Swisher LS10528H User manual

Swisher
Brand
Swisher
Model
LS10528H
Category
Log splitters
Type
User manual

This manual is also suitable for

ReadandfollowallSafety
PrecautionsandInstructions
beforeoperatingthis
equipment.
LOG
SPLITTER
OWNER’S
MANUAL
1602CORPORATEDRIVE,WARRENSBURG,MISSOURI64093PHONE660-747-8183
FAX660-747-8650
MODELNO.
LS722H
STARTINGSERIAL#:
L206-010001
LS728H
STARTINGSERIAL#:
L206-010001
LS10528H
STARTINGSERIAL#:
L206-010001
LS12534H
STARTINGSERIAL#:
L206-010001
LS12534H12V
STARTINGSERIAL#:
L206-010001
Manufacturingqualitylawncareequipmentsince1945
Safety
Assembly
Operation
ServiceandAdjustment
RepairParts
MadeInThe
USA
IMPORTANT
swisherinc.com
12489
Rev.06-164
ModelLS12534HShown
2
Intheeventyouhaveaclaimunderthiswarranty,youmustreturntheproducttoanauthorizedservicedealer.
Alltransportationcharges,damage,orlossincurredduringtransportationofpartssubmittedforreplacementor
repairunderthis warrantyshallbe bornebythe purchaser.Should youhaveany questions concerningthis
warranty,pleasecontactustoll-freeat1-800-222-8183.Themodelnumber,serialnumber,dateofpurchase,
andthenameoftheauthorizedSwisherdealerfromwhomyoupurchasedthesplitterwillbeneededbeforeany
warrantyclaimcanbeprocessed.
THIS WARRANTY DOES NOT APPLY TO ANY INCIDENTAL OR CONSEQUENTIAL
DAMAGESANDANYIMPLIEDWARRANTIESARELIMITEDTOTHESAMETIMEPERIODS
STATEDHEREINFORALLEXPRESSEDWARRANTIES.Somestatesdonotallowthelimitationof
consequentialdamagesorlimitationsonhowlonganimpliedwarrantymaylast,sotheabovelimitationsor
exclusionsmaynotapplytoyou.Thiswarrantygivesyouspecificlegalrightsandyoumayhaveotherrights,
whichvaryfromstate-to-state.ThisisalimitedwarrantyasdefinedbytheMagnuson-MossActof1975.
LIMITEDWARRANTY
Themanufacturer’swarrantytotheoriginalconsumerpurchaseris:Thisproductisfreefromdefectsin
materialsandworkmanshipforaperiodoftwo(2)yearfromthe dateofpurchasebytheoriginalconsumer
purchaser.Wewillrepairorreplace,atourdiscretion,partsfoundtobedefectiveduetomaterialsor
workmanship.Thiswarrantyissubjecttothefollowinglimitationsandexclusions:
TABLEOFCONTENTS
WARRANTY………………....….2
SAFETY..……………………….3-4
TOWING..….……..……………..5
OPERATION……………………6-8
MAINTENANCE.…………………….8
DECALS…..………….……………….9
PARTSBREAKDOWN…………….10-13
SPECIFICATIONS..…………………15
1) EngineWarranty Allenginesutilizedonourproductshaveaseparatewarrantyextended
tothembytheindividualenginemanufacturer.Anyengineservice
difficultyistheresponsibilityoftheenginemanufacturerandinno
wayisSwisherMowerCo.,Inc.oritsagentsresponsibleforthe engine
warranty.TheBriggs&StrattonEngineServiceHot-Lineis1-800-
233-3723.TheTecumsehEngineServiceHot-Lineis1-800-558-5402.
2) CommercialUse Thewarrantyperiodforanyproductusedforcommercialorrentalis
limitedtoninety(90)daysfromthedateoforiginalpurchase.
3) Limitation Thiswarrantyappliesonlytoproductswhichhavebeenproperly
assembled,adjusted,andoperatedinaccordancewiththeinstructions
containedwithinthismanual.Thiswarrantydoesnotapplytoany
productofSwisherMowerCo.,Inc.,thathasbeensubjecttoalteration,
misuse,abuse,improperassemblyorinstallation,shippingdamage,or
tonormalwearofproduct.
4) Exclusions Excludedfromthiswarrantyarenormalwear,normaladjustments, and
normalmaintenance.Thepump,valve,andcylindereachcarryseparate
manufacture’swarranties.Thevalveandcylinderbothcarryaone(1)year
limitedwarranty.Thepumpcarriesatwo(2)yearlimitedwarranty.
SAFETYPRECAUTIONS
WARNING:
TheengineexhaustfromthisproductcontainschemicalsknowntothestateofCalifornia
tocausecancer,birthdefectsorotherreproductiveharm.
DANGER:
Yourlogsplitterwasbuilttobeoperatedaccordingtotherulesforsafeoperationinthis
manual.Aswithanytypeofpowerequipment,carelessnessorerroronthepartoftheoperatorcanresult
inseriousinjury.Ifyouviolateanyoftheserules,youmaycauseseriousinjurytoyourselforothers.
• Readandunderstandthemanual.Learntooperatethisequipmentinasafemanner.Familiarize
yourselfwithallofthecontrolsinasafeenvironmentbeforestartingtoworkwiththismachine.
• DONOTunderanycircumstancesalterthislogsplitter.Thisequipmentwasdesignedand
engineeredinaccordancewithoperatinginstructions.Alteringthisequipment,orusingthis
equipmentinsuchawayastocircumventitsdesigncapabilitiesandcapacities,couldresultin
seriousinjuryorfatalityandWILLVOIDTHEWARRANTY.
• AllowONLYresponsibleadultswhohavereadthismanualtooperatethismachine.NEVER
allowchildrentooperatethismachine.
• NEVERoperateorallowsomeonetooperatethisequipmentwhileundertheinfluenceof
alcohol,drugsormedication.Beingcoherentisessentialforsafety.
• ALWAYSuseoutdoorswithadequateventilation.DON’Truntheengineinanenclosedarea.
Exhaustgasescontaincarbonmonoxide.Thisodorlessgascanbedeadlywheninhaled.
• NEVERusesplitterforanyotherpurposethansplittingwood.Anyotherusecanresultin
injury.Yoursplitterisaprecisionpieceofpowerequipment,notatoy.Therefore,exercise
extremecautionatalltimes.
•
ONLYasingleoperatoristoloadandoperatethelogsplitter.KEEPallothers,includingpets
andchildren,aminimumof20feetawayfromyourworkarea.Moreaccidentsoccurwhen
morethanonepersonoperatesthelogsplitterthananyothertime.
• ALWAYSwearprotectivegearsuchassafetygoggles,protectivehearingdevice,steel-toed
shoes,andtight-fittinggloveswithoutdrawstringsorloosecuffs.
• NEVERwearlooseclothingorjewelrythatcanbecaughtbymovingpartsofthesplitterand
pullyouintoit.Keephairawayfrommovingparts.
• NEVERoperateyoursplitteronwet,muddy,oricysurfaces.KEEPworkareacleanofsplit
wood.Safefootingisessentialinpreventingaccidents.
•
ONLYoperatesplitteronlevelgroundwithwheelsblocked,notonthesideofahill.Itcould
tip,orrollinglogs,poorfooting,etc.couldcauseanaccident.
ThisSafetyAlertSymbolindicatesimportantmessagesinthismanual.
Whenyouseethissymbol,carefullyreadthemessagethatfollowsandbe
alerttothepossibilityofpersonalinjury.
Readthismanualcompletely.Thismachinecanamputatehands,feet,andthrowobjects.
Failuretoobservethefollowingsafetyinstructionscouldresultinseriousinjuryordeath.
3
4
•
NEVERoperateyoursplitternearaflameorspark.Hydraulicoilandgasolineareflammableandcan
explode.
• NEVERfillgastankwhiletheengineishotorrunning.Allowtheenginetocoolbeforerefueling.
• Thisunitisequippedwithaninternalcombustionengineandshouldnotbeusedonornearany
unimprovedforest-covered,brush-coveredorgrass-coveredlandunlesstheengine’sexhaustsystemis
equippedwithasparkarrestermeetingapplicablelocalorstatelaws(ifany).Ifasparkarresterisusedit
shouldbemaintainedineffectiveworkingorderbytheoperator.
-NOTE-
InthestateofCalifornia,theaboveisrequiredbylaw(Section442oftheCaliforniaPublicResourcesCode).
Otherstatesmayhavesimilarlaws.Federallawsapplyonfederallands.Asparkarrestermuffler(optionalby
manufacturer)isavailableatyournearestenginedealer.Checklegalrequirementsinyourarea.
• ONLYuseyourhandstooperatethecontrollever.NEVERusefoot,knee,ropeoranyextensiondevice.
• SplitONLYonelogatatime.NEVERattempttosplittwologsontopofeachother.
• NEVERplacehandsorfeetbetweenlogandsplittingwedgeorbetweenlogandramduringforwardor
reversestroke.ALWAYSkeepfingersclearofsplitsthatopeninlogduringsplittingoperation.
• DONOTstraddleorreachacrossthesplittingareawhileoperatingthesplitter.
• DONOTstepoversplitterwhentheengineisrunning.Youmaytriporaccidentallyactivatethesplitting
wedge.Walkaroundtogettotheotherside.
• NEVERattempttoloadsplitterwhilesplittingwedgeisinmotion.Whenloadinglogsplitter,placehands
onthesidesofthelog,nottheends.
• NEVERattempttosplitwoodsacrossthegrain.Woodmayburstorflyoutofyoursplitterandresultin
seriousinjury.
• NEVERleaveyoursplitterunattendedwiththeenginerunning.Shutofftheengineifyouareleaving
yoursplitter,evenforashortperiodoftime.Someonecouldaccidentallyactivatetheramandbeinjured.
• Bothendsofthelogshouldbecutassquarelyaspossibletopreventthelogfromslidingoutofthesplitter
duringoperation.Loglengthshouldbekeptto24”orless.
• NEVERoperateyoursplitterwhileitisattachedtothetowvehicle.
• BEFOREtowing,becertainthatthesplitterissecurelyattachedtothetowingvehicleandthatthesupport
leg,beamandcylinderaresecuredinthererespectivetowingpositions.
• NEVERallowpersonstorideonsplitter.DONOTcarryanycargoorwoodonyoursplitter.Itmayfall
offandcauseanaccident.
• DONOTloosenorremoveanyhydraulicfitting,lineorreservoircapwhileyoursplitterorengineis
running.
• Fluidescapingfromaverysmallholecanalmostbeinvisible.DONOTcheckforleakswithyourhand.
Seemaintenancesectionforinstructions.IFinjuredbyescapingfluid,seeadoctoratonce.Serious
infectionorreactioncandevelopifpropermedicaltreatmentisnotadministeredimmediately.
• DONOToperateyoursplitterinpoormechanicalconditionorwhenitisneedofrepair.
• ALWAYSdisconnectthesparkplugwireandplacethewirewhereitcannotcontactthesparkplug,to
preventaccidentalstartingtheenginewhensettingup,transporting,adjustingorrepairing.
TOWINGSAFETY
• Donotallowpersonstorideonsplitter.Donotcarryanycargoorwoodonyour
splitter.Itmayfalloffandendangervehiclesthatarefollowingyou.
• Besuresupportlegisinthetravelpositionandcouplingsecure.Thismustalso
beretractedsonottointerferewhiletowing.Retractsupportlegbyremoving
pin,pivotingup,andreplacingpin.
• Neverexceed45MPHwhiletowingyoursplitter.Beextracautiouswhen
travelingoverroughterrain,especiallyoverrailroadtracks.
• Alwaysbecarefulwhilebackingyoursplitter.Youcouldjackknifeyourlog
splitterifnotcareful.
• Beforeusingsplitter,disconnectitfromtowvehicle.Alogcouldeasilybe
pushedforwardintothevehicle.
• SeetireandwheelspecificationsforPSIwhiletowing.
• Beawareoftheextralengthofsplitterwhileturning,parking,crossing
intersections,andinalldrivingsituations.
•
OPERATIONINSTRUCTIONS
POSI-LOCKCOUPLER
ADJUSTCOUPLERLOCKINGPRESSUREONBALLBEFOREUSE.PLACEHANDLEINLOCKED
POSITIONWITHBALLINCOUPLER.TIGHTENLOCKNUTAGAINSTTENSIONSPRINGSOTHAT
COUPLERISNOTLOOSEONBALL.CORRECTADJUSTMENTWILLALLOWHANDLETOBE
RELEASEDWITHMODERATEPRESSUREAPPLIEDTOHANDLE.
TOOPEN,PULLUPONCOUPLERHANDLEANDROTATEFORWARD.PLACECOUPLERONBALL
WHENBALLISCOMPLETELYNESTEDINBALLSOCKET,ROTATECOUPLERHANDLE
BACKWARDUNTILHANDLEISINLOCKEDPOSITION.
AFTERTOWINGFOR50MILES,CHECKCOUPLERFORTIGHTNESSONBALL.ALWAYSCHECK
TIGHTNESSBEFORETOWING.BESURECOUPLERHANDLEISINLOCKEDPOSITION.
WARNING:
NEVEREXCEEDWEIGHTCAPACITYANDALWAYSUSESAFETYCHAINS.ALWAYSUSE
CORRECTBALLSIZE,MAKINGSUREBALLISCOMPLETELYINSERTEDINTOCOUPLER.LOCK
COUPLERHANDLESECURELYBEFORETOWING.ALWAYSCHECKFORDAMAGESAND
REPLACEIFDAMAGED.AVOIDSHARPTURNSANDSTEEPVERTICALANGLESWHENTOWING.
5
6
ASSEMBLY
Thislogsplitterhasbeenpartiallyassembledatthefactory.Refertothedrawingsandpartlistsshoulditbecome
necessarytodisassembletheunitforrepairorreplacementofparts.
Inspectallcomponentsfordamage.Ifyoubelieveyouhaveadamagedpartpleasecontactcustomerservice
immediatelyat1-800-222-8183.
WARNING:
Exerciseextremecaution,aspartsareveryheavy.Sufficientpersonsormechanicalhandling
equipmentshouldbeused.
Refertouncratingandassemblyinstructionsforassemblyprocedures.
OPERATION
INTENDEDUSE:
Thislogsplitterisintendedanddesignedtoonlysplitwood.NEVERuseforanyother
purposes.DoingsocancauseinjuryorVOIDTHEWARRANTY.
IMPORTANT:
Thisunitisshippedwithoilbutwithoutgasolineintheengine.Afterassembly,seeseparate
EngineManualforproperfuelandoilrecommendations.
WARNING:
DONOTSTARTORRUNTHELOGSPLITTERWITHOUTOILINTHEENGINEAND
HYDRAULICRESERVOIR.
FILLINGTHEHYDRAULICRESERVOIR
FillthehydraulicreservoirtothetopmarkonthedipstickwithDexron
III/Mercon
IIIautomatictransmission
fluid,a10WAWhydraulicfluidorPro-Mix
AW-32Hydraulicoil.Afterthehydraulicreservoirandtheengine
crankcasearefilledcorrectlywiththeirrespectiveoils,starttheengine.Remembertosetthethrottleandturnon
thefuelshut-offvalve.Thehydraulicpumpshouldprimeitself.Withtheenginerunning,movethehydraulic
valvelevertowardthewedge.Thiswillcausethecylindertoextendandexpelair.Whenthecylinderisfully
extended,retractit.Repeatthisprocedureseveraltimes.(Anerraticmovementofthecylinderandwedgeindicates
thatthereisairinthesystem).Oncethecylinderhasasmoothandconstantspeedindicatingthatallairhasbeen
expelled,shutthesystemoffandrefillthereservoiruntilthefluidisinthesafeoperatingrangeasspecifiedbythe
marksonthedipstick.
STARTUP
WARNING:
DONOTSTARTORRUNTHELOGSPLITTERWITHOUTOILINTHEENGINE
ANDHYDRAULICRESERVOIR.
SeeseparateEngineManualforfuelandoilrecommendations.Ifapplicableyourlogsplitterhascomeequipped
withafuelshut-offvalvefortowingpurposes.
Beforestartingenginemakesurecrankcaseisfilledcorrectlywithoilandtheproperfuelhasbeenused.The
enginewillonlystartwhenthethrottleleverandfuelshut-offvalveifapplicableareturnedtotheirONpositions.
STARTINGINSTRUCTIONS
1. Movethrottlecontrolto“FAST.”
2. SetChoketoonposition(ifapplicable)orpushprimerbulbthree(3)times.NOTE:
Donotuseprimeror
choketorestartawarmengineafterashortshutdown.
3. Graspropehandleandpulloutslowlyuntilresistanceitfelt.Thenpullrapidlywithafullarmstroke.
NOTE:
Ifenginefailstostartafterthree(3)pulls,repeatsteps1and2.
4. WhenEnginestarts,setchoketooffposition(ifapplicable)leavethrottlecontrolat“FAST.”Thethrottle
mustbesetinthefastpositionformaximumperformance.
5. Tostopengine,movethrottleleverto“SLOW”forafewsecondsthento“STOP.”
7
COLDWEATHERSTARTUP
TheColdWeatherClutchenablestheenginetobestartedwithouthavingtopullthroughcold,
thickenedhydraulicfluid.Simplypullthehandleoutintolockedposition.Startengine,letitwarmup,
andreleaseColdWeatherClutch.Afterstarting,assurethattheleverhasreengaged.
SPLITTEROPERATION
1. Setupthelogsplitterinaclear,levelareaandblockthewheels.Thesuctionportonthetankshould
alwaysbeonthelowersideofthelogsplitter.
2. Placealogonthebeam,againstthefootplate.Makesurethelogissecurelyonthefootplateandup
againstthebeam.
3. Depressthevalveleversothatthecylinderwilldrivethepushblockintothelog.Extendthecylinder
untilthelogsplitsortotheendofitsstroke.Iftheloghasnotcompletelysplitafterthecylinderhas
reachedtheendofitsextension,retractthecylinder.NOTE:
Leavingthevalveinthe“actuate”position
attheendofthestrokemaydamagethepump.Alwaysuseextracarewhensplittinglogswithendsthat
arenotsquare.
NOTE:
Toextendthelifeofthehydrauliccylinder,avoid“BOTTOMINGOUT”thecylinder.
TOWINGSAFETY
Thisunitshouldnotbetowedonanystreet,highway,orpublicroadwithoutcheckingtheexistingfederal,local,
andstatelaws.Anylicensingormodificationssuchastaillights,etc.,needtocomplywithexistingfederal,local,
orstatevehiclerequirementsisthesoleresponsibilityofthepurchaser.Obeyallregulationswhentowingon
publicroadsandhighways.Seealso
SAFETYPERCAUTIONS.
Turnthefuelshut-offvalveifapplicableOFFtopreventfloodingoftheenginewhiletraveling.
Becarefulwhenbackingup.Youcaneasilyjack-knifeyoursplitter.
TOWINGATNIGHT
TherequirementsfortaillightsarebasedonStatesregulations.Somestatesallowtowingatnightas
longasthetowedequipmentdoesnotvisiblyimpairthetowvehicletaillights.Thisisbasedonastate,
tostaterequirements.Thecustomerisresponsibleformeetingthestatesrequirements.
Ifa“StatementofOrigin”isrequiredinyourstate,seeyourlocaldealertoreceiveone.
HYDRAULICSAFETY
Thehydraulicsystemonyoursplitterrequirescarefulinspectionalongwiththemechanicalparts.Besureto
replaceanyfrayed,kinked,crackedorotherwisedamagedhydrauliccomponents.Justbecauseitisn’tleaking
todaydoesn’tmeanthatitwillnotfailtomorrow.
Fluidescapingfromaverysmallholecanalmostbeinvisible.Donotcheckforleakswithyourhand.Escaping
fluidunderpressurecanhavesufficientforcetopenetrateskincausingseriouspersonalinjuryorevendeath.
Leakscanbedetectedbypassingapieceofcardboardorwoodoverthesuspectedleakandlookingfor
discoloration.
IFinjuredbyescapingfluid,seeadoctoratonce.Seriousinfectionorreactioncandevelopif
propermedicaltreatmentisnotadministeredimmediately.
Shoulditbecomenecessarytoloosenorremoveanyhydraulicfittings,linesorreservoircap,besuretorelieveall
pressurebyshuttingoftheengineandmovingthecontrolhandlebackandforthseveraltimes.
couldresultinseriousinjury.Seealso
SAFETYPERCAUTIONS.
Thepressurereliefvalveonyoursplitterispresetatthefactory.DONOTadjustthevalve.Onlyaqualified
technicianshouldperformthisadjustment.
8
MAINTENANCEANDSTORAGE
WARNING:

DISCONNECTTHESPARKPLUGBEFOREPERFORMINGANYMAINTENANCE.
Consulttheoperatingandmaintenanceinstructionsoftheenginemanufacturerforenginecare.
Alwayschecktheoillevelofthehydraulicreservoirbeforeoperation.Operatingwithoutanadequateoil
supplywillcauseseveredamagetothepump.Changethehydraulicfluidinthereservoirafterevery100hoursof
operation.Changethehydraulicfilterafterevery50hoursofoperation(useonlya10micronhydraulicfilter).
Periodicallycheckthatallnuts,bolts,screws,clampsandfittingsaretightandsecure.
Tokeepyoursplitterintopworkingconditionperformallrecommendedmaintenanceproceduresbeforeyouuse
yoursplitter.
Ifthewedgebecomesdullornickedagrinderorsharpeningtoolcanbeusedtosharpenit.
Completelydrainthefueltankpriortostorage.Alwaysstoregasolineinanapproved,tightlysealedcontainer.Store
containerinadry,coolplacewithadequateventilation.Keepfuelawayfromareaswherefumescouldcontactopen
flame,pilotlightorsparks.
Beawareoftheenvironmentwhendisposingofusedpetroleumproducts.Pleasedisposeofusedhydraulic
fluid,engineoilandanybyproductsfromthemaintenanceofyoursplitteratapprovedrecyclingcenters.
Shoulditbecomenecessarytodisassembletheunitforrepairorreplacementofparts,refertothedrawingsandparts
listonthefollowingpages.Exerciseextremecaution,assomepartsareveryheavyandwillrequiresufficient
personsormechanicalhandlingequipment.
YourSwisherLogSplitterhasbeenproducedwithcomponentsdesignedspecificallytothismachine.Although
standardsprings,hardwareandectmaylooksimilartopartsusedonothermachinery,theymayinsomecases
bemadeofadifferentconstructionand/ormaterials.Allreplacementpartsmustmeetmanufacturer’s
specifications.
Theoperationofanysplittercanproduceforeignobjectstobethrownintothe
eyes,resultinginsevereeyedamage.Alwayswearcertifiedsafetyglassesor
wide-visionsafetygogglesoverspectaclesbeforestaringanysplittingmachine
andwhileoperatingsuchamachine.
Theoperationofanysplitterproducessoundwavesthataredamagingtothe
humanear.Earprotectionisrecommended.
12494– HYDRAULICFILLPLUG
DECAL
11427– DANGERDECAL
12492– OPERATORINSTRUCTION
DECAL
OD16– FUELSHUTOFFDECAL 12493– COLDWEATHERDECAL
SAFETYDECALS
Replacedecalsimmediatelyifdamaged.
9
12549– DONOTEXCEED45MPH
DECAL
12532– HYDRAULICOILDECAL
10
ASSEMBLYDETAIL
LS7522H,LS728H,LS10528H&LS12534BMODELS
A
A
A
A
B
B
11
SERVICEPARTS
PleasehaveModelandSerialNumbersreadywhenorderingparts.
Colorcannotbeguaranteeduponserviceparts.
ITEMNUMBER DESCRIPTION PARTNUMBER
1 MotorBase/HydraulicTank 12350TK
2 36"SuctionHose 12362
3 #12HoseClamp LS5001
4 FilterHead LS1112
5 FilterElement LS1113
6 ReturnLineFitting 7329
7 BreatherCap 12379
8 BearingSeal 2203S
9 TaperedBearing 2203B
10 Tire&Wheel 7296
11 Washer3/4IDX11/4OD10GA NB184
12 CastleNut 2203CN
13 CotterPin NB633
14 WheelDustCover 2203DC
15 HighPressureHose48" 7289
16 Bolt3/8-16X11/2GR5 NB107
17 Washer3/8SAE NB272
18 IdlerBushing 6037
19 IdlerSpacer 6040
20 Nut3/8-16Nyloc NB182
21 Bolt3/8-16X21/2GR5 NB619
22 IdlerArm 6041TK
23 IdlerPulley B527
24 Nut3/8-162-WayLock NB280
25 ClutchLever 11226TK
26 ClutchLeverCap 2077
27 WireLinkForIdlerArm BRS6H
28 IdlerTensionSpring-BentLeg 4422
29 BoltSpade5/16-18X12 10636
30 Nut5/16-18Nyloc NB181
31 ReturnHose72" 12363
32 #16HoseClamp LS4999
NotShown Grommet 12441
NotShown 44"Belt 644
ITEM# DESCRIPTION PART#
HydraulicPump-ModelLS722H&LS728H 12360
HydraulicPump-ModelLS10528H,LS12534H&
LS12534H12V LS2002B
2
3 #16HoseClamp LS4999
4 36"SuctionHose 12362
5 PumpPulley 7306
6 1/8X1/2#3WoodruffKey 024002
7 5/16-18X1/2SetScreww/Loctite NB312
8 Bolt5/16-18X3/4Serr.Flange NB596
9 Nut5/16-18Serr.Flange NB170
1
PUMPDETAIL
ALLMODELS
Note:Installpulleycollarupandbottomside
ofpulleyflushwithendofpumpshaft.
B
B
12
ITEMNUMBER DESCRIPTION PARTNUMBER
BeamWeldment-ModelLS722H,LS728H&LS10528H 12465TC
BeamWeldment-ModelLS12534H&LS12534H12V 12399TC
2 WedgeWeldment 7233TK
3 ThickGIBPlate 7237TK
4 ThinGIBPlate(LS12534H&LS12534H12VOnly) 7388TK
5 BottomGIBPlate 7333TK
6 1/2-13X21/2GR5CarriageBolt NB643
7 1/2LockWasher NB508
8 1/2-13Nut NB213Z
9 1/2-13X31/2GR5ZP NB577
10 Washer TR150W
11 Nut1/2-13NylocJam NB121
RamCylinder-ModelLS722H 7284TK
RamCylinder-ModelLS728H&LS10528H 7354TK
RamCylinder-ModelLS12534H&LS12534H12V 7355TK
13 SteelPin 7293
14 ClipPin NB642
15 HydraulicFitting 7291
16 StationaryLineAssembly 7288TK
17 2-WayPipeNipple 7292
18 ReturnLineFitting 7329
19 ValveControl 7287TK
20 ValveInletFitting 7387
21 ValveControlHandle 7423
22 HandleGrip 7425
23 MasterChainLink 7424
1
12
BEAMDETAIL- ALLMODELS
NOTALLPARTSAREONALLMODELS
BeamWeldment12399TCShown
13
TONGUEDETAIL
ALLMODELS
ITEMNUMBER DESCRIPTION PARTNUMBER
1 TongueWeldment 12353TK
2 2"BallCoupler 7365
3 FoldingSupportLeg 11494TK
4 SafetyChainw/Hook 7366
5 Bolt3/8-16X4GR5 NB645
6 Bolt3/8-16X31/2GR5 NB649
7 Bolt3/8-16X3GR5 NB150
8 LatchPinGuideBushing 7840Z
9 WasherFender3/8 10177
10 WasherSAE3/8 NB272
11 Nut3/8-16Nyloc NB182
12 1/2X3BentPinw/HairPin NB606
13 1/2BentLockingPin 12345
14 CompressionSpring 12364
15 CotterPin1/8X1 NB126
14
ENGINEDETAIL
MODELLS722H&LS728H
ITEM# DESCRIPTION PART#
1 Engine N/A
2 Bolt5/16-18X11/4Serr.Flange NB253
3 Bolt5/16-18X21/4Serr.Flange NB622
4 Nut5/16-18Serr.Flange NB170
5 3/16X1Keystock 9030
6 EnginePulley7/8"ID 7323
7 5/16-18X1/2SetScreww/Loctite NB312
8 WasherBelleville 699
9 Bolt3/8-24X1w/Loctite NB238N
NOTSHOWN FuelShutOffValve(Inline) 7414
NOTSHOWN FuelLineClamp 6FLC
1
2
3
6
5
4
7
9
10
ENGINEDETAIL
MODELLS10528H&LS12534H
8
Note:Installpulleycollarupandbottomside
ofpulleyflushwithendofengineshaft.
ITEM# DESCRIPTION PART#
1 Engine N/A
Bolt5/16-18X11/4Serr.Flange NB253
Bolt5/16-18X13/4Serr.Flange(OnePer-12VoltEngines)
NB515
3 Nut5/16-18Serr.Flange NB170
4 UpperSpacer 689S
5 EnginePulley BB105
6 LowerSpacer 689L
7 Washer TR150W
8 WasherBelleville 699
9 Bolt7/16-20X1GR5w/Loctite NB452N
10 1/4X1Keystock 9031
NOTSHOWN FuelShutOffValve(Inline) 7414
NOTSHOWN FuelLineClamp 6FLC
2
15
12VoltAccessories
WiringDiagram
1
2
3
BATTERY
4
6
7
5
8
9
ITEM# DESCRIPTION PART#
1 Throttle&KeySwitchBracket 12491TK
2 ThrottleCable 686N
3 ThrottleKnob 686K
4 BatteryHoldDownStrap 12498TK
5 Nut3/8-16Nyloc NB181
6 Bolt3/8-16X7 NB732
7 SolenoidBracket 9913TK
8 Bolt5/16-18X3/4 NB143
NOTSHOWN Nut5/16-18SerrFlange NB170
9 Bolt1/4-20SerrFlange NB109
NOTSHOWN Nut1/4-20SerrFlange NB524
10 KeySwitch 3623
NOTSHOWN WiringHarness 12551
NOTSHOWN SolenoidAssembly 10806
NOTSHOWN NutM6-1.0 NB600
10
16
IdlerPulley
PumpPulley
EnginePulley
BELTROUTINGDIAGRAM
(VIEWEDFROMUNDERSIDEOFSPLITTER)
Problem Cause Remedy
Enginefailstostart. 1.Sparkplugwiredisconnected. 1.Connectwiretosparkplug.
2.Fueltanknotfullenoughorstalefuel. 2.Filltankfullwithclean,freshgasoline.
3.Throttlecontrollevernotincorrect
startingposition.
3.MovethrottlelevertoFASTposition.
4.ChokenotinCHOKEposition. 4.MovechoketoCHOKEposition.
5.Enginenotprimedproperly. 5.Primeengine.
6.FuelvalvenotONorblockedfuelline. 6.Turnonfuelvalveorcleanfuelline.
7.Faultysparkplug. 7.Clean,adjustgap,orreplacesparkplug.
Engineishardtostartor
runserratic.
1.Sparkplugwireloose. 1.Connectandtightensparkplugwire.
2.UnitrunningonCHOKE. 2.MovechokelevertoOFFposition.
3.Blockedfuellineorstalefuel. 3.Cleanfuelline;filltankwithclean,fresh
gasoline
4.Waterordirtinfuelsystem. 4.Drainfueltank.Refillwithfreshgasoline.
5.Dirtyaircleaner. 5.Cleanorreplaceaircleaner.
6.Carburetoroutofadjustment. 6.Seeauthorizedservicecenter.
Cylinderrodwillnotextend
orcontract. 1.Coldweatherclutchnotengaged. 1.Engagecoldweatherclutch.
2.Brokenorimproperlyinstalledbelt. 2.Replaceorreinstallbelt.
3.Lowhydraulicfluid. 3.Fillhydraulictanktocorrectfluidlevel.
4.Hydrauliclinesblocked. 4.Flushandcleanhydrualicsystem.*
5.Damagedorbrokenpump. 5.Seeauthorizedservicecenter.
6.Damagedcontrolvalve. 6.Seeauthorizedservicecenter.
Cylinderrodisslowor
erraticwhileextendingand
contracting.
1.Lowhydraulicfluid. 1.Fillhydraulictanktocorrectfluidlevel.
2.Contaminatedhydraulicfluid. 2.Drainfluid,flushsystem,andrefill.
3.Excessivepumpinletvacuum. 3.Makecertainpumphosesareclearand
unblocked.Makecertainhoseinnot
collapsingundersuction.
4.Damagedpump. 4.Seeauthorizedservicecenter.
5.Damagedcontrolvalve. 5.Seeauthorizedservicecenter.
6.Internalcylinderdamage. 6.Seeauthorizedservicecenter.
TROUBLESHOOTING
17
Problem Cause Remedy
LeakingCylinder 1.Brokenseals. 1.Seeauthorizedservicecenter.
2.Scoredcylinder. 2.Seeauthorizedservicecenter.
12VoltUnits
Enginewillnotturnover 1.Weakordeadbattery. 1.Rechargeorreplacebattery.
2.Blownfuse. 2.Replacefuse.
3.Corrodedbatteryterminals. 3.Cleanbatteryterminals.
4.Looseordamagedwiring. 4.Checkallwiring.
5.Faultyignitionswitch. 5.Check/replaceignitionswitch.
6.Faultysolenoid. 6.Check/replacesolenoid
Engineclicksbutwill
notstart 1.Weakordeadbattery. 1.Rechargeorreplacebattery.
2.Corrodedbatteryterminals. 2.Cleanbatteryterminals.
3.Looseordamagedwiring. 3.Checkallwiring.
4.Faultysolenoid. 4.Check/replacesolenoid.
Batterywillnotcharge 1.Badbattery. 1.Replacebattery.
2.Corrodedbatteryterminals. 2.Cleanbatteryterminals.
3.Faultysolenoid. 3.Check/replacesolenoid.
4.Badalternator. 4.Seeauthorizedservicecenter.
TROUBLESHOOTINGCONTINUED
NOTE:Forrepairsbeyondthoselistedhere,contactyournearestauthorizedservicecenter.
*Flushingthereservoirtankandhoseswithkerosenewheneverserviceisperformedonthetank,hydraulicpumpor
valveisrecommended.Contactanauthorizedservicecenter.
MAINTENANCELOG
Notes
DateofService ServicePerformed
19
LS722H LS728H LS10528H LS12534H&LS12534H12V
SplittingForce
22Tons 28Tons 28Tons 34Tons
Engine
6.5HPBriggsand
StrattonQuantum
7HPBriggsandStratton
INTEK
10.5HPBriggsand
StrattonI/C
12.5HPBriggsandStrattonI/C12
voltStart
SplittingPositions
HorizontalandVertical HorizontalandVertical HorizontalandVertical HorizontalandVertical
CylinderSize
4"X24" 41/2"X24" 41/2"X24" 5"X24"
Pump
2StagewithHeavyDuty
Bearings
2StagewithHeavyDuty
Bearings
2StagewithHeavyDuty
Bearings
2StagewithHeavyDutyBearings
PumpSpecs
11Gallons PerMinute 11GallonsPerMinute 16GallonsPerMinute 16GallonsPerMinute
Valve
AutoReturn AutoReturn AutoReturn AutoReturn
DriveSystem
BeltDrive1:1Ratiowith
ClutchforEasyStarting
BeltDrive1:1Ratiowith
ClutchforEasyStarting
BeltDrive1:1Ratiowith
ClutchforEasyStarting
BeltDrive1:1RatiowithClutchfor
EasyStarting
HydraulicSystemFluid
Capacity
18-22Quarts 19-23Quarts 19-23Quarts 20-24Quarts
MaximumLoglength
251/2" 251/2" 251/2" 251/2"
TireSpecs
4.00X4.80X8withHigh
SpeedBearings
4.00X4.80X8withHigh
SpeedBearings
4.00X4.80X8withHigh
SpeedBearings
4.00X4.80X8withHighSpeed
Bearings
MetalFenders
No No No No
BallHitch
2"Ball 2"Ball 2"Ball 2"Ball
UnitWeight
525Lbs 540Lbs 640Lbs 660Lbs
Models
SPECIFICATIONS
NOTES
:
18
SWISHERHISTORY
BackbeforeelectricitycametoruralMissouriMaxSwisherwasproducinglawnmowers
fromhismother’schickenhouse.Maxneverlikedtomowgrass.Heinstalleda
gearboxonhisfamily’slawnmowercreatingaself-propelledunit.Bytyingoneendofa
ropetothemowerandtheotherendtoatreeinthecenteroftheyardthemower
circledthetree,shorteningtheropeandguidingthemowerinconcentriccircles.Max
enjoyedrelaxingunderashadetreewhilehisinventiondidallthework.
Maxhaddesignedhisfirstself-propelledrotarylawnmowertodohisdirtyworkforhim.
Neighborsnoticedhisnewinventionandbeganaskinghimtomake more.Today,60
yearslater,SwisherMowerandMachineCompany,Inc.isstillproducinginnovative
lawnandgardenandATV/UTVequipmentdesignedtogiveusallmore“relaxinginthe
shade” time.
SwisherproductshavebeenfeaturednationallyontelevisionprogramssuchasRegis
andKathieLeeandseeninpublicationslikeATVMagazine
,CountryJournal,Popular
MechanicsMagazine andothers.InJanuary2000PopularMechanicsMagazine
namedMax’szeroturningradiusridingmoweroneofthe20
th
century’stophousehold
inventions.
Swisheroffersvalueandfunctioninitsproductstomeetyourgroundsmaintenance
needs.
CELEBRATING 60 YEARS OF INNOVATION
1945 - 2005
OWNER’S
MANUAL
MODELNO.
LS722H
LS728H
LS10528H
LS12534H
LS12534H12V
HOWTOORDER
REPAIRPARTS:
LOGSPLITTER
EachLogSplitterhasitsownserialnumber.Eachenginehas
itsownserialnumber.TheserialnumberfortheLogSplitter
willbefoundontherighthandsideofthehydraulicoil
reservoir.Theserialnumberfortheenginewillbefoundon
thetopoftheblowerfanhousing.
AllLogSplitterpartslistedhereinmaybeordereddirectly
fromSwisherMower&MachineCo.Inc.,yournearest
Swisherdealer,orfromourwebsite.
Allenginepartsmaybeorderedfromthenearestdealerofthe
enginesuppliedwithyourlogsplitter
.
Partssubjecttochange
withoutnotice.
WHENORDERINGPARTS,PLEASEHAVETHE
FOLLOWINGINFORMATIONAVAILABLE:
*PRODUCT– SWISHERLOGSPLITTER
*SERIALNUMBER- _______________
*MODELNUMBER- _______________
*ENGINEMODELNUMBER- _______________
TYPE- _______________
*PARTNUMBER
*PARTDESCRIPTION
www.swisherinc.com
TELEPHONE- 1-800-222-8183
FAX- 1-660-747-8650
SWISHERMOWER&MACHINECO.INC.
1602CORPORATEDRIVE
WARRENSBURG,MO64093
SWISHERMOWER&MACHINECO.INC.
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16
  • Page 17 17
  • Page 18 18
  • Page 19 19
  • Page 20 20

Swisher LS10528H User manual

Swisher
Brand
Swisher
Model
LS10528H
Category
Log splitters
Type
User manual
This manual is also suitable for
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents