Item # _____________________________________
Quantity ___________________________________
C.S.I. Section 11400
F-40189 – KleenScreen Plus
®
Filter System – Gas Fryers Page 1 of 2
KLEENSCREEN PLUS
®
FILTER SYSTEM – GAS FRYERS
701 S Ridge Avenue, Troy, OH 45374
1-888-4HOBART • www.hobartcorp.com
KLEENSCREEN PLUS
®
FILTER SYSTEM – GAS FRYERS
STANDARD FEATURES
■ Filter system accommodates:
– minimum of two, maximum of four 45 lb.
capacity tanks per fryer battery
– minimum of two, maximum of three 65 lb.
and 85 lb. capacity tanks per fryer battery
■ Controls – millivolt (M), solid state (D) or
computer (C)
■ Electronic ignition on solid state (D) and
computer control (C) fryers
■ Drain valve interlock switch – available on solid
state (D) and computer control (C) models
■ 18 gauge, #304 stainless steel filter vessel
■ 6" adjustable casters – 2 locking, 2 non-locking
■ Drawer style (seamless) filter pan. 70 lbs. frying
compound capacity on HG45F & HG65F;
110 lbs. capacity on HG85F
■ Paperless stainless steel filter screen filters
from two sides – filter area = 270 square inches;
Micro Filtration Fabric Envelope filter area = 350
square inches
■
1
⁄3 H.P. motor and pump circulates hot frying
compound at a rate of 8.0 gallons per minute
■ Patented solenoid activated one touch push
button switch to engage pump and motor (solid
state controls (D) and computer (C) models only)
■ 1
1
⁄4" rear gas connection
■ Oil discard hose - 6 ft. in length
■ Large primary crumb catch basket
■ Tank brush, stainless steel crumb scoop and
clean-out rod
■ 120 volt, 60 Hz, 1 phase
ACCESSORIES
❏ Auto basket lifts on solid state (D) or computer
control (C) units:
– 45 lb. double auto lifts
– 65 lb. single or double auto lifts
– 85 lb. single or double auto lifts
❏ “Add-On” Frymate
™
- HX15 for HG45, HX21 for
HG65, HX21S for HG85, and HX21MS for the
ability to store the Hobart Mobile Filter 85HMF
under the Frymate
™
MODELS
Millivolt Controls:
❏ 2HG45MF ❏ 3HG45MF ❏ 4HG45MF
❏ 2HG65MF ❏ 3HG65MF
❏ 2HG85MF ❏ 3HG85MF
Solid State Controls:
❏ 2HG45DF ❏ 3HG45DF ❏ 4HG45DF
❏ 2HG65DF ❏ 3HG65DF
❏ 2HG85DF ❏ 3HG85DF
Computer Controls:
❏ 2HG45CF ❏ 3HG45CF ❏ 4HG45CF
❏ 2HG65CF ❏ 3HG65CF
❏ 2HG85CF ❏ 3HG85CF
ACCESSORIES (Continued)
❏ Stainless steel tank cover
❏ Micro-Filtration Fabric Envelopes - 6 filters per
package
❏ Rear oil reclamation discard connection
Specifications, Details and Dimensions on Reverse Side.
701 S Ridge Avenue, Troy, OH 45374
1-888-4HOBART • www.hobartcorp.com
Page 2 of 2 F-40189 – KleenScreen Plus
®
Filter System – Gas Fryers
As continued product improvement is a policy of Hobart, specifications are subject to change without notice.
Printed On Recycled Paper
KLEENSCREEN PLUS
®
FILTER SYSTEM – GAS FRYERS
F-40189 (12/07) LITHO IN U.S.A. (H-01)
DETAILS AND DIMENSIONS
IMPORTANT
1. A combination valve with pressure regulator is provided with
this unit.
Natural Gas 4.0" W.C.
Propane Gas 10.0" W.C.
2. An adequate ventilation system is required for Commercial
Cooking Equipment. Information may be obtained by writing
to the National Fire Protection Association, Batterymarch
Park, Quincy, MA 02269. When writing refer to NFPA No. 96.
3. All models require a 6" clearance at both sides and rear
adjacent to combustible construction.
4. All models require a 16" minimum clearance to adjacent
open top burner units.
5. This appliance is manufactured for commercial installation
only and is not intended for home use.
SERVICE CONNECTIONS:
P1 1
1
⁄4" NPT common rear gas connection.
E1 120 volt, 60 Hz, 1 phase electrical connection (filter pump).
FILTER SECTION SPECIFICATIONS
FILTER PAN
CAPACITY
FILTER
AREA MOTOR PUMP
ELECTRIC
AMPS
ELECTRIC
POWER
HG45
70 lbs.
270 sq. in.
350 sq. in.
1
⁄3 H.P.
1750 RPM
8.0 gal./
minute
115V
5.0A
120V
60Hz
1 phase
HG65, HG85
110 lbs.
270 sq. in.
350 sq. in.
BATTERY DIMENSIONS
MODEL
NO.
2
FRYERS
3
FRYERS
4
FRYERS
Width Width Width
HG45 31" 46
1
⁄2" 62"
HG65 42" 63" –
HG85 42" 63" –
/