filters, Check Operation ........................ 13

Cleaning ..................................................................................... 13



 

30" Models 30" 28-5/16"

36" Models 36" 33-15/16"



 – Optional accessory for indoor remote

location of the blower/motor assembly. Use this kit

when the blower and motor assembly will be located

outside of the cabinet, such as below the cabinet oor.



'HVLJQ,QIRUPDWLRQ

$'9$1&(3/$11,1*

5HPRWH6ZLWFK

7KHDQG0RQRJUDPPRGHOVDQGWKH

DQG3UR¿OHPRGHOVKDYHDVHSDUDWHUDLVHORZHU

VZLWFK3ODQWRLQVWDOOWKHVZLWFKLQDFRQYHQLHQW

ORFDWLRQRXWVLGHRIWKHYHQWFRRNWRSFXWRXW

'RZQGUDIW9HQWDQG&RRNWRS&XWRXW

7KHLQVWDOODWLRQRIWKHVHGRZQGUDIWYHQWVZLWK

DQ\*(RU0RQRJUDPFRRNWRSUHTXLUHVFDUHIXO

FRQVLGHUDWLRQ%HIRUH\RXEHJLQUHYLHZWKH

FRPELQDWLRQFXWRXWLOOXVWUDWLRQVRQSDJH

&RXQWHUWRS5HTXLUHPHQWV

7KHFRXQWHUWRSPXVWKDYHDGHHSÀDWVXUIDFH

WRDFFRPPRGDWHWKHFRRNWRSDQGWKHYHQW

&RXQWHUWRSVZLWKDUROOHGIURQWHGJHDQGEDFNVSODVK

PD\QRWSURYLGHWKHÀDWVXUIDFHDUHDUHTXLUHG

%DVH&DELQHW5HTXLUHPHQWV

7KHEDVHFDELQHWPXVWEHGHHSHQRXJKWR

DFFRPPRGDWHWKHPLQLPXPFOHDUDQFHWRWKHIURQW

RIWKHFRXQWHUWRSWKHFRRNWRSEXUQHUER[

DQGWKHYHQW

%HIRUH\RXEHJLQ\RXPXVW

5HYLHZFRXQWHUWRSGLPHQVLRQLOOXVWUDWLRQVWR

EHVXUH\RXZLOOKDYHHQRXJKÀDWFRXQWHUWRS

VXUIDFH

&KHFNWREHVXUHWKDWWKHWRWDOFRXQWHUWRSGHSWK

UHTXLUHGLQFOXGLQJPLQLPXPFXWRXWWRIURQWHGJH

GHSWKDOORZVHQRXJKVSDFHIRUDEDFNVSODVK

5HYLHZWKHFDELQHWLOOXVWUDWLRQ&KHFNWREHVXUH

WKHLQWHULRUFDELQHWGHSWKZLOOKRXVHWKHFRRNWRS

EXUQHUER[WKHYHQWDQGWKHFXWRXWFOHDUDQFH

IURPWKHIURQW

:KHQFRXQWHUWRSDQGFDELQHWGHSWKSUHVHQW

DSUREOHPUHYLHZ&UHDWLYH6ROXWLRQV

5HDGWKLVERRNFRPSOHWHO\WRDFFXUDWHO\SODQ

WKHLQVWDOODWLRQORFDWLRQFOHDUDQFHVDQG

GXFWZRUNUHTXLUHPHQWV

:LWKFDUHIXOSODQQLQJ\RXFDQDFKLHYHDFXVWRP

ORRNZLWKPLQLPDODGMXVWPHQWV

&UHDWLYH6ROXWLRQV

:KHQWKHNLWFKHQGHVLJQFDOOVIRUDQDJDLQVW

WKHZDOOLQVWDOODWLRQPRYHWKHEDVHFDELQHW

IRUZDUGWR)LOOHUSDQHOVRUFRPSOHPHQWDU\

PROGLQJVFDQEHDGGHGWRH[SRVHGFDELQHWVLGHV

,QDQLVODQGRUSHQLQVXODXVHDQH[WUDGHHS

FRXQWHUWRS7KHFRXQWHUWRSRYHUKDQJDWWKH

IURQWFDQEHDGMXVWHGWRPHHWVHWEDFNWRFXWRXW

UHTXLUHPHQWV

:KHQWKHFXWRXWWRWKHIURQWHGJHRIWKH

FRXQWHUWRSUHTXLUHPHQWLVPRUHWKDQDGG

DEXOOQRVHWULPWRWKHIURQWHGJHRIWKH

FRXQWHUWRS,QFOXGHWKHWULPWKLFNQHVVZKHQ

PHDVXULQJWKHIURQWHGJHWRFXWRXWUHTXLUHPHQW

%\DGGLQJWKHWULPWKHFRRNWRSFDQEHPRYHG

IRUZDUGSURYLGLQJDGGLWLRQDOFRXQWHUWRSGHSWK

DQGLQWHULRUFDELQHWVSDFH

Cover Panel

End

Panel

Countertop

Overhang

per Cooktop

Clearances

Must be

Maintained

Base

Cabinet

Filler Panel

Base Sink

Filler Panel

Maintain Cutout Clearances

to Front Edge as Specified



'HVLJQ,QIRUPDWLRQ

&OHDUDQFHV

7KHGRZQGUDIWV\VWHPZLWKEORZHUPRWRU

DQGGXFWZRUNZLOORFFXS\WKHFDELQHWEHORZ

WKHFRXQWHUWRSDQGFRRNWRS

7KHEORZHUPRWRUDVVHPEO\FDQEHORFDWHG

EHORZWKHFDELQHWÀRRU7KHDVVHPEO\ZLOO¿W

EHWZHHQÀRRUMRLVWV2UGHU-;5%IRULQGRRU

UHPRWHORFDWLRQV

5HIHUWR\RXUVSHFL¿FFRRNWRSLQVWDOODWLRQ

LQVWUXFWLRQIRUDSSURSULDWHFOHDUDQFHV

,QVWDOODWLRQPXVWFRQIRUPZLWKORFDOFRGHV

'XFWZRUN

3UHSDUHGXFWZRUNWRYHQWWRWKHRXWGRRUV

8VHWKHVKRUWHVWDQGVWUDLJKWHVWGXFWUXQSRVVLEOH

7KHPD[LPXPSHUPLVVLEOHHTXLYDOHQWOHQJWKIRU

GXFWUXQLVIHHW

5HIHUWR´'XFW)LWWLQJVµFKDUWWRFDOFXODWH

HTXLYDOHQWOHQJWKIRUYDULRXVGXFWFRQ¿JXUDWLRQV

7KHGRZQGUDIWEORZHUV\VWHPLVGHVLJQHGWRXVH

[GXFWZRUN,WFDQEHWUDQVLWLRQHGWR

URXQG

'XFWZRUN0867EHYHQWHGWRWKHRXWVLGH²QHYHU

LQWRDFUDZOVSDFHDWWLFRURWKHUHQFORVHGVSDFH

'HWHUPLQHWKHQHHGIRUDZDOOFDSRUURRIFDS

2UGHUWKHFDSLQDGYDQFH

(OHFWULFDODQG*DV/RFDWLRQV

3ODQWKHSODFHPHQWRIWKHHOHFWULFDORXWOHWDQGJDV

FRQQHFWLRQVLIXVHGFDUHIXOO\(OHFWULFDORXWOHWVDQG

JDVFRQQHFWLRQVFDQQRWEHSODFHGRQWKHEDFNZDOO

RIWKHFDELQHWEHFDXVHLWPD\LQWHUIHUHZLWKWKH

GRZQGUDIWSOHQXP5HIHUWR32:(56833/<VHFWLRQ

IRULQIRUPDWLRQRQORFDWLRQRIHOHFWULFDODQGJDV

FRQQHFWLRQV

,QVWDOODVWDQGDUGHOHFWULFDORXWOHWZLWKLQUHDFKRI

WKHYHQW·VWZRIRRWORQJSRZHUFRUG

7KHYHQWDQGD*(RU0RQRJUDPJDVFRRNWRS

FRPELQDWLRQFDQRSHUDWHIURPWKHVDPHYROW

VWDQGDUGGXSOH[RXWOHW

(OHFWULFFRRNWRSVPXVWRSHUDWHIURPDVHSDUDWH

YROWMXQFWLRQER[

$HOERZQRWVXSSOLHGFDQEHLQVWDOOHGRQWRWKH

LQOHWRIWKHJDVFRRNWRSDQGURXWHWKHJDVFRQQHF

WLRQVWRDYRLGLQWHUIHUHQFHZKHQLQVWDOOHGZLWKD

GRZQGUDIWYHQWRURWKHUFDELQHWU\IHDWXUHV



,QVWDOODWLRQ3UHSDUDWLRQ

&872876$1'&/($5$1&(6

0HDVXUHFDUHIXOO\ZKHQFXWWLQJWKHFRXQWHUWRS

0DNHVXUHVLGHVRIWKHRSHQLQJDUHSDUDOOHODQG

UHDUDQGIURQWFXWVDUHH[DFWO\SHUSHQGLFXODU

ULJKWDQJOHVWRWKHVLGHV

0HDVXUHWREHVXUHWKHUHLVURRPIRUFOHDUDQFHV

WRWKHIURQWHGJHRIWKHFRXQWHUWRS

5HIHUWRFRRNWRSLQVWDOODWLRQLQVWUXFWLRQVWREH

VXUHWKDWPRGHOV¿WLQWRWKHEDVHFDELQHWVEHLQJ

XVHG

'UDZOLQHVRQWKHFRXQWHUWRSWRIROORZDVD

FXWWLQJJXLGH

0HDVXUHDQGPDUNFRRNWRSDQGYHQWRYHUODSVWR

EHVXUHWKHUHLVHQRXJKÀDWFRXQWHUWRSGHSWK

&22.723$1''2:1'5$)7

&20%,1$7,21

7KHFRRNWRSPXVWEHLQVWDOOHGSHUPDQXIDFWXUHU·V

LQVWDOODWLRQLQVWUXFWLRQV

,03257$177KHFRXQWHUWRSFXWRXWGHSWKUHTXLUHV

PLQLPXPÀDWFRXQWHUWRSVXUIDFHDQG

PLQLPXPWRWDOFRXQWHUWRSGHSWK

127(%HIRUH\RXEHJLQPHDVXUHDQGPDUNGHSWK

WRHQVXUHWKDWDGHTXDWHÀDWFRXQWHUWRSVXUIDFH

LVDYDLODEOH

)RUFRRNWRSDQGGRZQGUDIWFRPELQDWLRQGHSWK

)ROORZFRRNWRSLQVWDOODWLRQLQVWUXFWLRQVIRUFRRNWRS

DQGGRZQGUDIWFRPELQDWLRQLQVWDOODWLRQ

2WKHUZLVHDGGWRWKHFRRNWRSFXWRXWGHSWK

127($GGWRWKHFRRNWRSFXWRXWGHSWKIRU

-3DQG-3

5HTXLUHGWRPDLQWDLQ8/RU&6$DSSURYDOV





0LQLPXP



0LQLPXPÀDWFRXQWHU

WRSEHKLQGFXWRXWUHTXLUHG

&22.723$1''2:1'5$)7

&20%,1$7,21

,03257$177KHFRXQWHUWRSFXWRXWGHSWKUHTXLUHV

PLQLPXPÀDWFRXQWHUWRSVXUIDFHDQG

PLQLPXPWRWDOFRXQWHUWRSGHSWK

127(%HIRUH\RXEHJLQPHDVXUHDQGPDUNGHSWK

WRHQVXUHWKDWDGHTXDWHÀDWFRXQWHUWRSVXUIDFH

LVDYDLODEOH

)RUFRRNWRSDQGGRZQGUDIWFRPELQDWLRQGHSWK

)ROORZFRRNWRSLQVWDOODWLRQLQVWUXFWLRQVIRUFRRNWRS

DQGGRZQGUDIWFRPELQDWLRQLQVWDOODWLRQ

2WKHUZLVHDGGWRWKHFRRNWRSFXWRXWGHSWK

127($GGWRWKHFRRNWRSFXWRXWGHSWKIRU

-3DQG-3

5HTXLUHGWRPDLQWDLQ8/RU&6$DSSURYDOV





0LQLPXP



0LQLPXPÀDWFRXQWHU

WRSEHKLQGFXWRXWUHTXLUHG



,QVWDOODWLRQ3UHSDUDWLRQ

3$5766833/,('

2SHQWKHFDUWRQDQGUHPRYHSDUWVSDFNDJH

&KHFNFRQWHQWVWREHVXUHDOOSLHFHVDUHSUHVHQW

722/6$1'0$7(5,$/65(48,5('

/DUJHÀDWEODGHVFUHZGULYHU

-LJVDZ

&DUSHQWHU·VVTXDUH

'XFWZRUNWRVXLWWKHLQVWDOODWLRQ

/HYHO

5(029(3$&.$*,1*

5HPRYHWKHVKLSSLQJPDWHULDOVDQGWKHFDUWRQ

VHWFDUWRQDVLGH7KHFDUWRQFDQEHXVHGDVDSDG

ZKHQFKDQJLQJRUDGMXVWLQJYHQWGLUHFWLRQ

6WDELOL]LQJ%UDFNHWV

:LWK6FUHZV

5HPRWH6ZLWFK

)LOWHUV

:LUHDQG:KLWH

&RQQHFWRU



,QVWDOODWLRQ3UHSDUDWLRQ



,03257$17

3OHDVHUHDGFDUHIXOO\

7KHSRZHUFRUGRIWKLVDSSOLDQFHLVHTXLSSHG

ZLWKDWKUHHSURQJJURXQGLQJSOXJZKLFKPDWHV

ZLWKDVWDQGDUGWKUHHSURQJJURXQGLQJZDOO

UHFHSWDFOHWRPLQLPL]HWKHSRVVLELOLW\RIHOHFWULF

VKRFN7KHFXVWRPHUVKRXOGKDYHWKHZDOO

UHFHSWDFOHDQGFLUFXLWFKHFNHGE\DTXDOL¿HG

HOHFWULFLDQWRPDNHVXUHWKHUHFHSWDFOHLV

SURSHUO\JURXQGHGDQGKDVFRUUHFWSRODULW\

:KHUHDVWDQGDUGWZRSURQJZDOOUHFHSWDFOH

LVHQFRXQWHUHGLWLVWKHSHUVRQDOUHVSRQVLELOLW\

DQGREOLJDWLRQRIWKHFXVWRPHUWRKDYHLW

UHSODFHGZLWKDSURSHUO\JURXQGHGWKUHHSURQJ

ZDOOUHFHSWDFOH

'RQRWXQGHUDQ\FLUFXPVWDQFHVFXWRUUHPRYH

WKHWKLUGJURXQGSURQJIURPWKHSRZHUFRUG

'212786($1(;7(16,21&25'

:$51,1*6+2&.+$=$5'

)253(5621$/6$)(7<7+,6$33/,$1&(0867

%(3523(5/<*5281'('

5HPRYHKRXVHIXVHRURSHQFLUFXLWEUHDNHUEHIRUH

EHJLQQLQJLQVWDOODWLRQ

'RQRWXVHDQH[WHQVLRQFRUGRUDGDSWHUSOXJ

ZLWKWKLVDSSOLDQFH)ROORZ1DWLRQDO(OHFWULFDO&RGH

RUSUHYDLOLQJORFDOFRGHVDQGRUGLQDQFHV

7KLVGRZQGUDIWYHQWPXVWEHVXSSOLHGZLWK9

+]DQGFRQQHFWHGWRDQLQGLYLGXDOSURSHUO\

JURXQGHGEUDQFKFLUFXLWSURWHFWHGE\D

RUDPSHUHFLUFXLWEUHDNHURUWLPHGHOD\IXVH

$SURSHUO\JURXQGHGSURQJUHFHSWDFOHVKRXOG

EHORFDWHGZLWKLQUHDFKRIWKHYHQW·VWZRIRRWSRZHU

FRUG



*DV&RRNWRSV

,IWKLVYHQWLVLQVWDOOHGLQFRPELQDWLRQZLWKD*(

RU0RQRJUDPJDVFRRNWRSLWPD\RSHUDWHIURP

WKHVDPHGXSOH[RXWOHW



(OHFWULF&RRNWRSV

,IWKLVYHQWLVLQVWDOOHGLQFRPELQDWLRQZLWKD*(

RU0RQRJUDPHOHFWULFFRRNWRSWKHYHQWPXVW

RSHUDWHIURPDVHSDUDWH9RXWOHW

/RFDWHWKHUHFHSWDFOHLQVLGHWKHFDELQHWRQWKHULJKW

VLGHZDOOVHHLOOXVWUDWLRQ7KHUHFHSWDFOHFDQQRWEH

SODFHGRQWKHEDFNRIWKHFDELQHWZDOOZKHUHLWPD\

LQWHUIHUHZLWKWKHGRZQGUDIWSOHQXP

7KHGRZQGUDIWYHQWSRZHUFRUGLVWREHURXWHG

EHQHDWKWKHFRRNWRSDQGURXWHGDZD\IURPKHDW

JHQHUDWHGE\WKHFRRNWRS

(QVXUHWKDWWKHFRRNWRSLVLQVWDOOHGSHU

PDQXIDFWXUHU·VLQVWDOODWLRQLQVWUXFWLRQV

32:(56833/<

/RFDWHWKH*DVRU(OHFWULFDO

&RQQHFWLRQ2QO\:LWKLQWKH

6KDGHG$UHD

'2127/RFDWH

*DVRU(OHFWULFDO

&RQQHFWLRQVZLWKLQ

WKLV$UHD

IRU0RGHOV

IRU0RGHOV





(OHFWULFDO

2XWOHW

$ERYH

&DELQHW

)ORRU



,QVWDOODWLRQ3UHSDUDWLRQ

9(17,1*237,216

7KHGRZQGUDIWYHQWLVVKLSSHGZLWKWKH

GLVFKDUJHRXWOHWSRLQWLQJVWUDLJKWGRZQ

DQGFDQEHFKDQJHGWRWKHOHIWRUULJKW

VLGH

7KHEORZHURXWOHWLVVL]HGIRU[

DQGFDQEHWUDQVLWLRQHGWRURXQG

6LGHWR6LGH$GMXVWPHQWV

7KHHQWLUHEORZHUPRXQWLQJSODWHFDQEH

DGMXVWHGWRWKHOHIWRUULJKW7KLVZLOO

KHOSWRDOLJQYHQWGLVFKDUJHWRKRXVH

GXFWZRUN

'LVFKDUJH'LUHFWLRQ

7KHEORZHUDVVHPEO\PD\EHUHPRYHGDQGWXUQHG

IRUDOHIWRUULJKWVLGHGLVFKDUJH

$OHIWRUULJKWGLUHFWLRQDGMXVWPHQWVKRXOGEH

SHUIRUPHGEHIRUHGURSSLQJLQWRWKHFRXQWHUWRS

RSHQLQJ

)ODWWHQWKHVKLSSLQJER[WRXVHDVDSDG

/D\WKHYHQWRQLWVEDFNDQGRQWRWKHSDG

7RFKDQJHWRDOHIWRUULJKWGLVFKDUJH

5HPRYHWKHVFUHZVKROGLQJWKHEORZHUDQG

WKHPRXQWLQJSODWHDVVHPEO\WRWKHGRZQGUDIW

YHQW5HWDLQVFUHZV

5HPRYHEORZHUDVVHPEO\WXUQLWRYHUWRDFFHVV

WKHQXWVKROGLQJWKHEORZHUWRWKHPRXQWLQJ

SODWH5HPRYHWKHQXWV

,03257$17'RQRWOLIWPRWRUE\WKHSRZHUFDEOH

7XUQWKHEORZHUWRWKHOHIWRUULJKWGLVFKDUJH

GLUHFWLRQDQGUHLQVWDOOWKHQXWV

5HLQVWDOOEORZHUDQGPRXQWLQJSODWHZLWKRULJLQDO

VFUHZV

7RORFDWHWKHGXFWZRUNKROHVLQWKHFDELQHW

ÀRRURUVLGHZDOOV

7HPSRUDULO\SODFHYHQWLQWRWKHFRXQWHUWRS

RSHQLQJ

3XVKWKHYHQWDOOWKHZD\WRWKHEDFNRIWKH

RSHQLQJ

,I\RXDUHWUDQVLWLRQLQJWRURXQGREWDLQHG

ORFDOO\SODFHWUDQVLWLRQSLHFHRYHUWKHGLVFKDUJH

RXWOHW

0DUNWKHORFDWLRQDQGUHPRYHWKHDVVHPEO\

&XWKROHVDQGLQVWDOOGXFWZRUNFRQQHFWLRQV

2UGHU-;5%IRULQVWDOODWLRQRIWKHEORZHUDQG

PRWRUEHORZWKHÀRRU

'LVFKDUJH'RZQ

$V6XSSOLHG

/RRVHQ6FUHZV

WR$GMXVW

WR

/HIWRU5LJKW

'LVFKDUJH'RZQ

$V6XSSOLHG

'LVFKDUJH/HIW

'LVFKDUJH5LJKW



,QVWDOODWLRQ3UHSDUDWLRQ

'8&7

),77,1*6

8VH[

GXFW,WFDQ

WUDQVLWLRQWR

URXQG

     7RWDO

   (TXLYDOHQW 4XDQWLW\ (TXLYDOHQW

 'XFW3LHFH 'LPHQVLRQV /HQJWK 8VHG /HQJWK

   IW

  URXQG SHUIRRW

  VWUDLJKW OHQJWK

   IW

  ø[ SHUIRRW

  VWUDLJKW OHQJWK



 

  HOERZ IW



 

  HOERZ IW



  ø[

  HOERZ IW



  ø[

  HOERZ IW



  ø[

  ÀDWHOERZ IW

  URXQG

  WRø[

  WUDQVLWLRQ IW

  ø[

  URXQGWR

  WUDQVLWLRQ IW

  URXQGWR

  ø[

  WUDQVLWLRQ

  HOERZ IW

  ø[WR

  URXQGWUDQVLWLRQ

  HOERZ IW

  URXQG

  ZDOOFDS

  ZLWKGDPSHU IW

  ø[

  ZDOOFDS

  ZLWKGDPSHU IW



  URXQG

  URRIFDS IW

7RWDO'XFW5XQ

8VHWKLVFKDUWWR

FRPSXWHPD[LPXP

SHUPLVVLEOHOHQJWKV

IRUGXFWUXQVWR

RXWGRRUV

127('RQRWH[FHHG

PD[LPXPSHUPLVVLEOH

HTXLYDOHQWOHQJWKV

'RZQGUDIW9HQW

PD[LPXP

HTXLYDOHQWOHQJWK

)OH[LEOHGXFWLQJ

,IÀH[LEOHPHWDO

GXFWLQJLVXVHGDOOWKH

HTXLYDOHQWIHHWYDOXHV

LQWKHWDEOHVKRXOGEH

GRXEOHG7KHÀH[LEOH

PHWDOGXFWVKRXOGEH

VWUDLJKWDQGVPRRWK

DQGH[WHQGHGDVPXFK

DVSRVVLEOH

'2127XVHÀH[LEOH

SODVWLFGXFWLQJ

$FWXDOOHQJWKRIVWUDLJKWGXFWSOXVGXFW¿WWLQJ

HTXLYDOHQW(TXLYDOHQWOHQJWKRIGXFWSLHFHVLVEDVHG

RQDFWXDOWHVWVFRQGXFWHGE\*((YDOXDWLRQ(QJLQHHULQJ

DQGUHÀHFWUHTXLUHPHQWVIRUJRRGYHQWLQJSHUIRUPDQFH

ZLWKDQ\GRZQGUDIWFRRNWRS

127($Q\KRPH

YHQWLODWLRQV\VWHP

VXFKDVDFRRNWRSZLWK

DGRZQGUDIWH[KDXVW

PHFKDQLVPPD\

LQWHUUXSWWKHSURSHU

ÀRZRIFRPEXVWLRQDLU

DQGH[KDXVWUHTXLUHG

E\¿UHSODFHVJDV

IXUQDFHVJDVZDWHU

KHDWHUVDQGRWKHU

QDWXUDOO\YHQWHG

V\VWHPV7RPLQLPL]H

WKHFKDQFHRI

LQWHUUXSWLRQRIVXFK

QDWXUDOO\YHQWHG

V\VWHPVIROORZWKH

KHDWLQJHTXLSPHQW

PDQXIDFWXUHU·V

JXLGHOLQHVDQGVDIHW\

VWDQGDUGVVXFKDV

WKRVHSXEOLVKHGE\

1)3$DQG$6+5$(



,167$//'2:1'5$)79(17

2QHVWDELOL]LQJEUDFNHWPXVWEHLQVWDOOHGRQ

HDFKVLGHRIWKHGRZQGUDIWYHQW

)RUULJKWVLGHRUVWUDLJKWGRZQEORZHU

GLVFKDUJHIDVWHQWKHVWDELOL]LQJEUDFNHWVDW

ORFDWLRQV$DQG%

)RUOHIWVLGHEORZHUGLVFKDUJHIDVWHQWKH

VWDELOL]LQJEUDFNHWVDWORFDWLRQV%DQG&

3ODFHWKHGRZQGUDIWYHQWLQWRWKHFRXQWHUWRS

FXWRXWVRWKDWWKHEDFNÀDQJHRIWKHYHQWLV

VLWWLQJRQWRSRIWKHFRXQWHUWRS

1RWH7KHGRZQGUDIWYHQWPD\QHHGWREH

WXUQHGDWDQDQJOHWR¿WLQWRWKHFRXQWHUWRS

FXWRXW

6HFXUHWKHVFUHZVIRUWKHVWDELOL]LQJEUDFNHWVWR

WKHFDELQHWEDFNZDOO

:KHQLQVWDOOLQJWKHGRZQGUDIWYHQWLQDWLOH

FRXQWHUWRSVXUIDFHLWPD\EHQHFHVVDU\WRDSSO\

DORFDOO\DSSURYHGFDXONLQJWRFRYHUDQ\JDSV

(

&KHFNWKDWWKHGRZQGUDIWYHQWLVYHUWLFDOO\OHYHO

2SHUDWHWKHYHQWWRWLPHVWRHQVXUHSURSHU

LQVWDOODWLRQ

,QVWDOODWLRQ,QVWUXFWLRQV

,167$//'8&7:25.

7KHGRZQGUDIWEORZHUV\VWHPLVGHVLJQHGIRUXVH

ZLWK[GXFWZRUN,WFDQEHWUDQVLWLRQHG

WRURXQG

'XFWZRUN0867EHYHQWHGWRWKHRXWVLGH³QHYHU

LQDFUDZOVSDFHDWWLFRURWKHUHQFORVHGVSDFH

39&GXFWVKRXOGEHXVHGZKHQLQVWDOOLQJXQGHU

DFRQFUHWHVODE

127(/RFDOEXLOGLQJFRGHPXVWEHIROORZHG

IRULQVWDOODWLRQLQVSHFLI\LQJDSSURYHGW\SHDQG

VFKHGXOHRI39&GXFWXVHG

'212786(ÀH[LEOHSODVWLFGXFWLQJ

$OZD\VXVHDSSURSULDWHURRIRUZDOOFDSZLWK

GDPSHU/DXQGU\W\SHZDOOFDSVVKRXOGQHYHU

EHXVHG

8VHWKHVWUDLJKWHVWGXFWUXQSRVVLEOH

)RUVDWLVIDFWRU\SHUIRUPDQFHWKHGXFWUXQVKRXOG

QRWH[FHHGIWRULWVHTXLYDOHQWOHQJWKZKHQ

EHQGVRUYDULRXV¿WWLQJVDUHXVHG5HIHUWRWKH

WDEOHRIHTXLYDOHQWOHQJWKVWRFDOFXODWH\RXULQVWDO

ODWLRQ

,QVWDOOGXFWZRUNVRWKHSLHFHRIGXFWQHDUHVWWKH

GRZQGUDIWXQLWVORWV,172WKHQH[WSLHFHRIWKH

GXFW6HFXUHWKHMRLQWVZLWKVHOIWDSSLQJVFUHZV

DQGDSSO\GXFWWDSHDURXQGWKHMRLQWVWRHQVXUHDQ

DLUWLJKWVHDO

Duct Tape

Over Seam and Screw

Screw

Air

Flow

%UDFNHW

&DELQHW%DFN

:DOO

'RZQGUDIW9HQW

/RFDWLRQ$

7239,(:



,QVWDOODWLRQ,QVWUXFWLRQV

,167$//5(027(6:,7&+

&RQQHFW:LUH/HDGWR&RQWURO%R[

&RQQHFWWKHPDWLQJZLUHHQGV

3ODFHWKHDGKHVLYHZLUHFODPSVSURYLGHGQHDU

WKHPDWLQJFRQQHFWRU

.HHSDSSUR[LPDWHO\ORQJZLUHDQGDWWDFK

WKHZLUHWRWKHFODPSZLWKDZLUHWLH7KLVZLOODFW

DVDVWUDLQUHOLHI

 'ULOODGLDKROHLQWRWKHGHVLUHGORFDWLRQ8VH

WKHPRXQWLQJEUDFNHWDVDWHPSODWHWRORFDWHWKH

KROHDFFXUDWHO\&KHFNIRULQWHUIHUHQFHEHWZHHQ

WKHVZLWFKFRYHUDGMDFHQWREMHFWVDQGFRRNWRS

YHQWRYHUODSV

 ,IVZLWFKLVPRXQWHGLQWRDWLOHVXUIDFHGULOOWKH

KROHEHWZHHQWLOHV8VHORFDOO\DSSURYHGFDXONLQJ

WRFRYHUDQ\JDSV

 ,IWKHUHPRWHVZLWFKLVQRWLQVWDOOHGRQWKHFRXQ

WHUWRSHQVXUHWKDWLWLVLQVWDOOHGLQDORFDWLRQWKDW

PHHWVORFDOFRGHVDQGLVHDVLO\DFFHVVLEOH

&RQQHFW5HPRWH6ZLWFKWR5HPRWH+DUQHVV

7KUHDGWKHUHPRWHKDUQHVVWKURXJKWKHGLD

KROHDQGDWWDFKWKHKDUQHVVFRQQHFWRUWRWKH

UHPRWHFRQQHFWRU

5HPRYHWKHSDSHUEDFNLQJRQWKHUHPRWHVZLWFK

IRDPSLHFHDQGPRXQWWKHUHPRWHVZLWFKRQWKH

FRXQWHUWRSVXFKWKDWWKHVZLWFKFRQQHFWRUVVWD\

ORFDWHGLQWKHGLDKROH

6WLFNDGKHVLYHZLUHFODPSQHDUWKHGLDKROH

DQGDWWDFKWKHORRVHZLUHZLWKDZLUHWLH

:$51,1*6+2&.+$=$5'

'LVFRQQHFWHOHFWULFDOSRZHUIURPXQLWEHIRUH

EHJLQQLQJVZLWFKLQVWDOODWLRQ)DLOXUHWRGRVRFRXOG

UHVXOWLQSHUVRQDOLQMXU\RUGDPDJHWRWKHHOHFWULFDO

FRQWUROV

:$51,1*%851+$=$5'

7KHUHPRWHVZLWFKPXVWEHORFDWHGVRWKDWLWFDQEH

RSHUDWHGZLWKRXWUHDFKLQJRYHUWKHFRRNWRS)DLOXUH

WRGRVRPD\UHVXOWLQLJQLWLRQRIFORWKLQJZKLFKFRXOG

FDXVHVHULRXVLQMXU\RUGHDWK

'HWHUPLQHWKHORFDWLRQIRUWKHUHPRWHVZLWFK

 7KHUHPRWHVZLWFKVKRXOGEHORFDWHGVRWKDWWKH

YHUWLFDOGLVWDQFHIURPWKHÀRRUWRWKHUHPRWH

VZLWFKLVOHVVWKDQDQGPRUHWKDQ

 7KHUHPRWHVZLWFKKDUQHVVLVORQJDQGVKRXOG

EHLQVWDOOHGVRWKDWLWLVQRWSLQFKHGDQGLVDZD\

IURPPRYLQJSDUWV

Control

Box

'LD+ROH

'LD

+ROH

)RDP3LHFH:LWK

$GKHVLYH0RXQWLQJ

6XUIDFH

)RDP3LHFH:LWK$GKHVLYH

0RXQWLQJ6XUIDFH

5HPRWH6ZLWFK

5HPRWH

6ZLWFK

6WUDLQ5HOLHI

$GKHVLYHZLUHFODPS

ZLWKWLH

5HPRWH

+DUQHVV

5HPRWH+DUQHVV

0DWLQJ&RQQHFWRUV

6WUDLQ5HOLHI

$GKHVLYHZLUH

FODPSZLWKWLH



,QVWDOODWLRQ,QVWUXFWLRQV

&211(&732:(5

3OXJSRZHUFRUGLQWRSURSHUO\JURXQGHGUHFHSWDFOH



,167$//),/7(56&+(&.23(5$7,21

3UHVVWKH212))SDGRQWKHFRQWURO

WRUDLVHWKHYHQW

6OLS¿QJHUVLQWRWKHYHQWKROHV/LIWWKHYHQW

VWUDLJKWXSDQGSXOOIRUZDUG

6OLGH¿OWHULQWRWKHUHWDLQHUVDQGFORVHWKHYHQW

3UHVVWKH)DQ6SHHG+,*+(5SDGWRVWDUWWKH

EORZHU$GMXVWWKHEORZHUE\SUHVVLQJ+,*+(5RU

/2:(5

7RORZHUWKHYHQWSUHVVWKH212))SDG

127(,WLVQRWQHFHVVDU\WRWXUQWKHIDQ2))

EHIRUHORZHULQJWKHYHQW7KHIDQZLOODXWRPDWLFDOO\

WXUQRȺZKHQWKHYHQWLVORZHUHG:KHQWKHIDQ

LVQRWWXUQHGRȺEHIRUHORZHULQJWKHYHQWLWZLOO

DXWRPDWLFDOO\FRPHRQDWWKHSUHYLRXVO\VHWVSHHG

ZKHQWKHYHQWLVIXOO\UDLVHG

,03257$177KHYHQWFDQEHDFWLYDWHGE\SUHVVLQJ

WKHSDGVRQWKHVZLWFK'RQRWXVHH[FHVVLYHIRUFH

RUVKDUSREMHFWVWRDFWLYDWHWKHVZLWFK'DPDJH

FRXOGRFFXUDQGYRLGWKHZDUUDQW\

)LOWHU7DEV

5HWDLQHUV



1RWHV



1RWHV



127(:KLOHSHUIRUPLQJLQVWDOODWLRQVGHVFULEHGLQWKLVERRN

VDIHW\JODVVHVRUJRJJOHVVKRXOGEHZRUQ

127(3URGXFWLPSURYHPHQWLVDFRQWLQXLQJHQGHDYRU

DW*HQHUDO(OHFWULF7KHUHIRUHPDWHULDOVDSSHDUDQFH

DQGVSHFL¿FDWLRQVDUHVXEMHFWWRFKDQJHZLWKRXWQRWLFH



*(

GE PVB94DTBB, PVB98DTBB, PVB98STSS Operating instructions

Related papers

Other documents