BARRON VEX-8 NYC Steel Series Installation guide

Brand
BARRON
Model
VEX-8 NYC Steel Series
Type
Installation guide
IMPORTANT SAFEGUARDS
READ AND FOLLOW ALL SAFETY INSTRUCTIONS.
When using electrical equipment, basic safety precautions should always be followed including the following:
• DISCONNECT AC POWER SUPPLY BEFORE SERVICING.
• Installation and servicing of this equipment should be performed by qualified service personnel only.
• Ensure that the electrical wiring conforms to the National Electrical Code NEC® and local regulations,
if applicable.
• Do not mount near gas or electrical heaters.
• Equipment should be mounted in locations and at heights where it will not be readily subjected to tampering by
unauthorized personnel.
• The use of accessory equipment not recommended by the manufacturer may cause an unsafe condition.
• Any modification or use of non-original components will void the warranty and product liability.
• Do not use this equipment for other than intended use.
• Allow battery to charge for 24 hours before first use.
SAVE THESE INSTRUCTIONS!
Technical SupportŶŶWHFKQLFDOVXSSRUW#EDUURQOWJFRP
VEX-8 NEMA Series
Installation Instructions
R(9 1ZZZEDUURQOWJFRP
Assembly of VEX-8 inside NEMA enclosure for NY
2SHQWKHFOHDUFRYHURIWKH1(0$HQFORVXUHE\IOLSSLQJWKHSODVWLFODWFKHVXS)LJ
5HPRYHWKHPHWDOPRXQWLQJSODWHZLWKLQWKHHQFORVXUHDQGVHWDVLGHIRUODWHUXVH)LJDQG
8VLQJWKHVXSSOLHGHQFORVXUHPRXQWLQJWHPSODWHRQ3DJHFKRRVHWKHQHFHVVDU\KROHVIRUWKH-ER[)LJ
Fig. 1 Fig. 2
)LJ Fig. 4
Metal
mounting
plate
VEX-8 NEMA Series
Installation Instructions
R(9 2ZZZEDUURQOWJFRP
&HQWHUWKHWHPSODWHRQWKHEDFNRIWKH1(0$ER[)LJ
$IWHUFHQWHULQJWKHWHPSODWHPDUNWKHORFDWLRQRIWKHQHFHVVDU\KROHVRQWRWKH1(0$ER[)LJ
'ULOOKROHVDWWKHPDUNHGORFDWLRQVDVZHOODVDKROHLQWKHFHQWHUIRUWKHZLUHVWRSDVVWKURXJK)LJ
:LWKWKHKROHVGULOOHGSDVVWKHZLUHVIURPWKH-ER[WKURXJKWKHFHQWHUKROH)LJ
)LJ )LJ
)LJ )LJ
VEX-8 NEMA Series
Installation Instructions
R(9  ZZZEDUURQOWJFRP
6HFXUHWKH1(0$HQFORVXUHWRWKH-ER[XVLQJWKHQHFHVVDU\KDUGZDUHSURYLGHGE\RWKHUV)LJ
5HLQVWDOOWKHPHWDOPRXQWLQJSODWHXVLQJWKHVXSSOLHGVFUHZV)LJ
5HPRYHWKHIURQWIDFHRIWKH9(;IL[WXUHXVLQJDVFUHZGULYHU)LJDQG
)LJ )LJ
Fig. 11 Fig. 12
VEX-8 NEMA Series
Installation Instructions
R(9 4ZZZEDUURQOWJFRP
11. Remove the LED indicator and test button from the side of the enclosure, making note of the location on the PCBA
ZKHUHWKH\DUHSOXJJHGLQDQGGLVFDUG)LJ
5HPRYHWKHFHQWHUNQRFNRXWIURPWKHEDFNRIWKHIL[WXUH)LJ
5HPRYHDQ\EXUUVIURPWKHKROHLIQHFHVVDU\DQGLQVHUWWKHSODVWLFJURPPHW)LJ
3DVVWKHZLUHVIURPWKH1(0$HQFORVXUH¶VWHVWEXWWRQWKURXJKWKHVTXDUHKROHRQWKHVLGHRIWKHIL[WXUHZKHUHWKHWHVW
EXWWRQZDVPDNLQJVXUHWRSDVVLWDURXQGWKHULJKWVLGHRIWKHPRXQWLQJSODWH)LJ
)LJ Fig. 14
)LJ )LJ
VEX-8 NEMA Series
Installation Instructions
R(9  ZZZEDUURQOWJFRP
3DVVWKHZLUHVIURPWKH-ER[WKURXJKWKHFHQWHUKROHRIWKHIL[WXUH)LJ
3ODFHWKHIL[WXUHRQWKHPRXQWLQJSODWHPDNLQJVXUHWKHIL[WXUHVLWVEHKLQGWKHIURQWOLSRIWKHPRXQWLQJSODWH
7KLVZLOOPDNHLWHDVLHUWRPDNHWKHZLUHFRQQHFWLRQV)LJDQGD
5HPRYHWKHEDWWHU\FRPSDUWPHQWZLWKLQWKHWRSRIWKHIL[WXUH)LJ

Pass the power wires found within the battery compartment through the hole in the bottom of the wire housing.
All
HOHFWULFDOFRQQHFWLRQVVKRXOGEHPDGHLQVLGHWKH-ER[0DNHHOHFWULFDOFRQQHFWLRQVDVIROORZV)LJ
%ODFN9$&
5HGRU2UDQJH9$&
White - Common
Green - Ground
Note: Cap unused leads to prevent shorting.
)LJ )LJ
)LJ )LJ
)LJD
VEX-8 NEMA Series
Installation Instructions
R(9  ZZZEDUURQOWJFRP
:LWKWKHSURSHUFRQQHFWLRQVPDGHSXVKWKHZLUHVWKURXJKWKHEDFNSODWH)LJ
6QDSWKHEDWWHU\FRPSDUWPHQWEDFNLQWRSODFHVRWKDWWKHWDEVRQERWKVLGHVDUHORFNHGDQGVHFXUHG)LJ
21. Locate the battery wire coming from the battery compartment and plug the connector into the PCBA connector at the
location shown. The PCBA connector for the battery is located behind the connector for the test switch, labeled
³7(67´)LJDQGD
22. Locate the wire labeled “TEST” from the button wire harness and plug it into the corresponding PCBA connector
ODEHOHG³7(67´)LJDQGD
Fig. 21 Fig. 22
)LJ Fig. 24
)LJD Fig. 24a
VEX-8 NEMA Series
Installation Instructions
R(9  ZZZEDUURQOWJFRP
/RFDWHWKHZLUHODEHOHG³$&21´IURPWKHEXWWRQZLUHKDUQHVVDQGSOXJLWLQWRWKHFRUUHVSRQGLQJ3&%$FRQQHFWRU
ODEHOHG³$&21´)LJ
7KHIL[WXUHLVQRZFRPSOHWHO\ZLUHG)LJ
/LIWWKHIL[WXUHRXWRIWKHPHWDOPRXQWLQJSODWH$WWKLVWLPHWKHZLUHVFDQEHFRQFHDOHGZLWKLQWKH-ER[DOOSRZHU
VXSSO\ZLUHFRQQHFWLRQVQHHGWREHPDGHLQVLGHWKH-ER[)LJ
5HLQVWDOOWKHIURQWIDFHRIWKHIL[WXUH)LJ
)LJ )LJ
)LJ )LJ
VEX-8 NEMA Series
Installation Instructions
R(9  ZZZEDUURQOWJFRP
3ODFHWKHIL[WXUHEDFNRQWRWKHPHWDOPRXQWLQJSODWHDJDLQEHLQJVXUHLWVLWVEHKLQGWKHIURQWOLSRIWKHPRXQWLQJSODWH
6OLGHWKHWZRSODVWLFVWRSSHUVLQWRWKHVORWVLQWKH1(0$HQFORVXUHDVVKRZQ7KHVHSUHYHQWWKHIL[WXUHIURPIDOOLQJ
IRUZDUG)LJ
&ORVHWKHOLGRIWKH1(0$HQFORVXUH)LJ
6HFXUHWKHOLGE\FORVLQJWKHWZRSODVWLFODWFKHV)LJ
,QVWDOOWDPSHUUHVLVWDQWVFUHZWKURXJKWKHKROHVIRXQGZLWKLQWKHOLG)LJD
$SSO\VLOLFRQHWRVHDOWKHHQFORVXUHDJDLQVWWKHPRXQWLQJVXUIDFHLQRUGHUWRSUHYHQWZDWHUIURPJHWWLQJWRWKH-ER[
)LJ
)LJ )LJ
)LJ )LJ
)LJD
VEX-8 NEMA Series
Installation Instructions
R(9  ZZZEDUURQOWJFRP
7XUQWKHSRZHU21DQGHQVXUHWKDWWKHVLJQDQGWHVWEXWWRQDUHERWKLOOXPLQDWHG3HUIRUPDWHVWRIWKHIL[WXUHE\
depressing the test button for 1 second, checking that the sign briefly flashes once. )LJDQG
Test button
)LJ)LJ
VEX-8 NEMA Series
Installation Instructions
R(9  ZZZEDUURQOWJFRP
Mounting Template
VEX-8 NEMA Series
Installation Instructions
R(9 11 ZZZEDUURQOWJFRP
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11

BARRON VEX-8 NYC Steel Series Installation guide

Brand
BARRON
Model
VEX-8 NYC Steel Series
Type
Installation guide
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Other documents