Axxera AXM120 User manual

INSTALLATION/OWNER'S MANUAL

AM/FM Receiver with Detachable Face

MXD105

MXD105 INSTALLATION

TYPICAL FRONT-LOAD

DIN MOUNTING METHOD

REMOVAL KEYS

MOUNTING SLEEVE

INSTALLATION

MOUNTING KIT

OR DASHBOARD

HEAD UNIT

Preparation

Please read entire manual before installation.

Before You Start

•Disconnectnegativebatteryterminal.Consultaqualifiedtechnicianforinstructions.

•Avoidinstallingtheunitwhereitwouldbesubjecttohightemperatures,suchasfrom

directsunlight,orwhereitwouldbesubjecttodust,dirtorexcessivevibration.

Getting Started

•Removetrimringfromunit.

•Remove2transitscrewslocatedontopoftheunit.

•Insertthesuppliedkeysintotheslotsasshown,andslidetheunitoutofthemounting

sleeve.

•Installmountingsleeveintoopening,bendingtabstosecure.

•Connectwiringharnessandantenna.Consultaqualifiedtechnicianifyouareunsure.

•Certaininstallationsmayrequireaninstallationkitand/orwiring

harnessadapter(soldseparately).

•Testforcorrectoperationandslideintomountingsleevetosecure.

•Snaptrimringintoplace.

MXD105 INSTALLATION

Wiring Diagram

Antenna

Connector

10 AMP

AGC Fuse

FUSE

Whenreplacingthefuse,

makesurenewfuseisthe

correcttypeandamperage.

Usinganincorrectfusecould

damagetheradio.

TheMXD105usesone

10ampAGCfuselocated

in-line.

MXD105 OPERATION

Control Locations - Receiver

Preset3/Intro

Preset2/Random

Preset1/Repeat

Display

TuneUp

TuneDown

Band/GoBack

Mode

Mute

Release

Power

Volume Knob

Audio/Menu

USBPort

AuxiliaryInput

Preset6/FolderUp

Preset5/FolderDown

Preset4/Play/Pause

1 2 3 4 5

1 10

2 11

3 12

4 13

5 14

6 15

7 16

8 17

9 18

13 12 11 10 9 8 71617

1415

MXD105 OPERATION

Control Locations - Remote

VolumeDown

TuneDown

Mode

Power

VolumeUp

TuneUp

1 4

2 5

3 6

MXD105 OPERATION

General Operation

Press RELEASEandpullawayfromtheleftsideto

remove.Tore-install,insertrightsideoffaceplatefirst

thenpushleftsidetosecure.

Press or any other button toturntheuniton.Press

againtoturntheunitoff.

Press MODE toselectbetweenAM/FM,USB,SDorauxil-

iaryinputmodes.Modesofoperationareindicatedinthe

display.SDandUSBmodeswillnotappearunlessanSD

CardisinsertedoraUSBdeviceisconnected.

Theradiofrequency(tunermode)orMP3/WMAtitle/track

information(USBandSDmodes)willbeshownbydefault.

Press DISPtodisplaytheclock.Thedefaultdisplaywill

returnafterfiveseconds.

WheninUSBorSDmode,thedisplaywillalternate

betweentracknumber/elapsedtimeandavailableMP3/

WMAinformation,includingfilename,songtitle,artist

name,albumnameandfoldername.

Press RESETuponinitialinstallationorifabnormalopera-

tionoccurs.Resetbuttonislocatedbehindthefrontpanel.

Press DISP todisplaytheclock,thenpressandholdDISP

untilthehourswillflash.Rotatethevolume knobtoadjust

thehours.Pressthevolume knob,andtheminuteswill

flash.Rotatethevolume knobtoadjusttheminutes.

Inserta3.5mmconnectorinthefrontpanelAUXport.

Connecttheotherendofthe3.5mmconnectortothehead-

phoneoutputofanaudiodevice,MP3player,etc.

Adjustvolumeusingthe volume knob(00-40).

Press EQtoselectbetweenthefollowingpresetequaliza-

tioncurves:FLAT,POP,JAZZ,ROCKandOFF.

Note:AbilitytomanuallyadjustBassandTreblesettings

isdisabledwhenapresetequalizationcurveisselected.

SettingequalizationcurvestoOFFenablesmanualBass

andTrebleadjustmentsasoutlinedonpage7.

Faceplate Removal

Power On/Off

Mode

Display

Reset

Set the Clock

Auxiliary Input

Volume

Preset EQ Curves

MXD105 OPERATION

General Operation

Pressthevolume knobtoselectbetweenBass,Treble,

Balance,Fader,Loudness,DistanceandStereo.

Pressthevolume knob until BASappears.

Rotatethevolume knobleft/righttoadjust.

(-7minimum/+7maximum)

Pressthevolume knob until TRE appears.

Rotatethevolume knobleft/righttoadjust.

(-7minimum/+7maximum)

Pressthevolume knob until BALappears.

Rotatethevolume knobleft/righttoadjust.

10L (left)to10R(right)."L=R"representsequalbalance.

Pressthevolume knob until FADappears.

Rotatethevolume knobleft/righttoadjust.

10R(rear)to10F(front)"F=R"representsequalbalance.

Pressthevolume knob until LOUD ON or LOUD OFFappears,

thenrotatethevolume knobtoselectdesiredoption.

Activatingthisfeaturewillenhancethebassandtreblefre-

quencieswhenlisteningtomusicatlowvolumes.

Fromtunermodeonly,pressthevolume knob until DX

or LOCALappears,thenrotatethevolume knobtoselect

desiredoption.SelectingLOCALprogramstheunittostopat

onlystrongstationswhenseektuning.

Fromtunermodeonly,pressthevolume knob until STEREO

or MONOappears,thenrotatethevolume knobtoselect

desiredoption.SelectingMONOcanimprovelisteningin

areaswithaweakFMsignal.

Pressandholdthevolume knobuntilBEEPONorBEEP

OFFappears,thenrotatethe volume knobtoselectdesired

option.Activatingthisfeatureprogramstheunittobeepeach

timecertainbuttonsarepressed.

Fromtunermodeonly,pressandholdthevolume knob

untilBEEPONorBEEPOFFappears.Pressthevolume knob

againtodisplayAREAUSAorAREAEURO,thenrotatethe

volume knobtoselectoptionappropriateforyourlocation.

Theclockwilldisplay12-hourAM/PMtimeinUSAfrequency

spacingmode(PM10.00).InEuropeanfrequencyspacing

mode,theclockwilldisplay24-hourtime(22.00).

Audio / Menu

Bass

Treble

Balance

Fader

Loudness

Distance Tuning

Stereo / Mono

Audible Beep

Area Selection

12/24-Hour Clock

BASS

TREBLE

BALANCE

FADER LOUDNESS

DISTANCE STEREO

MXD105 OPERATION

Seek Tuning

Manual Tuning

Band

Storing and Recalling

Station Presets

Connecting a USB Device

(sold separately)

Inserting an SD Card

(sold separately)

Playing Music

Track Select

Fast Forward and

Reverse

Pause

Displaying Information

Press TUNE

or TUNE

momentarilytoseektothe

nextstrongstation.

PressandholdTUNE

or TUNE

until"MANUAL"

appears,thenpressTUNE

or TUNE

momentarily

tochangeradiofrequencyupordownonestepatatime.

Pressandholdtoadvancequickly.

Press BANDtoselectbetweenFM1,FM2,FM3,AM1and

AM2bands.

Upto18FMstationsand12AMstationscanbestored.To

storeastation,selectthedesiredbandandstation.Press

andholdthedesiredpresetbutton(1-6)formorethan

2seconds.Whenstored,thepresetnumberwillappearin

thedisplay.Thestationcanberecalledanytimebypressing

thecorrespondingpresetbutton.

ToplayMP3/WMAfilesfrommostUSBmassstorage

devices,lineuptheUSBconnectorandinserttheUSB

deviceintotheMXD105'sUSBport.

ToplayMP3/WMA/WAVfilesfromanSDcard,insertanSD

cardintotheSDcardslotwiththelabelfacingleft.Itwill

clickintoplacewhenproperlyinserted.Toremovethecard,

pressinuntilitclicks,thenpulltoremove.

WhenaUSBdeviceisfirstconnected,“LOAD”willappearin

thedisplayandplaybackwillbeginmomentarily.Depending

onthenumberoffilesandfolders,itmaytakeseveral

secondsforthedevicetobeginplaying.IfnovalidMP3/

WMAfilesaredetected,“NOFILE”willbedisplayedandthe

lastmodewillberesumed.

Press TRACK

toskiptothebeginningofthenext

track.PressTRACK

toreturntothebeginningofthe

currenttrack.PressingTRACK

againskipstothe

beginningoftheprevioustrack.

PressandholdTRACK

or TRACK

ontheremote

controltofastforwardorreverseatrack.

Press

totemporarilystopUSBplayback.

Press

againtoresumeplayback.

ID3tagandfile/folderinformationwillbeautomatically

changedduringplayback.PressDISPtoviewtheclock.

Defaultdisplaywillresumeafterfiveseconds.

AM/FM Tuner Operation

USB / SD Card Operation

MXD105 OPERATION

USB / SD Card Operation

PressRPTtochoosebetween:

•CurrentSong-Continuouslyrepeatsselectedtrack.

•CurrentFolder-Continuouslyrepeatsallfilesinfolder.

PressRDMtochoosebetween:

•Off-CancelsRDMfunction.

•AllSongs-Playsalltracksinrandomorder.

•CurrentFolder-Playsalltracksinfolderinrandom

order.

PressINTtoentertheIntromenu,thenturnthevolume

knobtoselectoneofthefollowingoptions:

•Off-CancelstheINTfunction.

•AllSongs-Playsfirst10secondsofeachtrack.

•CurrentFolder-Playsfirst10secondsofeachtrackin

folder.

Maximumcharacterdisplayinformation

•Trackname–64charactermaximum

•Directoryname–64charactermaximum

•*Songtitle–64charactermaximum

•*Artistname–64charactermaximum

•*Albumname–64charactermaximum

*Songtitle,artistnameandalbumnamewillonlybe

displayedifincludedwiththeMP3/WMAfile.

Thefollowingtypesoffilesarecompatible:

•MP3data

•WMAdata

Thefollowingtypesoffilesarenotcompatible:

•WMAfilesthatareprotectedbyDRM(DigitalRights 

 Management).

•WMAlosslessformat

•MP3PROformat

•MP3playlists

•WAVformat

MP3/WMAplaybacksequenceisbasedonorderthefiles

arecopiedtotheUSB/SDdeviceandbeginsintheroot

folder.AnyemptyfoldersorfoldersthatdonotincludeMP3/

WMAfilesareskipped.Dependingonyoursoftware,the

playbackordermayvary.

Repeat

Random

Intro Character Support

Media Compatibility

Playback Order

MXD105 OPERATION

USB / SD Card Operation

•Maximumnumberoffiles:1024

•Maximumnumberoffolders:512

•Maximumnumberoffolderlevels(subfolders):8

Note:Ifthenumberoffiles/foldersexceedsthemaximum

outlinedabove,theadditionalfiles/folderswillbeignored.

Note: Devicesthatexceedthemaximumnumberoffilesor

foldersmaynotfunctionproperly.

DuetothedifferencesofUSBdevices,somedevicesmay

notbecompatible.USBdevicesmustbe‘massstorage

class’andformattedtotheFATorFAT32filesystemin

ordertoensurecompatibility.USBdevicesmustbe32GBor

smallerincapacitytobecompatible.

OnlyMP3fileswithfilenameextension(.mp3)canbeplayed.

OnlyWMAfileswithfilenameextension(.wma)canbe

played.Donotattempttoplaynon-MP3/WMAfileswiththe

MP3/WMAextension.

8kHz~48kHz

8kHz~48kHz

8kbps~320kbpsconstant

Variable bit rates

8kbps~384kbpsconstant

Variable bit rates

Note:Somefilesmaynotplayorbedisplayedcorrectly,

dependingonsamplingratesandbitrates.

ID3tagsVersion1.0to2.0

Note:IfaninvalidID3tagversionisdetected,"NO

SUPPORT"willscrollonthedisplay.

Playback Capacity

USB Device Compatibility

Additional MP3/WMA

Information

Sampling Frequency

Rates

MP3

WMA

Transfer Bit rates

MP3

WMA

MP3 Tag Display

MXD105 INSTALLATION

Troubleshooting

Problem Cause Action

Unit will not turn on

(no power)

Yellowwirenotconnectedorincorrect

voltageRedwirenotconnectedor

incorrectvoltage

Checkconnectionsforproper

voltage(11~16VDC)

Blackwirenotconnected Checkconnectiontoground

Fuseblown Replacefuse

Unit has power

(but no sound)

Speakerwiresnotconnected Checkconnectionsatspeakers

Oneormorespeakerwirestouching

eachotherortouchingchassisground

Insulateallbarespeakerwires

fromeachotherandchassis

ground

Unit blows fuses

Yelloworredwiretouchingchassis

ground

Checkforpinchedwire

Speakerwirestouchingchassisground Checkforpinchedwire

Incorrectfuserating Usefusewithcorrectrating

NO FILE appears

on display

NoplayableMP3/WMAfilesfoundon

thedevice

Checkthedeviceforvalid

MP3/WMAfiles

NO SUPPORT appears

on display

AninvalidID3tagversionispresent

Version1.0to2.0ID3tagsare

supported.

MXD105 OPERATION

Limited One Year Warranty

Thiswarrantygivesyouspecificlegal

rights.Youmayalsohaveotherrights

whichvaryfromstatetostate.

DualElectronicsCorp.warrantsthis

producttotheoriginalpurchasertobefree

fromdefectsinmaterialandworkmanship

foraperiodofoneyearfromthedateof

theoriginalpurchase.

DualElectronicsCorp.agrees,atour

option,duringthewarrantyperiod,

torepairanydefectinmaterialor

workmanshiportofurnishanequal

new,renewedorcomparableproduct

(whicheverisdeemednecessary)in

exchangewithoutcharges,subjectto

verificationofthedefectormalfunctionand

proofofthedateofpurchase.Subsequent

replacementproductsarewarrantedfor

thebalanceoftheoriginalwarrantyperiod.

Who is covered?Thiswarrantyisextended

totheoriginalretailpurchaserforproducts

purchasedfromanauthorizedDualdealer

andusedintheU.S.A.

What is covered?Thiswarrantycoversall

defectsinmaterialandworkmanshipin

thisproduct.Thefollowingarenotcovered:

software,installation/removalcosts,

damageresultingfromaccident,misuse,

abuse,neglect,productmodification,

improperinstallation,incorrectline

voltage,unauthorizedrepairorfailure

tofollowinstructionssuppliedwiththe

product,ordamageoccurringduring

returnshipmentoftheproduct.Specific

licenseconditionsandcopyrightnoticesfor

thesoftwarecanbefoundviawww.dualav.

com.

What to do?

1.Beforeyoucallforservice,checkthe

troubleshootingguideinyourowner’s

manual.Aslightadjustmentofany

customcontrolsmaysaveyouaservice

call.

2.Ifyourequireserviceduringthe

warrantyperiod,youmustcarefully

packtheproduct(preferablyinthe

originalpackage)andshipitbyprepaid

transportationwithacopyoftheoriginal

receiptfromtheretailertoan

authorizedservicecenter.

3.Pleasedescribeyourproblemin

writingandincludeyourname,a

returnUPSshippingaddress(P.O.Box

notacceptable),andadaytimephone

numberwithyourshipment.

4.Formoreinformationandforthe

locationofthenearestauthorized

servicecenterpleasecontactusbyone

ofthefollowingmethods:

•Callustoll-freeat1-866-382-5476

•E-mailusat[email protected]

ExclusionofCertainDamages:This

warrantyisexclusiveandinlieuofany

andallotherwarranties,expressedor

implied,includingwithoutlimitationthe

impliedwarrantiesofmerchantabilityand

fitnessforaparticularpurposeandany

obligation,liability,right,claimorremedy

incontractortort,whetherornotarising

fromthecompany’snegligence,actual

orimputed.Nopersonorrepresentative

isauthorizedtoassumeforthecompany

anyotherliabilityinconnectionwiththe

saleofthisproduct.Innoeventshallthe

companybeliableforindirect,incidentalor

consequentialdamages.

MXD105 OPERATION

FCC Compliance

ThisdevicecomplieswithPart15oftheFCCRules.Operationissubjecttothefollowing

twoconditions:

(1)thisdevicemaynotcauseharmfulinterference,and

(2)thisdevicemustacceptanyinterferencereceived,includinginterferencethatmay

causeundesiredoperation.

Warning:Changesormodificationstothisunitnotexpresslyapprovedbytheparty

responsibleforcompliancecouldvoidtheuser’sauthoritytooperatetheequipment.

Note:ThisequipmenthasbeentestedandfoundtocomplywiththelimitsforaClassB

digitaldevice,pursuanttoPart15oftheFCCRules.Theselimitsaredesignedtoprovide

reasonableprotectionagainstharmfulinterferenceinaresidentialinstallation.This

equipmentgenerates,usesandcanradiateradiofrequencyenergyand,ifnotinstalled

andusedinaccordancewiththeinstructions,maycauseharmfulinterferencetoradio

communications.However,thereisnoguaranteethatinterferencewillnotoccurina

particularinstallation.Ifthisequipmentdoescauseharmfulinterferencetoradioor

televisionreception,whichcanbedeterminedbyturningtheequipmentoffandon,the

userisencouragedtotrytocorrecttheinterferencebyoneormoreofthefollowing

measures:

• Reorientorrelocatethereceivingantenna.

• Increasetheseparationbetweentheequipmentandreceiver.

• Connecttheequipmentintoanoutletonacircuitdifferentfromthattowhichthe

receiverisconnected.

• Consultthedealeroranexperiencedradio/TVtechnicianforhelp.

MXD105 OPERATION

Specifications

Tuningrange: 87.5MHz-107.9MHz

Usablesensitivity: 10dBf

50dBquietingsensitivity: 25dbu

Stereoseparation@1kHz: >30dB

Frequencyresponse: 30Hz-13kHz

Tuningrange:530kHz-1710kHz

Usablesensitivity: <42dBu

Frequencyresponse: 30Hz-2.2kHz

Speakeroutputimpedance: 4~8 ohms

Lineoutputvoltage:2 Volts RMS

Dimensions: 7" x 7" x 2" (178 x 178 x 50 mm)

Designandspecificationssubjecttochangewithoutnotice.

FM Tuner

AM Tuner

General

CEA-2006PowerStandardSpecifications

(reference:14.4VDC+/-0.2V,20Hz~20kHz)

PowerOutput:18WattsRMSx4channelsat4ohmsand<1%THD+N

SignaltoNoiseRatio:70dBA(reference:1wattinto4ohms)

MXD105 OPERATION

Notes

DualElectronicsCorp.

TollFree:1-866-382-5476

9AM-5PMEST,Monday-Friday

www.dualav.com

Othertrademarksandtradenamesarethoseoftheirrespectiveowners.

NSA0314-V01

Axxera AXM120, MCP105, MXD105 User manual

Related papers

Other documents