Brinly-Hardy P20-500BH Owner's manual

Brinly-Hardy
Brand
Brinly-Hardy
Model
P20-500BH
Category
Spreader
Type
Owner's manual
1008066 Rev. A
Owner's Manual
Push Spreader
MODEL:
P20-500BH
• Assembly
• Installation
• Operation
• RepairParts
This manual contains information for the safety
of persons and property. Read it carefully before
assembly and operation of the equipment!
Visit us on the web!
www.brinly.com
For the latest product updates and setup tips:
IMPORTANT
©2010Brinly-HardyCompany
1008066 Rev. A 2
INTRODUCTION
SAFETY
CONGRATULATIONSonthepurchaseofyournewBrinly-Hardy
BroadcastSpreader!YourBroadcastSpreaderisdesigned,engineered
andmanufacturedtogiveyouthebestpossibledependabilityand
performance.
CUSTOMER RESPONSIBILITIES
Pleasereadandretainthismanual.Theinstructionsenablesyouto
assembleandmaintainyourBroadcastSpreaderproperly.Bethoroughly
familiarwiththecontrolsandtheproperuseoftheequipment.Know
howtostopthemachineanddisengagethecontrolsquickly.And
please,alwaysobservethe“Safety”instructions.
TABLE OF CONTENTS
SAFETY......................................................................................... 2-3
PARTSBREAKDOWN................................................................. 4-5
ASSEMBLY................................................................................... 6-9
OPERATIONANDMAINTENANCE..........................................10-11
APPLICATIONRATECHART................................................... 12-15
WARRANTY......................................................................Backpage
RECORD PURCHASE INFORMATION
Recordyourpurchaseinformationinthespacesprovidedbelow:
DATEOFPURCHASE:
COMPANYNAME:
COMPANYPHONE:
SERIALNUMBER:
SAFETY LABELS
UNDERSTANDING THE MACHINE SAFETY LABELS:
Themachinesafetylabelsshowninthissectionareplacedinimportant
areasonyourmachinetodrawattentiontopotentialsafetyhazards.
Onyourmachinesafetylabels,thewordsDANGER,WARNING,and
CAUTIONareusedwiththissafety-alertsymbol.DANGERidentiesthe
mostserioushazards.
Theoperator'smanualalsoexplainsanypotentialsafetyhazards
whenevernecessaryinspecialsafetymessagesthatareidentiedwith
theword,CAUTION,andthesafety-alertsymbol.
SAFETY ALERT SYMBOL
1008066 Rev. A
3
SAFETY
OPERATE SAFELY
Keepbystandersawaywhenyouoperatethismachine.
Usethismachineforintendedpurposeonly.
Thismachineisintendedforuseinlawncareandhome
applications.
Donotletchildrenoranuntrainedpersonoperatemachine.
Keepallpartsingoodconditionandproperlyinstalled.Fix
damagedpartsimmediately.Replacewornorbrokenparts.
Donotmodifythemachineorsafetydevices.Unauthorized
modicationstothemachinemayimpairitsfunctionand
safety,andvoidthewarranty.
Donotletanyonesitorrideonequipmentduringoperation.
Keepridersoffattachment.
Wearsubstantialfootwearandlongtrousers.Donotoperate
theequipmentwhenbarefootorwearingopensandals.
Donotwearloosettingclothingthatcangetcaughtin
movingparts.
Alwaysweareyeprotectionwhenoperatingtheequipment.
Stayalertforholesintheterrainandotherhiddenhazards.
Watchoutfortrafcwhencrossingornearroadways.
Beforeyouoperateanyfeatureofthismachine,observeyour
surroundingsandlookforbystanders.
Alwayswashhandsaftercontactwithfertilizersand
pesticides.
Keepallnuts,boltsandscrewstighttobesuretheequipment
isinsafeworkingcondition.
1008066 Rev. A 4
Item Description Part # Qty
1 Handlespacer 1007081 1
2 Carriagebolt,M6x25 1007082 1
3 Washer,M6 1007083 1
4 Gaugeandleverassembly 1007084 1
5 Adjusthandleassembly 1007085 1
6 Adjusthandleknobside1 1007086 1
7 Adjusthandleknobside2 1007087 1
8 Screw,M4x18 1007088 1
9 Handlespacer 1007089 1
10 Wingnut,M6 1007090 1
11 Bolt,M6x45 1007091 7
12 Nylonwasher 1007092 1
13 Flatwasher,M6,big 1007093 1
14 Screen 1007094 1
15 Handlecover 1007095 2
16 HopperAssembly,Black* 1008017* 1
17 Rpin,M2diameter 1007097 1
18 Hopperbushing 1007098 1
19 Pivotandbracketassembly 1007099 1
20 Wheelframetube 1007100 2
21 Nut,M6 1007101 2
22 Endcover 1007102 2
23 Upperhandle 1007103 2
24 Locknut,M6 1007104 11
25 ControlrodA 1007105 1
26 Handleshaft 1007106 1
Item Description Part # Qty
27 Shutoffplate 1007107 1
28 Flatwasher,M4,big 1007108 3
29 Screw,M4x12 1007109 3
30 Frame 1007110 1
31 Framebrace 1007111 2
32 Bolt,M6x50 1007112 2
33 Bolt,M6x30 1007113 2
34 Flatwasher,M16 1007114 1
35 Endcap 1007115 2
36 Pneumaticwheel 1007116 2
37 Axlebushing 1007117 2
38 Axlebearing 1007118 2
39 Gearbox&axleassembly 1007119 1
40 2.9x28mmCotterPin,SS 1008031 1
41 Screw,M4x20 1007121 1
42 Impeller 1007122 1
43 Screw,M6x40 1007123 4
44 Hexlocknut,M5 1007124 1
45 Crossbrace 1007125 1
46 Adjustconnectrod,B 1007126 1
47 Hexbolt,M5x45 1007127 1
48 Flatwasher,M6 1007128 3
49 CotterPin,Small 1008098 2
50 NylonWasher 1007531 4
51 Decal,Brinly 1008099 1
PARTS BREAKDOWN
STOP
Installation Questions?
Missing Parts?
Replacement Parts?
Please call Customer Service
Department Toll Free
877.728.8224 or
customerservice@brinly.com
DON’T GO BACK
TO THE STORE!
*AssemblyincludesPartNumbers16,18,27,28,29
1008066 Rev. A
5
22 15
23
24
26
4
48
1
23 8
7
24
13
5
12
25
21
46
48
24
11
31
30
45
31
32
33
24
24
32
14
17
18
30
39
41 40
36
43
47 35
44
36
37
38
38
37
50
50
34
35
20
28
51
27
29
42
20
16
33
11
20
20
11
15
6
10
9
3
2
22
Hopper/Frame/Axle Exploded
Handle/Frame Exploded
50
50
49
11
19
PARTS BREAKDOWN
1008066 Rev. A 6
ASSEMBLY
TOOLS REQUIRED:
2-10mmWrenches
1.RemovetwoM6locknutsandM6x45mmlong
boltstoremovepivotandbracketassemblyfrom
wheelframetubes.Setboltsandnutstotheside.
Youwillre-installtheminStep3.
2.Tiltarmassembly,andinsertrodintoowcontrol
handle.
Figure 1
Figure 2
1008066 Rev. A
7
ASSEMBLY
3.Insertarmassemblybetweenframetubes.Re-
installpivotandbracketassemblythroughwheel
frametubesandarmassemblywithtwoM6x45mm
boltsandM6locknutsremovedinStep1.
4.Tightennutsandboltsonbothsidesofspreader
atlocationsshown.
Figure 3
Figure 4
1008066 Rev. A 8
10
15
20
25
30
10
15
20
25
30
ASSEMBLY
5.Pushtheowcontrolhandledownwardtothe
fullyclosedposition,closetheshutoffplateunder
thehopper,andhandtightenbottomnutonlinkage
roduntilsnug.Handtightentopnutonlinkagerod
untilsnug.
Figure 5
Figure 6
6.NOTE:Theedgeofthewingnutisthemarker,andnotthecenterof
wingnut.Whentheowcontrolhandleisopenedfully,theedgeofthe
wingnutshouldbeonthe30mark.
Setedgeofwingnuton30markandtighten.
Moveowcontrolhandleupwardandbackdownward,andverifythe
shutoffplateunderhopperopensandclosesproperly.Ifnecessary,
adjustlinkagerodnutsandtightenhandtight.
1008066 Rev. A
9
Figure 7
Figure 8
Avoiddamage!Onlyuseawrenchonthelowernut.
Donotusewrenchontheuppernut.
7.Onceadjustmentiscomplete,tightenlowernutonlinkagerodwith
wrench.
8.Handlecanbeloweredbyremovingboltsandnutsand
movinghandleassemblydownward,usingupperholesfor
boltsandnuts.
ASSEMBLY
1008066 Rev. A 10
READ BEFORE USING
BecomeFamiliarWithTheOperationOfTheSpreader
BeforeYouPutMaterialInTheHopper.
Practicewalkingwiththespreader,openingandclosingthe
rategateattheappropriatetimes.
Travelataconstantspeedandoperatethespreaderlever
position.Remember:Opentherategateafterthespreader
isinmotionatoperatingspeed(about3mph,oratabrisk
walkingpace).
Closetherategatewhilespreaderisstillatoperational
speed.
Flow Control Setting Information
Theowcontrolleveroperatesthecontrolplate.Thecontrol
leverplateismarked0-30.Thepositionselecteddetermines
theamountofmaterialtobebroadcast.Thehigherthe
number,theheaviertheapplicationofthematerial.This
allowsforaccuratecontrolofthespreadingrate.
Thefanspeedandthespreadwidtharecontrolledbythe
speedatwhichyouoperatethespreader.Thespreadwidth
alsodependsonthevolume/density,andtheparticlesizeof
thematerial.
Thespreadthinsorfeathersattheouteredges,eliminating
sharp,"EdgeOfSpread"lineswhichcausestripesand
streaks.Extracoveragecanbegivenundertreesandother
heavyfeedingareaswithoutshowing"EdgeOfSpread"
lines.
Gapsanddoubleoverlapsarelesslikely.Smallerrorsin
travelareforgivenanddonotshow.
Filling The Spreader
AvoidInjury!Chemicalscanbedangerous.
Avoidinjurytooperatororbystanders:
• Readchemicalcontainerlabelforhandlinginstructions.
AMaterialSafetyDataSheet(MSDS)shouldbesupplied
bythechemicaldealerandprovidespropersafety
information.
• Wearproperclothingandsafetyequipmentwhile
handlingorapplyingchemicals.
• Prohibitallsmoking,drinking,andeatingaround
chemicals.
• Whenspreadingproductscontainingherbicides,exercise
extremecautionwithrespecttocarelessspreading
andtowind-drift.ContactOfSomeProductsOnSome
PlantsCanBeFatal.
Operating Tips
Pushowcontrolleverdowntowardshoppertoclosethe
rategate.
Fillthespreaderonaat,levelsurfaceonly.Fillonsidewalk,
driveway,cardboard,etc.toavoidmaterialloss.
DONOToverloadwithmorethanmaximumcapacityof50
lbs.
DONOTuseonwindydays.
Whenllinghopperwithmaterial,alwaysusescreentohelp
breakupclumps.
Keepspinnerbladeclean.Excessmaterialbuild-upcan
causeanunevenspreadpattern.
Keeptheimpellerlevelwhenspreading.
Spreading Material
Determinesettingrequiredfortheproductyouarespreading
(SeeApplicationRateChart).Ifasettingisnotfound,usea
similarsize/weightmaterial.Determineaowcontrolsetting
onthelowside.Ifthesettingprovestobetoolow,coverthe
areamorethanonetime.Ahighersettingcanbeusedwhen
aprovensettingisestablished.GenericGrassSeedand
FertilizerSettingsareshownattheendofthelist.
Remember:Publishedowcontrolsettingsareapproximate
only.Theoperationofthespreader,theconditionofthe
material(dampordryorover-pulverized)andweather
conditions,areallcontributingfactors.Forthesereasons,it
isoftenagoodideatospreadthearea2times-orone-half
rate-incrossdirections.One-halfratesettingsarehighly
recommendedunderdampandhumidconditions.
Rotary Agitator
Usetherotaryagitatoronlyifneeded.Free-owing,lump-
freematerialswillnotrequiretheagitator.Therotaryagitator
iseasilyinstalledorremoved.Placefeltwasheraround
spinnershaftbeforeinsertingagitator.
Neverleavefertilizerorothermaterialinthehopper.Itcan
drawmoisture,formclumps,andcauseunnecessaryrusting
orjammingofcontrolsandotherparts.Icemeltresidueis
especiallycorrosive.Cleanandoilspreaderimmediately
aftereachuse.
WARNING
OPERATION
1008066 Rev. A
11
10
15
20
25
30
10
15
20
25
30
NOTE:Whendeterminingrequiredsetting,theedgeofthe
wingnutisthemarker,andnotthecenterofwingnut.When
theowcontrolhandleisopenedfully,theedgeofthe
wingnutshouldbeonthe30mark.
IMPORTANT!Remembertostartandstopthespreadwhile
moving.Donotopentheowcontrolleverwhilestoppedor
materialwillsimplyrunontothegroundwithoutbeingspread.
Spreadheaderstripsateachendofarea.Thisallowsa
turn-aroundareatoalignspreaderfornextpass.Thenstart
ontheedgeoftheareatobespread.Spreaduntilyouhit
theheaderarea.Turntheowcontrolhandletooffwhilestill
moving.Makeyourturnandstartdownthenextrow.Turn
theowcontrolhandlebackonasyouhittheedgeofyour
headerarea.Turntheowcontrolhandleonwhilemove.
Header
6’ 6’3’
Header
Spreading Ice Melt
Removescreenfromhoppertopreventdamage.
Startwithowcontrolsettingat20andmakeatrialpass.
Adjustasneededtoincreaseordecreasecoverage.
Whencompletebesuretothoroughlycleanspreaderasice
meltcanbehighlycorrosive.
Re-installscreenwhencomplete.
Calibrating Shut Off Plate
SeeFigure6andFigure7onpage8and9.
MAINTENANCE
Toensureyearsoftroublefreeservice,cleanthespreader
thoroughlyaftereachuse.Moveowcontrolhandleasyou
rinsetoavoidbuildupofmaterial.
Forrustonframeparts,sandlightlyandpaintwithenamel.
Periodicallylubricateallbearingsurfaces.
Neverallowmaterialtoremaininhopperforextended
periodsoftime.
Periodicallycheckallfastenersfortightness.
TROUBLESHOOTING
Flowcontrolhandleishardtoactuateorwillnotmove:
Checkforbuildupofmaterialbetweenbottomofhopperand
shutoffplate.Cleanasneeded.
OPERATION
1008066 Rev. A 12
Media lbs/1000
square
feet
Flow
Control
Setting at
3MPH
AllAmerican
AllPurposeFertilizer10-10-
10.
10 16.0
Bayer
SeasonLongGrubControl 3.8 15.0
SeasonLongGrubControl 2.9 13.5
CompleteInsectKiller 3 13.5
CompleteInsectKiller 2 12.0
PowerForceMulti-Insect
Killer
3 12.0
PowerForceMulti-Insect
Killer
2 11.0
GrubControl 3 12.0
GrubControl 2 12.0
LawnFertilizerPlusWeed
ControlII30-3-4
3.2 13.5
SeasonLongGrubControl 3.8 13.5
SeasonLongGrubControl 2.9 12.0
LawnStarterFertilizer20-
27-5
3.6 13.5
LawnFertilizerPlus
CrabgrassPreventer30-3-4
3.2 13.5
Eliminator
Ant,Flea,andTickKiller
Granules
3 13.5
2.5 12.0
2 12.0
5%DiazinonInsectKiller
Granules
2 13.5
HowardJohnsons
All-purposeFertilizer8-8-8 7 15.0
All-purposeFertilizer10-
10-10
7 15.0
All-purposeFertilizer12-12-
12
7 15.0
Ironite1-0-0 5 13.5
Klay
SoftPelletizedGypsumSoil
Conditioner
4 13.5
SoftPelletizedGypsumSoil
Conditioner
3 12.0
SoftPelletizedGypsumSoil
Conditioner
2 12.0
Lesco
46-0-0 2.2 15.5
39-0-0 2.6 15.5
Media lbs/1000
square
feet
Flow
Control
Setting at
3MPH
34-3-11 2.9 16.0
32-3-8 3.1 16.0
30-3-7 3.3 16.0
28-5-12 3.6 16.0
24-5-11 4.2 16.0
19-19-19 5.3 16.0
18-24-12 4.2 15.0
24-2-11 4.2 15.0
26-2-11 3.8 15.5
24-0-11 4.2 16.0
18-0-18Fall/Winter 4.2 16.0
17-17-17AllPurpose 5.9 16.0
16-4-8 6.3 16.0
15-5-10 6.7 16.0
15-0-15 6.7 16.0
Atrazine+17-2-11 6.0 16.0
Dimension.015%+19-3-6 3.5 16.0
Mach2™1.33%+24-5-11 3.4 16.0
Merit®0.2%+24-5-11 3.5 15.5
Momentum®+Fertilizer 3.6 15.0
PCNB12.5%10-0-20M
75%PPSCU
4.0 15.5
PRE-M®1.5%+Fertilizer 2.3 15.0
PRE-M®0.86%+Fertilizer 4.0 16.0
Talstar®0.069%+Fertilizer 3.3 16.0
Weed&Feed+18-0-9 4.0 15.5
Weed&Feed+18-2-9 4.0 15.5
Dylox®6.2* 3.0 16.0
MasterTurf
UltimateTallFescueBlend 8 17.0
UltimateTallFescueBlend 4 15.0
Milogranite6-2-0 8 17.0
Milogranite6-2-0 16 20.0
Miracle-Gro
LawnFertilizerplusWeed
Control28-3-3
3.2 13.5
StarterLawnFertilizer20-
27-5
3.6 13.5
StarterLawnFertilizer29-
3-4
3.1 12.0
Ortho
LawnInsectKillerGranules 9.6 16.0
LawnInsectKillerGranules 4.8 13.5
LawnInsectKillerGranules 2.4 11.5
APPLICATION RATE CHART
1008066 Rev. A
13
APPLICATION RATE CHART
Media lbs/1000
square
feet
Flow
Control
Setting at
3MPH
LawnInsectKillerGranules 1.2 11.5
MaxInsectKillerforLawns 4 13.5
MaxInsectKillerforLawns 2 12.0
MaxInsectKillerforLawns 1 11.5
Parkers
SuperSoilifeLawn&
GardenFertilizer10-10-10
10 16.0
SuperSoilifeLawn&
GardenFertilizer16-4-8
6.5 13.5
Pennington
LawnStarterFertilizer18-
24-6
3.6 15.0
MasterTurfHighTrafc
LawnSeedMixture
10 18.0
MasterTurfHighTrafc
LawnSeedMixture
5 16.0
MasterTurfShadyLawn
SeedMixture
8 18.0
MasterTurfShadyLawn
SeedMixture
4 16.0
MasterTurfSun&Shade
LawnSeedMixture
10 18.0
MasterTurfSun&Shade
LawnSeedMixture
5 16.0
LawnFood27-4-6 3.6 16.5
CentipedeFood18-0-18 4.0 17.0
St.Augustine,Bahia&
BermudaFood26-6-9
4.0 18.0
FallLawnFood10-5-15 4.0 15.5
CrabgrassPreventerplus
Fertilizer5-10-25
4.0 16.5
LawnStarter18-24-6 3.6 16.5
Weed&Feedw/Atrazine
25-4-6
4.0 17.0
FescueFood28-5-10 4.0 16.5
Weed&Feedw/Triamine
25-4-6
3.6 16.5
Real-Kill
Multi-PurposeLawnand
GardenInsectKiller
2 12.0
Multi-PurposeLawnand
GardenInsectKiller
2.5 12.0
Rebel's
SupremeBlendGrassSeed
forSun&Shade
10 18.0
SupremeBlendGrassSeed
forSun&Shade
5 16.0
Media lbs/1000
square
feet
Flow
Control
Setting at
3MPH
Ringer
LawnRestore10-2-6 10 18.0
Sam'sChoice
CrabgrassPreventer30-3-4 12.3 19.0
CrabgrassPreventer30-3-4 8.1 16.0
CrabgrassPreventer30-3-4 6 16.0
CrabgrassPreventer30-3-4 5.4 15.0
InsectControlPlusFertilizer
28-4-6
3 12.0
LawnFood29-3-4 3.2 13.5
StarterFertilizer20-27-5 6 16.0
StarterFertilizer20-27-5 3.6 13.5
Scotts
ClassicGrassSeedFall
GrassSeedMix
4 16.0
ClassicGrassSeedFall
GrassSeedMix
2 13.5
Grubex 2.3 12.0
GrubexSeasonLongGrub
Control
3.1 13.5
GrubexSeasonLongGrub
Control
2.3 13.5
LawnFungusControl 1.4 12.0
LawnFungusControl 2.7 13.5
PurePremiumKentucky
BluegrassMix
2.2 13.5
PurePremiumKentucky
BluegrassMix
1.1 12.0
PurePremiumSun&Shade
GrassSeedMixture
2.5 13.5
PurePremiumSun&Shade
GrassSeedMixture
1.25 12.0
StarterFertilizer20-27-5 3.6 13.5
StarterFertilizer20-27-5 5.9 13.5
TurfBuilder28-3-8 2.7 13.5
TurfBuilderLawnFertilizer
29-3-4
3.1 12.0
TurfBuilderwithSummer
Guard
2.7 13.5
TurfBuilderPlusWeed
Control
2.9 13.5
Winterizer22-4-1 3.3 11.5
TurfBuilder+Halt25-3-3 3.6 15.0
TurfBuilderPlus2Weed
Control&LawnFertilizer
26-3-3
3.5 14.5
1008066 Rev. A 14
Media lbs/1000
square
feet
Flow
Control
Setting at
3MPH
TurfBuilderLawnFertilizer
NewConcentratedNuggets
34-4-4
2.7 13.5
StarterFertilizer17-23-6 4.0 15.0
LawnDiseasePreventer 2.7 15.5
LawnWeedControl25-4-6 1.0 11.5
TurfBuilder28-3-3 3.2 17.0
5.0 20.0
Weed&Feed33-3-3 2.5 13.5
SCOTTSPROTURF
FungicideVII8-2-1 25.0 25.0
12.7 27.0
13.4 13.0
TurfBuilderLawnFertilizer
29-3-4
8.2 15.5
TurfStarterw/PolyS16-
26-12
4.1 18.0
Fertilizer+FungicideVIII
23-3-3
1.6 13.5
HDFertilizer+Iron29-3-3 3.2 14.5
HDFairwayFertilizer32-3-
10
3.1 16.5
FertilizerwithMinors26-4-
13
3.9 14.5
HiKGreensFertilizer15-
0-30
3.4 13.5
HDStarter(SmallGranule)
19-26-5
3.5 14.5
HiKFertilizer15-0-30 3.4 15.5
MossControl16-0-0 3.9 13.0
Iron-S16-0-0 1.7 13.5
SuperGreensFertilizer19-
0-17
4.6 14.5
TurfFertilizer+2%Few/
PolyS25-3-10
3.3 16.5
ProTurfFertilizerw/PolyS
34-3-6
2.8 16.5
NPKTurfFert.w/PolyS21-
3-20
4.6 16.5
FungicideX 4.9 15.5
FF-II14-3-3 4.7 13.5
SystemicFungicide 2.6 15.0
FertilizerPlusPreemergent
WeedControl22-4-4
3.3 18.0
3.8 18.5
4.5 19.5
Media lbs/1000
square
feet
Flow
Control
Setting at
3MPH
4.9 20.0
TurfFertilizerPlus
PreemergentWeedControl
22-0-6
3.8 18.5
4.2 19.5
4.9 20.0
5.8 21.0
6.1 22.0
8.7 27.0
9.6 30.0
SCOTTSFOURSEASON
PROGRAM
Step1-Crabgrass
PreventerplusFertilizer
3 15
Step2-WeedControlplus
Fertilizer
2.5 15
Step3-InsectControlplus
Fertilizer
3.1 16.5
Step4-LawnFertilizer 2.8 15.5
Sevin
LawnInsectGranules 4.6 13.5
LawnInsectGranules 2.33 13.5
LawnInsectGranules 2.25 13.5
Spectracide
GrubStop 3 13.5
TriazicideInsectKiller
Granules
3 11.5
Sta-Green
LawnFertilizer29-2-5 3.6 13.5
LawnWeedControl 2 12.0
200PlusWeed&Feed
28-3-3
3.2 13.5
StarterFertilizer18-24-10 3.6 13.5
Weed&Feed28-2-4 3.2 13.5
Sun&ShadeGrassSeed
Mixture
10 18.0
Sun&ShadeGrassSeed
Mixture
5 16.0
Vigoro
InsectControlPlusFertilizer 3 11.5
StarterFertilizer 3.6 13.5
TurfFertilizer29-3-4 3.2 13.5
UltraTurfWinterizer22-3-14 3 12.0
WeedandFeed 3.2 13.5
Wal-Mart
APPLICATION RATE CHART
1008066 Rev. A
15
Media lbs/1000
square
feet
Flow
Control
Setting at
3MPH
GardensKentucky
BluegrassGrassSeed
4 16.0
GardensKentucky
BluegrassGrassSeed
2 13.5
GardensKentucky31Tall
Fescue
8 18.0
GardensKentucky31Tall
Fescue
4 16.0
Weed&Feed28-3-3 3.2 13.5
GenericFertilizers(ifyoudon't
haveanyothermethod)
1 12
2 13
3 14
4 15
5 17
6 18
7 19
8 20
9 22
10 24
GenericGrassSeed(ifyoudon't
haveanyothermethod)
2 18
3 20
4 22
5 24
APPLICATION RATE CHART
1008066 Rev. A
ThelimitedwarrantysetforthbelowisgivenbyBrinly-Hardy
Companywithrespecttonewmerchandisepurchasedand
usedintheUnitedStates,itspossessionsandterritories.
Brinly-HardyCompanywarrantstheproductslistedbelow
againstdefectsinmaterialandworkmanship,andwillat
itsoption,repairorreplace,freeofcharge,anypartfound
tobedefectiveinmaterialsorworkmanship.Thislimited
warrantyshallonlyapplyifthisproducthasbeenassembled,
operated,andmaintainedinaccordancewiththeOperator’s
manualfurnishedwiththeproduct,andhasnotbeensubject
tomisuse,abuse,commercialuse,neglect,accident,
impropermaintenance,alteration,vandalism,theft,re,
water,ordamagebecauseofotherperilornaturaldisaster.
NormalWearPartsorcomponentsthereofaresubject
toseparatetermsasfollows:Allnormalwearpartsor
componentfailureswillbecoveredontheproductfora
periodof90days.
Partsfoundtobedefectivewithinthewarrantyperiodwill
bereplacedatourexpense.Ourobligationunderthis
warrantyisexpresslylimitedtothereplacementorrepair,
atouroption,ofpartsfoundtobedefectiveinmaterialand
workmanship.
HOW TO OBTAIN SERVICE:Warrantypartsreplacements
areavailable,ONLYWITHPROOFOFPURCHASE,through
ourCustomerServiceDepartment.Call877-728-8224.
Thislimitedwarrantydoesnotprovidecoverageinthe
followingcases:
• Routinemaintenanceitemssuchaslubricantsandlters.
• Normaldeteriorationoftheexteriornishduetouseor
exposure.
• Transportationand/orlaborcharges.
• Thewarrantydoesnotincludecommercialand/orrental
use.
No implied warranty, including any implied warranty
of merchantability of tness for a particular purpose,
applies after the applicable period of express written
warranty above as to the part as identied below.
No other express warranty whether written or oral,
except as mentioned above, given by any person or
entity, including a dealer or retailer, with respect to
any product, shall bind Brinly-Hardy Co. During the
period of the warranty, the exclusive remedy is repair or
replacement of the product as set forth above.
The provisions as set forth in this warranty provide
the sole and exclusive remedy arising from the sale.
Brinly-Hardy Co. shall not be liable for incidental or
consequential loss or damage including, without
limitation, expenses incurred for substitute or
replacement lawn care services or for rental expenses to
temporarily replace a warranted product.
Somestatesdonotallowtheexclusionorlimitationof
incidentalorconsequentialdamages,orlimitationsonhow
longanimpliedwarrantylasts,sotheaboveexclusionsor
limitationsmaynotapplytoyou.
Duringthewarrantyperiod,theexclusiveremedyis
replacementofthepart.Innoeventshallrecoveryofany
kindbegreaterthattheamountofthepurchasepriceofthe
productsold.Alterationofsafetyfeaturesoftheproductshall
voidthiswarranty.Youassumetheriskandliabilityforloss,
damage,orinjurytoyouandyourpropertyand/ortoothers
andtheirpropertyarisingoutofthemisuseorinabilitytouse
thisproduct.
Thislimitedwarrantyshallnotextendtoanyoneotherthan
theoriginalpurchaserortothepersonforwhomitwas
purchasedasagift.
HOW STATE LAW RELATES TO THIS WARRANTY:This
limitedwarrantygivesyouspeciclegalrights,andyoumay
alsohaveotherrightswhichvaryfromstatetostate.
IMPORTANT:TheWarrantyperiodstatedbelowbeginswith
thePROOFOFPURCHASE.Withouttheproofofpurchase,
theWarrantyperiodbeginsfromthedateofmanufacture
determinedbytheserialnumbermanufacturingdate.
SPREADER WARRANTY PERIOD:
Thewarrantyperiodforthisspreaderisasfollows:1year
non-commercialuse.Tiresandwheelsarenormalwear
items:90days.
MANUFACTURER'S LIMITED WARRANTY FOR
Accessories
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16

Brinly-Hardy P20-500BH Owner's manual

Brinly-Hardy
Brand
Brinly-Hardy
Model
P20-500BH
Category
Spreader
Type
Owner's manual
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents