Southbend P36D-GRAD Datasheet

Brand: Southbend

Model: P36D-GRAD

Category: Cookers

Type: Datasheet

This manual is also suitable for

Job Item#

www.yatesgd.com www.yatesgraphicdesign.com

STANDARD CONSTRUCTION SPECIFICATIONS

36" Se c t i o n a l Ra n g e

Full-Width Graduated Hot Top

 P36N-GRAD (Modular Mount)

 P36C-GRAD (Cabinet Base)

 P36D-GRAD (Standard-Oven Base)

 P36A-GRAD (Convection-Oven Base)

Standard Features

• 36"-widesectionalrangewithfull-widthgraduatedhottop

availablewithastandard-ovenbase,convection-ovenbase,

cabinetbase,orasamodularunit(formounting

oncountertop,refrigeratedorfreezerbase)

• One62,000BTUNAT(45,000BTULP)burner

• Electronicpilotignition-Piezo

• Removablesteelplateswithcentersurfacetemperatureupto

900°Fatthecenter

• High/Lowsetting

• 9-1/4"deepfrontrail

• Stainlesssteelfront,sides,rearandexteriorbottom

• Fullyinsulatedliningandburnerbox

• 1-1/4"frontgasmanifoldand1"reargasconnection

• 5"highstainlesssteelueriser

• Freebattery-designassistance

• Warranty:twoyearsonspeciedoperationalpartsandoneyear

onlaborfromdateofpurchase

Standard Features of Oven-Base Models

• 45,000BTUNAT42,000BTULP)ovenwithstandingpilot

• Cool-to-the-touchhandle

• Porcelainenamelinterior

• Ovenracks(2forstandardoven,3forconvectionoven)

• “Insta-On”thermostatrangingfrom175°Fto550°F

• Standard-oveninteriorislargeenough(26"by26-1/2")forsheet

panstoteitherway

• Convection-ovenmodelshave1/3hp,two-speedblower

Standard Features of Cabinet-Base Model

• Stainlesssteelcabinetwithremovabledoorsthatopenfromthe

center

Exterior Finish:Front,sides,rearandexteriorbottom

constructedof#3polished430and304stainlesssteel.

Range: 36"-widefront-manifoldsectionalrangewithfull-

widthgraduatedhottopwitha64,000BTUNAT(45,000BTU

LP)burner.Removablesteelplatesandanoperatingsurface

temperatureofupto800°F(427°C).

Front Rail: 9-1/4"deepfrontrail.

Flue Riser: 5"Standard,Optional24"or36"highueriser

withoptionalshelves(oneon24"ueriser,twoon36"ue

riser).Standardshelvesaresolid.

Battery: Unitcanbeinanypositioninabattery.Iftheunitis

attheendofthebattery,theendsidewillbesolid(ratherthan

haveacoverplateovertheendofthefrontmanifold).

Legs:6"stainlesssteeladjustablelegsstandard.

Model 36D:45,000BTUNAT(42,000BTULP)ovenwith

standingpilotandthermostatrangeof175°Fto550°F(79°C

to288°C).Porcelainenamelinterior,measuring14”highx

26”widex26.5”deep.Tworackswithve-positionsiderails.

Model 36A:45,000BTUNAT(42,000BTULP)convection

ovenwithstandingpilotandthermostatrangeof175°Fto

550°F(79°Cto288°C).Porcelainenamelinterior,measuring

14”highx26”widex24”deep.Threerackswithve-position

siderails.Two-speed,1/3hpblowermotor.

Model 36C:Stainlesssteelcabinetbasewithtworemovable

doorsthatopenfromthecenter.

PrintedinUSA

FormP36-GRADRev2(09/08)

Model P36A-GRAD with optional 24" ue riser

1100 Old Honeycutt Road, Fuquay-Varina, NC 27526

(919) 762-1000 www.southbendnc.com

Models:

www.yatesgd.com www.yatesgraphicdesign.com

FRONT VIEW

36" (914)

REAR VIEW

2-1/2" (64)

18"

(457)

7" (178)

20"

(508)

TOP VIEW

43"

(1092)

24"

(610)

60"

(1524)

41"

(1041)

72"

(1829)

Electrical

Connection

for Oven

Models

Rear Gas

Connection

5" Flue Riser

24" Flue Riser

36" Flue Riser

8-1/2" (216)

SIDE VIEW of MODULAR MODEL

SIDE VIEW

33-3/4"

(859)

Motor for

Convection

Oven Models

15-3/4"

(400)

36"

(914)

37-1/2"

(953)

9-1/4"

(235)

37-1/2" (953)

34" (864)

40" (1016)

43-1/2" (1105)

5" (127)

Front Gas

Manifold

20-1/2"

(521)

11-3/4"

(298)

Optional extra-deep flue riser (cooking area is

same as for models with standard flue riser).

Optional Shelf

 P36N-GRAD  P36C-GRAD  P36D-GRAD  P36A-GRAD

INTENDED FOR COMMERCIAL USE ONLY.

NOT FOR HOUSEHOLD USE.

OPTIONS and ACCESSORIES

MISCELLANEOUS

UTILITY INFORMATION

GAS:Eachunithasa

1-1/4"frontmanifold

thatcouplestothe

adjacentsectional

unit(s),anda1"rear

gasconnectionwitha

maleNPTconnector.

Minimumgassupply

pressureis7"W.C.

fornaturalgasand

11"W.C.forpropane.

All sectional units

requirearegulatedgassupply(apressureregulatormustbeordered

separately).Ifusingaexible-hosegasconnection,theinside

diameterofthehosemustnotbesmallerthantheconnectoron

theunitandmustcomplywithANSIZ21.69,providinganadequate

meansofrestrainttopreventunduestrainonthegasconnection.

ELECTRICITY: Allovenmodelswithoptionalelectronicignition

require50Hzor60Hzsingle-phasepower.120Vmodelshavea

7-footpowercordwithgroundplug(1.0Afor"D"models&4.8Afor

"A"models).208/240Vmodelshaveaterminalblockforconnection

toasingle-phase208/240Vsource(1.0Afor"D"models&2.6Afor

"A"models).

• Ifcastersareusedwithaexible-hosegasconnection,a

restrainingdeviceshouldbeusedtopreventunduestrain

onthehose.

• Minimumclearancefromnoncombustibleconstructionis

zero(excepttheremustbe2"clearancebehindtheblower

motorofconvection-ovenmodels).Minimumclearance

fromcombustibleconstructionis10"(254mm)onsides

and6"(152mm)onrear.

• Installationunderaventedhoodisrecommended.

• Checklocalcodesforreandsanitaryregulations.

NOTICE:

Southbendhasapolicyofcontinuousproductresearchand

improvement.Wereservetherighttochangespecicationsand

productdesignwithoutnotice.Suchrevisionsdonotentitlethebuyer

tocorrespondingchanges,improvements,additionsorreplacements

forpreviouslypurchasedequipment.

 Externalpressureregulator

 Frontrailoptions:

Cutoutsinfrontrailforsaucepans

7-1/4"deepfrontrail(tomatchold

stylesectional)

Squarebellybarmountedon7-1/4"

deepfrontrail

 Casters(fronttwocasterslock)

 Cablerestraintkit(torestrict

movementwhenoncasters)

 24"or36"highueriser

 Shelvesonueriser(oneon24"ue

riser,oneortwoon36"ueriser)

 Trayortubularshelves

 Open-framebasewithcastersfor

battery

 Extra-deeprear-extendingueriser

 Stainless steel oven interior

 Salamanderorcheesemelter

mountedon36"highueriser

 Removableshelfinsidecabinet

 Electronicovenpilotignition

 120V,NEMA4waterresistant

controls

FormP36-GRADRev2(09/08)

Dimensionsshownininchesand(millimeters)

Sh i p p i n g Cr a t e Di m e n S i o n S & We i g h t

mo D e l Wi D t h he i g h t De p t h Vo l u m e We i g h t

P36N-GRAD

45.5"

(1156)

23"

(584)

55"

(1397)

33.3cuft

(0.94cum)

346lbs

(156.9kg)

P36C-GRAD

45.5"

(1156)

45"

(1143)

55"

(1397)

65.2cuft

(1.85cum)

523lbs

(237.2kg)

P36D-GRAD

45.5"

(1156)

45"

(1143)

55"

(1397)

65.2cuft

(1.85cum)

629lbs

(285.3kg)

P36A-GRAD

45.5"

(1156)

45"

(1143)

55"

(1397)

65.2cuft

(1.85cum)

682lbs

(309.3kg)

mo D e l

ga S (Btu/h o u r ) el e C t r i C i t y (am p S )

na t u r a l pr o p a n e 120V 208/240V

P36N-GRAD 62,000 45,000 - -

P36C-GRAD 62,000 45,000 - -

P36D-GRAD 107,000 87,000 0* 0*

P36A-GRAD 107,000 87,000 3.8* 1.6*

*StandingOvenPilotModels

Southbend P36D-GRAD Datasheet

Brand: Southbend

Model: P36D-GRAD

Category: Cookers

Type: Datasheet

This manual is also suitable for

Download PDF

report

Southbend P36D-GRAD Datasheet

This manual is also suitable for

Southbend P36D-GRAD Datasheet

Related papers

Other documents