Empire Heating Systems Floor Furnace Owner's manual

Empire Heating Systems
Brand
Empire Heating Systems
Model
Floor Furnace
Category
Stoves
Type
Owner's manual
Page 1
WARNING
FIRE OR EXPLOSION HAZARD
If the information in these instructions is


injury or loss of life.
— Do not store or use gasoline or other


— WHAT TO DO IF YOU SMELL GAS
 
 

 
 


 

 


INSTALLER:

CONSUMER:
Retain this manual for future reference.
WARNING
    
accordance with the manufacturer's instruc-
-

can cause death or serious illness.
FLOOR FURNACE
MODELS
3588XLP-1 5088XLP-1 7088XLP-1
3588XNAT-1 5088XNAT-1 7088XNAT-1
INSTALLATION INSTRUCTIONS
37407-3-0319Page 2
Introduction
Always consult your local Building Department regarding regulations,

Instructions to Installer
 -

 -

 
WARNING

        


General Information
        -



Any alteration of the original design, installed other than as
           





*Available from the American National Standards Institute, Inc. 11 West 42nd St.,
New York, N.Y. 10018.


of Massachusetts.



NOTICE: 
-











          

        


WARNING
CARBON MONOXIDE POISONING HAZARD
         
        
        



 
         
pitch, as required in the National Fuel Gas Code 
Natural Gas and Propane Installation
Code       
        

          
         


 
 Turn on clothes dryers and any appliance not connected



        


 Test for spillage from draft hood equipped appliances at


          

with National Fuel Gas Code
Natural Gas and Propane Installation Code
 

      


37407-3-0319 Page 3
 

 


 

 

        
        

 qUALIFIED
SERvICE PERSON. 





 



 

 


 
        

 

THIS IS A HEATING APPLIANCE
DO NOT OPERATE THIS APPLIANCE WITHOUT FLOOR REGISTER INSTALLED

Models   
   
Dimensions
   
   
   
   
   


   
   
   
   
Gas Inlet
   
   
venting
   
   
   
CONvERSION KITS
  Used On
  
  
  
  
  
  
37407-3-0319
SAFETY INFORMATION FOR USERS OF PROPANE GAS
-






exactly what to do. If, after reading the following information,


PROPANE GAS WARNING ODOR


signal to go into immediate action!
 

 

 
 



    



 Finally, 

       

NO ODOR DETECTED - ODOR FADE
        








some circumstances.       



           







SOME POINTS TO REMEMBER
 




 




          


area where the conditions are such that you may not detect

 








PA
sniff test of the P   
under any condition.
 



 




-



37407-3-0319 
INSTALLATION PLANNING

 
 
 


vENTING


 
See Figure 1.
Figure 1
 
See Figures 2 and 3.
 
Figure 2
Figure 3
NOTICE: Uninsulated


      

    See Figure 4 


Figure 4
 

             
See Figure 5.
 -
See Figure 6.
 

See Figure 6. 
into
 
 See Figure 3.
37407-3-0319

 
 
See Figure 1. Select




See Figure 8.
Figure 8
 -

See
Figure 9         


Figure 9
Figure 5
 
See Figure 7. 

See Figure 7.

See Figure 5.
Figure 6
 

Figure 7
37407-3-0319 Page 7
CUTTING THE FLOOR
HERE'S HOW TO DO IT
 


 


 

 -
See Figure 10.
 


 

See Figure 10.
 


 


 
See Figure 10. 



 
          

See Figure 10.
 

See Figure 10.
 
 


 
          

 


See Figure 10.


See Figure 10



the dimensions




         



a gate or door as an entrance to the crawl space so that the



          

  

37407-3-0319




-

See Figure
10.

Model
No.
Register
width
Register
length
Casing
width
Casing
length

height
Floor to
Flue C.
Floor to
shield
Floor to
gas inlet
Flue C.

A B C D E F G H I
    32     
   22      
         
Figure 10

Figure 11
*Model 3588 only
37407-3-0319 
INSTALLING DRAFT DIvERTER






Figure 12



DEBRIS PAN

This pan is designed to catch hot particles that might drop from

Figure 13




-

GAS CONNECTIONS
 

 


 
           

-


-






         


-

TESTING THE SUPPLY PIPING

from the gas supply piping system during any pressure testing of

The appliance must isolated from the gas supply piping system

testing of the gas supply piping system at test pressures equal to

ATTENTION! 











ON/OFF
DEVICE
Figure 14
37407-3-0319
  

       


 
 
 

         

 


 


-



 




 
 
 
 
 
PROPER MAIN BURNER FLAME
AND PILOT FLAME 3588
TROUBLESHOOTING INFORMATION
PIEZO LIGHTING INSTRUCTIONS




REGISTER TEMPERATURE CONTROLS
        
         -
          



CAUTION

KEEP CHILDREN OFF!
           

MILLIvOLT INFORMATION




CAUTION



SOME HELPFUL WARNINGS
 
 

 

            

Figure 15
 

 


WARNING
NEvER


OPERATING INFORMATION
37407-3-0319 Page 11
 

B. BEFORE LIGHTING 


WHAT TO DO IF YOU SMELL GAS
 
 

 

     

       
           



 



LIGHTING INSTRUCTIONS
1. STOP!
 
NOTE: The gas control rod is attached to the gas control

 
to "OFF."
NOTE:-

 

 



 


7. Turn gas control rod

to "PILOT."
8. Push and hold control
   
   -





 -


           


 
      to
"ON."
 
TO TURN OFF GAS TO APPLIANCE
 
 
to "OFF." Do not force.
 



WARNING


INTERMITTENT PILOT LIGHTING INSTRUCTIONS
FOR YOUR SAFETY READ BEFORE LIGHTING
37407-3-0319Page 12
Figure 16

-


PROPER MAIN BURNER FLAME
5088, 7088
B
A
C
Figure 17
Model Gas
Inner
Cone
Outer
Cone
Carry
Down
Flame

Blue

Blue

Blue
  1 inch

inches

Propane  2 inches small cone
   2 inches 
Propane   small cone


FLAME 360° AROUND
GENERATOR-COMING
TO TOPOF GENERATOR
Figure 18
PROPER PILOT BURNER FLAME 5088, 7088

      
 
generator
HIGH ALTITUDES
-





CHECKING MANIFOLD PRESSURE
         

        








CLEANING THE MAIN BURNER


     

SERvICING
INSTALLATION AND REPAIR SHOULD BE DONE BY A qUALI-
FIED SERvICE PERSON.     


-




DON'T








37407-3-0319 Page 13





-

MASTER PARTS DISTRIBUTOR LIST
Parts Not Under Warranty
-


Warranty Parts
 for


not-

 Part Description
 



HOW TO ORDER REPAIR PARTS



Phone: 
Toll Free:

Parts: Heater, Hearth and Grills



Phone:
Toll Free: 
Fax: 
Toll Free Fax:

Parts: Heater, Hearth and Grills
East Coast Energy Products


Phone: 
Toll Free:
Fax: 

Parts: Heater, Hearth and Grills
37407-3-0319
PLEASE NOTE: 
PARTS LIST
INDEX
NO.
PART NO.
DESCRIPTION
3588 5088 7088
1    
2    
3    
   
   
   
7    
   
   
    
11
  
11
  
11


11


11



Shown

  

Shown

  
12   23217 
13    
    
    
    
17    
    
    
    
21    
22A    
22B    
23    
    
    
 -  - 

Shown
   

Shown
   

37407-3-0319 
20
21
22A
22B
23
24
25
EXPLODED vIEW
37407-3-0319
WARRANTY












Limited Ten-Year Parts Warranty – Combustion Chamber
 

Limited One-Year Parts Warranty – Remote Controls, Accessories, and Parts


Duties Of The Owner



What Is Not Covered






How To Get Service







Your Rights Under State Law

  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16

Empire Heating Systems Floor Furnace Owner's manual

Empire Heating Systems
Brand
Empire Heating Systems
Model
Floor Furnace
Category
Stoves
Type
Owner's manual
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents