1
Star
Manufacturing
International Inc.
10 Sunnen Drive
St. Louis, MO 63143
Phone: (314) 781-2777
FAX: (314) 781-2714
Installation
and
Operating
Instructions
2M-Y4404 Rev. F 2-2-2007
STA-RITE
HEAT LAMP
MODELS
14HL, 14HLR
34HL, 34HLR
Model 14-HL
2
GENERAL INSTALLATION DATA
CAUTION
This equipment is designed and sold for commercial use only by personnel trained and
experienced in its operation and is not sold for consumer use in and around the home nor for
use directly by the general public in food service locations. For equipment to be used by the
general public, please contact the factory.
VOLTAGE
These heat lamps are equipped for use on the voltage specied on the nameplate.
WARNING
DO NOT CONNECT TO ANY OTHER TYPE OF CURRENT OR THE MACHINE
WILL BE SERIOUSLY DAMAGED.
GENERAL OPERATING INSTRUCTIONS
On the 14HL models, the height of the lamps is controlled by a thumb screw on the side of the
lamp arm.
On the 34HL models, assemble the two "T" base assemblies to the tray assembly using the
sheet metal screws provided.
Lamps are controlled by a switch on the cord assembly (
14HL, 14HLR) and by a switch
mounted on the arm assembly (34HL, 34HLR).
CLEANING
1. Disconnect electrical cord before cleaning.
CAUTION
ALLOW UNIT TO COOL PRIOR TO CLEANING.
2. To maintain nish and shine of unit, wipe arm, pan and screen with a damp cloth and a mild
soap. Do not use harsh detergents or scouring pads.
MAINTENANCE AND REPAIRS
Contact the factory, a service representative or a local service company for service or required
maintenance.
3
Part# 2M-4497-2 05/06 RB
The foregoing warranty is in lieu of any and all other warranties expressed or implied and constitutes the entire warranty.
FOR ASSISTANCE
Should you need any assistance regarding the Operation or Maintenance of any Star equipment; write, phone, fax or email our Service Department.
In all correspondence mention the Model number and the Serial number of your unit, and the voltage or type of gas you are using.
ALL:
* Pop-Up Toasters
* Butter Dispensers
* Pretzel Merchandisers
* Pastry Display Cabinets
* Nacho Chip Merchandisers
* Accessories of any kind
* Sneeze Guards
* Pizza Ovens
* Heat Lamps
* Pumps
Visit our Website at: www.star-mfg.com Email: service@star-mfg.com
THOROUGHLY INSPECT YOUR UNIT ON ARRIVAL
This unit has been tested for proper operation before leaving our plant to insure delivery of your unit in perfect condition. However, there are instances in
which the unit may be damaged in transit. In the event you discover any type of damage to your product upon receipt, you must immediately contact the
transportation company who delivered the item to you and initiate your claim with same. If this procedure is not followed, it may affect the warranty
status of the unit.
LIMITED EQUIPMENT WARRANTY
All workmanship and material in Star products have a one (1) year limited warranty on parts & labor in the United States and Canada. Such warranty is
limited to the original purchaser only and shall be effective from the date the equipment is placed in service. Star's obligation under this warranty is limited
to the repair of defects without charge, by the factory authorized service agency or one of its sub-agencies. Models that are considered portable (see below)
should be taken to the closest Star service agency, transportation prepaid.
> Star will not assume any responsibility for loss of revenue.
> On all shipments outside the United States and Canada, see International Warranty.
* The warranty period for the JetStar six (6) ounce & Super JetStar eight (8) ounce series popcorn machines is two (2) years.
* The warranty period for the Chrome-Max Griddles is five (5) years on the griddle surface. See detailed warranty provided with unit.
* The warranty period for Teflon/Dura-Tec coatings is one year under normal use and reasonable care. This warranty does not apply if damage occurs to
Teflon/Dura-Tec coatings from improper cleaning, maintenance, use of metallic utensils, or abrasive cleaners. This warranty does not apply to the
“non-stick” properties of such materials.
> This warranty does not apply to "Special Products" but to regular catalog items only. Star's warranty on "Special Products" is six (6) months on parts
and ninety (90) days on labor.
> This warranty does not apply to any item that is disassembled or tampered with for any purpose other than repair by a Star Authorized Service Center or
the Service Center's sub-agency.
> This warranty does not apply if damage occurs from improper installation, misuse, wrong voltage, wrong gas or operated contrary to the Installation and
Operating instructions.
> This warranty is not valid on Conveyor Ovens unless a "start-up/check-out" has been performed by a Factory Authorized Technician.
PARTS WARRANTY
Parts that are sold to repair out of warranty equipment are warranted for ninety (90) days. The part only is warranted. Labor to replace the part is
chargeable to the customer.
SERVICES NOT COVERED BY WARRANTY
PORTABLE EQUIPMENT
Star will not honor service bills that include travel time and mileage charges for servicing any products considered "Portable" including items listed below.
These products should be taken to the Service Agency for repair:
1. Travel time and mileage rendered beyond the 50 mile radius limit
2. Mileage and travel time on portable equipment (see below)
3. Labor to replace such items that can be replaced easily during a daily cleaning
routine, ie; removable kettles on fryers, knobs, grease drawers on griddles, etc.
4. Installation of equipment
5. Damages due to improper installation
6. Damages from abuse or misuse
7. Operated contrary to the Operating and Installation Instructions
8. Cleaning of equipment
9. Seasoning of griddle plates
10. Voltage conversions
11. Gas conversions
12. Pilot light adjustment
13. Miscellaneous adjustments
14. Thermostat calibration and by-pass adjustment
15. Resetting of circuit breakers or safety controls or reset buttons
16. Replacement of bulbs
17. Replacement of fuses
18. Repair of damage created during transit, delivery, &
installation OR created by acts of God
* The Model 510FD Fryer.
* The Model J4R, 4 oz. Popcorn Machine.
* The Model 518CMA & 526CMA Cheese Melter.
* The Model 12MC & 15MC & 18MCP Hot Food Merchandisers.
* The Model 12NCPW & 15NCPW Nacho Chip/Popcorn Warmer.
* All Hot Dog Equipment except Roller Grills & Drawer Bun Warmers.
* All Nacho Cheese Warmers except Model 11WLA Series Nacho Cheese Warmer.
* All Condiment Dispensers except the Model HPDE, & SPDE Series Dispenser.
* All Specialty Food Warmers except Model 130R, 11RW Series, and 11WSA Series.
* All QCS/RCS Series Toasters except Model QCS3 & RCS3 Series.
4
LAMP LAMP
SWITCH
CORD SET G
B
W
LAMP
SWITCH
LAMP LAMP
CORD SET
W
B
G
14 HL
34 HL
MODEL:
14HL, 34HL
THIS DRAWING CONTAINS INFORMATION CONFIDENTIAL TO STAR MFG. INT'L. INC.
NO REPRODUCTION OR DISCLOSURE OF ITS CONTENTS IS PERMITTED.
STAR MANUFACTURING INTERNATIONAL INC.
SK1401 Rev -
10/25/1995
5
16
15
14
13
18
2
3
7
8
10
11
9
4
SK1397
MODEL: 14HL, 14HLR 120V
REV A 10-24-95
STAR MANUFACTURING INTERNATIONAL, INC.
6
1-11 D1-143075 1 LAMP ARM ASSEMBLY COMPLETE (LAMPS NOT INCLUDED)
2 D1-143071 1 LAMP ARM ASSEMBLY
2C-Y1545 1 NUT-WELD (WELDED TO LAMP ARM)
3 2E-Y1392 1 LEAD-IN-CORD ASSEMBLY with SWITCH
4 2S-Y2238 2 LAMP - INFRA-RED (WHITE) 14HL, 14HL-2
2S-Y1508 2 LAMP - INFRA-RED (RED) 14HLR, 14HLR-2
7 2E-Y5636 2 SOCKET - PORCELAIN with 31” LEADS
8 2H-Y1119 2 GASKET - SOCKET
9 2L-Y1112 2 REFLECTOR
10 2E-Y1241 1 SWITCH
11 2K-H5417 1 BUSHING-CORD
13 D1-143072 1 LAMP BASE ASSEMBLY
2C-Y1546 1 THUMB SCREW (NOT SHOWN)
14 D1-Y1111 1 TRAY - BASE 14HL, 14HLR
15 2D-Y1143 1 PAN - ALUMINUM (FULL SIZE) 14HL, 14HLR
8V-P-1220 1 PAN 12" X 20" X 2 1/2"
16 D1-Z0771 1 SCREEN 14HL, 14HLR
2A-H7804 4 FOOT (NOT SHOWN)
2P-Y1547 3 PLUG - PLASTIC (NOT SHOWN)
2K-Y1139 2 BUSHING - SNAP (NOT SHOWN)
IMPORTANT: WHEN ORDERING, SPECIFY VOLTAGE OR TYPE GAS DESIRED PAGE
INCLUDE MODEL AND SERIAL NUMBER OF
Some items are included for illustrative purposes only and in certain instances may not be available.
Number
Per
Unit
Description
Part
Number
Key
Number
Star Manufacturing International, Inc.
1
1
PARTS LIST February 2, 2007, Rev. F
MODEL 14HL, 14HL-2, 14HLR and 14HLR-2
7
17
18
16
3
10
64
2
12
13
11
9
1
15
8
7
14
SK1400
MODEL: 34HL, 34HLR 120V
REV A 2-2-07
STAR MANUFACTURING INTERNATIONAL, INC.
8
1-10 D2-143105 1 LAMP ARM ASSEMBLY COMPLETE (LAMPS NOT INCLUDED)
1 D2-143104 1 LAMP ARM ASSEMBLY
2C-Y1545 1 NUT-WELD (WELDED TO LAMP ARM)
2 D2-143110 1 LEAD-IN-CORD ASSEMBLY with SWITCH
3 2K-H5417 1 BUSHING - CORD
4 D2-Y1539 1 SWITCH BOX
5 D2-143101 1 COVER - SWITCH BOX
6 2E-Y3070 1 SWITCH
7 2K-Y1139 6 BUSHING SNAP
8 2H-Y1119 3 GASKET - SOCKET
9 2E-Y5636 3 SOCKET - PORCELAIN with 31” LEADS
10 2L-Y1112 3 REFLECTOR
11 2S-Y1508 3 LAMP - INFRA-RED (RED) 34HLR, 34HLR-2
2S-Y2238 3 LAMP - INFRA-RED (WHITE) 34HL, 34HL-2
12 D2-143103 2 LAMP “T” BASE ASSEMBLY
13 2A-H7804 4 FOOT
14 2P-Y1547 4 PLUG
15 2C-Y1546 2 THUMB SCREW
16 D2-143102 1 TRAY ASSEMBLY 34HL, 34HLR
17 2D-Y1548 1 PAN
18 D2-Y2479 1 SCREEN - TRAY
2C-8823 2 SCREWS FOR HOLDING TRAY TO LEGS
IMPORTANT: WHEN ORDERING, SPECIFY VOLTAGE OR TYPE GAS DESIRED PAGE
INCLUDE MODEL AND SERIAL NUMBER OF
Some items are included for illustrative purposes only and in certain instances may not be available.
Number
Per
Unit
Description
Part
Number
Key
Number
Star Manufacturing International, Inc.
1
1
PARTS LIST February 2, 2007, Rev. F
MODEL 14HL, 14HL-2, 14HLR and 14HLR-2
/
