TP814
Triple Round Wood
Multiplay
INSTRUCTIONS FOR ASSEMBLY
MAINTENANCE AND USE.
PLEASE RETAIN FOR FUTURE REFERENCE.
2 Person
Assembly Build Recommended
TOY MUST BE ASSEMBLED BY AN ADULT BEFORE USE.
THIS PRODUCT CONTAINS SMALL PARTS AND IS NOT SUITABLE FOR CHILDREN
UNDER 36 MONTHS. SMALL PARTS. CHOKING HAZARD.
CHILDREN MUST NOT USE THE EQUIPMENT UNTIL PROPERLY INSTALLED.
REMOVE ALL PACKAGING BEFORE GIVING TO YOUR CHILDREN.
WARNING! ONLY FOR DOMESTIC USE. FOR OUTDOOR USE. ADULT SUPERVISION IS REQUIRED.
WARNING! THIS PRODUCT IS INTENDED FOR USE BY CHILDREN FROM AGES 3 TO 12 YEARS.
WARNING! MAXIMUM COMBINED USER WEIGHT FOR SWING FRAME 200KGS
SINGLE SEAT USER WEIGHT - 60KGS GLIDE RIDE USER WEIGHT - 2 X 35KGS
ANCHORS THAT ARE SUPPLIED WITH THIS PRODUCT MUST BE FITTED BEFORE USE.
WARNING!
Important!
These instructions must be followed
for safe assembly and use.
Please retain for future reference.
Instructions Enclosed
IMPORTANT
This is the UPDATED
Instruction Manual.
Please destroy any
other instructions
included with this
product.
For assembly advice, please view the assembly video for this product on www.smythstoys.com,
email [email protected] or call 01525 722769 (office hours).
TP814 Roundwood Triple Multiplay NEW In0814-D 25.09.17.indd 1 25/09/2017 10:41
TP Triple Round Wood Multiplay
2
TP814 Roundwood Triple Multiplay NEW In0814-D 25.09.17.indd 2 25/09/2017 10:41
TP Triple Round Wood Multiplay
3
INSTRUCTIONS FOR ASSEMBLY, MAINTENANCE AND USE OF TP TOYS -
Please read carefully and keep all enclosed information for future reference.
1. ASSEMBLY AND SAFETY INFORMATION
TP toys must be assembled by an adult. They must be erected exactly in accordance with the assembly instructions. Enlisting
the aid of a helper will make assembly easier. In order to ensure the correct tensions and to ease assembly, it is important to
assemble the product hand tight to begin with. Only when complete, should the fastenings be fully tightened and checked. This
pack may contain small parts and is not suitable for children under 36 months. We recommend that you place small parts on a
tray, or something similar, to prevent the frustration and disappointment of mislaying them. Please take care during assembly as
the manufacturing process can sometimes result in the occasional sharp edge and small pieces of waste metalwork.
Should there be any missing parts, the toy must not be used until replacement parts have been fitted.
2. SITING
Under no circumstances should any of our toys be positioned on a hard surface such as concrete or asphalt, unless the ground
under the toy plus the recommended freespace area is covered with a safety surface. Examples of suitable surfaces are grass,
sand or a play surface intended for this use. TP toys should be sited on level ground.
3. USAGE
TP toys are designed and made for use only by children aged between 36 months and 12 years, unless otherwise stated, and
must not be used by anybody else. Misuse can result in injury. TP tents must not be walked or climbed upon. “Warning only for
Domestic use.” For outdoor use only.
4. SUPERVISION
Children should always be supervised while they are playing on TP toys and should be instructed not to use the toy in an
inappropriate or hazardous manner. We recommend that they do not wear loose-fitting clothing or jewellery that may catch or
snag during play. Children should not wear cycle helmets while playing on TP toys. Whilst using this swing seat children must
have constant adult supervision.
5. WEATHER CONDITIONS
Special care should be taken as weather conditions change. In particular, outdoor toys can become slippery in wet weather and
tongues and lips can stick to metalwork at subzero temperatures. In warmer and sunnier weather, parts can become hot, and
the temperature should be regularly checked during play, especially metal parts and slides. If there is any doubt over safety then
the toys should not be used. If high wind is expected or forecasted, please ensure that the outdoor toys are either moved to a
sheltered position or well secured to the ground or other immoveable object. Please store plastic swing accessories indoors if
temperature falls below 40˚F (4˚C).
6. WATER PLAY
Many surfaces can become slippery during water play. Extra caution and supervision is required when combining water (e.g.
paddling pools, aqua slides etc.) with other forms of outdoor play.
7. MAINTENANCE
With all toys it is vital that the equipment is checked regularly and often by an adult. The complete toy should be checked at
least once a month, and particular attention should be paid to connections and fastenings. If any parts exhibit signs of wear
and tear, they may need to be replaced. Replace defective parts in accordance with the manufacturer’s instructions.” Checks
must be carried out at the beginning of the usage season as well as at regular intervals throughout the usage season. Check all
nuts and bolts for tightness and tighten when required. Failure to do this may result in the product malfunctioning and causing
injury. Children must not be allowed to use the toy until properly installed and checked. Galvanised tubular products may require
occasional maintenance. If surface rust appears it should be removed with either a wire brush or coarse sandpaper, and the area
treated with a non-toxic paint. Changes to the original toy (for example the adding of an accessory) shall be carried out according
to the instructions of the retailer of the original toy.
8. FIRE RISKS AND DISPOSAL
Never allow TP toys to be placed or used near a fire. When it becomes necessary to dispose of your equipment, remove all
bolts and disassemble. Store out of the reach of children until it can be properly disposed of. These instructions are issued in the
interest of child safety, and we do ask you to follow our advice.
9. SWINGING TOYS
When fitting swinging toys it is vital that moving parts have no metal to metal contact. Children should be instructed not to pass
in front of or behind moving items, not to twist or swing an empty swing seat, and not to get off a swinging toy when it is in
motion.
10. ROPES
These ropes will degrade over time. When signs of degradation appear, the toy should be replaced.
TP814 Roundwood Triple Multiplay NEW In0814-D 25.09.17.indd 3 25/09/2017 10:41
4
TP Triple Round Wood Multiplay
KNOW ABOUT ROUND WOOD
l
Round timbers tend to come from younger smaller trees and are complete tree poles,
stripped of any bark and other rough materials but subject to no further processing apart from
the application of a suitable environmentally friendly preservative.
l
As a natural material, every pole is different but they are predominantly heartwood
surrounded by sapwood.
l
Heartwood naturally has many cracks and splits so our round timber frames are dimensioned
and designed to ensure these natural characteristics do not have an impact upon the structural
integrity of the frame. Moreover, these cracks will change over time due to atmospheric
conditions. When wet, the wood will take in water, swell and the cracks will close up. When dry,
the wood contracts and the cracks will open up.
l
As a result of the natural characteristics of such wood products, it is vital that parents check
their play frame regularly so as to identify any splintering or lifting of the surface layers of the
wood or any exposure of rough wood due to changes in cracks and splits. Affected areas must
be rubbed down using coarse sandpaper to restore a smooth, safe surface.
We understand that splits and cracks may appear alarming, however our frames are designed
and dimensioned to ensure that these natural characteristics do not have an impact on the
structural integrity of the frame.
If you are concerned, please do not hesitate to email us at [email protected] with a
photograph of your frame, we’d be happy to check it for you!
TP814 Roundwood Triple Multiplay NEW In0814-D 25.09.17.indd 4 25/09/2017 10:41
5
TP Triple Round Wood Multiplay
Instruction Guide
10 20 30 40 50 60 70 80 90 100 110 120 130 140 150
Read Instructions Before Starting Hidden Lines
Sort Fixings
Sort Parts
Need Help? Visit www.tptoys.com TP Customer Services:
(English Speaking)
5
TP Round Wood Swing Frames
TP802 Double - TP803 Triple Round Wood Swing IN7046-C 02 15.qxp_TP802 Double - TP803 Triple Round Wood Swing IN7046-C 02 15 12/02/2015 11:52 Page 5
Read Instructions Before Starting
Instruction Guide
Sort Parts
Sort Fixings
Assembly Tips - Fixings
Hidden Lines
Bolt Tightening Guide
TP814 Roundwood Triple Multiplay NEW In0814-D 25.09.17.indd 5 25/09/2017 10:41
Stage
x
6
TP Triple Round Wood Multiplay
Triple Roundwood Deck Top bar x1
MW0228 795mm
Stage
1
TP814 Triple Round Wood Multiplay
Contents - Please check
3mm & 5mm
Drill Bits
Step Ladder
Tools - You will need:
Spirit LevelTape MeasureMallet
Combi Drill
Pozi #2
Pozi #3
Screwdriver WrenchSockets
10 & 13mm
Spanner
10 & 13mm
Roundwood Multiplay Deck Boards x14
MW0223 700mm
Roundwood Multiplay Deck Supports x2
MW0226 1550mm
Roundwood Multiplay Deck Cross Beams x3
MW0225 612mm
Multiplay Ladder Rung x4
MW0224 850mm
Roundwood Barrier Board_4 x2
MW0221 825mm
Roundwood Barrier Board_3 x2
MW0220 1015mm
Roundwood Barrier Board_2 x2
MW0219 1210mm
Roundwood Barrier Board_1 x2
MW0218 1400mm
Legs (Deck) x4
MW0222 2668mm
Pack - 2
Triple Roundwood Extension Top bar - section x1
MW0227 2865mm
Legs (Swing Arm) x2
MW0200 2700mm
Pack - 3
Pack - 1
Shovel
Not Supplied
Also
Required:
TP Badge (Pre - installed)
TP814 Roundwood Triple Multiplay NEW In0814-D 25.09.17.indd 6 25/09/2017 10:41
7
TP Triple Round Wood Multiplay
6 x 155mm Woodscrew x6
FA9784
M8 x25mm
Washer
FA8440
x12
M8
Nylon Insert Nut
FA5174
x8
70mm Coachscrew x18
FA8439
4.5 x 40mm Woodscrew x60
FA4517
5 x 60mm Woodscrew x2
FA9768
M8 x 120mm Bolt x4
FA9771
M8 Hook bolt x4
FA9774
5 x 80mm Woodscrew x16
FA4521
Pack - 5Pack - 4
Fixings - SP0076
Swing Seat
FC5220
x2
Stake
PR5069
x4
Glide Ride
Bracket
PR5070
x2
Glider Seat
PM0520
x2
Glider
Foot Rest
PM0519
x2
Glider Downtube Top MT0523 x2
Glider Seat Tubes MT0522 x2
Glider Downtube Bottom MT0521 x2
M8 x 25mm
Bolt
FA8381
x2
Spacer
Bush (Bracket)
PM1989
x4
40mm
Coach screw
FA8380
x4
35mm
40mm
FA2827 Bolt/washer/locknut Set x4
M6 x 40mm
35mm
40mm
FA2828 Bolt/washer/locknut Set x4
M6 x 35mm
35mm
40mm
FA2829 Male/female Bolt Set x2
M8 x 21mm
35mm
40mm
FA2830 Male/female Bolt Set x2
M8 x 73mm
Fixings - SP0078
FA6100
x2
PR9554
x1
PR8163
x1
Plastic Toggle
PM8387
x8
Slide
PM9752
x1
4 x 16mm
Woodscrew
x16
FA4527
FA2826 Bolt/locknut Set x2
M6 x 40mm
35mm
40mm
M8
Nylon Insert Nut
FA5174
x2
Bracket
Roundwood
90 Degrees x2
FB6052
Bracket
Roundwood
Swing Leg x1
FB6051
TP814 Roundwood Triple Multiplay NEW In0814-D 25.09.17.indd 7 25/09/2017 10:41
8
TP Triple Round Wood Multiplay
Stage
2
Stage
3
Bracket Roundwood
90 Degrees x2
FB6052
70mm
Coachscrew
ASSEMBLY
TIP
70mm Coachscrew x4
FA8439
Triple Roundwood Deck Top bar x1
MW0228 795mm
Legs (Deck) x2
MW0222 2668mm
125mm
125mm
30mm
1300mm
120mm
Ensure legs are
assembled this way.
1300mm dimension is
from the ground.
IMPORTANT
ASSEMBLY TIP
1300mm
Drill 5mm
Pilot holes
Do not use screws
until Stage 8.
IMPORTANT ASSEMBLY TIP
TOP is stamped on the wood.
Take the pieces with TOP on them
and insert into the brackets.
IMPORTANT ASSEMBLY TIP
TP814 Roundwood Triple Multiplay NEW In0814-D 25.09.17.indd 8 25/09/2017 10:41
9
TP Triple Round Wood Multiplay
Stage
4
Legs (Deck) x2
MW0222 2668mm
1300mm
1300mm
Ensure legs are
assembled this way.
1300mm dimension is
from the ground.
IMPORTANT
ASSEMBLY TIP
ASSEMBLY
TIP
Do not use screws
until Stage 8.
IMPORTANT ASSEMBLY TIP
TOP is stamped on the wood.
Take the pieces with TOP on them
and insert into the brackets.
IMPORTANT ASSEMBLY TIP
TP814 Roundwood Triple Multiplay NEW In0814-D 25.09.17.indd 9 25/09/2017 10:41
10
TP Triple Round Wood Multiplay
Stage
6
6 x 155mm Woodscrew x6
FA9784
Roundwood Multiplay Deck Cross Beams x3
MW0225 612mm
Roundwood Multiplay Deck Supports x2
MW0226 1550mm
Stage
5
2 People required to
rotate frame into the
upright postion.
IMPORTANT
ASSEMBLY TIP
ASSEMBLY
TIP
MW0225
MW0225
MW0225
x6
60mm
Approx
60mm
Approx
MW0225
Drill 3-5mm
Pilot holes
Drill 3-5mm
Pilot holes
MW0225 Drill 3-5mm pilot
holes in CENTRE of each end.
IMPORTANT
ASSEMBLY TIP
TP814 Roundwood Triple Multiplay NEW In0814-D 25.09.17.indd 10 25/09/2017 10:41
11
TP Triple Round Wood Multiplay
Stage
7
M8 x25mm
Washer
FA8440
x8
M8 x 120mm Bolt x4
FA9771
M8
Nylon Insert Nut
FA5174
x4
Stage
8
70mm Coachscrew x4
FA8439
Drill 5mm
Pilot holes
ASSEMBLY TIP
Step
ladders
required.
Fully tighten these
4 bolts.
IMPORTANT
ASSEMBLY TIP
TP814 Roundwood Triple Multiplay NEW In0814-D 25.09.17.indd 11 25/09/2017 10:41
12
TP Triple Round Wood Multiplay
Stage
9
4.5 x 40mm Woodscrew x28
FA4517
Deckboards - Spacing
Space evenly with a minimum gap of 13mm between boards
Swing Arm End
Roundwood Multiplay Deck Boards x14
MW0223 700mm
13mm
13mm
IMPORTANT
ASSEMBLY TIP
DECKBOARD
COULD OVERHANG
HERE SLIGHTLY
SLIDE END
TP Branding Badge
to face SLIDE END
of Platform
ASSEMBLY TIP
TP814 Roundwood Triple Multiplay NEW In0814-D 25.09.17.indd 12 25/09/2017 10:41
13
TP Triple Round Wood Multiplay
Stage
10
5 x 80mm Woodscrew x16
FA4521
Multiplay ladder Rung x4
MW0224 850mm
236mm
236mm
236mm
310mm
70mm
WARNING
70mm
Branding badge
is on this side.
IMPORTANT
ASSEMBLY TIP
1
1
25mm
Approx
25mm
Approx
Drill 3mm
pilot holes
IMPORTANT
ASSEMBLY TIP
2
x8
1
1
1
1
1
1
1
TP814 Roundwood Triple Multiplay NEW In0814-D 25.09.17.indd 13 25/09/2017 10:41
14
TP Triple Round Wood Multiplay
Stage
11
ASSEMBLY
TIP
4.5 x 40mm Woodscrew x32
FA4517
Roundwood Barrier Board_4 x2
MW0221 825mm
Roundwood Barrier Board_3 x2
MW0220 1015mm
Roundwood Barrier Board_2 x2
MW0219 1210mm
Roundwood Barrier Board_1 x2
MW0218 1400mm
x2
Space evenly
Space evenly
Space evenly
Min
600mm
WARNING
Fit Barrier boards in
this order
IMPORTANT
ASSEMBLY TIP
1
4
3
2
TP814 Roundwood Triple Multiplay NEW In0814-D 25.09.17.indd 14 25/09/2017 10:41
15
TP Triple Round Wood Multiplay
Stage
12
Plastic Toggle
PM8387
x8
4 x 16mm
Woodscrew
x16
FA4527
x8
SLIDE END
IMPORTANT
ASSEMBLY TIP
TP Branding Badge
to face SLIDE END
of Platform
ASSEMBLY TIP
IMPORTANT
ASSEMBLY TIP
TOGGLES MUST BE
ATTACHED AS SHOWN.
THESE ARE TO ELIMINATE
POTENTIAL TRAPS
ie: CLOTHING WITH
STRAPS/TOGGLES.
TP814 Roundwood Triple Multiplay NEW In0814-D 25.09.17.indd 15 25/09/2017 10:41
16
TP Triple Round Wood Multiplay
Stage
14
70mm Coachscrew x2
FA8439
Drill 5mm
Pilot holes
Stage
13
70mm Coachscrew x2
FA8439
Bracket
Roundwood
Swing Leg x1
FB6051
Drill 5mm
Pilot holes
Triple Roundwood Extension Top bar - section x1
MW0227 2865mm
Legs ( Swing Arm) x2
MW0200 2700mm
ASSEMBLY
TIP
Ensure pre-drilled
holes in MW0227
are vertical.
IMPORTANT
ASSEMBLY TIP
30mm
2 holes
must face
downwards
TP814 Roundwood Triple Multiplay NEW In0814-D 25.09.17.indd 16 25/09/2017 10:42
17
TP Triple Round Wood Multiplay
Stage
15
70mm Coachscrew x2
FA8439
Drill 5mm
Pilot holes
ASSEMBLY TIP
Step
ladders
required.
TP814 Roundwood Triple Multiplay NEW In0814-D 25.09.17.indd 17 25/09/2017 10:42
18
TP Triple Round Wood Multiplay
Stage
16
5 x 60mm Woodscrew x2
FA9768
Space
equally
Space
equally
Space
equally
Space
equally
Slide
PM9752
x
Gap
IMPORTANT
ASSEMBLY TIP
ENSURE FIXINGS SCREW
INTO DECKBOARD
AND ALSO
DECK CROSS BEAM
TP814 Roundwood Triple Multiplay NEW In0814-D 25.09.17.indd 18 25/09/2017 10:42
19
TP Triple Round Wood Multiplay
Stage
17
M8 Hook bolt x4
FA9774
M8
Nylon Insert Nut
FA5174
x4
M8 x25mm
Washer
FA8440
x4
Swing Seat
FC5220
x2
Use Mallet to
firmly locate
Hook bolt in
pilot hole
ASSEMBLY TIP
Attach swing seat ‘S’ hook to
M8 Hook bolt before inserting
Hook bolt to top bar (see left).
IMPORTANT
Seat with
‘S’ hook
‘S’ hook
Hook Bolt
M8 Nylon Insert Nut
M8 washer
Glide Ride Swing
Postion
Swing Seat
Postion
Swing Seat
Postion
ASSEMBLY TIP
Step
ladders
required.
TP814 Roundwood Triple Multiplay NEW In0814-D 25.09.17.indd 19 25/09/2017 10:42
20
TP Triple Round Wood Multiplay
Stage
18
350mm
Min
Stage
19
Glider Downtube Bottom x2
MT0521
Glider Seat Tubes x2
MT0522
MT0522
MT0522
MT0521
MT0521
Plastic
washer
Plastic
washer
35mm
40mm
FA2830 Male/female Bolt Set x2
M8 x 73mm
Spring
washer
IMPORTANT
ASSEMBLY TIP
All fixings should only be
done to finger tight during
assembly.
TP814 Roundwood Triple Multiplay NEW In0814-D 25.09.17.indd 20 25/09/2017 10:42
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
/
