Kenmore 146.23770310 Owner's manual

Brand: Kenmore

Model: 146.23770310

Category: Barbecues & grills

Type: Owner's manual

OWNER'S MANUAL

BBQ PRO 4 BURNER GAS GRILL

Product code: 23770 / 0-05307038-9

Item: 146.23770310

UPC code: 182995000903

Date of purchase: / /

If you smell gas:

I. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open lid.

4. If odor continues, keep away from the

appliance and immediately call your gas

supplier or your fire department.

1. Do not store or use gasoline or other

flammable liquids or vapors in the vicinity of

this or any other appliance.

2. An LP cylinder not connected for use shall not

be stored in the vicinity of this or any other

appliance.

Call Grill Service Center For Help And Parts

If you havequestionsor needassistanceduring assembly,

pleasecall 1-888-287-0735.Youwill be speakingtoa

representativeof the grill manufacturer.Toorder new partscall

at 1-800-4-MY-HOME®.

Product Record

IMPORTANT:Fill out the product record information below.

Model Number

Serial Number

Seeratinglabelongrillforserialnumber.

Date Purchased

For residential use only. Do not use for commercial

cooking.

2 o146.23770310

Installation Safety Precautions

• Please readthis User'sManualin its entirety beforeusingthe

grill.

• Failureto follow the providedinstructioncan result in seriously

bodilyinjuryand/orproperty damage.

• Some partsof this grill mayhave sharpedges.Pleasewear

suitable protectivegloves.

• Use grill,as purchased,onlywith LP(propane)gas and the

regulator/valveassembly supplied.

• Grill installationmustconformwith localcodes,or in their

absence of localcodes,with either the National Fuel Gas

Code,ANSI Z223.1/NFPA 54, Natural Gasand Propane

Installation Code,CSA B149.1,or PropaneStorageand

HandlingCode, B149.2, orthe StandardforRecreationa

Vehicles,ANSl A 119.2/NFPA1192,andCSAZ240 RV Serles,

Recreational VehicleCode,as applicable.

• Allelectricalaccessories(such as rotisserie)mustbe

electrically groundedinaccordancewith localcodes,or

NationalElectrical Code,ANSI / NFPA 70or Canadian

ElectricalCode, CSAC22,1,Keep anyelectrical cordsand/or

fuel supply hosesawayfrom any hotsurfaces.

• Thisgrill is safety certifiedfor usein the UnitedStatesand/or

Canadaonly. Donot modifyfor use inany other location.

Modificationwill result ina safety hazard.

IMPORTANT:This grill is intendedforoutdoor useonly and is not

intendedto be installedin or on recreationalvehiclesor boats.

NOTETO INSTALLER: Leavethis User'sManualwith the

customer afterdeliveryand/or installation.

NOTETO CONSUMER:Leavethis User'sManualin a convenient

placefor future reference.

Safety Symbols

The symbolsand boxesshown belowexplainwhat each heading

means. Readand followall of themessagesfound throughout

the manual.

DANGER: Indicates an imminently hazardous situation

which, if not avoided, will result in death or serious injury.

WARNING: Indicates an potentially hazardous situation

which, if not avoided, could result in death or serious injury

CAUTION: Indicates a potentially hazardous situation or

unsafe practice which, if not avoided, may result in minor

or moderate injury.

ForYourSafety•..

GrillServiceCenter•••

ProductRecordInformation...

InstallationSafety Precautions...

SafetySymbols ...

BBQ PRO GrillWarranty•••

Use andCare•••

Parts List•••

Parts Diagram ..

BeforeAssembly•..

Assembly•..

Troubleshooting...

...4-10

...11

..12

•. •13-14

•15-22

•23-25

CALIFORNIA PROPOSITION 65

1. Combustion by-productsproducedwhen using

this productcontainchemicalsknownto the State

of Californiato causecancer, birthdefects,and

other reproductiveharm.

2. Thisproductcontainschemicals,includinglead

and leadcompounds,knowntothe State of

Californiato causecancer, birthdefectsor other

reproductiveharm.

Wash your hands after usinq this product.

BBQ PROGRILL WARRANTY

One Year Full Warranty on BBQ PRO Grill

If thisgrillfails due to a defect inmaterialor workmanship

within oneyear from thedate of purchase,call 1-800-4-MY

HOME®toarrangefor free repair(or replacementif repair

provesimpossible).

COOKINGGRIDSand HEATDIFFUSERS:1yearLIMITED

warranty;doesnotcoverdropping,chipping,scratching,or

surfacedamage.

STAINLESSSTEELPARTS:1yearLIMITEDwarrantyagainst

perforation;doesnotcovercosmeticissueslikesurfacecorrosion,

scratchesand rust.

ALL OTHERPARTS:1yearLIMITEDwarranty(Includes,butnot

limitedto,valves,frame,housing,cart,controlpanel,igniter,

regulator,hoses).Doesnotcoverchipping,scratching,cracking

surfacecorrosion,scratchesor rust.

Limited Warranty on Burners

Forone yearfrom the date of purchase,any burner that

ruststhroughwill be replacedfree of charge.Afterthe first

year from thedate of purchase,youpay for labor ifyou wish

to have itinstalled.

All warranty coverageis void ifthis grill isever usedfor

commercial orrentalpurposes•All warrantycoverage applies

only if this grillis usedin the United States•

This warrantygives you specificlegalrights,and you may

also haveother rightswhich vary fromstate to state•

Kmart Corporation

HoffmanEstates, IL 60179

Installation Service

Forprofessionalinstallationof homeappliances,garage

door openers, water heaters, and other major home items, in

the U.S.A.call 1-800-4-MY-HOME®.

146.23770310 • 3

• NEVERstore a spare LP cylinder underor near the

appliance or in an enclosed area.

• Never fill a cylinder beyond 80%full.

• If the information in the two points above is not

followed exactly, a fire causing death or serious

injury may occur.

• An overfilled or improperly stored cylinder is a

hazard due to possible gas release from the safety

relief valve. This could cause an intense fire with

risk of property damage, serious injury or death.

• If you see, smell or hear gas escaping, immediately

get away from the LP cylinder and appliance and

call your fire department.

LP Tank Removal, Transport And Storage

•Turn OFFall control knobs andLP tank valve. Turncoupling

nutcounterclockwisebyhand only - donot usetools to

disconnect. Lift LPtankwire upwardoff of LP tankcollar, then

lift LPtank up and offof support bracket. Installsafety caponto

LP tankvalve.Alwaysuse capand strap suppliedwith valve.

Failure to use safety cap as directed may result in serious

personal injuryand/or property damage.

LPTankValve_

"\,.'_.J "X_Safety Cap

°_et'ain erStrap

• A disconnected LP tank in storage or being transportedmust

have a safety cap installed (as shown). Do not store an LP

tank in enclosed spaces such as a carport, garage, porch,

covered patio orother building.Never leavean LP tank inside

a vehiclewhich may become overheatedby thesun.

• Donot storean LP tankinan area where childrenplay.

LP Cylinder

• The LPcylinder usedwith your grill mustmeet the

following requirements:

• Use LPcylindersonlywith these requiredmeasurements: 12"

(30.5cm)(diameter)x 18" (45.7cm) (tall)with 20 lb.(9 kg.)

Capacitymaximum.

• LP cylindersmustbe constructedand marked in accordance

with specificationsfor LPcylindersof the U.S. Departmentof

Transportation (DOT)orfor Canada, CAN/CSA-B339,

cylinders, spheresand tubesfor transportationof dangerous

goods. TransportCanada (TC).See LP cylindercollarfor

marking.

• LP cylindervalvemust have:

•Type 1 outlet compatiblewith

regulatoror grill.

•Safetyrelief valve.

•UL listed Overfill Protection

OPDHandWheel

Device(OPD). This OPDsafety

feature isidentified bya uniquetriangular handwheel. Use

only LP cylinders equipped with this type of valve.

• LP cylindermustbearrangedfor vaporwithdrawal and

includecollarto protectLP cylinder valve.Always keepLP

cylinders in uprightposition duringuse,transit or storage.

LP cylinderin uprightpositionfor vaporwithdrawal

LP (Liquefied Petroleum Gas)

• LP gas isnontoxic, odorlessandcolorlesswhen produced. For

Your Safety, LP gas has beengiven anodor (similar torotten

cabbage)so that itcan be smelled.

• LP gas ishighlyflammableand may igniteunexpectedlywhen

mixedwith air.

LP Cylinder Filling

• Use onlylicensed andexperienceddealers.

• LP dealermust purge new cylinder beforefilling.

• DealershouldNEVER fill LPcylinder morethan80% of LP

cylindervolume.Volumeof propanein cylinder willvary by

temperature.

•A frosty regulatorindicatesgasoverfill. Immediatelyclose LP

cylindervalve andcall localLP gas dealerfor assistance.

• Donot releaseliquid propane(LP) gasinto theatmosphere.

This isa hazardouspractice.

• Toremove gasfrom LP cylinder,contact an LPdealer or call a

localfire departmentfor assistance. Checkthetelephone

directoryunder"Gas Companies"for nearest certifiedLP

dealers.

4 • 146.23770310

LP Tank Exchange Connecting Regulator To The LP Tank

• Manyretailers thatsellgrills offer youthe optionof replacing

your emptyLP tank throughan exchangeservice. Use only

those reputableexchange companiesthat inspect,precisionfill,

test and certifytheircylinders. Exchange your tank only for

an OPDsafety feature-equipped tank as described in the

"LP Tank" section of this manual.

•Always keepnewand exchangedLP tanks in uprightposition

during use,transitor storage.

• Leaktest new and exchanged LPtanks BEFORE

connecting to grill.

1. LP tankmust be properlysecured ontogrill. (Referto

assemblysection.)

2. Turnall control knobsto the OFFposition.

3. TurnLP tank OFF byturning OPDhand wheelclockwiseto a

full stop.

4. Removethe protectivecapfrom LP tank valve.Always use

capand strap suppliedwith valve.

LP Tank Leak Test

For your safety

• Leaktest mustbe repeatedeachtime LP tankisexchanged

or refilled.

• Donot smokeduring leaktest.

• Donot usean openflame to checkfor gas leaks.

• Grill mustbe leaktested outdoorsin a well-ventilatedarea,

away fromignitionsourcessuch as gasfired or electrical

appliances. Duringleak test, keepgrill awayfrom open

flamesor sparks.

• Usea cleanpaintbrush anda 50/50 mildsoapand water

solution. Brushsoapysolution onto areasindicated byarrows

infigure below. Leaksare indicatedby growingbubbles.

Safety

OPD Hand Wheel

_e1 outlet with

thread on outside

StrapandCap

Do not inserta POLtransportplug

(plastic part with external threads)

into the type 1 valve outlet. Itwill

defeat the Safety Relief Valve

feature.

ADo not use household cleaning agents. Damageto thegas

train components(valve/hose/reclulator)can result.

5. Holdregulatorand insert nippleinto LP

tank valve. Hand-tightenthecoupling

nut, holdingregulatorin a straight line

with LPtank valve so as notto crossth-

threadthe connection.

Nipple has to be

centeredinto theLPtank

146.23770310 • 5

Hold coupling nut and regulator

as shown for proper connection

to LP tank valve.

Leak Testing Valves, Hose and Regulator

1.Turn all grill control knobs to OFF.

2.Be sureregulatoris tightlyconnectedto LP tank.

3.Completelyopen LP tankvalve by turningOPDhand wheel

counterclockwise.Ifyou hear a rushingsound,turn gasoff

immediately.There isa majorleakat the connection.Correct

before proceeding bycallingfor replacementparts at

1-800-4-MY-HOME®.

4.Brush soapysolutiononto areaswhere bubblesare shown in

picture below:

6.Turn thecoupling nutclockwiseand tighten to a full stop.The

regulatorwill sealon the back-checkfeature inthe LP tank

valve, resulting insomeresistance.An additional one-half

to three-quarters turn isrequired to complete the

connection. Tighten by hand only- do not use tools.

NOTE:

If you cannotcompletethe connection,disconnect regulator

and repeatsteps 5 and6. If you are still unabletocompletethe

connection,do not use this regulator!

Call 1-800-4-MY-HOME®for anidentical replacementpart.

• Do not insert any tool or foreign object into the valve

outlet or safety relief valve. You may damage the valve

and cause a leak. Leaking propane may result in

explosion, fire, severe personal injury, or death.

• Outdoor gas appliance is not intended to be installed

in or on a boat.

• Outdoor gas appliance is not intended to be installed

in or on an RV.

• Never attempt to attach this grill to the self-contained

LP gas system of a camper trailer or motor home.

• Do not use grill until leak-tested.

• If a leak is detected at any time, STOP and call the fire

department.

• If you cannot stop a gas leak, immediately close

LP cylinder valve and call LP gas supplier or your fire

department!

5.If "growing" bubblesappear,there is a leak. Close LPtank

valve immediatelyandretighten connections.If leaks cannot

be stopped do not try to repair. Callfor replacementparts

at 1-800-4-MY-HOME®.

6.Alwaysclose LPtank valve after performingleaktest

by turninghand wheelclockwise.

6 o146.23770310

Safety Tips

• Beforeopening LP cylindervalve,checkthe couplingnutfor

tightness.

• Whengrill is not in use,turnoffall control knobsand LPcylinder

valve.

• Never movegrillwhile inoperationor still hot.

• Use long-handledbarbecueutensilsand oven mitts toavoid burns

and splatters.

• Maximumload for sideshelf is 10 Ibs.

• Thegreasetray must be inserted intogrill and emptiedafter each

use. Do notremove greasetray until grillhascompletelycooled.

• Cleangrill often, preferablyafter eachcookout. Ifa bristle brushis

usedto cleanany ofthe grill cooking surfaces,ensure no loose

bristlesremainon cookingsurfaces prior to grilling.It is not

recommendedto cleancooking surfaceswhile grill is hot.

• If you noticegreaseor other hotmaterial drippingfrom grill

Determinethecause, correctit, thenclean and inspectvalve,

Keep ventilationopeningsin cylinder enclosure(grillcart) free and

clearof debris.

• Do notstore objectsor materialsinsidethegrill cart enclosurethat

wouldblock theflow ofcombustion air to the undersideof either

thecontrol panel orthe firebox bowl.

• Theregulator may makea hummingor whistling noiseduring

operation.This will not affectsafetyor useof grill.

• If you havea grill problemseethe "TroubleshootingSection':

• If the regulatorfrosts, turn offgrill and LP cylindervalve

immediately.This indicatesa problemwith the cylinderand it

shouldnot be usedon any product.

! I

Putting out grease fires by closingthe lid is not possible.

Grills are well ventilatedfor safety reasons.

Do not usewater on a grease fire. Personal injury may

result. Ifa grease fire develops, turn knobs and LP

cylinder off.

Do not leavegrill unattendedwhile preheating or burning

off food residueon HI. Ifgrill has not been regularly

cleaned, a grease fire can occur that maydamage the

product.

IVlainBurner Ignitor Lighting

• Do not lean over grill while lighting.

1. Open lid during lighting.

2. Turn ON valve from source or tank.

3. Pushand turn Ignition Burnercontrol knobto _ HI and

immediatelypress andhold ElectronicIgnition button.

4. If ignitiondoes NOT occurin 5 seconds, turn IgnitionBurner

control knobOFF,wait 5 minutes,and repeatthe lighting

instructions.

5. To LightOtherBurnersturn control knobto HI.

If ignitordoes notwork, follow Match Lighting instructions.

After Lighting:Turn knobsto HI positionfor 5 minutes to

pre-heatgrill.Then turn knobto desiredsettingfor cooking.

146.23770310 • 7

Turn controls and gas source or tank OFFwhen not

in use.

If ignition does NOT occur in 5 seconds, turn the

burner controls OFF, wait 5 minutes and repeat the

lighting procedure. If the burner does not ignite with

The valve open, gas will contiune to flow out of the

burner and could accidently ignite with risk of injury

Match-Lighting

ADo not lean over grill while lighting.

1. Open lid during lighting.

2. Placematch intomatchholder (hangingfrom sideof cart).

Lightmatch, placeinto lightinghole on left side offirebox.

3. Pushin and turn right knobto Hi position.Be sureburner lights

and stay lit.

4. Lightother burnersfollow with steps 3.

Burner Flame Check

• Removecookinggrates and flametamers.Lightburners, rotate

knobsfrom HIGHto LOW.You shouldsee a smallerflamein

LOWpositionthan seen on HIGH. Performburnerflame check

on sideburner,also.Always checkflame priorto each use. If

onlylowflame isseen referto "Suddendropor lowflame" in

the TroubleshootingSection.

Turning Grill Off

•Turnall knobsto OFF position.Turn LP cylinderoff byturning

Ignitor Check

• Turn gas off at LP cylinder. Pressand holdelectronic ignitor

button."Click" shouldbe heard and sparkseen eachtime

betweencollector boxor burnerand electrode.See

"Troubleshooting'if no click orspark.

Valve Check

• Important: Makesure gas is off at LP cylinder before

checking valves. Knobslock in OFF position.Tocheck

valves,first push in knobsand release,knobs shouldspring

back. If knobsdo notspring back,replacevalve assembly

beforeusinggrill. Turn knobsto LOWposition thenturn back to

OFF position.Valves shouldturnsmoothly.

Hose Check

• Beforeeach use, checkto see if hosesare cut orworn.

Replacedamaged hosesbefore usinggrill. Useonly

valve/hose/regulatoras specifiedin the parts listof this Use & Care

Guide.

General Grill Cleaning

•Do notmistake brownor blackaccumulationof greaseand

smokefor paint. Interiorsof gasgrills are not paintedat the

factory (and should never be painted). Apply a strong solution

ofdetergent and wateror use a grill cleanerwith scrubbrush

on insidesofgrill lid andbottom. Rinseand allow tocompletely

air dry. Donot apply a caustic grill/oven cleaner to painted

surfaces.

• Porcelain surfaces: Becauseofglass-like composition,most

residuecan be wipedaway with bakingsoda/water solutionor

speciallyformulatedcleaner. Usenonabrasivescouringpowder

forstubborn stains.

• Painted surfaces: Wash with milddetergentor nonabrasive

cleanerand warm soapywater.Wipedry with a soft

nonabrasivecloth.

• Cooking surfaces: If a bristlebrush is usedto cleanany of

thegrill cooking surfaces,ensure no loosebristlesremainon

cookingsurfaces priorto grilling.It is not recommendedto

cleancooking surfaceswhile grill is hot.

8 • 146.23770310

CAUTION

SPIDER ALERT!

IMPORTANT:Always ensure thatthe venturi burner tubes

are clean.A venturi burner tube has a narrow area in

whichspiders tend to build nests.

If you notice thatyour grill is getting hard to light or that

the flame isn't as strong as it should be,take the time to

checkand clean the venturi's.

Spiders or small insects have been knownto create "flashback"

problems. The spiders spinwebs, build nests and lay eggs inthe

grill's venturi tube(s) obstructing theflow of gas to the burner. The

backed-upgas can ignite inthe venturi behindthe control panel.

This is knownas aflashback and it can damage your grill and even

causeinjury.

Topreventflashbacksandensuregoodperformancetheburnerand

venturiassemblyshouldberemovedfromthegrillandcleaned

Storing Your Grill

•Cleancooking grates.

•Store indrylocation.

•When LPcylinderis connectedtogrill, store outdoors in a

well-ventilatedspace andout of reachofchildren.

•Covergrill if storedoutdoors. Choosefrom a variety ofgrill

covers offeredby manufactureronceavailable.

•Storegrill indoorsONLYif LP cylinder isturned off and

Disconnected,removefrom grillandstored outdoors.

•When removinggrill from storage,follow "Cleaningthe Burner

Assemb/y' instructionsbeforestartinggrill.

Cleaning the Burner Assembly

Followthese instructionsto cleanand/orreplace partsof burner

assembly orif you havetroubleignitinggrill.

1. Turn gas off at control knobs and LP cylinder

2. Removecooking gratesand heatdiffusers.

3. Removecarryovertubes from rearof burners.

4. Removecotter pin fromrear of burners.

5. Carefullylift eachburner up andaway from valve openings.

We suggestthreeways to cleanthe burner tubes.Use theone

easiestfor you.

(A) (Benda stiffwire (a lightweight coat hangerworks well)

intoa small hook.Runthe hookthrougheach burner

tubeseveral times.

(B) Usea narrowbottle brushwith a flexible handle(do not

usea brasswire brush), runthe brushthrougheach

burner tubeseveral times.

(C)Wear eye protection: Use an air hoseto force air into

the burnertube and out theburner ports.Check each

portto make sureair comesouteach hole.

6. Wire brushentireouter surfaceof burner to remove

food residueand dirt.

7. Cleanany blockedports with astiff wire such asan

open paperclip.

8. Checkburnerfor damage,due to normalwear and

corrosion someholesmay become enlarged.If any

large cracksor holes are foundreplaceburner.

VERY IMPORTANT: Burner tubes must reengage

valve openings. See illustrations at hr..

9. Carefullyreplaceburners.

10. Attach burnersto brackets withcotter pins.

11. Repositioncarryovertubes and attach

to burners. Replaceheatdiffusers and

cookinggrates.

146.23770310,9

Indirect Cooking

Poultry andlarge cutsof meat cook slowlyto perfectionon the grill

by indirectheat. Placefood over unlitburner(s); theheat from lit

burnerscirculates gentlythroughout thegrill, cooking meator

poultrywithout thetouch of a directflame.This methodgreatly

reducesflare-ups whencooking extrafatty cuts becausethere is no

direct flameto ignitethefats andjuices that drip duringcooking.

1 Burner Cooking

Cook with direct or indirect heat.

Best for smaller meals or foods

Consumes less fuel.

Indirect Cooking Instructions

• Always cookwith the lid closed.

• Dueto weatherconditions, cookingtimes may vary. During

coldand windy conditionsthe temperaturesetting may

need to beincreasedto insuresufficientcooking

temperature.

• Placefoodover over unlitburner(s).

2Burner Cooking

Great indirect cooking on low.

Produces slow, even heating.

Ideal for slow roasting and baking.

Food Safety

Foodsafety isa very importantpartof enjoyingthe outdoor

cooking experience.To keepfood safe fromharmful bacteria,

follow thesefour basicsteps:

Clean: Wash hands, utensils,andsurfaceswith hotsoapywater

beforeand after handlingraw meatand poultry.

Separate: Separaterawmeatsand poultryfrom ready-to-eat

foods to avoidcrosscontamination.Use a clean platter and

utensilswhen removingcooked foods.

Cook: Cookmeat and poultrythoroughly to killbacteria. Usea

thermometerto ensureproper internalfood temperatures.

Chill: Refrigeratepreparedfoods and leftovers promptly.For

more information call: USDA Meat and Poultry Hotline at

1-800-535-4555(In Washington, DC (202)720-3333,10:00 am

4:00 pm EST).

How To Tell If Meat Is Grilled Thoroughly

• Meat and poultry cooked on a grill often browns very fast

on the outside. Use a meat thermometer to be sure food

has reacheda safe internal temperature, and cut intofood

tocheckfor visual signsof doneness.

• Wholepoultry shouldreach 180° F; breasts, 170° F. Juices

shouldrun clearand flesh should notbe pink.

• Hamburgers made of any ground meat or poultry should

reach 160° F, and be brown in the middle with no pink

juices. Beef, veal and lamb steaks, roasts and chops can

be cookedto 145° F. All cutsof pork shouldreach 160° F.

• NEVER partiallygrillmeator poultry and finishcooking

later. Cookfood completelyto destroyharmful bacteria.

• Whenreheatingtakeoutfoods or fullycooked meats like

hotdogs, grill to 165° F, oruntilsteaminghot.

WARNING: To ensurethat it is safetoeat, food must be cooked

to the minimuminternaltemperatureslisted in the tablebelow.

USDA_Recommended Safe MinimumInternal Temperatures

Beef,Veal,Lamband Pork- WholeCuts** 145° F

Fish 145° F

Beef,Veal,Lamband Pork- Ground 160° F

Egg Dishes 160° F

Turkey, Chicken & Duck - Whole, Pieces & 165°F

Ground

* UnitedStates Departmentof Agriculture

**Allow meatto rest three minutesbeforecarving or consuming.

10 o146.23770310

KEY DESCRIPTION QUANTITY PART NUMBER

1 Warming Rack 1 40800109

2 Cooking Grate 2 408D00110

3 Ignitor Wire, Main Burner 1 50300214

4 Side Shelf 2 408D00040

5 Electronic Ignition Module 1 408D00116

6 Control Panel 1 408D00029

7 Gas Valve, Main Burner 4 40800111

8 Manifold, Main Burner 1 408D00037

9 Bezel, Control Knob 4 40800034

10 Control Knob 4 408D00112

11 Regulator 1 408D00115

12 Right Leg Assembly 1 40800079

13 Wheel 2 40800124

14 Axle Rod Space 2 408D00126

15 Hex Nut 3 110011

16 Cotter Pin 10 110050

17 Axle Washer 3 110018

18 Axle Rod 1 408D00125

19 Bottom Shelf 1 40800089

20 Tank Holder 1 40800130

21 Leg Extender, Front 1 40800D126

22 Leg Extender, Rear 1 40800127

23 Hose Retaining Pin 1 40800134

24 Match Holder Bracket 1 40800129

25 Match Holder 1 40800128

26 Left Leg Assembly 1 40800068

27 Tank Baffle 1 408D00090

28 Front Panel 1 408D00087

29 Back Rail 1 40800085

30 Grease Accumulate Tray 1 40800025

31 Grease Cup 1 40800026

32 Grease Cup Clip 1 40800131

33 Firebox 1 408D00007

34 Lid 1 408D00019

35 Silicone Rubber Bumper 4 40700103

36 Bezel, Temperature Gauge 1 40800105

37 Temperature Gauge 1 40800104

38 Heat Diffuser 4 40800023

39 Flame Carry Over Tube 3 40800022

40 Main Burner 4 40700125

41 Rotate Rod, Lid 2 50300207

No pictured

Hardware pack

Manual

1 408D00176

1 408D00148

If you are missing hardware or have

damaged parts after unpacking grill,

call 1-888-287-0735for replacement.

To order replacement parts after using grill,

call 1-800-4-MY-HOME®

146.23770310 • 11

\\\\

12"146.237703_0

PLEASE READ AND FOLLOW THE INSTRUCTIONS BELOW TO CORRECTLY UNPACK GRILL PARTS

FROM SHIPPING BOX.

Step 1: Open shipping box by slicing down its edges with a box cutter, take out hardware pack, manual,

right leg assembly, bottom shelf from top. Next remove left leg assembly, back brace from front. Remove

all packing materials, take out axle rod, grease cup and grease cup bracket from left Styrofoam, take out

front panel from right Styrofoam.

146.23770310,13

Step 2: Open grill lid, take out the three boxes packed in it. Remove all packing materials, take out the

parts from these boxes.

14 o146.23770310

PLEASE READ AND FOLLOW THEINSTRUCTIONS CAREFULLY STEP BY STEP

Tools Required:

• Adjustable wrench (not provided)

• Screwdriver (not provided)

• 7/16"Combination wrench (not provided)

• The following hardware is provided in blister pack:

Item Description Figure Quantity

M4X10 screw

M6X13 screw

M6 compression washer

AAA Battery

15 pcs

16 pcs

8 pcs

1pc

146.23770310 • 15

D BottomShelfto Legs

[] Placebottomshelf endwithcut out holefor LP cylinder betweenlegswith axle holes.Attach to rightand

left legassemblieswith (6) M4xl0 screws.

[] Tightensecurely.

t,,,,

M4xl0 screw 6 pcs

Leg Assembly

Front

LeftLegAssembly

Axle hole

Rear/

BottomShelf

16 • 146.23770310

Wheels and Leg Extendersto Cart

[] Turnassemblyupsidedown.

[] Attachbottomshelfto fourlegswith (4) M6x13screws.

[] Insertaxle rod throughwheel, axle rod spacer,two right legs, anotheraxle rodspacer and other wheel.

Attachwith (1)Axlewasher,nut and hitchpin.

[] Hammerlegextendersintoleft legs.

M6x13screw 4 pcs

Leg Extender,Front

Leg Extender,Rear

Axle Rod

Axle Rod Spacers

Hitch Pin

Nut

AxleWasher

146.23770310,17

Front Panel

[] Standcart upright.

[] Attachback braceto topof cartwith (4) M4xl0 screws.

[] Attachfront panelto line up withtop of cart with (3) M4xl0 screwsand leavethe bottomhole of left front

leg uninstalled.

[] Attachone side of tank baffleon front panel to the bottomhole of leftfront legwith (1) M4xl0 screw;and

othersideto bottomshelfwith tl) M4xl0 screw.

M4xl0 screw 9 pcs

BackBrace

tank baffle

18 • 146.23770310

H Grill Headto Cart

[] Standcart upright.

[] This steprequirestwo peopleto lift and positiongrillhead ontocart.

[] Carefully lower the grill head onto the cart. Make sure the regulator hose is hangingoutside the cart.

Attachwith (4) MGx13screwsand (4)M6compressionwashers.

M6x13screw 4 pcs

M6compressionwashers 4 pcs

146.23770310 • 19

Left& RightSide Shelf

[] Attachleft shelf tofireboxas follows:

- Frominsideto outsideoffireboxwith (2)M6x13screws and(2) M6compressionwashers.

- Fromoutsideto insideoffireboxwith (2) M6x13screws.

Repeatabovestepfor therightside shelf.

M6x13screw 8 pcs

M6compressionwashers 4 pcs

20 • 146.23770310

Page is loading ...

Kenmore 146.23770310 Owner's manual

Brand: Kenmore

Model: 146.23770310

Category: Barbecues & grills

Type: Owner's manual

Download PDF

report

in other languages

español: Kenmore 146.23770310 El manual del propietario

Kenmore 146.23770310 Owner's manual

Kenmore 146.23770310 Owner's manual

in other languages

Related papers

Other documents