Diagrams within this manual may not be drawn proportionally. Due to continuing improvements,
actual product may differ slightly from the product described herein.
er’sManual
2 Gallon Air Compressor
Model No. PCE6020K
Read and follow all safety rules and instructions in this manual before attempting
to operate this machine. Failure to comply with these instructions may result in
personal injury.
WARNING
For Service Please Call Toll Free: 1-866-591-8921
Table of Contents
Topic
Page
Safety Guidelines-Definitions 4
Hazard Warnings 5
Air Compressor
15
Precautions
15
Basic Air Compressor Components 16
Assembling the Air Compressor 16
Compressor Controls 18
Electrical Power Requirements 19
Breaking In The Pump 21
Operating Instructions 21
Maintenance 23
Storage 24
Service 24
Troubleshooting 25
Glossary Terms 29
Parts Listing 30
2
Limited Warranty 33
Owner’s Manual
3
Air Compressor
Air Compressor
Prior to installation and usage, thoroughly inspect air compressor for damages.
&KHFN WKH WDQN FRPSUHVVRU FRPSUHVVRU PRWRU DQG SXPS IRU DQ\ VLgns of damage
or corrosion.
&KHFN DOO VFUHZV EROWV QXWV DQG IDVWHQHUV FRQILUP WKDW WKHy are secure.
&RQILUP WKDW DOO ILWWLQJV WDQN SHWFRFN KDUGZDUH DQG SDLQW are free from rust
and corrosion.
&RQILUP WKDW DOO FRPSUHVVRU VHWWLQJV DUH FRUUHFW SULRU WR VWDrt up and usage.
Air Tool Inspection
Prior to connecting and using the compressor, thoroughly inspect each air tool for
damage.
&KHFN WKH HQWLUH WRRO DVVHPEO\ IRU DQ\ VLJQV RI GDPDJH RU FRUURVLon.
&KHFN DOO DVVHPEO\ VFUHZV EROWV QXWV DQG IDVWHQHUV FRQILUP that they
are secure.
&RQILUP WKDW DOO ILWWLQJV ELWV DQG KDUGZDUH DUH LQ JRRG FRQGition.
&RQILUP WKDW WKH WRRO VHWWLQJV DUH FRUUHFW SULRU WR FRQQHFWLRQ DQ
d usage.
Warning! Read And Understand All Safety Precautions In
This Manual Before Operating. Failure To Comply With
Instructions In This Manual Could Result In Personal
Injury, Property Damage, And / Or Voiding Of Your
Warranty. Pulsar Products, Inc Will Not Be Liable For Any
Damage Because Of Failure To Follow These Instruc-
tions.
4
SAFETY GUIDELINES-DEFINITIONS
This manual contains important information that you need to
know and understand in order to protect YOUR SAFETY and to
PREVENT EQUIPMENT PROBLEMS. The following symbols help
you recognize this information. Please read the manual and pay
attention to these sections.
WARNING!
IMPROPER OPERATION OR MAINTENANCE OF
THIS PRODUCT COULD RESULT IN SERIOUS INJURY AND PROPERTY
DAMAGE. READ AND UNDERSTAND ALL WARNINGS AND OPERATING
INSTRUCTIONS BEFORE USING THIS EQUIPMENT. WHEN USING AIR TOOLS,
BASIC SAFETY PRECAUTIONS SHOULD ALWAYS BE FOLLOWED TO REDUCE
THE RISK OF PERSONAL INJURY.
WARNING! WARNINGS INDICATE A CERTAINTY OR
STRONG POSSIBILITY OF PERSONAL INJURY OR DEATH IF INSTRUCTIONS
ARE NOT FOLLOWED.
CAUTION: CAUTIONS INDICATE A POSSIBILITY OF
EQUIPMENT DAMAGE IF INSTRUCTIONS ARE NOT FOLLOWED.
NOTE: NOTES GIVE HELPFUL INFORMATION.
Save These Important Safety Instructions!
Read and understand all of these safety instructions. Be sure to retain them
for future use.
Owner’s Manual
5
Hazard Warnings
Dust
WARNING! DUST FROM POWER SANDING, SAWING,
GRINDING, DRILLING, AND OTHER CONSTRUCTION ACTIVITIES CONTAIN
CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER,
BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
These chemicals may include (but are not limited to) the following:
/HDG IURP OHDGEDVHG SDLQWV
&U\VWDOOLQH VLOLFD IURP EULFNV FHPHQW DQG RWKHU PDVRQU\ SURGucts
$UVHQLF DQG FKURPLXP IURP FKHPLFDOO\WUHDWHG OXPEHU
7KH ULVN IURP WKHVH H[SRVXUHV YDU\ GHSHQGLQJ RQ KRZ RIWHQ \RX GR WKLV W\SH RI
ZRUN 7R UHGXFH \RXU H[SRVXUH WR WKHVH FKHPLFDOV :RUN LQ D ZHOOYHQWLODWHG DUHD
DQG ZRUN ZLWK DSSURYHG VDIHW\ HTXLSPHQW $OZD\V ZHDU 0$+$0,26+ DSSURYHG
SURSHUO\ ILWWHG IDFH PDVNV RU UHVSLUDWRUV ZKHQ XVLQJ VXFK WRRls. Always follow
EDVLF VDIHW\ SUHFDXWLRQV ZKHQ XVLQJ DLU WRROV WR UHGXFH WKH ULVN RI SHUVRQDO LQMXU\
Bursting:
5XVW FDQ ZHDNHQ WKH WDQN 'UDLQ WKH FRQGHQVHG ZDWHU IURP WKH WDQN DIWHU HDFK XVH
WR UHGXFH UXVWLQJ ,I D OHDN LV GHWHFWHG LQ WKH WDQN UHSODFH WKH WDQN LPPHGLDWHO\
'R QRW ZHOG GULOO RU PRGLI\ WKH DLU WDQN RI WKLV FRPSUHVVRU :elding or modifications
RQ WKH DLU FRPSUHVVRU WDQN FDQ VHYHUHO\ LPSDLU WDQN VWUHQJWK DQG FDXVH DQ H[WUHPHO\
KD]DUGRXV FRQGLWLRQ :HOGLQJ RU PRGLI\LQJ WKH WDQN LQ DQ\ PDQQHU ZLOO YRLG WKH
warranty.
&KHFN WKH PDQXIDFWXUHU¶V PD[LPXP SUHVVXUH UDWLQJ IRU DLU WRROV and accessories.
&RPSUHVVRU RXWOHW SUHVVXUH PXVW EH UHJXODWHG VR QRW WR H[FHHG WKH PD[LPXP
SUHVVXUH UDWLQJ RI WKH WRRO 5HOLHYH DOO SUHVVXUH LQ WKH KRVH Eefore attaching or
UHPRYLQJ DFFHVVRULHV
'R QRW WDPSHU ZLWK WKH SUHVVXUH VZLWFK RU UHOLHI YDOYH IRU DQ\ UHDVRQ 'RLQJ VR YRLGV
DOO ZDUUDQWLHV 7KH\ KDYH EHHQ SUHVHW DW WKH IDFWRU\ IRU WKH PD[LPXP SUHVVXUH RI WKLV
XQLW 3HUVRQDO LQMXU\ DQGRU SURSHUW\ GDPDJH PD\ UHVXOW LI WKH SUHVVXUH VZLWFK RU WKH
UHOLHI YDOYH DUH WDPSHUHG ZLWK
'R QRW XVH SODVWLF RU 39& SLSH IRU FRPSUHVVHG DLU 8VH RQO\ JDOYDQL]HG VWHHO SLSH
ILWWLQJV IRU FRPSUHVVHG DLU GLVWULEXWLRQ OLQHV
Air Compressor
6
Owner’s Manual
Hazard Warnings (cont’d)
RISK OF EYE OR HEAD INJURY
What could happen:
$LU SRZHUHG HTXLSPHQW DQG SRZHU WRROV DUH FDSDEOH RI SURSHOOLQJ PDWHULDOV VXFK DV
IDVWHQHUV PHWDO FKLSV VDZ GXVW DQG RWKHU GHEULV DW KLJK VSHHG ZKLFK FRXOG UHVXOW
LQ VHULRXV H\H LQMXU\
&RPSUHVVHG DLU FDQ EH KD]DUGRXV 7KH DLU VWUHDP FDQ FDXVH LQMXU\ WR VRIW WLVVXH
DUHDV VXFK DV H\HV HDUV HWF 3DUWLFOHV RU REMHFWV SURSHOOHG E\ WKH VWUHDP FDQ FDXVH
LQMXU\
7RRO DWWDFKPHQWV FDQ EH EHFRPH ORRVH RU EUHDN DQG IO\ DSDUW SURSHOOLQJ SDUWLFOHV DW
WKH RSHUDWRU DQG RWKHUV LQ WKH ZRUN DUHD
How to prevent it:
$OZD\V ZHDU $16, DSSURYHG = VDIHW\ JODVVHV ZLWK VLGH VKLHOGV
1HYHU OHDYH RSHUDWLQJ WRRO XQDWWHQGHG 'LVFRQQHFW DLU KRVH ZKHQ WRRO LV QRW LQ XVH
)RU DGGLWLRQDO SURWHFWLRQ XVH DQ DSSURYHG IDFH VKLHOG LQ DGGLWLRQ WR VDIHW\ JODVVHV
0DNH VXUH WKDW DQ\ DWWDFKPHQWV DUH VHFXUHO\ DVVHPEOHG
1HYHU SRLQW DQ\ QR]]OH RU VSUD\HU WRZDUG D SHUVRQ RU DQ\ SDUW RI WKH ERG\
(TXLSPHQW FDQ FDXVH VHULRXVV LQMXU\ LI WKH VSUD\ SHQHWUDWHV WKH VNLQ
7
Hazard Warnings (cont’d)
RISK OF FIRE OR EXPLOSION
What could happen:
$EUDVLYH WRROV VXFK DV VDQGHUV DQG JULQGHUV URWDWLQJ WRROV VXFK DV GULOOV DQG
LPSDFW WRROV VXFK DV QDLOHUV VWDSOHV ZUHQFKHV KDPPHUV DQG UHFLSURFDWLQJ VDZV
DUH FDSDEOH RI JHQHUDWLQJ VSDUNV ZKLFK FRXOG UHVXOW LQ LJQLWLRQ RI IODPPDEOH PDWHULDOV
,W LV QRUPDO IRU WKH FRPSUHVVRU PRWRU DQG SUHVVXUH VZLWFK WR SURGXFH VSDUNV ZKLOH
RSHUDWLQJ ,I VSDUNV FRPH LQWR ZLWK YDSRUV IURP JDVROLQH RU RWKHU VROYHQWV
WKH\ PD\ LJQLWH FDXVLQJ D ILUH RU H[SORVLRQ
([FHHGLQJ WKH PD[LPXP SUHVVXUH UDWLQJ RI WRROV RU DFFHVVRULHV FRXOG FDXVH DQ
H[SORVLRQ UHVXOWLQJ LQ VHULRXV LQMXU\
How to prevent it:
1HYHU RSHUDWH WRROV QHDU IODPPDEOH VXEVWDQFHV VXFK DV JDVROLQH FOHDQLQJ VROYHQWV
HWF
:RUN LQ D FOHDQ ZHOOYHQWLODWHG DUHD IUHH RI FRPEXVWLEOH PDWHULDOV
1HYHU XVH R[\JHQ FDUERQ GLR[LGH RU RWKHU ERWWOHG JDVHV DV D SRZHU VRXUFH IRU DLU
WRROV
8VH FRPSUHVVHG DLU UHJXODWHG WR PD[LPXP SUHVVXUH DW RU EHORZ WKH UDWHG SUHVVXUH
RI DQ\ DWWDFKPHQWV
1HYHU FRQQHFW WR DQ DLU VRXUFH WKDW LV FDSDEOH RI H[FHHGLQJ SVL
$OZD\V YHULI\ SULRU WR XVLQJ WKH WRRO WKDW WKH DLU VRXUFH KDV EHHQ DGMXVWHG WR WKH UDWHG
DLU SUHVVXUH UDQJH
1HYHU VSUD\ IODPPDEOH OLTXLGV LQ D FRQILQHG DUHD 'R QRW VSUD\ ZKHUH VSDUNV RU
IODPHV DUH SUHVHQW
'R QRW VPRNH ZKLOH VSUD\LQJ
.HHS FRPSUHVVRU DV IDU IURP VSUD\ DUHD DV SRVVLEOH
Air Compressor
8
Owner’s Manual
Hazard Warnings (cont’d)
RISK OF HEARING LOSS
What could happen:
/RQJ WHUP H[SRVXUH WR QRLVH SURGXFHG IURP WKH RSHUDWLRQ RI DLU WRROV FDQ OHDG WR
SHUPDQHQW KHDULQJ ORVV
How to prevent:
$OZD\V ZHDU $16, 6 KHDULQJ SURWHFWLRQ ZKHQ XVLQJ D FRPSUHVVRU
RISK TO BREATHING/INHALATION HAZARD
What could happen:
$EUDVLYH WRROV VXFK DV JULQGHUV VDQGHUV DQG FXWRII WRROV JHQHUDWH GXVW DQG
DEUDVLYH PDWHULDOV ZKLFK FDQ EH KDUPIXO WR KXPDQ OXQJV DQG UHVSLUDWRU\ V\VWHP
6RPH PDWHULDOV VXFK DV DGKHVLYHV DQG WDU FRQWDLQ FKHPLFDOV ZKRVH YDSRUV FRXOG
FDXVH UHVSLUDWRU\ GDPDJH 5HDG DOO LQVWUXFWLRQV WR EH VXUH WKDW \RXU UHVSLUDWRU
PDVN ZLOO SURWHFW \RX
$OZD\V ZRUN LQ D FOHDQ GU\ ZHOOYHQWLODWHG DUHD
1HYHU GLUHFWO\ LQKDOH FRPSUHVVHG DLU SURGXFHG E\ D FRPSUHVVRU ,W LV QRW VXLWDEOH
IRU EUHDWKLQJ SXUSRVHV
%H FHUWDLQ WR UHDG DOO ODEHOV DQG IROORZ WKH VDIHW\ LQVWUXFWLRQV ZKHQ \RX DUH VSUD\LQJ
SDLQWV RU WR[LF PDWHULDOV
9
Hazard Warnings (cont’d)
RISK OF INJURY
What could happen:
7RROV OHIW XQDWWHQGHG RU ZLWK WKH DLU KRVH DWWDFKHG FDQ EH DFWLYDWHG E\ XQDXWKRUL]HG
SHUVRQV OHDGLQJ WR WKHLU LQMXU\ DQGRU LQMXU\ WR RWKHUV
$LU WRROV FDQ SURSHO IDVWHQHUV RU RWKHU PDWHULDOV WKURXJKRXW WKH ZRUN DUHD
$ ZUHQFK RU NH\ WKDW LV OHIW DWWDFKHG WR D URWDWLQJ SDUW RI WKH WRRO LQFUHDVHV WKH ULVN RI
SHUVRQDO LQMXU\
8VLQJ LQIODWRU QR]]OHV IRU GXVWHU DSSOLFDWLRQV FDQ FDXVH VHULRXV LQMXU\
$LU WRROV FDQ EHFRPH DFWLYDWHG E\ DFFLGHQW GXULQJ PDLQWHQDQFH RU WRRO FKDQJHV
$LU WRROV FDQ FDXVH WKH ZRUN SLHFH WR PRYH XSRQ FRQWDFW OHDGLQJ WR LQMXU\
/RVV RI FRQWURO RI WKH WRRO FDQ OHDG WR LQMXU\ DQGRU LQMXU\ WR RWKHUV
3RRU TXDOLW\ LPSURSHU RU GDPDJHG WRROV VXFK DV JULQGLQJ ZKHHOV FKLVHOV VRFNHWV
GULOOV QDLOHUV VWDSOHV HWF FDQ IO\ DSDUW GXULQJ RSHUDWLRQ SURSHOOLQJ SDUWLFOHV
WKURXJKRXW WKH ZRUN DUHD FDXVLQJ VHULRXV LQMXU\
)DVWHQHUV FRXOG ULFRFKHW RU EH SURSHOOHG FDXVLQJ VHULRXV LQMXU\ RU SURSHUW\ GDPDJH
,PSURSHUO\ PDLQWDLQHG WRROV DQG DFFHVVRULHV FDQ FDXVH VHULRXV LQMXU\
7KHUH LV D ULVN RI EXUVWLQJ LI WKH WRRO LV GDPDJHG
7KH FRPSUHVVRU XQLW VWDUWV DXWRPDWLFDOO\ 6HULRXV LQMXU\ FRXOG RFFXU IURP FRQWDFW
ZLWK PRYLQJ SDUWV
Air Compressor
10
Owner’s Manual
Hazard Warnings (cont’d)
RISK OF INJURY (cont’d)
How to prevent it:
5HPRYH WKH DLU KRVH ZKHQ WKH WRRO LV QRW LQ XVH DQG VWRUH WRRO LQ D VHFXUH ORFDWLRQ DZD\ IURP
WKH UHDFK RI FKLOGUHQ DQGRU XQWUDLQHG XVHUV
8VH RQO\ SDUWV IDVWHQHUV DQG DFFHVVRULHV UHFRPPHQGHG E\ WKH PDQXIDFWXUHU
.HHS WKH ZRUN DUHD FOHDQ DQG IUHH RI FOXWWHU .HHS FKLOGUHQ DQG RWKHUV DZD\ IURP WKH DUHD
GXULQJ RSHUDWLRQ RI WKH WRRO
.HHS WKH ZRUN DUHD ZHOO OLW
5HPRYH DGMXVWLQJ NH\V DQG ZUHQFKHV EHIRUH WXUQLQJ WKH WRRO RQ
'2 127 XVH LQIODWRU QR]]OHV IRU GXVWLQJ DSSOLFDWLRQV
5HPRYH WKH DLU KRVH WR OXEULFDWH RU DGG JULQGLQJ DWWDFKPHQWV VDQGLQJ GLVFV GULOOV HWF
1HYHU FDUU\ WKH WRRO E\ WKH KRVH
$YRLG XQLQWHQWLRQDO VWDUWLQJ
5HSDLU VHUYLFLQJ VKRXOG EH GRQH RQO\ E\ DQ DXWKRUL]HG VHUYLFH UHSUHVHQWDWLYH
1HYHU RSHUDWH WKH WRRO ZKLOH XQGHU WKH LQIOXHQFH RI GUXJV RU DOFRKRO
'RQ¶W RYHUUHDFK .HHS SURSHU IRRWLQJ DQG EDODQFH DW DOO WLPHV
.HHS WKH KDQGOHV GU\ FOHDQ DQG IUHH IURP RLO DQG JUHDVH
6WD\ DOHUW :DWFK ZKDW \RX DUH GRLQJ 8VH FRPPRQ VHQVH 'R QRW RSHUDWH WKH WRRO ZKHQ
\RX DUH WLUHG
1HYHU XVH WRROV ZKLFK KDYH EHHQ GURSSHG LPSDFWHG RU GDPDJHG
11
Hazard Warnings (cont’d)
RISK OF INJURY (cont’d)
8VH RQO\ LPSDFW JUDGH VRFNHWV RQ DQ LPSDFW ZUHQFK
'R QRW DSSO\ H[FHVVLYH IRUFH WR WKH WRRO /HW WKH WRRO SHUIRUP WKH ZRUN
1HYHU SRLQW GLVFKDUJH RI WRRO DW \RXUVHOI RU RWKHUV
'R QRW SXOO WKH WULJJHU XQOHVV WKH WRRO FRQWDFW VDIHW\ RI WKHGHYLFH LV DJDLQVW ZRUN VXUIDFH
1HYHU DWWHPSW WR GULYH IDVWHQHUV LQWR KDUG VXUIDFHV VXFK DV VWHHO FRQFUHWH RU WLOH
ZKHQ XVLQJ DLU WRROV
8VH RQO\ DFFHVVRULHV LGHQWLILHG E\ WKH PDQXIDFWXUHU WR EH XVHG ZLWK VSHFLILF WRROV
0DLQWDLQ WKH WRRO ZLWK FDUH
.HHS D FXWWLQJ WRRO VKDUS DQG FOHDQ $ SURSHUO\ PDLQWDLQHG WRRO ZLWK VKDUS FXWWLQJ
HGJHV UHGXFHV WKH ULVN RI ELQGLQJ DQG LV HDVLHU WR FRQWURO
&KHFN IRU PLVDOLJQPHQW RI ELQGLQJ RU PRYLQJ SDUWV EUHDNDJH RI SDUWV DQG DQ\ RWKHU
FRQGLWLRQ WKDW DIIHFWV WKH WRRO¶V RSHUDWLRQ ,I GDPDJHG KDYH WKH WRRO VHUYLFHG EHIRUH
XVLQJ
8VH RI DQ DFFHVVRU\ QRW LQWHQGHG IRU XVH ZLWK WKH VSHFLILF WRROV LQFUHDVHV WKH ULVN RI
LQMXU\
$OZD\V VKXW WKH FRPSUHVVRU RII UHPRYH WKH SOXJ IURP WKH RXWOHW DQG EOHHG DOO
SUHVVXUH IURP WKH V\VWHP EHIRUH VHUYLFLQJ WKH FRPSUHVVRU RU ZKHQ WKH
FRPSUHVVRU LV QRW LQ XVH
'R QRW RSHUDWH WKH XQLW ZLWK WKH VKURXG UHPRYHG
Air Compressor
12
Owner’s Manual
Hazard Warnings (cont’d)
RISK OF ELECTRIC SHOCK
What could happen:
8VLQJ DLU WRROV WR DWWDFK HOHFWULFDO ZLULQJ FDQ UHVXOW LQ HOHFWURFXWLRQ RU GHDWK
,PSURSHU HOHFWULFDO FRQQHFWLRQV FDQ UHVXOW LQ ILUHV HOHFWURFXWLRQ RU GHDWK
,I WKH WRRO LV QRW SURYLGHG ZLWK DQ LQVXODWHG JULSSLQJ VXUIDFH FRQWDFW ZLWK D ³OLYH´ ZLUH
PDNHV H[SRVHG PHWDO WRRO SDUWV DOVR ³OLYH´ UHVXOWLQJ LQ SRVVLEOH HOHFWURFXWLRQ RU GHDWK
)DVWHQHUV FRPLQJ LQ FRQWDFW ZLWK KLGGHQ HOHFWULFDO ZLULQJ FRXOG FDXVH HOHFWURFXWLRQ RU
GHDWK
How to prevent it:
1HYHU DWWDFK HOHFWULFDO ZLULQJ ZLWK HQHUJL]HG WRROV
$YRLG ERG\ FRQWDFW ZLWK JURXQGHG VXUIDFHV VXFK DV SLSHV UDGLDWRUV UDQJHV DQG
UHIULJHUDWRUV 7KHUH LV DQ LQFUHDVHG ULVN RI HOHFWULF VKRFN LI \RXU ERG\ LV JURXQGHG
7KRURXJKO\ LQYHVWLJDWH WKH ZRUN SODFH IRU SRVVLEOH KLGGHQ ZLULQJ EHIRUH SHUIRUPLQJ
ZRUN
$ OLFHQVHG HOHFWULFLDQ LQ DFFRUGDQFH ZLWK DOO ORFDO DQG QDWLRQDO FRGHV PXVW LQVWDOO DOO
ZLULQJ
1HYHU XVH DQ HOHFWULF DLU FRPSUHVVRU RXWGRRUV ZKHQ LW LV UDLQLQJ RU RQ D ZHW VXUIDFH
DV LW PD\ FDXVH DQ HOHFWULF VKRFN
13
Hazard Warnings (cont’d)
RISK OF ENTANGLEMENT
What could happen:
7RROV FRQWDLQLQJ PRYLQJ HOHPHQWV RU GULYLQJ RWKHU PRYLQJ WRROV JULQGLQJ ZKHHOV
VRFNHWV VDQGLQJ GLVFV HWF FDQ EHFRPH HQWDQJOHG LQ KDLU FORWKLQJ MHZHOU\ DQG
RWKHU ORRVH REMHFWVWKHUHE\ UHVXOWLQJ LQ LQMXU\
How to prevent it:
1HYHU ZHDU ORRVH ILWWLQJ FORWKHV RU DSSDUHO WKDW FRQWDLQ ORRVH VWUDSV WLHV HWF
ZKLFK FRXOG EHFRPH HQWDQJOHG LQ PRYLQJ SDUWV
5HPRYH DQ\ MHZHOU\ ZDWFKHV EUDFHOHWV QHFNODFHV HWFZKLFK PLJKW EHFRPH
FDXJKW LQ WKH WRRO
.HHS \RXU KDQGV DZD\ IURP PRYLQJ SDUWV 7LH XS RU FRYHU ORQJ KDLU
Air Compressor
14
Owner’s Manual
Hazard Warnings (cont’d)
RISK OF CUT OR BURNS
What could happen:
7RROV ZKLFK FXW VKHDU GULOO VWDSOH SXQFK FKLVHO HWF DUH FDSDEOH RI FDXVLQJ VHULRXV
LQMXU\
7KH SXPS DQG PDQLIROG JHQHUDWH KLJK WHPSHUDWXUHV
How to prevent it:
.HHS WKH ZRUNLQJ SDUW RI WKH WRRO DZD\ IURP \RXU KDQGV DQG ERG\
'R QRW WRXFK WKH SXPS PDQLIROG RU WUDQVIHU WXEH ZKLOH WKH SXPS LV UXQQLQJ $OORZ
WKHP WR FRRO EHIRUH KDQGOLQJ RU VHUYLFLQJ
.HHS FKLOGUHQ DZD\ IURP WKH FRPSUHVVRU DW DOO WLPHV
15
Precautions
'UDLQ WKH PRLVWXUH IURP WKH WDQN EHIRUH HDFK XVH WR KHOS SUHYent corros
ion.
3XOO WKH SUHVVXUH UHOLHI YDOYH ULQJ EHIRUH HDFK XVH WR
e
QVXUH SURSHU IXQFWLRQ DQG
WR FOHDU SRVVLEOH REVWUXFWLRQV
7R SURYLGH SURSHU YHQWLODWLRQ IRU FRROLQJ tKH FRPSUHVVRU PXVW EH NHSW DW OHDVW
LQFKHV FP IURP WKH QHDUHVW ZDOO LQ D ZHOOYHQWLODWHG DUHa.
)DVWHQ WKH FRPSUHVVRU VHFXUHO\ DQG UHOHaVH WKH WDQN SUHVVXUH EHIRUH WUDQVSRUWLQJ
3URWHFW WKH DLU KRVH DQG HOHFWULF FRUG IURP GDPDJH DQG SXQFWXUH ,QVSHFW
WKHP IRU ZHDN RU ZRUQ VSRWV DQG UHSODFH LI QHFHVVDU\
7R UHGXFH WKH ULVN RI HOHFWULF VKRFN GR QRW H[SRVH WR UDLQ 6WRUH LQGRRUV
1HYHU RSHUDWH WKH FRPSUHVVRU LI WKH SRZHU FRUG RU SOXJ LV GDPDJHG 7DNH
WKH HTXLSPHQW WR QHDUHVW DXWKRUL]HG VHUYLFH FHQWHU DQG D WHFKQLFLDQ
ZLOO UHSODFH LW
WARNING! The power cord on this product contains
lead, a chemical, known to the state of California to cause
cancer and birth defects or other reproductive harm.
Wash your hands after handling
Air Compressor
0RGHO 1XPEHU 3&(.
+RUVH 3RZHU
7DQN &DSDFLW\
*DOORQV/LWHUV
*DOORQ
9ROWDJH$PSV3KDVH
.LFN,Q 3UHVVXUH 75
.LFN2XW 3UHVVXUH 100
&RPSUHVVRU 6SHFLILFDWLRQV
16
Owner’s Manual
Compressor (cont’d)
Basic Air Compressor Components
Oil-less aircompressors are factory
lubricated for life and do not require
any oil.
The basic components of the air
compressor are the electric motor,
pump, pressure switch, and tank.
The electric motor (see A) powers
the pump. The electric motor is
equipped with an overload protector
and an automatic reset. If the motor
becomes overheated, the overload
protector will shut it down to prevent
damage to the motor. When the motor
sufficiently cools, it will automatically
restart.
The pump (see B) compresses the air
and discharges it into the tank.
The tank (see C) stores the compressed
air.
The pressure switch (located internally) shuts down the motor and relieves air
pressure in the pump and transfer tube when the air pressure in the tank reaches
the kick-out pressure. As compressed air is used and the pressure level in the
tank drops to the kick-in pressure, the pressure switch restarts the motor
automatically, without warning, and the pump resumes compressing air.
A & B
17
Compressor (cont’d)
Assembling the Air Compressor
Unpack the air compressor. Inspect the unit for damage. If the unit has been damaged
in transit, contact the carrier and complete a damage claim. Do this immediatly
because there are time limitations to damage claims. The carton should contain.
$LU &RPSUHVVRU
0DQXDO
+DQGOH
$FFHVVRULHV
1) Attach handle and srew in properly.
Air Compressor
18
Owner’s Manual
Compressor (cont’d)
COMPRESSOR CONTROLS
Power switch: This switch turns the compressor power ON and OFF.
Pressure Relieve Valve: If the pressure switch does not shut down the motor when
pressure reaches the preset level, this valve will pop open automatically to prevent
over pressurization. To operate manually, pull the ring on the valve to relieve air
pressure in the tank.
Tank Pressure Gauge: This gauge measures the pressure level of the air stored in
the tank. It is not adjustable by the operator and does not indicate line pressure.
Air Pressure Regulator: This air pressure regulator enables you to adjust line
pressure to the tool you are using.
WARNING! NEVER EXCEED THE MAXIMUM WORKING
PRESSURE OF THE TOOL. TURN THE KNOB CLOCKWISE TO INCREASE
PRESSURE, AND COUNTERCLOCKWISE TO DECREASE PRESSURE.
Power Switch
Tank Pressure Gauges
Air Pressure Regulator
Pressure Relieve Valve
19
Compressor (cont’d)
Electrical Power Requirements
Electrical Wiring
Refer to the air compressor’s registration label for the unit’s voltage and amperage
requirements. Use a dedicated circuit. For best performance and reliable starting, the
air compressor must be plugged into a dedicated circuit, as close as possible to the
fuse box or circuit breaker. The compressor will use the full capacity of a typical
15 amp household circuit. If other devices are on the same circuit, the compressor
may fail to start. Low voltage or an overloaded circuit can result in sluggish starting
that causes the motors overload protection system circuit breaker to trip, especially in
cold conditions.
Note: A circuit breaker is recommended. If the air compressor is connected to
a circuit protected by a fuse, use dual element time delay fuses (Buss Fusetron type“1”
only).
Note: Avoid use of extension cords. If using an extension cord is necessary,
be sure to use an extension with the correct specifications.
For optimum performance, plug the compressor power cord directly into a grounded
wall socket. Do not use an extension cord unless absolutely necessary. Instead, use a
longer air hose to reach the area where the air is needed.
If use of an extension cord cannot be avoided, the cord should be no longer than 100
feet and be a minimum wire size of 14 gauge (AWG).
Air Compressor
20
Owner’s Manual
Compressor (cont’d)
ELECTRICAL POWER REQUIREMENTS (cont’d)
This product is for use on a nominal 110 volt circuit. An outlet having the
same configuration as the plug. No adapter should be used with this product.
Do not alter the plug to fit into a non–Ground or 2-slot receptacle.
WARNING! IMPROPER INSTALLATION OF THE GROUNDING PLUG
CAN RESULT IN THE RISK OF ELECTRIC SHOCK. IF REPAIR OR
REPLACEMENT OF THE CORD OR PLUG IS NECESSARY, DO NOT
CONNECT THE GROUNDING WIRE TO THE FLAT BLADE TERMINAL.
THE WIRE INSULATION THAT HAS AN OUTER SURFACE THAT IS GREEN
GREEN WITH, OR WITHOUT, YELLOW STRIPES IS THE GROUNDING WIRE.
Extension Cord
Use the chart on the right for
the proper extension cord length.
Use only a 3-wire extension cord
that has a 3-blade grounding plug
and a 3-slot receptacle that will
accept the plug of the product. Make
sure your extension cord is in good
condition. An undersized cord will
cause a drop in line voltage as well
as a loss of power and overheating.
The smaller the gauge number, the
heavier the cord.
Grounding Instructions
This product is equipped with a cord having a grounding wire and an
appropriate grounding plug. The plug must be plugged into an outlet
that is properly installed and grounded in accordance with all local codes
and ordinance.
AMP
RATING
LENGTH OF
CORD IN FEET
(120 Volts)
10 12
12 14
14 16
16 18
18 20
25’
16
16
16
14
14
50’
14
12
12
12
12
100’
10
10
10
8
8
150’
8
8
8
8
8
21
Compressor (cont’d)
BREAKING IN THE PUMP
1.Turn the switch to the OFF position.
2. Open the petcock. Turn counterclockwise (loosen).
3. Plug in the power switch to the ON position.
4. The compressor will start.
ALLOW THE COMPRESSOR TO RUN FOR 15 MINUTES, TO BREAK IN THE
INTERNAL PARTS.
CAUTION: AFTER ABOUT 15 MINUTES. IF THE UNIT DOES NOT
OPERATE PROPERLY, SHUT IT DOWN IMMEDIATELY AND CONTACT
PRODUCT SERVICE CENTER 1-866-591-8921.
5. After about 15 minutes, turn the power switch to the OFF position.
6. Close the petcock. Turn in the clockwise direction.
7. Turn the power switch to the ON position. The compressor will start and fill the tank
to the kick-out pressure and stop.
Note: As compressed air is used, the pressure switch will restart the
motor automatically.
Note: During the initial break-in cycle, there will be a slight electrical
smell as the motor brushes seat.This is normal for universal motors and will last for
about 5 minutes.
OPERATING INSTRUCTIONS
Periodic Starting
1. Turn the power switch to the OFF position.
2. Close the tank petcock. Turn in the clockwise direction.
3. Plug in the power cord.
4. Turn the power switch to the ON position.
Air Compressor
22
Owner’s Manual
Compressor (cont’d)
OPERATING INSTRUCTIONS
WARNING! HIGH TEMPERATURES ARE GENERATED BY THE
ELECTRIC MOTOR AND THE PUMP. TO PREVENT BURNS OR OTHER NJURIES,
I DO NOT TOUCH THE COMPRESSOR WHILE IT IS RUNNING. ALLOW IT TO COOL
I BEFORE HANDLING OR SERVICING. KEEP CHILDREN AWAY FROM THE
COMPRESSOR AT ALL TIMES.
WARNING! WHEN ADJUSTING FROM A HIGHER TO A LOWER
PRESSURE, TURN THE KNOB COUNTERCLOCKWISE TO REACH THE DESIRED
PRESSURE. DO NOT EXCEED THE OPERATING PRESSURE OF THE TOOL OR
ACCESSORY BEING USED.
5. Adjust the regulator to the working pressure of the tool. (never exceed 90 PSI)
Shut down
1. Turn the power switch to the OFF position.
2. Unplug the power cord.
3. Reduce pressure in the tank thorough the outlet hose. You can also pull the relief
valve ring and keep it open in the tank.
WARNING! ESCAPING AIR AND MOISTURE CAN PROPEL DEBRIS
THAT MAY CAUSE EYE INJURY. WEAR SAFETY GOGGLES WHEN OPENING
PETCOCK.
4. Tip the compressor (if necessary for your model ) so the petcock is at the bottom of
the tank(s).Then open the petcock to allow moisture to drain from the tank.
23
Compressor (cont’d)
MAINTENANCE
WARNING! TO AVOID PERSONAL INJURY, ALWAYS SHUT
OFF AND UNPLUG THE COMPRESSOR AND RELIEVE ALL AIR PRESSURE
FROM THE SYSTEM BEFORE PERFORMING ANY SERVICE ON THE AIR
COMPRESSOR.
Air Compressor
24
Owner’s Manual
Compressor (cont’d)
MAINTENANCE (cont’d)
Relieve the air pressure in the system and open the petcock on the
bottom of the tank to drain.
WARNING! CONDENSATION WILL ACCUMULATE IN THE TANK. TO
PREVENT CORROSION OF THE TANK FROM THE INSIDE, THIS MOISTURE
MUST BE DRAINED AT THE END OF EVERY USE. BE SURE TO WEAR
PROTECTIVE EYEWEAR.
Note: In cold climates, drain the tank after each use to reduce problems with
freezing of water condensation.
Testing for Leaks
Check that all connections are right. A small leak in any of the hoses or pipe
connections will substantially reduce the performance of your air compressor. If you
suspect a leak, spray a small amount of soapy water with spray bottle. If bubbles
appear, repair or replace the faulty component. Do not over tighten any connections.
Storage
Before storing the compressor for a prolonged period, use the nozzle to clean all
dust and debris from the STORAGE compressor. Disconnect the power cord and coil
it up. Pull the pressure relief valve to release all pressure from the tank. Cover the
entire unit to protect it from moisture and dust.
Servicing
Perform the following maintenance at the intervals indicated below:
2SHUDWH WKH SUHVVXUH UHOLHI YDOYH $IWHU HDFK XVH
'UDLQ DLU IURP WDQN $IWHU HDFK XVH
25
Compressor (cont’d)
TROUBLE SHOOTING
Note: Trouble shooting problems may have similar causes and solutions.
7KH 7DQN SHWFRFN LV RSHQ &ORVH WKH SHW FRFN
Low pressure, not enough air or compressor does not stop.
3URORQJHG H[FHVVLYH FRQVXPSWLRQ RI DLU
'HFUHDVH DPRXQW RI DLU XVHG
7KH &RPSUHVVRU QRW ODUJH HQRXJK IRU MRE
&KHFN WKH DLU UHTXLUHPHQW RI DFFHVVRU\ ,I LW LV KLJKHU WKDQ WKH &)0 DQG SUHVVXUH RI
WKH FRPSUHVVRU \RX QHHG D ODUJHU FRPSUHVVRU 0RVW DFFHVVRULHV DUH UDWHG DW RI
DFWXDO &)0 ZKLOH UXQQLQJ FRQWLQXRXVO\
5HVWULFWHG FKHFN YDOYH
Remove and clean or replace.
+ROH LQ DLU KRVH
&KHFN DQG UHSODFH LI QHFHVVDU\
7DQN OHDNV
5HSODFH WDQN
WARNING! ,00(',$7(/< 5(3/$&( 7$1. '2 127 $77(037
72 5(3$,5
%ORZQ VHDOV
5HSODFH DQ\ IDXOW\ VHDOV
Replace worn parts and reassemble with new seals.
Air Compressor
26
Owner’s Manual
Compressor (cont’d)
TROUBLE SHOOTING (cont’d)
Excessive starting and stopping, while not in use
)LWWLQJV OHDN
&KHFN WKH ILWWLQJV ZLWK VRDS\ ZDWHU 7LJKWHQ RU UHVHDO OHDNLQJ ILWWLQJV '2 127
29(57,*+7(1
5HSODFH ZRUQ SDUWV DQG UHDVVHPEOH ZLWK QHZ VHDOV
5HSODFH DQ\ UHJXODWRU LQWHUQDO SDUWV
7KH 5HJXODWHG SUHVVXUH JDXJH UHDGLQJ GURSV ZKHQ D WRRO LV EHLQJ XVHG
This is normal in some applications
&RPSUHVVRU QRW ODUJH HQRXJK
,I SUHVVXUH GURSV WRR ORZ DGMXVW WKH UHJXODWRU ZKLOH DFFHVVRU\ LV XVHG
&KHFN DLU UHTXLUHPHQWV RI D WRRO LW PD\ EH KLJKHU WKDQ WKH &)0 SUHVVXUH VXSSOLHG E\
WKH FRPSUHVVRU 0RVW DFFHVVRULHV DUH UDWHG DW RI DFWXDO &)0 Zhile running
FRQWLQXRXVO\
&LUFXLW EUHDNHU WULSV IXVH EORZV WRR RIWHQ
/RZ YROWDJH FRQVXOW DQ HOHFWULFLDQ
([FHVVLYH ZLUH OHQJWK
)XUQLVK DGHTXDWH SRZHU ,I XVLQJ H[WHQVLRQ FRUG WU\ DJDLQ ZLWKRXW LW
5HVWULFWHG DLU SDVVDJHV
&RQWDFW DQ DXWKRUL]HG VHUYLFH FHQWHU
%DFN SUHVVXUH LQ SXPS KHDG
5HSODFH WKH FKHFN YDOYH
5HSODFH WKH SUHVVXUH VZLWFK EOHHGHU YDOYH
27
Compressor (cont’d)
TROUBLE SHOOTING (cont’d)
Overheating
3RRU YHQWLODWLRQ
5HORFDWH WKH FRPSUHVVRU WR DQ DUHD ZLWK FRRO GU\ DQG ZHOOFLUFXOated air.
'LUW\ FRROLQJ VXUIDFH
&OHDQ DOO FRROLQJ VXUIDFHV RI WKH SXPS WKRURXJKO\
/HDNLQJ YDOYH
5HSODFH WKH ZRUQ SDUWV DQG UHDVVHPEOH ZLWK QHZ VHDOV
0RWRU VWDOOV
/RZ YROWDJH
)XUQLVK DGHTXDWH SRZHU
'HIHFWLYH SUHVVXUH VZLWFK EOHHGHU YDOYH
5HSODFH WKH SUHVVXUH VZLWFK EOHHGHU YDOYH
3UHVVXUH UHOLHI YDOYH RSHQV
7DQN SUHVVXUH WKLV H[FHHGHG WKH QRUPDO RSHUDWLQJ SUHVVXUH
5HSODFH WKH SUHVVXUH VZLWFK
0RWRU ZLOO QRW UXQ
7KH WDQN SUHVVXUH H[FHHGV WKH SUHVVXUH VZLWFK OLPLW
0RWRU ZLOO VWDUW DXWRPDWLFDOO\ ZKHQ WDQN SUHVVXUH GURSV EHORZ WKH NLFNLQ SUHVVXUH WDQN
0RWRU RYHUORDG SURWHFWLRQ KDV WULSSHG
/HW WKH PRWRU FRRO RII DQG WKH RYHUORDG VZLWFK ZLOO DXWRPDWLFDOO\ UHV
HW 7KLV PD\ WDNH VHYHUDO
PLQXWHV
Air Compressor
28
Owner’s Manual
Compressor (cont’d)
TROUBLE SHOOTING (cont’d)
Motor will not run (cont’d)
$ IXVH EORZQ RU FLUFXLW EUHDNHU WULSSHG
5HSODFH WKH EORZQ IXVH RU UHVHW WKH FLUFXLW EUHDNHU 'R QRW XVH D IXVH
RU FLUFXLW EUHDNHU ZLWK D
KLJKHU UDWLQJ WKDQ VSHFLILHG IRU \RXU FLUFXLW
&KHFN IRU D SURSHU IXVH ³)XVHWURQ´ W\SH 7 LV DFFHSWDEOH
&KHFN IRU ORZ YROWDJH DQG WKH SURSHU H[WHQVLRQ FRUG VL]H
'LVFRQQHFW RWKHU DSSOLFDWLRQV IURP FLUFXLW 2SHUDWH FRPSUHVVRU RQ D GHGLFDWHG FLUFXLW
&KHFN YDOYH LV VWXFN RSHQ
5HPRYH DQG FOHDQ RU UHSODFH
,I WKH EOHHGHU YDOYH GRHV QRW RSHQ
5HSODFH WKH EOHHGHU YDOYH
:URQJ ZLUH JDXJH LQ H[WHQVLRQ FRUG
&KHFN IRU WKH SURSHU JDXJH DQG H[WHQVLRQ FRUG OHQJWK
3DLQW VSUD\ RQ LQWHUQDO PRWRU SDUWV
%ULQJ WKH XQLW WR D VHUYLFH FHQWHU IRU VHUYLFH 'R QRW RSHUDWH WKH FRPSUHVVR
VSUD\ DUHD
U LQ WKH SDLQW
3RVVLEOH GHIHFWLYH PRWRU
%ULQJ WKH XQLW WR D VHUYLFH FHQWHU IRU LQVSHFWLRQ DQG UHSDLU
29
Compressor (cont’d)
TROUBLE SHOOTING (cont’d)
Glossary of Terms
&)0 &XELF IHHW SHU PLQXWH D XQLW RI PHDVXUH RI DLU IORZ
36, 3RXQGV SHU VTXDUH LQFK D XQLW RI PHDVXUH RI DLU SUHVVXUH
.LFNLQ SUHVVXUH $ IDFWRU\ VHW ORZ SUHVVXUH SRLQW WKDW HQJDJHV WKH FRPSUHVVRU WR
GHSUHVVXUL]H WKH WDQN WR D KLJKHU SUHVVXUH
.LFNRXW SUHVVXUH $ IDFWRU\ VHW KLJK SUHVVXUH SRLQW WKDW VWRSV WKH FRPSUHVVRU IURP
LQFUHDVLQJ WKH SUHVVXUH LQ WKH WDQN DERYH D FHUWDLQ OHYHO
:HOOYHQWLODWHG $ PHDQV RI SURYLGLQJ IUHVK DLU LQ H[FKDQJH IRU GDQJHURXV H[KDXVW
RU YDSRUV
$60( $PHULFDQ 6RFLHW\ RI 0HFKDQLFDO (QJLQHHUV ,QGLFDWHV WKDW WKH FRPSRQHQWV
DUH PDQXIDFWXUHG WHVWHG DQG LQVSHFWHG IRU WKH H[FOXVLYH XVH RI WKH DLU
FRPSUHVVRU
&6$ &DQDGLDQ 6WDQGDUGV $VVRFLDWLRQ ,QGLFDWHV WKDW WKH SURGXFWV WKDW KDYH
WKLV PDUNLQJ KDYH EHHQ PDQXIDFWXUHG WHVWHG DQG LQVSHFWHG WR VWDQGDUGV WKDW DUH
VHW E\ &6$ 7KHVH SURGXFWV DOVR FRQILUP WR 8/ VWDQGDUG
Air Compressor
30
Parts Listing
Owner’s Manual
4
21
13
34
8
10
7
36
23
33
27
26
28
30
20
2
3
921
19
38
5
22
16
24
9
25
9
11
15
6
12
14
18
31
32
35
37
39
18
31
Air Compressor
Parts Listing
PCE6020K-A-01 Air tank assmbly
PCE6020K-A-02 Moisture release valve
PCE6020K-A-03 Rubber foot
PCE6020K-A-04 Cover
PCE6020K-A-05 Handle
PCE6020K-A-06 Handle protection
PCE6020K-A-07 Power switch
PCE6020K-A-08 Fuse base
PCE6020K-A-09 Motor head
PCE6020K-A-10 Cir cuit assmbly
PCE6020K-A-11 Plain washer
4
PCE6020K-A-12 Plain washer
6
PCE6020K-A-13 Spring washer
4
PCE6020K-A-14 Spring washer
6
PCE6020K-A-15 Bolt M4
40
PCE6020K-A-16 Bolt M5
18
PCE6020K-A-17 Bolt M3
8
PCE6020K-A-18 Bolt M4
10
PCE6020K-A-19 Bolt M4
15
PCE6020K-A-20 Bolt M6
15
PARTS NO. DESCRIPTI ON
32
Parts Listing
Owner’s Manual
PCE6020K-A-21 Bolt M6 15
PCE6020K-A-22 Plain washer
6
PCE6020K-A-23 Plain washer
4
PCE6020K-A-24 Vibration foot
PCE6020K-A-25 Bolt
PCE6020K-A-26 Pressure switch
PCE6020K-A-27 Electrical wire
PCE6020K-A-28 Wire clamp
PCE6020K-A-29 Wire plate
PCE6020K-A-30 Washer
PCE6020K-A-31 Spring
PCE6020K-A-32 Bolt
PCE6020K-A-33 Tube connector
PCE6020K-A-34 Nut
8
PCE6020K-A-35 Sylinder cover
PCE6020K-A-36 Air hose
PCE6020K-A-37 Safety valve
PCE6020K-A-38 Combination connector
PCE6020K-A-39 Pressure gauge
DESCRIPTIONPARTS NO.
33
Air Compressor
LIMITED WARRANTY
Pulsar Products, Inc. warrants to the original purchaser who uses the product in a consumer
application (personal, residential or household usage) that all products covered under this
warranty are free from defects in material and workmanship for one year from the date of
purchase. All products covered by this limited warranty which are used in commercial
applications (i.e. income producing) are warranted to be free of defects in material and
workmanship for 90 days from the date of original purchase. Products covered under this
warranty include air compressors, air tools, service parts, pressure washers and generators.
Pulsar Products, Inc. will repair or replace at Pulsar Products, Inc. sole option, products or
components which have failed within the warranty period. Service will be scheduled
according to the normal work flow and business hours at the service center location, and
the availability of replacement parts. All decisions of
Pulsar Products, Inc. with regard to this
limited warranty shall be final. This warranty gives you specific legal rights, and you may
also have other rights which vary from state to state.
RESPONSIBILITY OF ORIGINAL PURCHASER (Initial User):
To process a warranty claim on this product, DO NOT return item to the retailer. The
product must be evaluated by an Authorized Warranty Service Center. For the location of
the nearest Authorized Warranty Service Center contact the retailer or place of purchase.
Retain original cash register sales receipt as proof of purchase for warranty work.
Use reasonable care in the operation and maintenance of the product as described in the
Owner’s Manual(s).
Deliver or ship the product to the nearest Authorized Warranty Service Center. Freight
costs, if any, must be paid by the purchaser.
Air compressors with 60 and 80 gallon tanks will be inspected at the site of installation.
Contact the nearest Authorized Warranty Service Center that provides on-site service calls
for service call arrangements.
If the purchaser does not receive satisfactory results from the Authorized Warranty Service
Center, the purchaser should contact Pulsar Products, Inc.
34
Owner’s Manual
LIMITED WARRANTY (cont’d)
THIS WARRANTY DOES NOT COVER:
Merchandise sold as reconditioned, used as rental equipment, or floor or display
models.
Merchandise that has become damaged or inoperative because of ordinary wear,
misuse, cold, heat, rain, excessive humidity, freeze damage, use of improper
chemicals, negligence, accident, failure to operate the product in accordance
with the instructions provided in the Owner’s Manual(s) supplied with the
product, improper maintenance, the use of accessories or attachments not
recommended by Pulsar Products, Inc , or unauthorized repair or alterations.
Repair and transportation costs of merchandise determined not to be defective.
Costs associated with assembly, required oil, adjustments or other installation and
start-up costs.
Expendable parts or accessories supplied with the product which are expected to
become inoperative or unusable after a reasonable period of use.
Merchandise sold by Pulsar Products, Inc. which has been manufactured by and
identified as the product of another company, such as gasoline engines. The
product manufacturer's warranty, if any, will apply.
ANY INCIDENTAL, INDIRECT OR CONSEQUENTIAL LOSS, DAMAGE, OR
EXPENSE THAT MAY RESULT FROM ANY DEFECTS, FAILURE OR
MALFUNCTION OF THE PRODUCT IS NOT COVERED BY THIS
WARRANTY. Some states do not allow the exclusion, so it may not apply to you.
IMPLIED WARRANTIES, INCLUDING THOSE OF MERCHANTABILITY OR
FITNESS FOR A PARTICULAR PURPOSE, ARE LIMITED TO ONE YEAR
FROM THE DATE OF ORIGINAL PURCHASE. Some states do not allow
limitations on how long an implied warranty lasts, so the above limitations may not apply.
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
Pulsar PCE6050T Owner's manual
- Category
- Air compressors
- Type
- Owner's manual
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
Other documents
-
All-Power APC005 Owner's manual
-
Pulsar Products PCE6031PK User manual
-
-
Milwaukee 5263-20 User manual
-
-
-
Ryobi RPP755E Owner's manual
-
-
Mitsubishi MSZGL35VGDKIT Installation guide
-
