DUROMAX DS1500 Owner's manual

DS1500 GENERATOR

This manual provides information regarding the operation

and maintenance of these products. We have made every

effort to ensure the accuracy of the information in this

manual. We reserve the right to change this product at

any time without prior notice.

5800 Ontario Mills Pkwy

Ontario, CA 91764 USA

www.duromaxpower.com

Call our Customer Care Team Toll Free 8-5pm PST Mon-Fri

844-DUROMAX

User Manual

REV: DS1500-01242018

CONTENTS

3

1.

Introduction ..................................................................................................................... 6

General Safety Procedures ............................................................................................ 7

Quick Start Guide .......................................................................................................... 10

Generator Components ............................................................................................... 12

Package Contents ......................................................................................................... 14

Introduction

3.

Checking the Oil ............................................................................................................ 20

Check the Gas Level ...................................................................................................... 21

Starting the Generator ................................................................................................. 22

Starting the Generator

2.

Adding Oil ...................................................................................................................... 16

Adding Gasoline ............................................................................................................ 17

Grounding the Generator ............................................................................................ 18

High Altitude Operation ............................................................................................... 18

Generator Setup

4.

AC Usage ........................................................................................................................ 26

Connecting a Load to the Generator .......................................................................... 26

Using the Generator

CONTENTS

4

5.

6.

7.

Maintenance Schedule ................................................................................................. 32

Maintenance Log .......................................................................................................... 33

Checking the Oil ........................................................................................................... 34

Changing the Oil ............................................................................................................ 35

Cleaning the Air Cleaner .............................................................................................. 36

Spark Plug Maintenance .............................................................................................. 38

Storage and Transportation ........................................................................................ 40

Specications ................................................................................................................. 41

......................................................................................................................... 52

Basic Troubleshooting ................................................................................................. 44

Changing / Inspecting the Carbon Brushes .............................................................. 45

Changing / Inspecting the AVR ................................................................................... 46

Maintenance and Care

Warranty

Troubleshooting

8. .................................................................................................. 56

Contact Information

INTRODUCTION

Notice Regarding Emissions

DuroMax has cemented its reputation as one of the markets leading power equipment companies

who are headquartered in the US. All of our products are manufactured to the strictest guidelines

and go through countless testing in all phases of production.

Evolving our strong engine line, DuroMax has complemented its oerings to include Pressure

Washers, Water Pumps, Engines and now oering V-Twin engines. Reliability is the highest

standard we hold ourselves to, whether its powering a heater during a winter storm that knocks

out power, dewatering a ooded property, or washing away a deck for the summer season

Engines that are certied to comply with U.S. EPA emission regulations for SORE (Small o Road

Equipment), are certied to operate on regular unleaded gasoline, and may include the following

emission control systems: (EM) Engine Modications and (TWC) Three-Way Catalyst (if so equipped).

6

STOP

Please do not return

to store.

Durostar representatives are ready to help you

with any questions, concerns, or issues about your

new product. We can guide you through assembly,

start up, and how to operate your new generator.

We want you to be able to put your new generator

to use right away!

CALL US BEFORE YOU CONSIDER

RETURNING THE PRODUCT!

1-844-DUROMAX

TOLL FREE

SAFETY ALERT SYMBOL

DANGER: This generator produces poisonous carbon monoxide gas when running. This

gas is both odorless and colorless. Even if you do not see or smell gas, carbon monoxide

may still be present. Breathing this poison can lead to headaches, dizziness, drowsiness,

and eventually death.

●Use outdoors ONLY in non-conned areas.

●Keep several feet of clearance on all sides to allow proper ventilation of the generator.

WARNING: The exhaust from this product contains chemicals known to the State of

California to cause cancer, birth defects, or other reproductive harm.

WARNING: This generator produces heat when running. Temperatures near exhaust can

exceed 150°F (65°C).

●Do not touch hot surfaces. Pay attention to warning labels on the generator denoting

hot parts of the machine.

●Allow generator to cool several minutes after use before touching engine or areas

which heat during use.

The safety alert symbol is used with one of the safety words (DANGER,

CAUTION, or WARNING) to alert you of hazards. Please pay attention to

these hazard notices both in this manual and on the generator.

GENERAL SAFETY PROCEDURES

7

Please familiarize yourself with the following safety symbols and words:

●DANGER: Indicates a hazard that will result in serious injury or death if instructions are not

followed.

●WARNING: Indicates a strong possibility of causing serious injury or death if instructions are not

followed.

●CAUTION: Indicates a possibility of personal injury or equipment damage if instructions are not

followed.

WARNING: This generator may emit highly ammable and explosive gasoline vapors,

which can cause severe burns or even death. A nearby open ame can lead to an

explosion even if not directly in contact with gas.

●Do not operate near an open ame.

●Do not smoke near generator.

●Always operate on a rm, level surface.

●Always turn generator o before refueling.

●Allow generator to cool for at least 2 minutes before removing fuel cap. Loosen cap

slowly to relieve pressure in tank.

●Do not overll gas tank. Gas may expand during operation. Do not ll to the top of

the tank.

●Always check for spilled gas before operating.

●Empty the gasoline tank before storing or transporting the generator.

●Before transporting, turn fuel valve to the o position and disconnect the spark plug.

WARNING: This generator produces a powerful voltage, which can result in electrocution.

●ALWAYS ground the generator before using it (see the “Grounding the Generator”

portion of the “PREPARlNG THE GENERATOR FOR USE section).

●Generator should only be plugged into electrical devices, either directly or with an

extension cord. NEVER connect to a building electrical system without a qualied

electrician. Such connections must comply with local electrical laws and codes. Failure

to comply can create a backow of power, which may result in serious injury or death

to utility workers.

●Use a ground fault circuit interrupter (GFCI) in highly conductive areas such as metal

decking or steel work. GFCls are available in-line with some extension cords.

●Do not use uncovered in rainy or wet conditions.

●Do not touch bare wires or receptacles (outlets).

●Do not allow children or non-qualied persons to operate.

GENERAL SAFETY PROCEDURES

8

In addition to the above safety notices, please familiarize yourself with the safety and

hazard markings on the generator.

GENERAL SAFETY PROCEDURES

9

Read owner/operator manual before operating generator. Do not operate generator under wet conditions.

electric shock can occur. Connect generator grounding terminal to a good earth ground. Do not touch hot

engine or muffler. Do not connect this generator to any building’s electrical system unless an isolation

switch has been installed by a qualified electrician, electrocution or property damage may occur.

DANGER TO REDUCE THE RISK OF INJURY OR DEATH .

Exhuast outlet and muffler will

become extremely hot. Do Not Touch.

QUICK START GUIDE

10

Add gasoline

The fuel cap is located on top of the fuel tank. Fill the tank

with fresh unleaded gasoline 87 octane or higher. The tank

is full when you see fuel in the bottom of the fuel lter cup.

DO NOT overll the tank.

2.

Add oil

The oil ll cap is located on the lower engine block to the

right of the recoil start housing. Remove the oil ll cap and

ll with 10w30 oil.

1.

Turn gas valve on

The gas valve is located above the recoil start on the

bottom of the fuel tank. Rotate the valve clockwise to the

vertical position to turn on the gas supply.

3.

Close choke

The choke lever is located above the air lter to the right

of the recoil start. Slide the lever to the left to cut the air

supply and allow more gas into the engine to start.

4.

Flip engine switch to ON

The engine switch is located on the left side of the front

power panel. Flip the switch to on.

5.

Pull recoil start

Open choke

Pull the recoil start handle quickly the complete length of the

rope and then let it retract slowly. The unit will generally start

within 3 pulls. CAUTION: DO NOT let go of the handle while

the rope is extended this may cause damage to yourself or

your machine.

The choke lever is located above the air lter to the right

of the recoil start. Slide the lever to the right to open the

choke and increase air into the carburetor for normal

running.

6.

7.

Connect devices

Connect your devices to the receptacles on the front panel.

Start with the largest loads rst.

8.

11

11. Muer

GENERATOR COMPONENTS

12

2. Choke Lever

4. Air Cleaner

1. Volt Meter

10. 110V 3-Prong

Receptacle

9. 5.3A T-Shaped

12v Outlet

8. Ground Terminal

7. Engine Switch

5. Recoil Start

1. Volt Meter - Provides reading of voltage output.

2. Choke Lever - Allows the airow into the carburetor to be restricted to assist in starting the

engine.

3. Fuel Valve - On/O Valve that allows fuel into the engine.

4. Air Cleaner - a removable, cleanable, oiled, sponge-like element that cleans the air going into

the engine.

5. Recoil Start – Easy Pull Recoil Start to start the engine without the electric start.

6. Oil Fill and Dipstick - Use to add or check the oil.

7. Engine Switch – 3 Position Switch to “Start”, “Run”, or turn “O” the generator.

8. Ground Terminal - Connect a ground wire here to properly ground the generator.

9. 5.3 Amp 12V Plug - Use when charging automotive type batteries (charging cord included)

3. Fuel Valve

6. Oil Fill and Dipstick

15. Fuel Cap

14. Fuel Filter Cup

11. Muer

12. Spark Plug

13. Fuel Gauge

10. 110v 3-Prong Receptacle - Use to connect electrical devices that run 110 Volt, 60 Hz, single

phase, AC current (NEMA 5-20).

11. Muer – Reduces engine emissions and reduces noise.

12. Spark plug – Provides ignition to the engine.

13. Fuel Gauge - Indicates the amount of fuel in the gasoline tank.

14. Fuel Filter Cup - Traps dirt and debris in gasoline before it enters the engine.

15. Fuel Cap - Allows access to ll the gasoline tank.

13

PACKAGE CONTENTS

Your generator comes with the items listed below. Please check to see that all of the following

items are included with your generator.

●Note: Actual tools may dier in appearance or design from image shown.

Spark Plug Wrench

DC Charging Cables

Used in spark plug

maintenance, inspection, and

installation.

Used to charge batteries.

14

GENERATOR SETUP

Proper setup of your generator will get you going as soon as possible while making sure you and

your equipment are safe and cared for.

-20 20 40 60 800 100 F

-30-40 -10 0 10 20 30

-20 40 C

30

10W-30

ENVIRONMENTAL TEMPERATURE

5W-30

SAE

GENERATOR SETUP

Add oil

The generator requires engine oil to operate properly. The generator, when new from the package

contains no oil in the crankcase*. You must add the proper amount of oil before operating the

generator for the rst time. This amount is equal to the oil capacity of the engine crankcase:

WARNING: Do not apply engine oils with additives or 2-stroke gasoline engine oils. They don’t

have enough lubrication, and may shorten the engine’s service life.

a. Make sure the generator is on a level surface.

b. Unscrew the oil ller/dipstick cap from the engine .

c. Using a funnel, add the appropriate amount of oil

into the crankcase. You will know the crankcase is

full when the oil level has reached the lower lip of

the opening you have just poured the oil into.

d. Replace oil ller cap.

1.

Step 1 - Adding Oil

Engine oil recommended: SAE 10W-30. Viscosity varies with

regions and temperatures. Choose your oil viscosity using the

chart to the left.

* A small amount of oil from factory testing may be present on

arrival.

Model Number DS1500

Engine Oil Capacity 13.5 . oz (0.4L)

16

WARNING: DO NOT overll the crankcase. This

may damage the motor and shorting overall life

of your generator.

WARNING: Gasoline and gas fumes are highly ammable.

●Do not ll tank near an open ame.

●Do not overll. Always check for fuel spills.

17

Step 2 - Adding Gasoline

Add Gasoline

a. Make sure the generator is on a level surface.

b. Unscrew gas cap and set aside (NOTE: the gas cap

may be tight and hard to unscrew).

c. Slowly add unleaded gasoline to the fuel tank. Be

careful not to overll. Please refer to the chart below

to nd the gas capacity of your generator model.

d. Replace fuel cap and wipe up any spilled gasoline

with a dry cloth.

NOTE: Gas can expand. Do not ll the gas tank

to the very top. Leave a minimum of 1.5 in of open

space.

IMPORTANT:

●Never use an oil/gasoline mixture. Never use old gas.

●Avoid getting dirt or water in the fuel tank.

●Gas can age in the tank and make it hard to start up

the generator in the future.

●Never store generator for extended periods of time

with fuel in the tank.

2.

To ensure that the generator runs smoothly use only FRESH, UNLEADED GAS WITH AN OCTANE

RATING OF 87 OR HIGHER.

Model Number DS1500

Gas Tank Capacity 1.59 US Gallons (6L)

WARNING: DO NOT overll the crankcase. This

may damage the motor and shorting overall life

of your generator.

GENERATOR SETUP (CONTINUED)

Attach grounding wire

a. Ground the generator by tightening the grounding

nut against a grounding wire.

b. Connect the other end to a copper or brass

grounding rod that’s driven into the earth.

A generally acceptable grounding wire is a No. 12 AWG

(American Wire Gauge) stranded copper wire.

Grounding codes can vary by location. Please contact a local

electrician to check the grounding regulations for your area.

1.

Step 3 - Grounding the Generator

WARNING: Failure to properly ground the generator can result in electrocution.

18

High Altitude Operation

At high altitude, the standard carburetor air/fuel mixture will be too rich. Performance will decrease, and

fuel consumption will increase. A very rich mixture will also foul the spark plug and cause hard starting.

Operation at an altitude that diers from that at which this engine was certied, for extended periods of

time, may increase emissions. High altitude performance can be improved by specic modications to the

carburetor. If you always operate your generator at altitudes above 5,000 feet (1,500 meters), have a dealer

perform this carburetor modication. This engine, when operated at high altitude with the carburetor

modications for high altitude use, will meet each emission standard throughout its useful life. Even with

carburetor modication, engine horsepower will decrease about 3.5% for each 1,000-foot (300-meter)

increase in altitude. The eect of altitude on horsepower will be greater than this if no carburetor

modication is made.

When the carburetor has been modied for high altitude operation, the air/fuel mixture will be too lean

for low altitude use. Operation at altitudes below 5,000 feet (1,500 meters) with a modied carburetor may

cause the engine to overheat and result in serious engine damage.

19

STARTING THE GENERATOR

If this is not your rst time using the generator there are still steps you should take to prepare it for

operation each time you use it.

IMPORTANT: At this point you should be familiar with the procedures described in the rst

portion of this section entitled “GENERATOR SETUP” If you have not yet read this section, go

back and read it now.

Step 1 - Check the oil

Check the oil

The generator is equipped with an automatic shuto to

protect it from damage due to low oil. Nonetheless, you

should check the oil level of the engine before each use to

ensure that the engine crankcase has a sucient amount.

To check the oil level:

a. Make sure the generator is on a level surface.

b. Unscrew the oil ller/dipstick cap.

c. With a dry cloth, wipe the oil o of the stick on the

inside of the cap.

d. Insert the dipstick as if you were replacing the

cap and then remove again. There should now be

oil on the stick. If there is no oil on the stick, or oil

only at the very end of the stick, you should add

oil until the engine crankcase is lled (see “Adding

Oil” portion of the “Maintenance” section).

e. Be sure to replace the cap when nished checking

oil.

NOTE: The oil capacity for your generator can be found in

the “Specications” section of this manual.

1.

20

BEFORE YOU START YOUR GENERATOR

Page is loading ...

DUROMAX DS1500 Owner's manual

DUROMAX DS1500 Owner's manual

Related papers

Other documents