40023-0-1118 Page 1

WARNING

This conversion kit must be installed by an Empire Comfort Systems distributor (or other

qualied agency¹)*in accordance with the manufacturer’s instructions and all codes and

requirements of the authority having jurisdiction. Failure to follow instructions could result

in serious injury or property damage. The qualied agency performing this work assumes

responsibility for this conversion.

1National Fuel Gas Code Z223.1 (Latest Edition)

*The term “qualied individual, rm, corporation or company which either in person or through

Perform the safety shutdown test anytime work is done on a gas system to avoid the possibility

of re or explosion with property damage, personal injury or loss of life.

SAFETY SHUTDOWN SYSTEM

Intermittent Pilot System

1. Turn "OFF" using remote control. Main burner and pilot should go off.

2. Pilotgasowshouldstopwithin30seconds.

PARTS LIST

Part Description Conversion Kit Quantity Supplied

MainBurnerOrice,Front P210 1

MainBurnerOrice,Rear P308 1

Gas input for direct-vent replace converted to Propane Gas: DVCT50CFP95N

Thedirect-ventgasreplacewhenconvertedtoPropaneGaswillhaveamanifoldpressureofapproximately

10.0inchesw.c.(2.49kPa)atthevalveoutletwiththeinletpressuretothevalvefromaminimumof10.8inchesw.c.

(2.68kPa)forthepurposeofinputadjustmenttoamaximumof14.0inchesw.c.(3.484kPa).

FOR CONVERSION TO PROPANE GAS

40023-0-1118Page 2

Figure 1

3. Removefrontandrearburnersbyremovingscrewsonleft

andpullingouttowardsleftside.See Figure 2.

Figure 2

.

4. Remove(2)screwsholdingpilotassemblytoburnerpan.

Thiswillallowpilotassemblytodrop.

5. Remove(2)screwsholdingburnerbaseinplace.Liftburner

 baseoutofrebox.See Figure 4.

Figure 4

8. Usea7/16inchdeepsocketsettoinstalloricemarked

"1.4"inrearoriceholderand"#51"infrontoriceholder.

Figure 6

40023-0-1118 Page3

11. Usinga7/16inchopenwrench,loosenpilotbodybyslightly

turningcounter-clockwise.Slideoricebrackettootherside

andtightenpilotbodyclockwise.See Figure 8.

Figure 8

12. Replaceitemsremovedinsteps2-5inreverseorder.

40023-0-1118Page 4

Empire Comfort Systems Inc.

Belleville, IL

If you have a general question

aboutourproducts,pleasee-mail

us at [email protected].

If you have a service or repair

question,pleasecontactyourdealer.