American Hearth Rushmore 50 Conversion Kit Natural Gas to Propane (38226) Owner's manual

Brand: American Hearth

Model: Rushmore 50 Conversion Kit Natural Gas to Propane (38226)

Type: Owner's manual

This manual is also suitable for

40023-0-1118 Page 1

WARNING

This conversion kit must be installed by an Empire Comfort Systems distributor (or other

qualied agency¹)*in accordance with the manufacturer’s instructions and all codes and

requirements of the authority having jurisdiction. Failure to follow instructions could result

in serious injury or property damage. The qualied agency performing this work assumes

responsibility for this conversion.

1National Fuel Gas Code Z223.1 (Latest Edition)

*The term “qualied individual, rm, corporation or company which either in person or through

a representative is engaged in and is responsible for (a) the installation of gas piping or (b)

the connection, installation repair, or servicing of equipment, who is experienced in such

work, familiar with all precautions required, and has complied with all the requirements of the

authority having jurisdiction.

CHECK SAFETY SHUTDOWN PERFORMANCE

WARNING

Perform the safety shutdown test anytime work is done on a gas system to avoid the possibility

of re or explosion with property damage, personal injury or loss of life.

SAFETY SHUTDOWN SYSTEM

Intermittent Pilot System

1. Turn "OFF" using remote control. Main burner and pilot should go off.

2. Pilotgasowshouldstopwithin30seconds.

PARTS LIST

Part Description Conversion Kit Quantity Supplied

MainBurnerOrice,Front P210 1

MainBurnerOrice,Rear P308 1

SIT Gas Valve Conversion Kit R11382 1

Gas Conversion Label 1224 1

TOOLS NEEDED:

• StandardScrewdriver

• 1/4 Inch Hex Driver

• 5/16 Inch Hex Driver

• 7/16 Inch Wrench

• 7/16 Inch Deep

Socket Set

Gas input for direct-vent replace converted to Propane Gas: DVCT50CFP95N

Thedirect-ventgasreplacewhenconvertedtoPropaneGaswillhaveamanifoldpressureofapproximately

10.0inchesw.c.(2.49kPa)atthevalveoutletwiththeinletpressuretothevalvefromaminimumof10.8inchesw.c.

(2.68kPa)forthepurposeofinputadjustmenttoamaximumof14.0inchesw.c.(3.484kPa).

INSTALLATION INSTRUCTIONS

DIRECT VENT GAS FIREPLACE

FOR USE ON: DVCT50CFP95N CONVERSION KIT PART NUMBER 38226

FOR CONVERSION TO PROPANE GAS

40023-0-1118Page 2

INSTRUCTIONS FOR CONVERSION

1. Ifthereplaceisinstalled,turnOFFgasandelectricsupply

toreplacebeforemakinggasconversion.Allowreplaceto

cool completely.

2. Removebarrierscreen,glassdoor,logsandembers,and

liners(SeeHomeowner'sManualandLinerInstructions).

Figure 1

3. Removefrontandrearburnersbyremovingscrewsonleft

andpullingouttowardsleftside.See Figure 2.

Figure 2

4. Remove(2)screwsholdingpilotassemblytoburnerpan.

Thiswillallowpilotassemblytodrop.

5. Remove(2)screwsholdingburnerbaseinplace.Liftburner

 baseoutofrebox.See Figure 4.

Figure 4

6. Use needle-nose pliers to remove targets and discard.

See Figure 5.

REAR

FRONT

Figure 5

Use a 7/16 inch deep socket set to remove front and rear

orices.

8. Usea7/16inchdeepsocketsettoinstalloricemarked

"1.4"inrearoriceholderand"#51"infrontoriceholder.

REAR

FRONT

Figure 6

40023-0-1118 Page3

9.

Loosenrearairshutterscrewandrotatehandletotheright

untilfullopenisachievedandtightendownscrew.See Figure 7.

10.Repeatwithfront.

REAR AIR

SHUTTER

SCREW

FRONT AIR

SHUTTER

SCREW

CLOSED

OPEN

REAR

FRONT

Figure 7

11. Usinga7/16inchopenwrench,loosenpilotbodybyslightly

turningcounter-clockwise.Slideoricebrackettootherside

andtightenpilotbodyclockwise.See Figure 8.

“LP” MARKING

(HOLE, RED P

AINT)

Figure 8

12. Replaceitemsremovedinsteps2-5inreverseorder.

13. Turngasandelectricon.

14. Gas conversion completed.

Checkthemainburnerameandpilotburnerameforproper

amecharacteristics,asoutlinedintheInstallationInstructions

andOwner'sManual.

Ifreplaceisnotinstalledorproductregistrationcardhasnot

beenreturnedtoEmpireComfortSystem’s,checkofftypeof

gasconvertedtoonthecard.Alsoindicateconversionbyadding

“Conv.” behind type of gas.

40023-0-1118Page 4

www.empirecomfort.com

Empire Comfort Systems Inc.

Belleville, IL

If you have a general question

aboutourproducts,pleasee-mail

us at [email protected].

If you have a service or repair

question,pleasecontactyourdealer.

American Hearth Rushmore 50 Conversion Kit Natural Gas to Propane (38226) Owner's manual

Brand: American Hearth

Model: Rushmore 50 Conversion Kit Natural Gas to Propane (38226)

Type: Owner's manual

This manual is also suitable for

Download PDF

report

American Hearth Rushmore 50 Conversion Kit Natural Gas to Propane (38226) Owner's manual

This manual is also suitable for

American Hearth Rushmore 50 Conversion Kit Natural Gas to Propane (38226) Owner's manual

Related papers

Other documents