Cumberland Pork Tech Panel Owner's manual

Brand: Cumberland

Model: Pork Tech Panel

Type: Owner's manual

PN 4801-5095

Agricultural Heating and Ventilation Systems

Hired-Hand Mfg., Inc. Ph. 256-287-1000

PO Box 99 Fx. 256-287-2000

Bremen, AL 35033 Toll Free 800-642-0123

Pork Tech Panel 6625-0010

The following is a chart showing how the back-up and relay panel is tied in.

Operation of the Vents, Tunnel Inlet, and Side Wall Curtains

The Vents and Tunnel Inlets are wired to operate off of static pressure. The way

this works is as long as the Stage Master 12 is not calling for Unit 2 to open the tunnel

inlet will remain closed and the Vents will operate off of the Farm Hand Power Vent.

When the Stage Master 12 calls for Unit 2 to open the Vents will close and the Tunnel

Inlet will operate off of the Power Vent. The Stage Master 12 must be setup as if the

tunnel inlet is tied to Unit 2. The Auto/Manual switch for Unit 2 on the Stage Master

must be in the Auto position for proper operation. If Unit 2 of the Stage Master is put in

Manual and Open the Vents will close and the Tunnel Inlet can be run manually by the

Farm Hand Power Vent. If Unit 2 of the Stage Master is put in Manual and Close the

Tunnel Inlet will close and the Vents can be run manually by the Farm Hand Power Vent.

The Connections labeled Sidewalls in the main junction is for running a curtain actuator

off of unit 1 of the Stage Master. If no sidewalls are being operated a jumper must be

placed across the terminals labeled closed signal for this unit.

Wiring

Refer to the Stage Master and Power Vent Manuals for connections of sensors

and curtain actuators, all terminals are extended from the connection inside the

controllers to the junction boxes. The stages are tied in to the main junction box the same

as if they were tied into the relay panel such as L1 and L2 from the breaker box to the

terminals labeled IN for each stage and from the OUT of each stage to the equipment for

that stage.

Stage Master

Stages Relay Panel

Stages Back-up

Stages Main Junction

Box Stages

1 1

2 2

3 1 4 Heat 3

4 2 4

5 3 1Cool 5

6 4 6

7 5 7

8 6 2 Cool 8

9 7 3 Cool 9

10 8 10

11 11

12 12

Cumberland Pork Tech Panel Owner's manual

Cumberland Pork Tech Panel Owner's manual

Cumberland Pork Tech Panel Owner's manual

Related papers

Other documents