COMFORT-AIRE BFD300 User manual

I

-

DEHUMIDIFIER

Use & Care Guide

Full light Humldlstat

Control panel

Front grille

FRONT VIEW

Rear grille Evaporator toll

(on cabinet under

Dreln hose

water pan)

connection

REAR VIEW

Part No. 1169993

1% IT-t

&tents

Page

Important Safety Instructions ........................ 2

Before Using Your Dehumldifler .................... 3

Install properly ................................................ 3

Electrical requirements.. .................................

4

Using Your Dehumidifier ................................ 5

25, 30, 40, and 50 pint models ....................... 6

Setting the water level adjustment ................. 7

Water disposal methods ................................. 8

Caring for Your Dehumidifier ......................... 9

Troubleshooting.. ...........................................

1 1

Requesting Assistance or Senrice .............. 12

Warranty .........................................................

14

Thank you for buying this dehumidifier. Please

complete the form below. Have this information

ready if you need service or call with a question.

l

Copy model and serial numbers from label (see

diagram on front cover) and purchase date from

sales slip.

l

Keep this book and sales slip together in a

handy place.

Serial Number

Purchase Date

Service Company Phone Number

important Safety

instructions

To reduce the risk of fire, electrical shock,

or personal Injury when using your dehu-

midifier, follow these bask precautions:

l

Read all lnstructlons before using your

dehumidifier.

l

Complete the Installation and electrical

requirements as described in “Before

Using Your Dehumidifier” on pages 3

and 4.

l

Never allow children to operate or play

with the dehumidifier.

l

Never clean dehumidifier parts with

flammable fluids. The fumes can create a

fire hazard or explosion.

. FOR YOUR SAFETY

l

DO NOT STORE OR USE GASOUNE OR

OTHER FLAMMABLE VAPORS AND

UQUIDS IN THE VlClNlTY OF THIS OR ANY

OTHER APPUANCE. THE FUMES CAN

CREATE A FIRE HAZARD OR EXPLOSION.

It is your responsibility to be sure your dehu-

midifier:

l

Is properly installed on a floor, table, or shetf

that is reasonably level and strong enough to

support unit with a full pan of water. Unit can

weigh between 22.5 kg (50 Ibs.) and 33.8 kg

(75 lbs.), depending on the amount of water

collected in the pan.

l

Is the correct size for the area you want to

dehumidify.

l

Is connected to the proper kind of outlet, with

the correct electrical supply and grounding.

(See “Electrical requirements” on page 4.)

l

Is used only for jobs expected of home

dehumidifiers.

l

Is not used by children or anyone unable to

operate it properly.

l

Is properly maintained.

l

Is used in an area where the room tempera-

ture will not fall below 18.3% (65°F).

- SAVE THESE INSTRUCTIONS -

DO NOT REMOVE TECH SHEET from inside

cabinet. Your service technician will need this

information.

Before Using Your Dehumidifier

Install properly

12

lnchw

Personal Injury Hazard

Because your dehumidifier weighs be-

tween 225 kg (50 Ibs.) and 33.8 kg (75 Ibs.),

depending on the amount of water col-

lected in the pan, R is recommended that

you use proper lifting techniques when

lifting or moving your unit. Failure to do so

could result in personal injury.

1. Allow at least 30.5 cm (12 inches) of space on

all sides of the unit for good air circulation.

:

,

2. Install the unit on a floor, table, or shelf. When

installing the unit on a table or shelf, be sure it

is strong enough to support the unit with a full

pan of water. A table or shelf may be a better

position from which to handle the water pan.

Do not sit or stand on this product. The height

of a table or shelf may help prevent icing of

coils due to colder air near the floor (such as

can be found in a basement).

3. Keep all outside doors, windows, and other

openings closed when dehumidifier is operat-

ing. Humid outdoor air will add to the

dehumidifier’s operating load.

4. The water pan must be properly posi-

tioned, on the hangers inside the cabinet,

when dehumidifier is operating in order for the

automatic shutoff to operate correctly.

5. On most models, two rollers let you easily

move the dehumidifier. Remove the water

pan. Tilt unit forward and roll to another

position.

lf your model does not have rollers, pick up

the unit to move it to another position.

3

Before Using Your Dehumidifier

Continued

Electrical requirements

OBSERVE ALL GOVERNING CODES AND

ORDINANCES.

Electrical ground is required on this

appliance.

A 115 volt, 50 Hz., AC only, 15 ampere fused

electrical supply is recommended. (Time delay

fuse or circuit breaker is recommended.) It is

recommended that a separate circuit sewing only

this appliance be provided. Do not use an

extension cord.

DO NOT, UNDER ANY CIRCUMSTANCES,

REMOVE THE POWER SUPPLY CORD

GROUND PRONG.

Recommended grounding method

For your personal safety, this appliance must be

grounded. This appliance is equipped with a

power supply cord having a 3prong grounding

plug. To minimize possible shock hazard, the

cord must be plugged into a mating grounding

type wall receptacle, grounded in accordance

with all local codes and ordinances. If a mating

wall receptacle is not available, it is the responsi-

bility of the customer to have a properly

grounded, 3-prong wall receptacle installed by a

qualified electrician.

4

Using Your Dehumidifier

You will use your dehumidifier more during

months when you’re not heating your home.

However, your dehumidifier can help prevent

excessive moisture and keep you comfortable all

year long, in any area of your home.

l

Use in a basement to help prevent moisture

damage.

l

Use in cooking, laundry, bathing, and

dishwashing areas which have excess moisture.

l

Use to prevent moisture damage anywhere

books or valuables are stored.

5

Using Your Dehumidifier

Contmued

25,30,40, and 50 pint

models

r

PAN FULL

HUMIDISTAT

0

I

.

PAN FULL

HUMIDISTAT

0

r

PAN FULL

0

Control panel

These units have a control panel containing two

controls -the Pan Full Light and the Humidistat.

Pan Full Light -This light glows when the water

pan is full and needs to be emptied.

Humidistat - This controls the amount of

moisture left in the room. When the humidity in

the room increases, the unit automatically starts.

When the humidity decreases to the selected

level, the unit automatically stops. The unit will

run constantly when control is set to DRYEST.

Unit operation

1.

Turn Humidistat to OFF. Plug power supply

cord into electrical outlet. Be sure to use the

correct grounding technique. (See page 4.)

Turn the Humidistat toward DRYEST for

normal operation.

The Humidistat can be set anywhere

between OFF and DRYEST. lf you need more

dehumidification, turn the Humidistat toward

DRYEST. lf you need less dehumidification,

turn the Humidistat toward OFF.

Stop the unit manually by turning Humidistat

right to OFF.

/

NOTE: The dehumidifier will run continuously

when the control is set to DRYEST.

Water kvel

adJustmalt

\

Water level

control switch

c

\

@

//

&y 0

4. -

6

3\

’ --a

e’

Normal fill

screw

Msxknum fill

Ddcw control

NOTE: Do not operate dehumidifiir at tempera-

tures below 18.3% (65°F). The coils may

become iced over and unit will not operate

Properly.

Your dehumidifier is equipped with a feature to

help you get the most comfort from your new

appliince by permitting it to operate down to

18.3% (65°F). If your dehumidifier runs when

room temperature and humidity conditions are

low, frost can form on its evaporator coil. This

interferes with proper operation.

The De-icer Control senses frost buildup on

the evaporator coil and automatically shuts off

the compressor. The fan conttnues to run,

drawing air across the coil, and melting the frost.

When the coil is defrosted, the compressor

automatically restarts, and dehumidifying

resumes.

Setting the water level

adjustment

The Water Level Adjustment can be set in two

positions to turn off the unit automatically when

the pan is full. This prevents the danger of

overflow.

Pan must be in proper position for Water Level

Control Switch to work.

l

NORMAL FILL - set Water Level Adjustment

to the indentation on the left side. The water

pan and water will weigh approximately 7.2 kg

(16 Ibs.) and water pan will be ‘h full.

l

MAXIMUM FILL - set Water Level Adjustment

to the raised area on the right side. The water

pan and water will weigh approximately 10.8 kg

(24 Ibs.) and water pan will be % full.

The Water Level Control Switch will automatically

turn off the dehumidifier at the fill level you

selected when pan ia property placed. Loosen

the screw to move the Water Level Adjustment.

Retighten screw when adjusted to desired

setting.

7

Water disposal methods

Personal Injury Hazard

Do not use the water that collects in the

water pan for drinking purposes. R is not

sanitary and could cause Illness.

There are three methods of disposing of water.

1. Empty pan manually.

When pan is full, remove it, empty it into a

large sink or tub, and put it back in place. Be

sure pan Is properly placed so the Water

Level Control Switch will work to shut off

the unit automatically.

2. Place unit directly over drain.

Pan has a threaded hose connection which

can be left open. Cut out opening with a knife

or 19 mm (“h’) wood drill. Once opened, hose

connection will continually drain water from the

pan. Be sure to keep unit directly over a drain.

3. Attach garden hose to the threaded hose

connection to carry water to drain.

l

Pan has a threaded hose connection which

can be left open. Cut out opening with a

knife or 19 mm (%“) wood drill.

l

Attach garden hose. Be sure hose does not

kink or bend. It should lie flat from unit to

drain. (Hose is not included.)

l

Once hose connection is opened, pan will

continually drain through the hose. Be sure

to keep hose flat and in drain.

Caring for Your Dehumidifier

Your dehumidifier is designed to serve you year-

round. lt needs practically no attention. However,

you should check your dehumidifier and inspect

the coils annually.

You may call a service company to perform this

annual checkup. (Cost of annual inspection is the

owner’s responsibility.)

OR

tf you are familiar with electrical appliances and

their functions, below we have listed instructions

which would allow you to do the inspection and

maintenance yourself. However, we suggest you

contact a qualified service company to perform

this service, as we will not be held responsible for

any personal injury or damages, should you elect

to service this unit.

Electrkal Shock and

Personal Injury Hazard

l

Disconnect Power supply cord from

receptacle before performing any mainte-

nance. Failure to do so could result in

electrical shock

l

Be careful when cleaning the coils. Fins

are sharp. Failure to do so could result In

personal Injury.

1. Disconnect power supply cord.

2. To remove outer cabinet:

l

To take off the plastic front grille, remove the

two screws at the bottom. Drop grille down

and take out.

l

Remove the socket head screws on each

side of cabinet.

Socket head

screws

(on sides of cabinet)

--

Top flange screws

A

l

Remove the top flange screws.

l

Remove the rear grille. Pull down at bottom

and drop grille down.

l

Lii cabinet from base.

3. Coils should be inspected annually. Brush

clean, if necessary, with warm water and mild

detergent. Rinse and dry thoroughly. Be sure

power supply cord is disconnected from

receptecla

4. The compressor is sealed and needs no oiling.

5. The fan motor is permanently lubricated and

does not require further oiling.

6. Wash plastic parts with a soft cloth, warm

water, and mild detergent. Rinse and dry with

a soft cloth.

7. Replace cabinet and grilles.

8. Reconnect power supply cord.

10

Troubleshooting

Performance problems often result from little things you can find and fix without tools of any kind. Please

check the chart below for problems you can fix. It could save you the cost of a service call.

PROBLEM

Unlt will not run

Unlt blowa fuses

zps clrclJlt

breaker

POSSIBLE CAUSE

l

Is unit plugged into a live circuit with the proper voltage? Firmly plug power cord

intoelectricaloutlet.(Ifunitstilldoesnotopere&,haveaqualifiedelectrician

check the circuit voltage at the fuse/ckcult breaker box.)

~IstheHunMstatContrdsettoaposkionotherthanOFF?Tryadryersetting.

l

Has a household fuse blown or circuit breaker tripped7 Use the correct time-

delay fuses. Reset circuit breaker.

l

Is the correct capacky fuss beii used? Use the correct time-delay fuses. Reset

circuit breaker.

l

Is an extension cord being used? Do not use an extension cord with this or any

other applii.

MIS Ice over

l

Is room temperature below 18.3% (655°F) 7 Coils will become iced over at low

temperatures.

l

Are coils clogged with lint? Clean lint from coils (see “Caring for Your Dehumidi-

fief on pages 9 and 10).

l

Is room humidii low’? Do not operate unit when humidity is low.

l

Is room temperature below 18.3% (65”F)? Do not operate unit in low tempera-

tures - coils will become iced over. (See ‘Deicer control” on page 7.)

Water collects on

l

IsunitreasonaM y level’? Level unit front to back and side to side.

thefloor

l

Is hose kinked or drain clogged?

l

Is water pan overflowing? Remove and empty water pan. Replace pan property

and check to see that unit is level.

NOTE: When moving your dehumidifier, keep the unit in an upright position.

Requesting Assistance or Senrice

Before calling for assistance or service, please check Troubleshooting” on page 11. It may save you the

cost of a service call. If you still need help, follow the instructions below.

For assistance or service in the U.S.A.:

1. If you need assistance* . . .

El

Call Whlrlpool Consumer

w

Assistance Center telephone

number. Dlsl toll-frer from

anywhers In ths U.S.A.:

1-800-253-l 301

and talk with one of our trained consultants.

The consultant can instruct you in how to

obtain satisfactory operation from your appliance

or, if service is necessary, recommend a qualiii

service company in your area.

If you prefer, write to:

Mr. William Clark

Consumer Assiitance Representative

Whirlpool Corporation

2000 North M-63

Senton Harbor, MI 49022-2692

Please include a daytime phone number in your

correspondence.

2. Ii you need service* . . .

El

Whirlpool has a nationwide

network of authorized Whirlpool

SERVICE

service companies. Whirlpool

service technicians are trained to

fulfill the product warranty and pro-

vide after-warranty service, any

where in the United States. To locate the autho-

rized Whirlpool service company in your area, call

our Consumer Assistance Center telephone num-

ber (see Step 1) or look in your telephone directory

Yellow Pages under:

l APPLIANCE-HOUSEHOL~

l WASHING UACHHES L

YAJOR, SERvlcE L REPAIR

DRYERS, SERVICE L REPUR

-See: Whirlpoor Applincea or

-sU:WllMpoolAppl*nesr

mholimd wllnmirlpool savice

Aulhotizedwh~servdeQ

(Exam/h xxi! .sm-bw co.)

(EumM: xx! secvlcr co.)

3. tf you noed FSP replacement parts . . .

FSP is a registered trademark of Whirlpool

Corporation for qualii parts. Look for this symbol

of quality whenever you need a replacement part

for your Whirlpool appliance. FSP replacement

parts will fit right and work right, because they are

made to the same exacting specifications ueed to

build every new Whirlpool appliance.

To locate FSP replacement parts in your area,

refer to Step 2 or call the Whirlpool Consumer

Assistance Center number in Step 1.

4. tf you are not satlsfled with how the problem

was solved . . .

l

Contact the Major Appliance Consumer Action

Panel (MACAP). MACAP is a group of indepen-

dent consumer experts that voices consumer

views at the highest levels of the major appli-

ance industry.

l

Contact MACAP only when the dealer, autho-

rized servicer, and Whirlpool have failed to

resolve your problem.

Major Appliance Consumer Action Panel

20 North Wacker Drive

Chiigo, IL 60606

l

MACAP will in turn inform us of your action.

‘When asking for help or seervIce:

Please provide a detailed description of the

problem, your appliance’s complete model

and serial numbers, and the purchase date.

(See page 2.) This information will help us

respond property to your request.

12

For assistance or service in Canada:

1. If

the problem Ia not due to

one of the items listed in

“lroubleshootlng”...

Contact the dealer from whom you

purchased your appliance or your

nearest lnglis Limited Appliance

Service Branch. Please include a

daytime phone number in your

correspondence.

2.

If you need service...

Contact your nearest lnglis Limi-

ted Appliance Service Branch or

authorized servicing outlet to

service your appliance.

El

w

NOTE: When asking for help or

service, please provide a detailed description of

the problem, your appliance’s complete model

and serial numbers, and the purchase date. (See

page 2.) This information will help us respond

properly to your request.

Inglis Limited Appliance Service - Consumer Serviceo

Direct wrvice branches:

BRITISH COLUMBIA Vancouvw

Victoria

lnglis Limited Appliance Service

3627 E. 4th Avenue

lnglis Limited Appliance Service

3117 Steele street

(604) 2914426

1-6oO-6656766

(604) 2916426

16008656766

ALBERTA

Ca&w

Edmonton

lnglis Limited Appliance Service

#l&6025 12th Street S.E.

lngtis Limited Appliance Service

16236 116th Avenue

(403) 2539267

1-6OG661-1022

(403) 4539900

1-600-66142Ql

ONTARlO

Toronto

(Miwissauga)

Toronto

(Markham)

Ottawa

lngfis Limited Appliance Service

5945 Ambler Drive

lnglis Limited Appliance Service

Unit fl , 110 Torbay Road

lnglis Limited Appliance Service

26 Capital Drive

(905) 624-2600

1-600-607-6n7

(905) 475-95 11

l-600-6076777

(613) 2254510

l-600-267-3456

MANITOBA Winnipeg

lnglis Limited Appliance Service

1663 Church Avenue

(204) 6945306

l-600-665-1 663

QUEBEC

Montreal

(Laval)

Broosard

lnglis Limited Appliance Service

2750 Francis-Hughes

lnglis Limited Appliance Service

9605 F. lgnace Street

(514) 3826110

l-600-361 -3032

(514) 397-1640

l-600-361 -0950

Quebec City

lnglis Limited Appliance Service (416) 671-5251

5275 Blvd. Wilftid-Hamel, Suite 140

1-600-463-l 523

Sherbrooke

(Rock Forest)

lnglis Limited Appliance Service

3475 Industrial Blvd.

(619) 564-6565

l-600-5674966

NOVA SCOTIA

Dartmouth

lnglis Limited Appliance Service

900 Windmill Road

(902) 4666634

1-600-565-l 596

SASKATCHEWAN

Regina

1-600665-l 663

Saskatoon 1-600-665-l 663

For sewice in areas other than those listed, contact your Appliance Dealer.

Dehumidifier Warranty

LENGTH OF WARRANTY

FULL ONE-YEAR WARRANM

From Date of Purchase

FULL FIVE-YEAR

WARRANTY

From Date of Purchase

WE WILL PAY FOR

Replacement parts and repair labor to correct defects in

materials or workmanship.

Replacement parts to correct defects in materials or workman-

ship in the sealed refrigeration system.

These parts are:

1. Compressor 4. Drier-Strainer

2. Evaporator

5. Connecting Tubing

WE WlLL NOT PAY FOR

I

3. Condenser

I

A Service calls to:

1. Correct the installation of your dehumidifier.

2. Instruct you how to use your dehumidifier.

3. Replace house fuses or correct house wiring.

B. Pickup and delivery. Your dehumidifier is designed to be repaired in the home.

C. Damage to your dehumidifier caused by accident, misuse, fire, flood, acts of God, or use of

products not approved by Whirlpool.

D. Repairs to parts or systems caused by unauthorized modifications made to the appliance.

Service under the full warranties must be provided by an authorized service company. This warranty

gives you specific legal rights, and you may also have other rights which vary from state to state or

province to province.

Outside the United States or Canada, a different warranty may apply. For details, please contact your

authorized distributor or military exchange.

lf you need service, first see the “Requesting Assistance or Service” section of this book After checkfng

“Requesting Assistance or Service,” additional help can be found by calling our Consumer Assistance

Center telephone number, l-800-253-1301, from anywhere in the U.S.A. For service in Canada, see

‘Inglis Limited Appliance Service - Consumer Services” on page 13 for the service branch in your area.

’ Registered Trademark of Whirlpool, U.S.A.

Printed in U.S.A.

Page is loading ...

Pour appel d’aide ou de service au

Canada :

1. Sl la cause du problhne n’a pas

2.

Si vous avez besoin de service...

6t6 mentionhe danr la section

“-annage”...

Contactez le concessionnaire

chez qui vous avez achet6 votre

appareil mknager ou votre

succursale de service lnglis Limitbe.

Veuillez inclure un numb0 de

W6phone air I’on peut vous

joindre pendant la journke.

Contactez votre succursale de ser-

vice lnglis Limithe ou un centre

de service autorise pour

I’entretien de votre appareil

m6nager.

REMARQUE : Lorsque vous appelez le service

de depannage, veuillez inclure une description

dktailbe du probkme, les numkos de modkle et

de &tie, et la date d’achat. Ces renseignements

sont nbcessaires pour kpondre rapidement B

votre demande.

Service d’appareils mhnagers - Inglis Limit&

Service eux consommateure

Succur8eh de service direct :

COLOMBIE-BRITANNIQUE Vancouver

lnglis Limit& Service deppareils m&wgers

3627 E. 4th Avenue

(604) 291-6426

1-6OO-M58766

ALBERTA

lnglis Limit& Service d’appareils menagers

(604) 291 +I26

3117 Steele street

1-600-665-6766

lnglis Limit& Service d’appareils mbnagers

(403) 253-9267

#15,6025 12th Street S.E.

l-600-661-1022

Edmonton

lnglis Limit& Service d’appareils r&nagers

16236 116th Avenue

ONTARlO

Toronto

(Mi8sisaauga)

lnglis Limitee Sawics d’appareils tinagers

5945 Ambler Drive

Toronto

(Markham)

lnglis Limit& Service d’appareils tinagers

Unit tl, 110 Totbay Road

Ottawa

lnglis Limitee Setice d’appareils mdnagers

26 Capital Drive

(403) 453-3900

l-600-6616291

(905) 624-2600

l-600-6076777

(905) 475-9511

l-800-6076777

(613) 225-0510

l-600-267-3456

MANITOBA

Wnnipeg

lnglis LimitQe Swviw d’appareils mbnagers

(204) 694-5306

1663 Church Avenue 1-65-1663

QUEBEC

lnglis Limitbe Service d’appareils mdnagers

2750, Francis-Hughes

Brossard

QU6bM

lnglis LimitQe Sanka dappareils mdnagers

9605 F, rue lgnace

lnglis Limitee Service d’appareils mdnagers

5275, boul. Wilfrid-Hamel, Bureau 140

Shwbrooke

(Rock For-t)

lnglis Limitee Service d’appareils mbnagers

3475, boul. lndustrid

(514) 3628110

l-600-361 -3032

(514) 397-1640

l-600-361 -0950

(416) 671-5251

1-600-463-l 523

(619) 56446565

l-600-5676966

NOUVELLE-CCOSSE

Dartmouth

lnglis Limitie Setice d’appareils mbnagers

(902) 466*34

900 Windmill Road

1-600-565-l 596

SASKATCHEWAN

Regina

Sarkatoon

1-600-665-l 663

Pour obtenir des services techniques en dehors des centres menlionnk,

contactez votre marchand dappareils mbnagers.

Page is loading ...

COMFORT-AIRE BFD300 User manual

COMFORT-AIRE BFD300 User manual

in other languages

Related papers

Other documents