Charbroil 461742204 Owner's manual

Brand: Charbroil

Model: 461742204

Category: Barbecues & grills

Type: Owner's manual

Note: Grill lid

style may vary.

Qty: 2

461742204

Items to Assemble:

2 Wheel Assemblies

2 Hitch Pins

2 Leg Extenders

Items to Assemble:

2 Leg Assemblies

1 Bottom Shelf

6 Carriage Bolts

6 Wing Nuts

Qty: 6

Place Bottom Shelf and Legs as shown.

After assembling tighten all Wing Nuts.

Right Side:

Attach 2 Carriage Bolts and Wing Nuts in

front and back.

Left Side:

Place 1 Carriage Bolt

and Wing Nut in upper hole only

Items to Assemble:

1 Grill Bottom

1 Heat Shield

2 Carriage Bolts

2 Wing Nuts

2 Control Knobs

Items to Assemble:

1 Right Shelf

4 Wing Screws

Qty: 4

Items to Assemble:

2 End Caps

1 Toolholder

1Carriage Bolt

1 Wing Nut

Place Carriage Bolt in right hole on Toolholder. Secure with Wing Nut.

Items to Assemble:

1 Sideburner Body

1 Sideburner Frame

1 Carriage Bolt

1 Wing Nut

1 Crown Screw or Wing Nut

Join Sideburner Body and Frame. In back center hole attach with Carriage Bolt and Wing Nut.

In front use a Crown Screw or Wing Nut to attach Toolholder and Sideburner Body.

Items to Assemble:

1 Sideburner

1 Wing Nut

1 Sideburner Valve Cup

1 Sideburner Knob

1 Sideburner Grate

Place Sideburner into hole.

Attach Sideburner Valve Cup. Make sure

Sideburner Tube is inside of valve. Tighten

with Wing Nut.

Place Sideburner Knob and Grate

Correctly assembled Sideburner Tube in Valve

Attach long wire from beneath console

to electrode beneath Sideburner.

Item to Assemble:

1 Wire Shelf

1 Panel

2 Push Pins

Qty: 2

Assemble front panel first by

placing tabs into slots on Bottom Shelf.

Attach with push pins.

A Place Wire Shelf in 3rd hole from top.

Items to Assemble:

1 Lower Warming Rack

1 Upper Warming Rack

1 Grate

Insert pivot wire of Lower Warming Rack into Lid.

Flex leg wires to insert into Grill bottom.

Insert pivot wire of Upper Warming Rack into lid.

Flex leg wires to insert into loops on Lower Rack.

Place grate.

Leg wires on both Warming Racks

must run underneath surfaces.

Legs snap into loop

Qty: 1

Qty. 2

Qty.2

Attach Wheels with Hitch Pins

Qty: 1

Items to Assemble:

1 V-Bar

Push V-Bar down onto

rest in Grill Bottom

Hinge Pin

and Hitch Pin

Qty: 2

Qty:2

Items to Assemble:

1 Grill Lid

2 Hinge Pins

2 Hitch Pins

1 Handle

2 Wing Nuts

1 Logo Plate

1 Temp Gauge Bezel

1 Temperature Gauge

w/Wing Nut

Grate

See Use & Care Manual for “Match Lighting Instructions” and to

perform the Burner Flame Check” and important safety

instructions before using.

Hang grease clip from center of grill bottom.

Use an empty soup can (not included) to hang

from grease clip.

Back of Grill

Items to Assemble:

1 Grease Clip

1 Tank Wire Support Bracket

LP tank is sold separately. Use only with an

(over-fill protection device) OPD equipped LP Tank.

Fill and leak check before attaching to grill and regulator.

CAUTION

• Failure to install can in clip will cause hot grease

to drip from bottom of grill with risk of fire or

property damage.

• Tank collar opening must face to front of cart

once tank is attached.

• Failure to install tank correctly may allow gas

hose to be damaged in operation, resulting in

the risk of fire.

Qty: 1

Charbroil 461742204 Owner's manual

Brand: Charbroil

Model: 461742204

Category: Barbecues & grills

Type: Owner's manual

Download PDF

report

Charbroil 461742204 Owner's manual

Charbroil 461742204 Owner's manual

Related papers

Other documents