Axor 10407001 Installation guide

Axor
Brand
Axor
Model
10407001
Category
Sanitary ware
Type
Installation guide

This manual is also suitable for

Page is loading ...
Page is loading ...
Page is loading ...
4
À prendre en considération pour l’installation
Pourdemeilleursrésultats,Hansgroherecom-
mandequeceproduitsoitinstalléparunplom-
bierprofessionnellicencié.
Cedispositifrequiertunepièceintérieure
01850181.
Veuillezlireattentivementcesinstructionsavant
deprocéderàl’installation.Assurez-vousdedis-
poserdetouslesoutilsetdumatérielnécessaires
pourl’installation.
Pourempêcherdesblessuresparébouillan-
tement,latempératuredesortiemaximaledu
robinetdedouchenedoitpasexcéder120°F.
AuMassachusetts,latempératuredesortie
•
•
•
•
maximaledurobinetdedouchenedoitpas
excéder112°F.
Réglezlabutéelimitatricedetempératureaumo-
mentdel'installation(voirpage18).Ilpeutêtre
nécessairedefairedenouveauxréglagesparla
suiteenraisondesfluctuationssaisonnièresdela
températuredel'eau.
N'installezpasdedispositifd'arrêtsurunesortie
quelconquedecerobinet.Eninterrompant
l'écoulementdel'eau,cedispositifpeutempê-
cherlerobinetd'équilibrerlespressionsd'eau
chaudeetd'eaufroide.
•
•
Installation Considerations
Forbestresults,Hansgroherecommendsthat
thisunitbeinstalledbyalicensed,professional
plumber.
Pleasereadovertheseinstructionsthoroughlybe-
forebeginninginstallation.Makesurethatyou
havealltoolsandsuppliesneededtocomplete
theinstallation.
ThistrimisforusewithiBoxUniversalPlusmodel
01850181(notincluded).
Topreventscaldinjury,themaximumoutputtem-
peratureoftheshowervalvemustbenohigher
than120°F.InMassachusetts,themaximumout-
puttemperaturecanbenohigherthan112°F.
Adjusttherotationallimitstop(seepage18)
duringinstallation.Furtheradjustmentsmaybe
•
•
•
•
•
necessaryduetoseasonalwatertemperature
changes.
Donotinstallashut-odeviceoneitheroutletof
thisvalve.Useofsuchadevicecandefeatthe
abilityofthevalvetobalancethehotandcold
waterpressures.
Thepressurebalancetrimissuitableforaone-
functioninstallation,suchasasingleshowerhead
orhandshower.
Thepressurebalancetrimmaybeusedinatub/
showerapplicationusingadivertertubspout.
Keepthisbookletandthereceipt(orotherproof
ofdateandplaceofpurchase)forthisproductin
asafeplace.Thereceiptisrequiredshoulditbe
necessarytorequestwarrantyparts.
•
•
•
•
*Pleaseknowandfollowallapplicablelocalplumbingcodeswhensettingthetemperatureonthewaterheater.
*Vousdevezconnaîtreetrespectertouslescodesdeplomberielocauxapplicablespourleréglagedelatempératuredu
chaue-eau.
*Debeconocerycumplirtodosloscódigoslocalesaplicablesparaajustarlatemperaturadelcalentadordeagua.
Recommendedwater
pressure
Pressiond’eaurecommandée Presiónrecomendadaen
servicio
15-75psi
Max.waterpressure Pressiond’eaumaximum Presiónenserviciomax. 145psi
Recommendedhot
watertemp.
Températurerecommandée
d'eauchaude
Temperaturarecomen-
dadadelaguacaliente
120°-140°F*
Max.hotwatertemp Températuremaximumd'eau
chaude
Temperaturadelagua
calientemax.
176°F*
Flowrate Capaciténominale Caudalmáximo 4.5gpm@44psi
Technical Information / Données techniques / Datos tecnicos
Page is loading ...
6
English
Flush the hot and cold supplies
(1)Removethecover.
(2)Openthecoldstopusinga4mmAllen
wrench.
(3)Allowthecoldsupplytoushforatleastve
minutes.
(4)Closethecoldstop.
(1)Removetheushingblockusinga5mmAllen
wrench.Turnit90°andreinstall.
(2)Openthehotstop.
(3)Allowthehotsupplytoushforatleast5
minutes.
(4)Closethehotstop.
1.
2.
4 mm
2.
3.
4.
4.
1.
2. 4.
3.
Page is loading ...
8
English
Installation
Removethelabel(1).
Close the stops using a 4 mm Allen
wrench (2).
Cuttheplastershieldsothatitextends¹⁄₁₆"-⅛"
fromthenishedwallsurface.
Seal the wall around the plaster
shield with waterproof sealant (1).
Failure to seal the wall can lead to
possible water damage.
Removetheushinsertscrew,ushinsert,and
seals(2).
4 mm
1
2
1
2
Page is loading ...
10
English
Installthefunctionblock.
Tightenthescrewsusinga4mmAllenwrench.
Measurethedistancefromthefrontoftheplaster
shieldtooneofthescrew-inanges("X").
Add½"tothismeasurement.
CuteachscrewsothatitisX+½"long.
Page is loading ...
12
English
Openthestopsusinga4mmAllenwrench(1).
Openthestops(1).
Installthecarrierplate(2).
Installthecarrierplatescrews.
Placethehandleoverthestem(1).
Turnthehandlecounter-clockwiseasfarasitwill
go(2).
Measurethetemperatureoftheoutputwater(3).
If the valve opens through hot, re-
verse the cartridge. See page 16.
If the max. high temperature is
greater than 120°F adjust the
rotational limit stop. See page 18.
Turnthewatero.
Removethehandle(4).
Removethedisk.
1
2
3
4
4 mm
1
2
Page is loading ...
14
English
Installthehandle.
Tightenthehandlescrew.
Installthescrewcover.
Lubricatethecartridgeo-ringusingasmall
amountofwhiteplumber'sgrease.
Installthesleeve.
Installtheescutcheon.
2.5 mm
Page is loading ...
16
English
Reverse the cartridge
Ifthevalveopensthroughhot,reversethe
cartridge.
Close the stops using a 4 mm Allen
wrench, or turn the water o at the
main (1).
Unscrewthenut(2).
Placethehandleonthecartridgestem.
Turnthehandlecounter-clockwiseapproximately
¼turnafterhittingthestop.
Removethecartridge(1).
Do not attempt to pry the cartridge
from the function block by using
a screwdriver, or damage to the
cartridge will result.
Turnthecartridge180°,sothatthe"hotside"
markingisontheright(2).
Installthecartridge(3)
Installthenut(4).
Continuetheinstallation.
1
2
3
Ø
2
4
1
2
4 mm
Page is loading ...
18
English
Adjust the Rotational Limit Stop
Adjusttherotationallimitstopif:
Themaximumoutputtemperatureisgreaterthan
120°Forthatpermittedbylocalplumbingcode
Thetemperatureoftheincominghotorcold
watersupplychangesseasonally,orifchanges
aremadetothewaterheater.
•
•
Turntherotationallimitstop,clockwisetomake
thewatercooler,counter-clockwisetomakeit
warmer.
Dependingonlocalconditions,eachnotchrepre-
sentsachangeintemperatureof4°F-16°F.
Continuetheinstallation.
Page is loading ...
20
Replacement Parts / Pièces détachées / Repuestos
XX =Finishes/Couleurs/Acabados
00 chrome
62 oilrubbronze
82 brushednickel
83 polishednickel
92 rubbedbronze
96447000
96454000
96525000
13595000
(optional)
13596xx0
(optional)
98860xx0
(optional)
96454000
98793000
95181000
95181000
95181000
95181000
95181000
95181000
88727000
96540xx1
96540xx1
97987xx0
98133000
97407xx0
(optional)
21
Recommandations pour le nettoyage des produits Hansgrohe
Lesrobinetteriesmodernesdelavabo,decuisineetdedoucheutilisentdesmatériauxtrèsdiérentspourrépondreauxbesoinsdu
marchéentermesdeconceptionetdefonctionnalité. Certaines règles de base doivent être respectées lors du nettoyage de cesCertaines règles de base doivent être respectées lors du nettoyage de cesCertainesrèglesdebasedoiventêtrerespectéeslorsdunettoyagedeces
produitsand’éviterdelesendommageroud’avoiràlesretourner.
Produits de nettoyage pour robinetteries et douches
Lesacidessontunepartieintégrantenécessairedetouslesproduitsdedétartrage;ilfautcependantprendrelesprécautionssuivantes
lorsdunettoyagedesrobinetsetdesdouches:
N’utilisezquedesproduits/articlesdenettoyageconçusspéciquementpourlesarticlesderobinetterieetdedouche.
N’utilisezjamaisdeproduits/articlesdenettoyagecontenantdel’acidechlorhydrique,formique,phosphoriqueouacétiquecar
ilspourraientcauserdesdommagesconsidérables.
Nemélangezjamaisdeuxproduitsdenettoyage.
N’utilisezjamaisdeproduits/articlesdenettoyagedenatureabrasivetelsquepoudresdenettoyage,tampons-épongeou
chionsmicrobrenonappropriés.
Instructions de nettoyage pour robinetteries et douches
Veuillezsuivrelesinstructionsdufabricantdeproduits/articlesdenettoyage. De plus, tenez compte des conseils suivants :De plus, tenez compte des conseils suivants :Deplus,tenezcomptedesconseilssuivants:
Nettoyezvosproduitsderobinetterieetdedoucheaussisouventquenécessaire.
•
•
•
•
Cleaning Recommendation for Hansgrohe Products
Modernlavatoryfaucets,kitchenfaucets,andshowersconsistofverydierentmaterialstocomplywiththeneedsofthemarketwith
regardtodesignandfunctionality.Toavoiddamageandreturns,itisnecessarytoconsidercertaincriteriawhencleaning.
Cleaning Materials for Faucets and Showers
Acidsareanecessaryingredientofcleaningmaterialsforremovinglime,howeverpleasepayattentiontothefollowingpointswhen
cleaningfaucetsandshowers:
Onlyusecleaningmaterialswhichareexplicitlyintendedforthistypeofapplication.
Neverusecleaningmaterialswhichcontainhydrochloric,formic,phosphoric,oraceticacid,astheycauseconsiderable
damage.
Nevermixonecleaningmaterialwithanother.
Neverusecleaningmaterialsorapplianceswithanabrasiveeect,suchasunsuitablecleaningpowders,spongepads,ormicro
bercloths.
Cleaning Instructions for Faucets and Showers
Pleasefollowthecleaningmaterialmanufacturer’sinstructions.Inaddition,payattentiontothefollowingpoints:
Cleanthefaucetsandshowersasandwhenrequired
Usetheamountofcleaningproductandtheamountoftimerecommendedbythemanufacturer.Donotleavethecleaneronthe
xturelongerthannecessary.
Regularcleaningcanpreventcalcication.
Whenusingspraycleaners,sprayrstontoasoftclothorsponge.Neverspraydirectlyontothefaucetasdropletscanenter
openingsandgapsandcausedamage.
Aftercleaning,rinsethoroughlywithcleanwatertoremoveanycleanerresidue.
Important
Residuesofliquidsoaps,shampoos,andshowerfoamscanalsocausedamage,sorinsewithcleanwaterafterusing.
Please note:ifthesurfaceisalreadydamaged,theeectofcleaningmaterialswillcausefurtherdamage.
Components with damaged surfaces must be replaced or injury could result.
Damage caused by improper treatment is not covered under the warranty.
•
•
•
•
•
•
•
•
•
Page is loading ...
23
Limited Consumer Warranty
ThisproducthasbeenmanufacturedandtestedtothehighestqualitystandardsbyHansgrohe,Inc.(“Hansgrohe”).
ThiswarrantyislimitedtoHansgroheproductsthatarepurchasedbyaconsumerintheUnitedStatesorCanada
afterMarch1,1996,andinstalledineitherintheUnitedStatesorinCanada.
WHO IS COVERED BY THE WARRANTY
Thiswarrantyextendstotheoriginalpurchaseronly.Thiswarrantyisnon-transferable.
WHAT IS COVERED BY THE WARRANTY
ThewarrantycoversonlyyourHansgrohemanufacturedproduct.Hansgrohewarrantsthisproductagainstdefectsin
materialorworkmanshipasfollows:
Hansgrohewillreplaceatnochargeforpartsonlyor,atitsoption,replaceanyproductorpartoftheproductthat
provesdefectivebecauseofimproperworkmanshipand/ormaterial,undernormalinstallation,use,serviceand
maintenance.IfHansgroheisunabletoprovideareplacementandrepairisnotpracticalorcannotbemadein
timelyfashion,Hansgrohemayelecttorefundthepurchasepriceinexchangeforthereturnoftheproduct.
LENGTH OF WARRANTY
Replacementorrepairedpartsofproductswillbecoveredforthetermofthiswarranty,asstatedinthefollowing
twosentences.Ifyouareaconsumerwhopurchasedtheproductforuseprimarilyforpersonal,familyorhousehold
purposes,thiswarrantyextendsforaslongasyouowntheproductandthehomeinwhichtheproductisoriginally
installed.Ifyoupurchasedtheproductforuseprimarilyforanyotherpurpose,including,withoutlimitation,a
commercialpurpose,thiswarrantyextendsonly(i)for1year,withrespecttoHansgrohe&Commercialproducts,
and(ii)for5years,withrespecttoAxorproducts.
THIS WARRANTY DOES NOT COVER, AND HANSGROHE WILL NOT PAY FOR:
A.Conditions,malfunctionsordamagenotresultingfromdefectsinmaterialorworkmanship.
B.Conditions,malfunctionsordamageresultingfrom(1)normalwearandtear,improperinstallation,improper
maintenance,misuse,abuse,negligence,accidentoralteration;(2)theuseofabrasiveorcausticcleaningagents
or“no-rinse”cleaningproducts,ortheuseoftheproductinanymannercontrarytotheproductinstructions;or(3)
conditionsinthehomesuchasexcessivewaterpressureorcorrosion.
C.Laborandotherexpensesfordisconnection,deinstallation,orreturnoftheproductforwarrantyservice
(includingbutnotlimitedtoproperpackagingandshippingcosts),orforinstallationorreinstallationofthe
product.
D.Accessories,connectedmaterialsandproducts,orrelatedproductsnotmanufacturedbyHansgrohe.
E.AnyHansgroheorAxorproductsoldfordisplaypurposes.
F.RubbedBronzenishissubjecttoa3-yearlimitedwarranty.ChromeandallPVDnishesarecoveredbythe
limitedlifetimewarranty.
G.HansgroheWaterFiltrationSystemissubjecttoa1-yearlimitedwarranty.Warrantydoesnotinclude
replacementlters.
TO OBTAIN WARRANTY PARTS OR INFORMATION
ContactyourHansgroheretailer,orcontactTechnicalServiceat:
Hansgrohe,Inc.
1492BluegrassLakesParkway
Alpharetta,GA30004
Toll-free800-334-0455
Inrequestingwarrantyservice,youwillneedtoprovide:
1.Thesalesreceiptorotherevidenceofthedateandplaceofpurchase.
2.Adescriptionoftheproblem.
3.Deliveryoftheproductorthedefectivepart,postageprepaidandcarefullypackedandinsured,to:
Hansgrohe,Inc.
1492BluegrassLakesParkway
Alpharetta,GA30004
Toll-free800-334-0455
Hansgrohe, Inc. • 1490 Bluegrass Lakes Parkway • Alpharetta, GA 30004
Tel. 770-360-9880 • Fax 770-360-9887
www.hansgrohe-usa.com
US - Installation Instructions • Part No. 90146301 • Revised 09/2010
Whenwarrantyserviceiscompleted,anyrepairedorreplacementproductorpartwillbereturnedtoyoupostage
prepaid.
EXCLUSIONS AND LIMITATIONS
REPAIR OR REPLACEMENT (OR, IN LIMITED CIRCUMSTANCES, REFUND OF THE PURCHASE
PRICE) AS PROVIDED UNDER THIS WARRANTY IS THE EXCLUSIVE REMEDY OF THE PURCHASER.
HANSGROHE NEITHER ASSUMES NOR AUTHORIZES ANY PERSON TO CREATE FOR IT ANY
OTHER OBLIGATION OR LIABILITY IN CONNECTION WITH THIS PRODUCT. HANSGROHE SHALL
NOT BE LIABLE TO PURCHASER OR ANY OTHER PERSON FOR ANY INCIDENTAL, SPECIAL OR
CONSEQUENTIAL DAMAGES, ARISING OUT OF BREACH OF THIS WARRANTY OR ANY IMPLIED
WARRANTY (INCLUDING BUT NOT LIMITED TO ANY IMPLIED WARRANTY OF MERCHANTABILITY).
SomeStatesdonotallowtheexclusionorlimitationofincidentalorconsequentialdamages,sotheabovelimitation
orexclusionmaynotapplytoyou.Thiswarrantygivesyouspeciclegalrights,andyoumayalsohaveotherrights
thatvaryfromstatetostate.
TO THE EXTENT PERMITTED BY LAW, ANY IMPLIED WARRANTIES OF MERCHANTABILITY AND
FITNESS FOR A PARTICULAR PURPOSE, ARE LIMITED TO THE DURATION OF THE EXPRESS
WARRANTY.
Somestatesdonotallowlimitationsonhowlonganimpliedwarrantymaylast,sotheabovelimitationsmaynot
applytoyou.Youmayberequiredbylawtogiveusareasonableopportunitytocorrectorcureanyfailureto
complybeforeyoucanbringanyactionincourtagainstusundertheMagnuson-MossWarrantyAct.
PRODUCT INSTRUCTIONS AND QUESTIONS
Uponpurchaseorpriortoinstallation,pleasecarefullyinspectyourHansgroheproductforanydamageorvisible
defect.Priortoinstalling,alwayscarefullystudytheenclosedinstructionsontheproperinstallationandthecareand
maintenanceofthisproduct.Ifyouhavequestionsatanytimeabouttheuse,installationorperformanceofyour
Hansgroheproduct,orthiswarranty,pleasewriteusorcallustoll-freeat800-334-0455.
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16
  • Page 17 17
  • Page 18 18
  • Page 19 19
  • Page 20 20
  • Page 21 21
  • Page 22 22
  • Page 23 23
  • Page 24 24

Axor 10407001 Installation guide

Axor
Brand
Axor
Model
10407001
Category
Sanitary ware
Type
Installation guide
This manual is also suitable for
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

in other languages

Related papers

Other documents