Bertazzoni MAS304DFMXE Installation, Use and Care Manual

IMPORTANTSAFETYINFORMATION

PLEASEREADANDFOLLOWTHESEIMPORTANT

INSTRUCTIONSFORTHESAFETYOFYOURHOMEANDOF

THEPEOPLELIVINGINIT.

SavethisManualforlocalelectricalinspector’suse.

Readandsavetheseinstructionsforfuturereference.

Observeallgoverningcodes,ordinancesandregulations.



‐Donotstoreorusegasolineorotherflammablesubstances

inthevicinityofthisoranyotherappliance.

‐WHATTODOIFYOUSMELLGAS

 Donotlightanyappliance.

 Donottouchanyelectricalswitch.

 Donotuseanyphoneinyourbuilding.

 Immediatelycallyourgassupplierfromaneighbour’s

phone.Followthegassupplier’sinstructions.

 Ifyoucannotreachyourgassuppliers,callthefire

department.

‐Installationandservicemustbeperformedbyaqualified

installer,serviceagencyorthegassupplier.

InMassachusetts:Allgasproductsmustbeinstalledbya

"Massachusetts"licensedplumberorgasfitter.A"T"handle

typemanualgasvalvemustbeinstalledinthegasline

connectedtothisappliance.



 



WARNING!

Readthisinstructionbookletbeforeinstallingandusingthe

applianc



Themanufacturerwillnot

beresponsibleforanydamage

topropertyortopersonscausedbyincorrectinstallationor

improperuseoftheappliance.

The manufacturerreservestherighttomakechanges to its

products when considered necessary and useful, without

affectingtheessentialsafetyandoperatingcharacteristics.

Thisappliancehasbeendesignedfornon

‐professional,

domesticuseonly.

Donotusethisappliancetoheataroom.

Donotplaceanypotorpanontheopenovendoor.The

doorismadeofglassanditcanbreakifloadedwitha

weight.

Beforebeginninginstallation, please readthese instructions

completelyandcarefully.

Do not remove permanently affixed labels, warnings, or

platesfromtheproduct.Thismayvoidthewarranty.‐Please

observealllocalandnationalcodesandordinances.

Pleaseensuretherangeisproperlygrounded.

The installer should leave these instructions with the

consumerwhoshouldretainforlocalinspector'suseandfor



futurereference.

Theplugshouldalwaysbeaccessible.

Installationmustconformwithlocalcodesorintheabsence

of codes, the National Fuel Gas Code NSIZ223.1/NFPA54.

Electrical installation must be in accordance with the

National Electrical Code, ANSI/NFPA70‐latest edition

and/or local codes. IN CANADA: Installation must be in

accordance

with the current CAN/CGA‐B149.1 National Gas

Installation Code or CAN/CGA‐B 149.2, Propane Installation

Code and/or local codes. Electrical installation must be in

accordance with the current CSA C22.1 Canadian Electrical

CodesPart1and/orlocalcodes.

Installationofanygas‐firedequipmentshouldbemadebya

licensed plumber.

 A manual gas shut‐off valve must be

installedinthe gassupply line ahead of theoven inthe gas

flowforsafetyandeaseofservice.

WARNING!

ELECTRICALSHOCKHAZARD

Disconnectelectricalpoweratthecircuitbreakerboxor

fuseboxbeforeinstallingtheappliance.

Provideappropriateground

fortheappliance.

Usecopperconductorsonly.

Failuretofollowtheseinstructionscouldresultinserious

injuryordeath

CAUTION

Labelallwirespriortodisconnectingwhenservicing

controls.Wiringerrorscancauseimproperanddangerous

operation.

Verifyproperoperationafterservicing





WARNING

Readthisinstructionbookletbeforeinstallingand



usingtheappliance.



Warning!

This range can tip. Injury to persons could result.

Install anti-tip device shipped with range. See

Installation Instructions.

WARNING!

Iftheinformationinthismanualisnot

followedexactly,afireorexplosionmayresult

causingpropertydamage,personalinjuryor

death.



BERTAZZONISpA

ViaPalazzina8

42016GuastallaRE

ITALY



WWW.BERTAZZONI.COM



ModelsMAS304DFMXE

[M7S06ZA7X5DUG]





 

 



FromthedeskofthePresident



DearnewownerofaBertazzoniproduct,

Iwanttothankyouforchoosingoneofour

beautifulPROranges.Weknowthatyouhavemany

brandsandproductstochoosefromandweare

thrilledthatyouhavedecidedtotakeoneofour

productsintoyourhome.

Wetake

asmuchprideinmakingourrangesaswe

hopeyouwillinowningthem.Myfamilystarted

manufacturingcookingappliancesin1882.Eachof

ourproductsisablendofItaliandesignfinesseand

superiorappliancetechnolo gy.Whilewecannot

replaceyouruniquetalentatcookingdelicious

recipes

foryourself,yourfamilyandyourfriends,

wetryourbesttomakecookingeasier,more

effectiveandmorefun.

Ourappliancesaredesignedaccordingtothe

strictestsafetyandperformancestandardforthe

EuropeanandtheNorthAmericanmarket.We

followthemostadvancedmanufacturing

philosophy.Eachapplianceleavesthe

factoryafter

thoroughqualityinspectionandtesting.Our

distributorsandourservicepartnersarereadyto

answeranyquestionsyoumayhaveregardinghow

toinstall,useandcareforyourBertazzoniproduct.

Thismanualwillhelpyoulearntousetheproduct

inthesafestandmosteffectivemanner

andcare

foritsothatitmaygiveyouthehighestsatisfaction

foryearstocome.

Themanualalsoincludesdirectionsforthe

professionalinstallerthatwillinstalltheproductin

yourhome.Werecommendusingfactory‐trained

professionalsforthedelicatetaskofinstallingand

testingappliancesinyour

home.Pleasecall

CustomerServiceifyouneedhelplocatinga

factory‐trainedprofessionalinstallerinyourarea.

Pleasekeepthismanualforfutureuse.

Grazie!



TABLEOFCONTENTS

IMPORTANTSAFETYINFORMATION........................................................................................................................1

WARRANTYANDSERVICE........................................................................................................................................4

CUSTOMERSERVICE.......................................................................................................................................................4

REPLACEMENTPARTS....................................................................................................................................................4

BEFOREINSTALLATION............................................................................................................................................6

INSTALLINGTHELEGS..............................................................................................................................................7

INSTALLINGTHEWORKTOPFRONTGUARD..............................................................................................................7

INSTALLINGTHEBACKGUARD..................................................................................................................................8

INSTALLATIONREQUIREMENTS...............................................................................................................................9

ELECTRICAL....................................................................................................................................................................9

GAS.................................................................................................................................................................................9

INSTALLATIONADJACENTTOKITCHENCABINETS...................................................................................................10

EXHAUSTHOODINSTALLATION.............................................................................................................................10

ELECTRICALCONNECTION......................................................................................................................................11

WIRINGDIAGRAM.................................................................................................................................................13

GASCONNECTION.................................................................................................................................................14

PRESSUREREGULATOR................................................................................................................................................15

APPLIANCESERVING..............................................................................................................................................15

GASCONVERSION............................................................................................................................... ..................15

STEP1:PRESSUREREGULATOR....................................................................................................................................16

STEP2:SURFACEBURNERS..........................................................................................................................................16

STEP3:MINIMUMFLAMEADJUSTMENT.....................................................................................................................17

GASBURNERSDATATABLES..................................................................................................................................17

INSTALLATIONCHECKLIST............................................................................................................................... .......18

FINALPREPARATION.............................................................................................................................................18

USERMANUAL......................................................................................................................................................19

ROOMVENTILATION.............................................................................................................................................19

SURFACEBURNERLAYOUT....................................................................................................................................20

SURFACECOOKING................................................................................................................................................20

IMPORTANT.................................................................................................................................................................20

SYMBOLS......................................................................................................................................................................20

SURFACEBURNEROPERATION....................................................................................................................................21

TIPSFORUSINGBURNERSCORRECTLY........................................................................................................................21

TIPSFORUSINGPANSCORRECTLY...............................................................................................................................22

OVENCOOKING.....................................................................................................................................................22

IMPORTANT.................................................................................................................................................................23

SYMBOLS......................................................................................................................................................................23

OVENRACKS.................................................................................................................................................................23

OVENFUNCTIONSELECTOR.........................................................................................................................................23

USINGTHEOVEN...................................................................................................................................................24

OVENLIGHT..................................................................................................................................................................24

COOLINGFANS.............................................................................................................................................................24

FRONTINDICATORLIGHT.............................................................................................................................................24

OVENCONVECTIONFAN..............................................................................................................................................24

BAKE..................................................................................................................................................................24

PREHEATINGTHEOVEN.........................................................................................................................................24

GETTINGTHEBESTRESULTS...................................................................................................................................24

BAKEWARETYPE...................................................................................................................................................24

BAKERACKPOSITIONS............................................................................................................................... ........... 24

CONVECTION.........................................................................................................................................................25

RACKPOSITIONS............................................................................................................................... .................... 25

BAKINGRECOMMENDATIONS...............................................................................................................................26

BROIL/CONVECTIONBROIL..................................................................................................................................26

BROILINGANDROASTINGRECOMMENDATIONS...................................................................................................27

MAINTAININGYOURRANGE..................................................................................................................................28

CLEANINGYOURRANGE........................................................................................................................................28

TROUBLESHOOTINGGUIDE....................................................................................................................................29

IMPORTANTAPPLIANCEINFORMATION................................................................................................................30

WARRANTYANDSERVICE

AllBertazzoniproductscarrya2yearpartsandlabourwarranty.

ServiceonallBertazzoniproductsshallbecarriedoutbyfactory‐trainedprofessionalsonly.

ForwarrantyservicepleasecontactCustomerServiceatthenumbers indicatedbelow.



CUSTOMERSERVICE

English/Spanishhotline (866)905‐0010

French(800)561‐7625

Fax(714)

428‐0040

Email

[email protected]



Mailingaddress



SERVICEPOWER

1503SouthCoastdrive

Suite320

CostaMesaCA92626



REPLACEMENTPARTS

OnlyBertazzonireplacementpartsmaybeusedinperformingserviceontheappliance.

Replacementpartsareavailablefromfactoryauthorizedpartsdistributors.

APWagner PHONE

1 888 279 2463 FAX716 856 4779

ReliableParts PHONE 206 5758818 FAX206 5750910

Coast PHONE 800 821 0244 FAX604 321 6646



PRODUCTSPECIFICATIONS

Dimensions(insertdrawingsfront,sideandback)



Weight

Burnerpower

 Naturalgas

LPgas

Auxiliary 3750BTU/h 3750BTU/h

Semi‐rapid 6000BTU/h 6300BTU/h

Rapid 10400BTU/h 11400BTU/h

Dualburner(inner) 2730BTU/h 2900BTU/h

Dualburner(outer) 15000BTU/h 16400BTU/h



BEFOREINSTALLATION

This appliance shall only be installed by an

authorizedprofessional.

This appliance shall be installed in accordance

withthemanufacturer’sinstallationinstructions. 

This appliance must be installed in accordan ce

withthenorms&standar ds ofthecou ntry where

it will be installed. The installation of this

appliance must conform to local

 codes and

ordinances. In the absence of local codes,

InstallationsmustconformstoAmericanNational

Standards,NationalFuelGasCodeANSIZ223.1–

latestedition/NFPA54orB149.1.

The appliance, when installed, must be

electrically grounded in accordance with local

codes or, in the absence of local codes, with the

NationalElectricalCode,ANSI/NFPA70.

If local codes permit, a flexible metal appliance

connection with the new AGA or CGA certified

design, max. 5 feet (1,5 m) long, ½” I.D. is

recommended for connecting this appliance to

the gas supply line. Do not bend or damage the

flexibleconnectorwhenmoving

theappliance.

This appliance must be used with the pressure

regulator provided. The regulator shall be

properlyinstalled in order to be accessible when

theapplianceis installed in its final location. The

pressureregulatormustbesetforthetypeofgas

tobeused.Thepressureregulatorhas

½”female

pipe thread. The appropriate fitting must be

determined basedon the size of your gas supply

line,theflexiblemetalconnectorandtheshutoff

valve.

The appliance must be isolated from the gas

supply piping system by closing its individual

manualshutoffvalveduringanypressuretesting

ofthe

gassupplypipingsystemattestpressures

equal to or less than 1/2 PSI (13,8” w.c. or 3,5

kPa).

All opening andholes in the wall and floor, back

and under the appliance shall be sealed before

installationoftheappliance.

Amanualvalveshall beinstalledinanaccessible

location in the gas line external to the appliance

for the purpose of turning on or shutting off gas

totheappliance

WARNING: This appliance shall not be installed

with a ventilation system that air downward

towardthe ra nge/rangetop/cooktop;thistypeof

ventilation system may cause ignition and



combustion problem with the gas cooking

appliance resulting in a personal injury or

unintendedoperation.



WARNING: an air curtain or other overhead

range/rangetop/cooktop hood, which operates

by blowing a downward airflow onto a

range/rangetop/cooktop, shall not be

used/installed in conjunction with this gas

range/rangetop/cooktop.



WARNING!

Donotuseaerosol

spraysinthevicinityofthis

appliancewhileitisinoperation

ROOM VENTILATION: An exhaust fan may be

used with the appliance; in each case it shall be

installed in conformity with the appropriate

national and local standards. Exhaust hood

operationmay affect other vented appliances;in

each case it

 shall be installed in conformity with

theappropriatenationalandlocalstandards.



TYPEOFGAS

Thisapplianceisshippedfromthefactoryforuse

with natural gas. For use with propane LP gas

please follow the conversion procedure 

described on pg. 17. A step by step conversion

procedureisalso

includedwitheachsetofLPgas

nozzles.



GASPRESSURE

Themaximuminletgassupplypressureincoming

tothegasappliancepressureregulatoris1/2PSI

(13,8’’w.c.or3,5kPa).

The minimum gas supply pressure for checking

theregulatorsettingshallbeatleast1“w.c.(249

Pa)above

theinletspecifiedmanifoldpressureto

the appliance (this operating pressure is 4” w.c.

(1.00kPa)forNaturalGasand 11”w.c.(2.75 kPa

forLPGas).



INSTALLINGTHELEGS

Bertazzonirangesmustbeusedonlywiththe

legsproperlyinstalled.

Fourheight‐adjustablelegsareshippedwiththe

rangeinthepolystyrenecontainersituatedover

theappliance.

Before installing the legs, position the appliance

nearits final location asthelegsarenotsuitable

formovingtheapplianceoverlong

distances.

After unpacking the range, raise it enough to

insert the legs in the appropriate receptacles

situated on the lower  part of the appliance.

Lowerthe ra nge gently tokeepany unduestrain

fromlegsandmountinghardware.Ifpossibleuse

apalletorliftjackinsteadoftiltingthe

unit.

Adjust leg height to the desired level by twisting

the inside portion of the leg assembly until the

properheightis reached. Checkwith a levelthat

thecooktopisperfectlylevel.



INSTALLINGTHEWORKTOP

FRONTGUARD

Toincreasetheclearancebetweenthefrontedge

of the worktop and the burners it is possible  to

install the worktopfront guard shipped with the

appliance.

Toinstallthefrontguard,holditwiththepointed

edges looking up. Align the edges of the front

guard with the appropria te receptacles

 in the

bottomof the worktop andpressfirmlyuntilthe

frontguardissecurelyattachedtotheworktop.

ATTENTION: once installe d  the front guard may

only be removed by disassembling the worktop.

Attempting to remove the front guard without

disassembling the worktop will result in

permanentdamagetothe

worktop.



INSTALLINGTHEBACKGUARD

The back guard must be installed prior to

operation of the appliance for appropriate

ventilationoftheovencompartment.

Thesuppliedbackguardisa2‐partassembly.The

box also contains a set of metal screws for

securingthebackguardtotheworktop.



Disassemble the back guard

and position the

frontpart on the worktop.Align the screw holes

with the corresponding holes at the back of the

worktop.



If the holes are not aligned, partially loosen the

brackets at the back of the worktop as shown

below.





Installthefrontpartofthebackguardby

tighteningthe2centralscrewsfromthetopand

2lateralscrewsfromthebottom.



INSTALLINGTHEANTI‐TIPStabilityDEVICE

Theanti‐tipbracketshippedwiththerangemust

beproperly secured tothe rear wall as shown in

thepicturebelow.

Theheightofthebracketfromthefloormustbe

determined after the range legs have been

adjusted to the desired height and

 afterthe

rangehasbeenlevelled.

Measure the distance from the floor to the

bottom of the anti‐tip bracket receptacle on the

backoftheappliance.

Position the two anti‐tip brackets on the wall at

the desired height plus 1/8" (0.32  cm). The

bracketsmustbe placed  at

2”5/16(6,0cm)from

the side of the range. The distance between the

twobracketis25”1/4(64,1cm).

Secure the brackets to the wall with appropriate 

hardware.

Slidetherangeagainstthewall untilthebrackets

are fully inserted into their receptacles on the

backoftherange.



INSTALLATIONREQUIREMENTS



ELECTRICAL

A properly grounded and horizontally‐mounted 

electrical receptacle Type NEMA 14‐50R should

beinstallednohigherthan3"(7.6cm)abovethe

floor, no less than 2” (5 cm) and no more than

11” (28 cm) from the left side (facing product);

refer to ELECTRICAL CONNECTION section pag.

13.



Checkalllocalcoderequirements.



GAS

Anagency‐approved,properly‐sizedmanualshut‐

off valve should be installed no higher than 3"

(7.6 cm) above the floor and no less than 2” (5

cm)andnomorethan8”(20.3cm)fromtheright

side(facingproduct).

To connect gas

 between shut‐off valve and

regulator, use agency‐approved, properly sized

flexible or rigid pipe. Check all local code

requirements.



INSTALLATIONADJACENTTOKITCHEN

CABINETS

This range may be installed directly adjacent to

existingcountertophighcabinets(36"or91.5cm

fromthefloor).

For the best look, the worktop should be level

with the cabinet countertop. This can be

accomplished by raising the unit using the

adjustmentspindlesonthelegs.

ATTENTION: the range CANNOT

 be installed

directly adjacent to kitchen walls, tall cabinets,

tall appliances, or other vertical surfaces above

36" (91.4 cm) high. The minimum side clearance

insuchcasesis6"(15.2cm).

Wallcabinetswithminimum sideclearancemust

be installed 18" (45.7 cm) above the countertop

withcountertopheightbetween

35½”(90.2cm)

and37¼”(94.6cm).Themaximumdepthofwall

cabinetsabovetherangeshallbe13"(33.0cm)







EXHAUSTHOODINSTALLATION

ThisrangewillbestperformwhenusedwithPRO

lineBertazzoniexhausthoods.Thesehoods have

been designed to work in conjunction with the

Bertazzoni range and have the same finish for a

perfectlook.

For maximum performance, the height of the

bottomofthehood from theworktopshould be



between 25 1/2" (65 cm) and 31 1/2" (80 cm).

This would typically result in the bottom of the

hoodbeing 61 1/2" (156.2 cm)to 67 1/2"(171.5

cm) above the floor.  These measurements

provide for safe and efficient operation of the

hood.

Before installation of the exhaust hood,

consult

local or regional building and installation codes

foradditionalspecificclearancerequirements.

Refer to the range hood installation instructions

provided by the manufacturer for additional

information.



A 30” (76,2 cm)

B 36” (91,5 cm)

C 13” (33,0 cm)

D 18” (45,7 cm)

E 35”1/2(90,2 cm) / 37” ¼ (94,6 cm)

F 6” (15,2 cm)

ELECTRICALCONNECTION

The appliance shall be connected toa single

phase electric line rated at 120/208Vac or

120/240Vacand60Hzfrequency.



Electricpowerrating:

‐120/208Vac:2400Wattor12.0Amax.

‐120/240Vac:3100Wattor13.5Amax.



Heatingelementspowerrating:

‐Ovenbakeelement=1600Watt

‐Ovencircular

element=2800Watt

‐Ovendoublebroilelement=1200+1800Watt



Installasuitableelectricpowersupplyreceptacle

connection type NEMA 14‐50Rable to support a

load of at least 16 A (per line)according to local

coderequirements.Forfourorthreewirespower

supplyconnectionsystemsee

diagrambelow.

FOUR-WIRE CONN.RECEPTACLE NEMA 14-50R

THREE-WIRE CONN.RECEPTACLE NEMA 14-50R



Check your local code for which of the options

belowshould be usedin grounding the

receptaclepowersupplyconnections.

OPTION 1 – FOUR Wires connection:

‐ Connect the L1 receptacle terminal to the

incoming BLACK electrical supply wire (L1‐hot

wire)

‐ Connect the L2 receptacle terminal to the

incoming RED electrical supply wire (L2‐hot

wire)

‐ Connect the NEUTRAL receptacle terminal to

the incoming NEUTRAL (WHITE) electrical

supplywire

‐ Connect the GROUND receptacle terminal to



the incoming GROUND (GREEN) electrical

supplywire

OPTION 2 - THREE-Wires connection:

‐ Connect the L1 receptacle terminal to the

incoming BLACK electrical supply wire (L1‐hot

wire)

‐ Connect the L2 receptacle terminal to the

incoming RED electrical supply wire (L2‐hot

wire)

‐ Connect the NEUTRAL with the GROUND

receptacle terminal to the incoming NEUTRAL

(WHITE)electricalsupplywire

DO NOT USE EXTENSION CORDS WITH THIS

APPLIANCE AS IT MAY RESULT IN FIRE,

ELECTRIC SHOCK OR OTHER type of

PERSONAL INJURY.

The appliance isequipped at the factory with an

electric supply cord set 4 wires type with ring

terminals (L1, L2, N, Ground) suitable for range

use UL/CSA listed type SRDT/DRT 2x6AWG (L1,

L2)+2x8AWG (N, G) rated 300V, 40 or 50A with

fused plug type NEMA 14‐50P; cable length 1,5



m.;incasethesupplycordsetmustbereplaced,

it shall be replaced with anidentical set having

the same technical specs and followingcarefully

theinstructionsanddiagramsbelow: 

1) Disconnect appliance from electrical power

supplyreceptacle

2) Slideouttheappliancefrominstallationplace

toaccessto

backenclosurepanel

3) Remove back enclosure panel by removing

the6screwsasshownbelow

4) Loose strain relief byunscrewing the two

strainrelief'sscrewsasindiagram.



5) Remove damaged supply cord set by taking

off the 4 ele ctrical connection screws (block

L1,N,L2andGroundscrew,seediagram)

6) Insert the new supply cord set in the strain

relief and lock it with two strain relief's

screwsinsuitableposition.

7)

Fixwellthe ringterminalsG, L1, N, L2 of the

new supply  cord set asshown in diagram

withits4screws

8) Re‐install the back enclosure panel with 6

screws

9) Slide the appliance back into its proper

location

10) Re‐connect the appliance to the electrical

power.



ELECTRICALGROUNDING

Thisapplianceisequippedwithafour‐prongplug 

for your protection against shock hazard and

should be plugged dir ectly into a properly

grounded receptacle. Do not cut or remove the

groundingprongfromthisplug.

WARNING!

ELECTRICALSHOCKHAZARD

Disconnectelectricalpowe ratthecircuit

breakerbox

orfuseboxbeforeinstallingthe

appliance.

Provideappropriategroundfortheappliance.

Usecopperconductorsonly. 

Failuretofollowtheseinstructionscouldresult

inseriousinjuryordeath



CAUTION

Labelallwirespriortodisconnectingwhen

servicingcontrols.Wiringerrorscancause

improperanddangerousoperation.

Verifyproperoperation

afterservicing

WIRINGDIAGRAM

GASCONNECTION

All gas connections must comply with national

and local codes. The gas supply line (service )

must be the same size or greater than the inlet

lineof the appliance. Thisrange uses a1/2"NPT

inlet (see drawing below for details of gas

connection). On all pipe joints use appropriate

sealant

resistanttogas.

This range can be used with Natural or

LP/Propane gas. The range is shipped from the

factoryforusewithnaturalgas.

For LP/propane household installation, the

appliance must be converted by the dealer, by a

factory‐trained professional or by a qualified

licensedplumberorgas

servicecompany.

Gasconversionisimportantforsafeandeffective

useoftheappliance.Itistheresponsibilityofthe

dealerandtheowneroftherangetoperformthe

appropriate gas conversion following the

directionsofthemanufacturer.

THEGASCONVERSIONPROCEDUREIS

DESCRIBEDINTHISMANUALANDINTHE



PACKAGECONTAININGTHECONVERSION

NOZZLESSHIPPEDWITHEVERYRANGE.

Pleaseprovidetheservicepersonwiththis

manualbeforeworkisstartedontherange.



WARNING!

DONOTUSEANOPENFLAMEWHENCHECKING

FORLEAKS!

Leak testing of the appliance shall be conducted

according to the manufacturer's instructions.

Before placing

 the oven  into operation, always

check for leaks with soapy water solution or

otheracceptablemethod.

Check for gas leakage with soapy water solution

or other acceptable methods in  all gas

connections installed between inlet gas pipe of

the appliance, gas regulator, till to the manual

shut‐offvalve.



MANUALSHUT‐OFFVALVE

THISVALVEISNOTSHIPPEDWITHTHE

APPLIANCEANDMUSTBESUPPLIED BYTHE

INSTALLER.

The manual shut‐off valve must be installed in

the gas service line between the gas hook‐up on

the wall and the appliance inlet, in a position

whereitcan

bereachedquicklyintheeventofan

emergency.

In Massachusetts: A  'T' handle type manual gas

valve must be installed in the gas supply line to

thisappliance.



FLEXIBLECONNECTIONS

In case of installation with flexible couplings

and/or quick‐disconnect fittings, the installer

must use a heavy‐duty, AGA

 design‐certified 

commercial flexible  connector of at least 1/2"

(1.3 cm) ID NPT (with suitable strain reliefs) in

compliance with ANSI Z21.41 and Z21.69

standards.

In Massachusetts: The unit must be installed

witha36"(3‐foot)longflexiblegasconnector.

InCanada:useCAN1‐6.10‐88metalconnectors

forgasappliancesandCAN1‐6.9M79quick

disconnectdeviceforusewithgasfuel.



PRESSURETEST‐POINTSTOPPERVALVE

To avoid gas leaks, the pressure test‐point

stoppervalveandgasketsuppliedwiththerange

mustbeinstalledonthegasfittingatthebackof

therange

accordingtothediagrambelow.







PRESSUREREGULATOR

Since service pressure may fluctuate with local

demand, every gas cooking appliance must be

equipped with a pressure regulator on the

incoming service line for safe and efficient

operation.

The pressure regulator shipped with the

appliance has two female threads ½” NPT. The

regulatorshallbeinstalledproperly in

ordertobe

accessible when the appliance is installed in its

finalposition.



Manifoldpressureshouldbecheckedwitha

manometerandcomplywiththevaluesindicated

below:

Naturalgas4.0"W.c.P.

LP/Propane11.0"W.C.P.

Incominglinepressureupstreamfromthe

regulatormustbe1"W.c.P.higherthan

the

manifoldpressureinordertocheckthe

regulator.

Theregulatorusedonthisrangecanwithstanda

maximuminputpressureof1/2PSI(13.8"w.c.or

3,5kPa)Ifthelinepressureexceedsthatamount,

astep‐downregulatorisrequired.

The appliance, its individual shut‐off valve, and

the pressure regulator must be disconnected

from the gas line during any pressure testing of

that system at pressures in excess of 1/2 PSI

(13,8”w.c.or3.5kPa).

The individual manual shut‐off valve must be in

the OFF position during any pressure testing of

the gas supply piping system

 at test  pressures

equal to or less than 1/2 PSI (13,8” w.c. or 3.5

kPa).



APPLIANCESERVING

Beforecarryinganyservicingoperation

disconnecttheappliance fromgasandelectric

supplyandextraappliancefromfinalinstallation

placeinordertohaveaccesstotheappliancefor

properservicingintervention.

GASCONVERSION

WARNING!

Beforecarryingoutthisoperation,disconnect

theappliancefromgasandelectricity.

Gasconversionshallbeconductedbyafactory‐

trainedprofessional.

Callthecustomerservicehotlinetoidentifya

factory‐trainedprofessionalnearyourhome.

The gas conversion procedure for this range

includes6steps:

1. Pressureregulator

Surfaceburners

3. Adjustmentofminimumsetting

The conversion is not completed if all 6 steps

havenotbeenconcludedproperly.

Beforeperformingthegasconversion,locatethe

package containing the replacement nozzle

shipped with every range. IMPORTANT: Each

nozzle has a number indicating  itsflow diameter

printedonthe

body.Consultthetableonpage20

formatchingnozzlestoburners.

Savethenozzlesremovedfromtherangefor

futureuse.



STEP1:PRESSUREREGULATOR

Thepressureregulatorsuppliedwiththe

applianceisaconvertibletypepressure regulator

forusewithNaturalGasatanominaloutlet

pressureof4”w.c.orLPgasatanominaloutlet

pressureof11”w.c.anditispre‐arrangedfrom

thefactoryto

operatewithoneofthese

gas/pressureasindicatedinthelabelsaffixedon

theappliance,packageandInstructionbooklet.

Toconverttheregulatorforusewithotherliquid

propaneLPgas:

1. Unscrewbyhandtheuppercapofthe

regulator,removethewhiteplastic

attachmentfromthecap,reverseits



directionandscrewitagainfirmlyagainstthe

cap.Thewhiteplasticattachmenthasarrows

indicatingthepositionfornaturalgas(NAT)

andLPgas(LP).

2. Screwbyhandthemetalcapintheoriginal

positionontheregulator.



STEP2:SURFACEBURNERS

Toreplacethe

nozzlesofthesurfaceburners,lift

up the burners and unscrew the nozzles shipped

withtherangeusinga7mm{socketwrench).

Replacenozzlesusingtheconversionsetsupplied

with the range or by a Bertazzoni authorized

parts warehouse. Each nozzle has a number

indicating itsflow diameter printedon

 the body.

Consultthetableonpage20formatchingnozzles

toburners.



STEP3:MINIMUMFLAMEADJUSTMENT



WARNING!

Theseadjustmentsshouldbemadeonlyforuse

oftheappliancewithnaturalgas.Forusewith

liquidpropanegas,thechokescrewmustbe

fullyturnedinaclockwisedirection.



SURFACEBURNERS

1. Light one burner at a time and set the knob



totheMINIMUMposition(smallflame).

2. Removetheknob.

3. The range is equipped with a safety valve.

Using a small‐sizeslotted screwdriver, locate

the choke va lve on the valve body and turn

the choke screw to the right or left until the

burnerflameisadjustedto

desiredminimum.

4. Make sure that the flame does not go out

when switching quickly from the MAXIMUM

totheMINIMUMposition.



GASBURNERSDATATABLES



Burner Position Injector Gas Pressure MaxRate MinRate By‐pass

diam.[mm.] Type [i.w.c.] [BTU/h] [W] [BTU/h] [W] diam.[mm]

Auxiliary RearL 0,92 NG 4” 3750 1098 900 264 Regulated

0,56 LP(Propane) 11” 3750 1098 900 264 0,29

Semi‐Rapid FrontR 1,17 NG 4” 6000 1759 1500 439 Regulated

0,73 LP(Propane) 11” 6300 1845 1500 439 0,36

Rapid RearR 1,55 NG 4” 10400 3046 2500 732 Regulated

0,98 LP(Propane) 11” 11400 3339 2500 732 0,47

 FrontLInner 0,80 NG 4” 2730 799 900 264 Regulated

DualBurner 0,50 LP(Propane) 11” 2900 849 900 264 0,29

 FrontLOuter N°2x1,30 NG 4” 15000 4394 4500 1318 Regulated

N°2x0,83 LP(Propane) 11” 16400 4804 4500 1318 0,65



INSTALLATIONChecklist

1. Istherangemountedonitslegs?

2. Isthebackguardsecurelyconnected?

3. Hastheanti‐tipdevicebeenproperly

installed?

4. Doestheclearancefromthesidecabinets

complywiththemanufacturersdirections?

5. Istheelectricityproperlyg r ounded?

6. Isthegasservicelineconnectedfollowing



thedirectionsofthemanufacturer?

7. Haveallthepropervalves,stoppersand

gasketbeeninstalledbetweentherangeand

theserviceline?

8. Hasthegasconnectionbeencheckedfor

leaks?

9. Hastherangebeensetforthetypeofgas

availableinthehousehold?

10. Doesthe

flameappearsharpblue,withno

yellowtipping,shootingorflamelifting?

11. Hastheminimumsettingforallburnersbeen

adjusted?



FINALPREPARATION

Allstainlesssteelbodypartsshouldbewiped

withhot,soapywaterandwithaliquidstainless

steelcleanser.

Ifbuild‐upoccurs,donotusesteelwool,abrasive

cloths,cleaners,orpowders!Ifitisnecessaryto

scrapestainlesssteeltoremoveencrusted

materials,soakwithhot,wetclothsto

loosenthe

material,thenuseawoodornylonscraper.Do

notuseametalknife,spatula,oranyothermetal

tooltoscrapestainlesssteel!Scratchesare

almostimpossibletoremove.

Beforeusingtheovenforfoodpreparation,wash

thecavitythoroughlywithawarmsoapand

watersolution

toremovefilmresiduesandany

dustordebrisfrominstallation,thenrinseand

wipeddry.

USERMANUAL

IMPORTANT

Takecareofresetallworktop/oven/broiler

burnerscontrolsinOFFpositi onafteruseofthe

appliance.

WARNING!

ProperInstallation.Besureyourapplianceis

properlyinstalledandgrounded byaqualified

technician.

Donotleavechildrenalone.Childrenshouldnot

beleftaloneorunattendedinarea

where

applianceisinuse.Theyshouldneverbe

allowedtositorstandonanypartofthe

appliance.

Wearproperapparel.Loose‐fittingorhanging

garmentsshouldneverbewornwhileusingthe

appliance.

Userservicing.Donotrepairorreplaceanypart

oftheapplianceunlessspecifically

recommended

inthemanual.Allotherservicing

shouldbereferredtoaqualifiedtechnician.

Useonlydrypotholders.Moistordamp

potholdersonhotsurfacesmayresultinburns

fromsteam.Donotletpotholdertouchhot

heatingelements.Donotuseatowelorother

bulkycloth.

Donotto

covertheholesinsidetheovenwith

aluminiumfoil.

Donottocovertheworktopwithaluminium

foil.

Donotstoreanyflammableobjectorobjects

underpressureinthestoragecompartment.

Keeptheareaofoperationoftherangefree 

fromcombustiblematerials,gasolineandother

flammablevapoursandliquid.



Donotstoredangerousorflammablematerials

inthecabinetsabovetheappliance,sincethis

mayresultinapotentialfi rehazard.

Donotusetheapplianceforspaceheating.

Donotuseaerosolspraysinthevicinityofthe

appliancewhilecooking.

Donotsitorsteponthe

ovendoor.

Donotuseovencompartmentforstorage.

UseCareWhenOpeningDoor.Lethotairor

steamescapebeforeremovingorreplacingfood

Donotheatunopenedfoodcontainers.Build‐up

ofpressuremaycausecontainertoburstand

resultininjury.

Keepovenventductsunobstructed.

Alwaysplace

ovenracksindesiredlocation

whenoveniscool.Ifrackmustbemovedwhile

ovenishot,donotletpotholdercontacthot

heatingelementinoven.

Donotcleanovendoorgasket.Thedoorgasket

isessentialforagoodseal.Careshouldbetaken

nottorub,damage,ormovethegasket.

Donotuseovencleaningproducts.No

commercialovencleanerorovenliner

protectivecoatingofanykindshouldbeusedin

oraround

anypartoftheoven.

Cleanonlypartslistedinmanual.

Donotusewaterongreasefires.

Smotherfireorflamesorusedrychemicalor

foam‐typeextinguis her.



ROOMVENTILATION

The use of a gas cooking appliance generates

heat and humidity in the room where it is

installed. Proper ventila tion in the room is

needed. Make sure the kitchen is equipped with

a range hood of appropriate power (400 CFM 

minimum). Activate the exhaust fan/range hood

when possible. Intensive and continuous

 use of

the a ppliance may require additional ventilation,

forexamplebyopeningawindow.



SURFACEBURNERLAYOUT

1.SmallBurner

2.Mediumburner

3.Rapidburner

4.Dualburner(Powerburner)



Model



SURFACECOOKING

IMPORTANT

Takecareofresetallworktop/oven/broiler

burnerscontrolsinOFFpositi onafteruseofthe

appliance.

SYMBOLS



(*) 



 Burner position (in this case front

rightburner).

 Maximum temperature setting

/Recommended control knob

positionforburnerignition

 Minimumtemperaturesetting

Bertazzoni MAS304DFMXE Installation, Use and Care Manual

Related papers

Other documents