Hunter Fan 43006-01 User manual

www.hunterfan.com

Models 30580, 30581, & 30582

Replacement Filter Information

Main Filter

30978

Models

30580, 30581, 30582

ENGLISH

See page 2

FRANÇAIS

Voir page 34

ESPAÑOL

Vea la página 19

43006-01 2

43006-01 3

Table of Contents

Introduction ............................................................................................... 2

Safety Instructions .................................................................................... 3

Description of Air Sterilization System

How the Air Sterilizer Works ................................................................ 4

Air Sterilizer Components ................................................................... 4

Controls and Indicators ....................................................................... 5

Operation

Initial Operation ................................................................................... 6

Air Sterilizer Maintenance

Cleaning Your Air Sterilizer ................................................................. 6

Pre-Filter & Main Filter Information ..................................................... 6

Filter Life Counters .............................................................................. 7

Cleaning the Pre-Filter and Changing the Main Filter ......................... 7

Troubleshooting

Problems and Solutions .................................................................... 12

Obtaining Replacement Main Filters ................................................. 12

Technical Support ............................................................................. 12

Warranty Information .............................................................................. 13

SAFETY INSTRUCTIONS

IMPORTANT!

READ ALL INSTRUCTIONS BEFORE USING THIS Air Sterilizer.

READ AND SAVE ALL INSTRUCTIONS

 1. ThisAirSterilizerisdesignedforuseonaatleveloorandmaynotworkproperly

onanunevenoor.ALWAYSplacetheAirSterilizeronarmleveloor.ALWAYS

place the Air Sterilizer at least six (6) inches away from walls and heat sources such

asstoves,radiators,orheaters.

2. This Air Sterilizer is intended for indoor use only.

3. This Air Sterilizer is not intended for commercial or hospital use.

4. Place the Air Sterilizer in an area that is out of the reach of children.

 5. BeforeusingtheAirSterilizer,extendthecordandinspectforanysignsofdamage.

DO NOT use the product if the cord has been damaged.

6. Thepowercordhasathree-pronggroundedplug,andmustbeusedwithanelectrical

outlet that can accommodate the grounding pin. DO NOT, UNDER ANY CIRCUM-

STANCES, CUT OR REMOVE THE GROUNDING PIN FROM THIS PLUG. DO

NOT use an adaptor if your power outlet can not accommodate the three-prong

grounded plug.

7. Do not use an extension cord with this Air Sterilizer.

8. ALWAYS UNPLUG the Air Sterilizer while it is being cleaned.

9. DO NOTmoveortilttheAirSterilizerwhileitisinoperation.Turnoffandunplug

beforemoving.

10. DO NOT immerse the Air Sterilizer in water at any time because permanent damage

willoccur.ToproperlycleanyourAirSterilizer,followtheinstructionsintheMainte-

nance section of this manual (pg. 6).

Introduction

Congratulations!You’vepurchasedoneofthemostadvancedproductsavailableonthe

markettodaytoimproveindoorairquality.Manypeopledonottakethetimetoconsider

thesafetyoftheairwebreathe.Peopleareconcernedwithhavinghealthyfood,clean

water,andasafecleanhometoprotectthem,butmostoverlooktheairwebreathe.There

isnothingmoreimportanttoourhealththanhavingacontinuoussupplyofcleanair.while

airisessentialtolife,itcanalsocarrygerms,viruses,molds,andpollutants-airborne

pathogens that can do more harm than good. Many people realize that outdoor air can

becomepolluted,buttheEPAhasreportedthatindooraircanbeupto5timesmorepol-

lutedthanoutdoorair.ThatisthereasonHunterdevelopedtheAirSterilizer.

TheHunterAirSterilizercaptures99.97%ofairbornepathogens-germs,viruses,mold,

and mildew - that enter the system. Hunter’s licensed patented technology then kills 99.9%

ofvirtuallyeverythingthathasbeencapturedwithin24hoursofenteringthesystem.

TheHunterAirSterilizerisdesignedtoprovideyourfamilywithyearsoffreshcleanair

that is essentially free of airborne disease-causing pathogens.

To reduce the risk of electric shock, do not per form any servicing

other than that contained in these operating instructions unless

you are qualified to do so.

WARNING - RISK OF ELECTRIC SHOCK

!

This equipment should be inspected frequently and collected dirt

removed from it regularly to prevent excessive accumulation that

could result in flashover or risk of fire.

CAUTION

Description of Air Sterilization System

43006-014

Description of Air Sterilization System

43006-01 5

Fig. 1 - Illustration of the Air Sterilization System

Fig. 2 - Air Sterilizer Components

Fig. 2 - Air Sterilizer Controls and Indicators

Main Filter

Pre-Filter

TopCover

Base Unit

Fan Speed Control Dial Fan Speed Control Dial

(TopCoverRemoved)

Pre-Filter

Reset Button

Main Filter

Reset Button

Fault Indicator

Off

High

Medium

Low

Controls and Indicators

How the Air Sterilizer Works

Front

Back

Air Sterilizer Components

Pre-Filter Patented

Germicidal

Technology

Main Filter

Dust &

Irritants

Pollen &

Allergens

Pet Hair &

Dander

Dirty Air In Clean Air Out

Germs &

Bacteria

Power Indicator

43006-01

Operation

6

Air Sterilizer Maintenance

43006-01 7

Initial Operation

NOTE: The power cord has a three-prong grounded plug, and must be used with

an electrical outlet that can accommodate the grounding pin. DO NOT use an

adaptor if your power outlet can not accommodate the three-prong grounded

plug. DO NOT, UNDER ANY CIRCUMSTANCES, CUT OR REMOVE THE GROUND-

ING PIN FROM THIS PLUG.

 1. RemovetheAirSterilizerfromitsboxandremovetheclearplasticprotectivebag.

Placetheunitonarmleveloor.

2. Make certain the Fan Speed Control Dial is in the Off position.

2. Plug the unit into a standard household electrical outlet.

3. Turn the Fan Speed Control Dial to Medium. (You can select your desired fan speed

afteryouverifyfanoperation.)TheFanshouldbeginoperatingandthePowerLED

should illuminate. Verify fan operation by placing your hand at the top/back of the unit.

Youshouldfeelairmoving.Ifthefandoesnotbeginoperating,gototheTroubleshoot-

ing section on page 12 of this manual.

Cleaning Your Air Sterilizer

NOTES:

• TheAirSterilizermustbeunpluggedduringthecleaningprocess.

• Besuretheunitiscompletelydrybeforeplugginginandusing.

• Neverimmersetheunitinwater.

Proper maintenance of your Hunter Air Sterilizer will help ensure years of trouble free

service.

Follow these steps to properly maintain your Air Sterilizer:

 1. Approximatelyevery90days,theoutsideoftheunitshouldbecleanedwithasoft,

damp cloth.

 2. TodeterminewhenandhowtocleanthePre-FilterandchangetheMainFilter,follow

the instructions beginning in the Pre-Filter and Main Filter Information section of this

manual (pg. 6).

Pre-Filter and Main Filter Information

Tomaintainpropersterilizationperformance,thePre-Filtershouldbecleanedevery1400

hours(approximately3monthsofuse),andtheMainFiltershouldbechangedevery8000

hours(approximately1yearofuse).Ifnecessary,thePre-Filtercanbecleanedmoreoften,

and the Main Filter can be changed more often. Proper maintenance of the Pre-Filter will

help extend the life of the Main Filter. Refer to Obtaining Replacement Filters (pg. 12) if

youneedhelpndingreplacementMainFilters.

Filter Life Counters

WhenthePre-FilterLifeCounterexceeds1400hours,thePre-FilterIndicatorwillash

amber as a reminder that you should clean the Pre-Filter. When the Main Filter Life Coun-

terexceeds8000hours,theMainFilterIndicatorwillashamberasareminderthatyou

should change the Main Filter.

Cleaning the Pre-Filter and Changing the Main Filter

To access the Pre-Filter and the Main Filter:

1. Turn off and unplug the Air Sterilizer.

 2.RemovetheTopCover.PlaceyourngersundertheTopCoverTabsonthe

TopCover’sfrontcorners.SeeFigure4a.LiftthefrontoftheTopCover,then

pull it toward the front of the unit. See Figure 4b.

Pre-Filter Indicator

(Amber,ashing)

Fig.3-Pre-FilterandMainFilterIndicators,TopCoverOn

TopCoverTabs

1

2

Fig.4a-TopCoverTabs

Fig.4b-RemovingtheTopCover

Main Filter Indicator

(Amber,ashing)

Air Sterilizer Maintenance

Fan Speed Control Dial

(TopCoverRemoved)

Pre-Filter

Reset Button

43006-01 8

43006-01 9

NOTES:

• TheAirSterilizermustbeunpluggedduringthecleaningprocess.

• ThePre-FilterwilltintotheunitONLYwhenorientedcorrectly.IfthePre-Filter

does not slide easily into the unit, do not force it. Simply turn the Pre-Filter

around, and reinsert it into the unit.

• TheAirSterilizerwillnotoperateifthePre-Filteriseitheroutoftheunit,oris

not seated correctly in the unit.

To clean the Pre-Filter and reset the Pre-Filter Life Counter:

 1.RemovethePre-Filter.SeeFigure5.NotethePre-Filter’sorientation,asit

mustbereinstalledinthesameorientation.Useavacuumcleanertoclean

the Pre-Filter. Return the Pre-Filter to the unit.

Fig.5-RemovingthePre-Filter

2. Reset the Pre-Filter Life Counter by pressing the Pre-Filter Reset Button. for

5 seconds. See Figure 6.

Fig. 6 - Resetting the Pre-Filter Counter

NOTES:

• TheAirSterilizermustbeunpluggedduringthecleaningprocess.

• TheMainFilterwilltintotheunitONLYwhenpositionedcorrectly.TheMain

FilterhasridgesthattintogroovesintheBase.

• TheAirSterilizerwillnotoperateiftheMainFilteriseitheroutoftheunit,oris

not seated correctly in the unit.

To change the Main Filter and reset the Main Filter Life Counter:

 1.RemovetheusedMainFilter.SeeFigure7.ThrowawaytheusedMainFil-

ter.

Fig.7-RemovingtheMainFilter

2. Install a new Main Filter. Make certain the ridges on the Main Filter line up with

theGroovesintheBase.SeeFigure8.

Grooves

Ridges

Fig. 8 - Main Filter Installation

Cleaning the Pre-Filter and Changing the Main Filter (cont.)

Air Sterilizer Maintenance

43006-01 10

43006-01 11

Fan Speed Control Dial

(TopCoverRemoved)

Main Filter

Reset Button

3. Reset the Main Filter Life Counter by pressing the Main Filter Reset Button.

See Figure 9.

Fig. 9 - Resetting the Main Filter Life Counter

NOTES:

• MakecertainthePre-Filter,theMainFilter,andtheTopCoverareinstalledcor-

rectly.

• TheAirSterilizerwillnotoperateiftheTopCoveriseitheroffoftheunit,

or is not installed correctly on the unit.

ToreturntheAirSterilizertoservice:

 1.ReinstalltheTopCover. PlacetheTabsonthe backoftheTopCoverinto

thecorrespondingholesintheBase.Then,movethefrontoftheTopCover

downward. See Figure 10.

1

2

Fig.10-ReinstallingtheTopCover

2. Plug the unit into a standard household electrical outlet.

3. Turn the Fan Speed Control Dial to Medium. (You can select your desired fan

speedafteryouverifyfanoperation.)TheFanshouldbeginoperatingandthe

Power LED should illuminate. Verify fan operation by placing your hand at

thetop/backoftheunit.Youshouldfeelairmoving.Ifthefandoesnotbegin

operating,gototheTroubleshootingsectiononpage12ofthismanual.

Resetting the Air Sterilizer

InadditiontothePre-FilterandMainFilterIndicators,theAirSterilizerhasaredLED

Fault Indicator. See Figure 11.

ShouldtheFaultIndicatorevercomeon,resettheAirSterilizer.

1. Turn off the Air Sterilizer.

2. Unplug the unit for 5 seconds.

 3.CheckthePre-FilterandtheMainFilterforexcessivedirtaccumulation.(Refer

toCleaningthePre-FilterandChangingtheMainFilter,pg.7)

 3.Plugtheunitin,andturniton.

 4.IftheFaultIndicatorisstillon,contactHunterFanTechnicalSupportat1-888-

830-1326,orcontactusovertheinternetatwww.hunterfan.com.

Fault Indicator

Fig. 11 - Fault Indicator

Cleaning the Pre-Filter and Changing the Main Filter (cont.)

Troubleshooting

43006-01 12

Warranty

43006-01 13

Technical Support

IfyouhaveanyadditionalquestionsorproblemswithyourHunterAirSterilizer,please

call1-888-830-1326,orcontactusovertheInternetatwww.hunterfan.com.

Problem Solutions

Obtaining Replacement Main Filters

ToobtainreplacementMainFiltersforyourAirSterilizer,rstdetermineyourmodel

number by looking at the information label on the back of the Air Sterilizer. The model

numberwillbelistedonthelabel.Then,call1-800-4HUNTERforyournearestretailer

orHunterCustomerServiceat1-888-830-1326(CAN1-866-268-1936).Toensure

youobtainthecorrectlters,pleasendyourmodelnumberbelowthatspeciesthe

correctreplacementlters.

Hunter Air Sterilizer Model No.: .................... 30580,30581,30582

Replacement Main Filter No.: ....................... 30978

1. Unit does not

operate.

4. Unit has reduced air

ow or increased

noise.

5. Fault Indicator is on.

• Conrmthattheunitispluggedin.

• ChecktheinstallationofthePre-Filter,theMain

Filter,andtheTopCover.(Seepgs.8,9,&10.)

• ResettheAirSterilizer.(SeeResettingtheAir

Sterilizer,pg.11.)

• ChecktheinstallationofthePre-Filter,theMain

Filter,andtheTopCover.(Seepgs.8,9,&10.)

• ThePre-Filterand/orMainFilterLifeCounterhas

reached the estimated usage times. Check and

clean the Pre-Filter and/or replace the Main Filter

if needed. (See pgs. 7 - 10.)

• ThePre-Filterand/ortheMainFiltermaybe

excessivelydirty.CheckandcleanthePre-Filter

and/or replace the Main Filter if needed. (See

pgs. 7 - 10.)

• ChecktheinstallationofthePre-Filter,theMain

Filter,andtheTopCover.(Seepgs.8,9,&10.)

• ResettheAirSterilizer.(SeeResettingtheAir

Sterilizer,pg.11.)

• IftheFaultIndicatorremainsonafterresetting

theAirSterilizer,turntheunitoffandcontact

Hunter Technical Support.

• ThePre-Filterand/ortheMainFiltermaybe

excessivelydirty.CheckandcleanthePre-Filter

and/or replace the Main Filter if needed. (See

pgs. 7 - 10.)

2. Unusual noise; pop-

ping, sizzling, etc.

3. Pre-Filter and/or

Main Filter indicator

is on.

Hunter Fan Company

Air Sterilizer

5 YEAR LIMITED WARRANTY

The Hunter Fan Company makes the following limited warranty to the original resi-

dential user or consumer purchaser of the Air Sterilizer:

IfanypartofyourAirSterilizermotororcontrolpanelfailsduringtherstve(5)

yearsfromthedateofinstallationduetoadefectinmaterialorworkmanship,wewill

provideareplacementAirSterilizerfreeofcharge.Installationisdeemedtooccur

at the date of purchase.

IftheAirSterilizercordorTopCoverfailsanytimewithinone(1)yearafterinstallation

duetoadefectinmaterialorworkmanship,wewillreplaceor,atouroption,repair

theunitfreeofchargeatournearestservicecenteroratourTechnicalSupportin

Memphis,Tennessee.Youwillberesponsibleforallpartsandlaborcostsafterthis

one-year period.

IF THE ORIGINAL RESIDENTIAL USER OR CONSUMER PURCHASER CEASES

TOOWNTHEAIRSTERILIZER,THISWARRANTYANDANYIMPLIEDWARRANTY

WHICHTHEN REMAINS IN EFFECT,INCLUDING BUTNOTLIMITEDTOANY

IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR

PURPOSE,AREVOIDED.

NOWARRANTY,EXPRESSEDORIMPLIED,INCLUDINGANYWARRANTYOF

MERCHANTABILITYORFITNESSFORAPARTICULARPURPOSE,ISMADEIN

RESPECT TO THE FILTER MATERIAL.

THISWARRANTYISINLIEUOFALLOTHEREXPRESSWARRANTIES.THEDU-

RATION OF ANY IMPLIED WARRANTY INCLUDING BUT NOT LIMITED TO ANY

IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR

PURPOSE,INRESPECTTOTHEMOTORISEXPRESSLYLIMITEDTOTHEPE-

RIODOFTHEEXPRESSWARRANTYSETFORTHABOVE.

ThiswarrantyisvoidediftheAirSterilizerisnotpurchasedandusedintheUSAor

Canada.

Thiswarrantyexcludesanddoesnotcoverdefects,malfunctionsorfailuresofthe

AirSterilizerwhichwerecausedbyrepairsbypersonsnotauthorizedbyus,useof

partsoraccessoriesnotauthorizedbyus,mishandling,modications,ordamageto

theAirSterilizerwhileinyourpossession,orunreasonableuse,includingfailureto

providereasonableandnecessarymaintenance.ThiswarrantydoesnotcoverAir

Sterilizers used in commercial applications. There are no express or implied warran-

ties as to commercial purchasers or users.

Continued

Warranty

43006-01 14

TolearnmoreaboutHunterFanCompanyproducts,pleaseseeourWebpageat:

www.hunterfan.com

Other Home Comfort Products from Hunter

The Care-Free

Humidier

™

Programmable

Thermostat

®

Hunter Original

®

Fans

HUNTER FAN COMPANY

2500 FRISCO AVENUE

MEMPHIS,TN38114,USA

®

43006-01

Printed in China and Taiwan

M

AM

4

TEMP

Toobtainservice,contacttheHunterFanCompanyServiceDepartment,2500Frisco

Avenue,Memphis,Tennessee38114,1-888-830-1326.Youwillberesponsiblefor

insuranceandfreightorothertransportationtoourfactoryservicecenter.Wewill

return the Air Sterilizer freight prepaid. The Air Sterilizer should be properly packaged

toavoiddamageintransitsincewewillnotberesponsibleforanysuchdamage.

Proofofpurchaseisrequiredwhenrequestingwarrantyservice.Thepurchasermust

present sales receipt or other document that establishes proof of purchase.

INNOEVENTSHALLHUNTERFANCOMPANYBELIABLEFORDIRECT,INDI-

RECT,SPECIALCONSEQUENTIALORINCIDENTALDAMAGESINEXCESSOF

THE PURCHASE PRICE OF THE AIR STERILIZER. YOUR SOLE REMEDY WILL

BE REPAIR OR REPLACEMENT AS PROVIDED ABOVE.

SOME AMERICAN STATES AND CANADIAN PROVINCES DO NOT ALLOW LIM-

ITATIONSONHOWLONGANIMPLIEDWARRANTYLASTS,SOTHEABOVE

LIMITATION MAY NOT APPLY TO YOU.

SOME AMERICAN STATES AND CANADIAN PROVINCES DO NOT ALLOW THE

EXCLUSIONORLIMITATIONOFDIRECT,INDIRECTSPECIAL,INCIDENTAL

ORCONSEQUENTIALDAMAGES,SOTHEABOVELIMITATIONMAYNOTAP-

PLY TO YOU.

SOME AMERICAN STATES AND CANADIAN PROVINCES DO NOT ALLOW THE

EXCLUSIONORLIMITATIONOFEXPRESSORIMPLIEDWARRANTIESIFTHE

USERCEASESTOOWNTHEAIRSTERILIZER,SOTHEABOVELIMITATION

MAY NOT APPLY TO YOU.

THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY ALSO

HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE OR PROVINCE

TO PROVINCE.

Page is loading ...

www.hunterfan.com

Modèles 30580, 30581, & 30582

Information de remplacement de ltre

Filtre principal

30978

Modèles

30580, 30581, 30582

FRANÇAIS

Page is loading ...

Hunter Fan 43006-01 User manual

This manual is also suitable for

Hunter Fan 43006-01 User manual

in other languages

Related papers

Other documents