Aaeon GENE-LN05 Rev. B User manual

SubCompact Board GENE- LN05 Rev.B

GENE-LN05 Rev.B

Intel

®

Atom™N455/D525 Processors

Intel

®

82567V & 82583V

for 10/100/1000Mbps

2 SATA 3.0 Gb/s, 1 CompactFlash™

6 COM, 7 USB2.0, Digital I/O

1 Mini Card/ SMBus/ LPC

GENE-LN05 Rev.B Manual 4

th

Ed.

July 17, 2015

SubCompact Board GENE- LN05 Rev.B

Copyright Notice

This document is copyrighted, 2015. All rights are reserved. The

original manufacturer reserves the right to make improvements to the

products described in this manual at any time without notice.

No part of this manual may be reproduced, copied, translated, or

transmitted in any form or by any means without the prior written

permission of the original manufacturer. Information provided in this

manual is intended to be accurate and reliable. However, the original

manufacturer assumes no responsibility for its use, or for any in-

fringements upon the rights of third parties that may result from its

use.

The material in this document is for product information only and is

subject to change without notice. While reasonable efforts have been

made in the preparation of this document to assure its accuracy,

AAEON assumes no liabilities resulting from errors or omissions in

this document, or from the use of the information contained herein.

AAEON reserves the right to make changes in the product design

without notice to its users.

i

SubCompact Board GENE- LN05 Rev.B

Acknowledgments

All other products’ name or trademarks are properties of their

respective owners.

 AMI is a trademark of American Megatrends Inc.

 CompactFlash™ is a trademark of the Compact Flash

Association.

 Intel

®

, Atom™ are trademarks of Intel

®

Corporation.

 Microsoft Windows

®

is a registered trademark of Microsoft Corp.

 ITE is a trademark of Integrated Technology Express, Inc.

 IBM, PC/AT, PS/2, and VGA are trademarks of International

Business Machines Corporation.

 SoundBlaster is a trademark of Creative Labs, Inc.

All other product names or trademarks are properties of their

respective owners.

ii

SubCompact Board GENE- LN05 Rev.B

Packing List

Before you begin installing your card, please make sure that the

following materials have been shipped:

• CD-ROM for manual (in PDF format) and drivers

• GENE-LN05 Rev.B with Active Cooler (D525 Version)

or with Passive Cooler (N455 Version)

If any of these items should be missing or damaged, please

contact your distributor or sales representative immediately.

iii

SubCompact Board GENE- LN05 Rev.B

Contents

Chapter 1 General Information

1.1 Introduction ................................................................ 1-2

1.2 Features .................................................................... 1-3

1.3 Specifications ............................................................ 1-4

Chapter 2 Quick Installation Guide

2.1 Safety Precautions .................................................... 2-2

2.2 Location of Connectors & Jumpers ........................... 2-3

2.3 Mechanical Drawing .................................................. 2-5

2.4 List of Jumpers .......................................................... 2-7

2.5 List of Connectors ..................................................... 2-8

2.6 Setting Jumpers ........................................................ 2-10

2.7 Touch Screen 4/5/8-wire Mode Selection (JP1) ....... 2-11

2.8 Auto Power Button Selection (JP2) ........................... 2-11

2.9 COM2 RI/+5V/+12V Selection (JP3) ......................... 2-11

2.10 Clear CMOS (JP4) .................................................. 2-11

2.11 LVDS Backlight Bias/PWM Mode Selection (JP5)2-11

2.12 LVDS Operating Voltage Selection (JP6) ............... 2-12

2.13 LVDS Inverter Voltage Selection (JP7) ................... 2-12

2.14 2-Pin ATX Power Connector (CN1) (Optional) ....... 2-12

2.15 CPU FAN Connector (CN2) .................................... 2-12

2.16 +5VSB Output With SMBUS (CN3) ........................ 2-12

2.17 External +5VSB Input (CN4) ................................... 2-13

iv

SubCompact Board GENE- LN05 Rev.B

2.18 SATA Port #2 (CN5) ................................................ 2-13

2.19 SATA Port #1 (CN6) ................................................ 2-13

2.20 LPC Expansion I/F (CN7) ........................................ 2-14

2.21 External +5V Input –depends on the power input

configuration (CN8) ......................................................... 2-14

2.22 External +12V Input-depends on the power input

configuration (CN9) ......................................................... 2-14

2.23 Touch Screen Connector (CN10) ............................ 2-15

2.24 +5V Output For SATA HDD (CN11) ........................ 2-15

2.25 Front Panel (CN12) ................................................. 2-15

2.26 COM Port #6 (CN13) ............................................... 2-15

2.27 USB Port #7 (CN14) ................................................ 2-16

2.28 COM Port #5 (CN15) ............................................... 2-16

2.29 USB Port #6 (CN16) ................................................ 2-16

2.30 USB Port #5 (CN17) ................................................ 2-17

2.31 COM Port #4 (CN18) ............................................... 2-17

2.32 USB Port #4 (CN19) ................................................ 2-17

2.33 USB Port #3 (CN20) ................................................ 2-17

2.34 COM Port #3 (CN21) ............................................... 2-18

2.35 COM Port #2 (CN22) ............................................... 2-18

2.36 Audio Line-In/Out and MIC Connector (CN23) ....... 2-19

2.37 RJ-45 Ethernet #2 (CN24) ...................................... 2-19

2.38 RJ-45 Ethernet #1 (CN25) ...................................... 2-20

2.39 Digital I/O Connector (CN26) .................................. 2-20

2.40 Parallel Port (CN27) ................................................ 2-21

v

SubCompact Board GENE- LN05 Rev.B

2.41 LVDS Inverter Connector (CN28) ........................... 2-22

2.42 LVDS Output (CN29)............................................... 2-22

2.43 USB Port 1 & 2 (CN30) ........................................... 2-23

2.44 PS/2 Keyboard & Mouse (CN31) ............................ 2-23

2.45 COM Port #1 (CN32) ............................................... 2-23

2.46 CRT Display Connector (CN33) .............................. 2-23

2.47 SIM Card Socket (CN34) ........................................ 2-24

2.48 CompactFlash Disk (CFD1) .................................... 2-24

2.49 Mini-Card Slot #1 (PCIE1) ....................................... 2-25

2.50 DDR2 SODIMM Slot (DIMM1) ................................ 2-26

Chapter 3 AMI BIOS Setup

3.1 System Test and Initialization. .................................. 3-2

3.2 AMI BIOS Setup ........................................................ 3-3

Chapter 4 Driver Installation

4.1 Installation ................................................................. 4-3

Appendix A Programming The Watchdog Timer

A.1 Programming ......................................................... A-2

A.2 W83627DHG Watchdog Timer Initial Program ...... A-7

Appendix B I/O Information

B.1 I/O Address Map .................................................... B-2

B.2 1

st

MB Memory Address Map ................................ B-4

B.3 IRQ Mapping Chart ................................................ B-5

B.4 DMA Channel Assignments ................................... B-5

vi

SubCompact Board GENE- LN05 Rev.B

Appendix C Mating Connector

C.1 List of Mating Connectors and Cables.................. C-2

vii

SubCompact Board GENE- LN05 Rev.B

General

Information

Chapter

1

Chapter 1 General Information 1- 1

SubCompact Board GENE- LN05 Rev.B

1.1 Introduction

AAEON, a leading embedded boards manufacturer, is pleased to

announce a new 3.5” SubCompact Board—GENE-LN05 Rev.B. The

GENE-LN05 Rev.B is a cutting-edge product that provides high

performance and low power consumption in the embedded market.

GENE-LN05 Rev.B adopts the latest Intel

®

Atom processors and the

system memory is deployed with SODIMM DDR3 up to 4 GB (D525 is

up to 4 GB, N455 is up to 2 GB). In addition, Intel

®

82567V & 82583V

supports two 10/100/100Base-TX that allows faster network

connection. This model applies one Mini Card and one LPC Bus

expansions. Moreover, two SATA 3.0 Gb/s (optional RAID 0 &1) and

one Type2 CompactFlash

TM

storage is configured on the GENE-LN05

Rev.B. In addition to the diverse storages, GENE-LN05 Rev.B also

equips seven USB2.0, six COM, one parallel, and one

keyboard/mouse ports for flexible I/O expansions. There are no more

worries about installing many necessary devices to complete the

functions of your system.

The display of GENE-LN05 Rev.B supports CRT/LCD simultaneous/

dual view displays and 18/24-bit single channel LVDS. Moreover, the

GENE-LN05 Rev.B offers Wide Temperature Solution and the

temperature range will be -40

o

C~85

o

C. This SubCompact Board is

developed to cater to the requirements of Automation, Medical, ticket

machine, transportation, gaming, KIOSK, and POS/POI applications.

Chapter 1 General Information 1- 2

SubCompact Board GENE- LN05 Rev.B

1.2 Features

 Intel

®

Atom™ N455/D525 Processors Up To 1.8 GHz

 Intel

®

ICH8M

 DDR3 800 SODIMM, Max. 4 GB for D525; Max. 2 GB

for N455

 Gigabit Ethernet x 2

 CRT, 18/24-bit Single Channel LVDS LCD

 2CH HD Audio

 SATA 3.0Gb/s x 2 (Optional RAID 0 & 1), CompactFlash™

x 1

 USB 2.0 x 7, COM x 6, Parallel x 1, 8-bit Digital I/O

 Onboard 4/5/8-wire Resistive Touch Screen Controller

 Mini Card x 1

 +12V or +5V (Optional) Operation

 Onboard Trusted Platform Module (Optional)

Chapter 1 General Information

1 - 3

SubCompact Board GENE- LN05 Rev.B

1.3 Specifications

System

 Processor Intel

®

Atom™ N455/D525 1.8GHz

Processors

 System Memory 204-pin DDR3 800 SODIMM x 1, Max.

4 GB for Intel

®

Atom™ D525; Max. 2

GB for Intel

®

Atom™ N455

 Chipset Intel

®

ICH8M

 I/O Chipset Nuvoton W83627DHG-P, Fintek

F81216DG

 Ethernet Intel

®

82567V & 82583V,

10/100/1000Base-TX, RJ-45 x 2

 BIOS AMI Plug & Play SPI BIOS – 2MB

Flash

 Wake On LAN Yes

 Watchdog Timer Generates a time-out system reset

 H/W Monitor

Chipset

Supports power supply voltages and

temperature monitoring

 Expansion Interface Mini Card x 1, LPC Bus

 Trusted Platform

Module (TPM)

Infineon SLB 9635 TT 1.2 (Optional)

 Battery Lithium battery

 Power Requirement +12V or +5V (Optional), AT/ATX

Chapter 1 General Information 1- 4

SubCompact Board GENE- LN05 Rev.B

 Board Size 5.75”(L) x 4”(W) (146mm x 101.6mm)

 Gross Weight 0.88 lb (0.4 kg)

 Operating

Temperature

32°F~ 140°F (0°C ~ 60°C)

WiTAS 1: -4°F~ 158°F (-20°C~70°C)

(TF-GENE-LN05W1-B10-01)

WiTAS 2 : -40°F~ 185°F (-40°C~85°C)

(TF-GENE-LN05W2-B10-01)

 Storage

Temperature

-40˚F~ 176˚F (-40˚C ~ 80˚C)

 Operating Humidity 0%~90% relative humidity,

non-condensing

Display: Supports CRT/LCD simultaneous/dual view displays

 Chipset Intel

®

N455/D525 integrated

 Memory Shared system memory up to 224

MB/ DVMT4.0

 Resolution Up to 1920 x 1440 for CRT (D525)

Up to 1280x1024 for CRT (N455)

Up to 1366x768 or 1280 x 800 for

LCD

 LCD Interface 18/24-bit single channel LVDS

I/O

 Storage SATA 3.0 Gb/s x 2,

Type2 CompactFlash™ x 1

 Serial Port Serial Port :RS-232 x 5,

Chapter 1 General Information

1 - 5

SubCompact Board GENE- LN05 Rev.B

RS-232/422/485 (auto flow) x 1

(AAEON recommends for the

Serial Port to be at the 9600 baud

rate during high temperature

operation.)

 Parallel Port SPP/EPP/ECP x 1

 USB Port USB2.0 x 7

 PS/2 Port Keyboard x 1, Mouse x 1

 Digital I/O Supports 8-bit (Programmable)

 Audio Line-in, Line-out, Mic-in

 Touch Screen Supports 4/5/8-wire resistive touch

screen

Note: For TF-GENE-LN05W2-B10-01, a thermal module for the DDR3

memory is recommended. We recommended using “Fujipoly: SARCON

®

XR-L” (1.2 watt/m-K) or better thermal pad for the thermal module.

Note 2: According to Intel EDS documents, the chipset supports the 4 types of

DRAM as shown in the table below. Please choose your DRAM according to

the EDS document to avoid compatibility issues.

- DDR3 DRAM Device Technology:

Standard 1-Gb and 2-Gb technologies and addressing are supported for

x16/ x8 devices. There is no support for SODIMMs with different

technologies or capacities on opposite sides of the same SODIMM. If one

Chapter 1 General Information 1- 6

SubCompact Board GENE- LN05 Rev.B

side of a SODIMM is populated, the other side is either identical or empty.

- Supported DDR3 SODIMM module configurations.

Raw

Card

Type

DIMM

Capacity

DRAM

Device

Tech.

DRAM

Organization

# of

DRAM

Devices

# of

Ranks

# of

Banks

A

1 GB

1 Gb

64 M x 16

8

2

8

A

2 GB

2 Gb

128 M x 16

8

2

8

B

1 GB

1 Gb

128 M x 8

8

1

8

B

2 GB

2 Gb

256 M x 8

8

1

8

Chapter 1 General Information

1 - 7

SubCompact Board GENE-LN05 Rev.B

Chapter 2 Quick Installation Guide 2-1

Quick

Inst

allation

Chapter

2

Guide

SubCompact Board GENE-LN05 Rev.B

Chapter 2 Quick Installation Guide 2-2

2.1 Safety Precautions

Always completely disconnect the power cord

from your board whenever you are working on

it. Do not make connections while the power is

on, because a sudden rush of power can

damage sensitive electronic components.

Always ground yourself to remove any static

charge before touching the board. Modern

electronic devices are very sensitive to static

electric charges. Use a grounding wrist strap at

all times. Place all electronic components on a

static-dissipative surface or in a static-shielded

bag when they are not in the chassis

SubCompact Board GENE-LN05 Rev.B

Chapter 2 Quick Installation Guide 2-3

2.2 Location of Connectors and Jumpers

Component Side

SubCompact Board GENE-LN05 Rev.B

Chapter 2 Quick Installation Guide 2-4

Solder Side

SubCompact Board GENE-LN05 Rev.B

Chapter 2 Quick Installation Guide 2-5

2.3 Mechanical Drawing

Component Side

Aaeon GENE-LN05 Rev. B User manual

Related papers

Other documents