Invacare Pronto M61 User manual

Brand: Invacare

Model: Pronto M61

Category: Oxygen Equipment

Type: User manual

Owner’s Operator and Maintenance Manual

DEALER: This manual MUST be given to

the user of the product.

USER: BEFORE using this product, read this

manual and save for future reference.

For more information regarding

Invacare products, parts, and services,

please visit www.invacare.com

Pronto® M51™and

M61™with SureStep®

REFERENCE DOCUMENTS

Pronto® M51™and M61™with SureStep® 2Part No 1125085

 WARNING

A qualified technician MUST perform the initial set up of this wheelchair. Also, a

qualified technician MUST perform all procedures in the service manual.

DO NOT use this product or any available optional equipment without first

completely reading and understanding these instructions and any additional

instructional material such as owner’s manuals, service manuals or instruction

sheets supplied with this product or optional equipment. If you are unable to

understand the warnings, cautions or instructions, contact a healthcare

professional, dealer or technical personnel before attempting to use this equipment

- otherwise, injury or damage may occur.

 ACCESSORIES WARNING

Invacare products are specifically designed and manufactured for use in conjunction

with Invacare accessories. Accessories designed by other manufacturers have not

been tested by Invacare and are not recommended for use with Invacare products.

REFERENCE DOCUMENTS

DOCUMENT PART NUMBER

M50/M51/M61 Service Manual 1125075

MK5™NX™Electronics Manual (M51 Wheelchairs) 1110532

MK6i™Electronics Field Reference Guide (M61 Wheelchairs) 1141471

NOTE:Updatedversionsofthismanualareavailableonwww.invacare.com.

TABLE OF CONTENTS

Part No 1125085 3Pronto® M51™and M61™with SureStep®

TABLE OF CONTENTS

REFERENCE DOCUMENTS ................................................................. 2

SPECIAL NOTES ................................................................................ 5

LABEL LOCATION ............................................................................ 7

TYPICAL PRODUCT PARAMETERS .................................................... 8

SECTION 1—GENERAL GUIDELINES ................................................. 10

Controller Settings/Repair or Service .................................................................................................10

Accessories ................................................................................................................................................10

Operation Information............................................................................................................................10

Batteries......................................................................................................................................................12

Grounding Instructions ...........................................................................................................................13

Rain Test.....................................................................................................................................................13

Weight Training ........................................................................................................................................13

Weight Limitation.....................................................................................................................................13

SECTION 2—EMI INFORMATION ..................................................... 14

SECTION 3—SAFETY/HANDLING OF WHEELCHAIRS ......................... 16

Stability and Balance.................................................................................................................................16

Coping With Everyday Obstacles.........................................................................................................17

A Note to Wheelchair Assistants ........................................................................................................18

Pinch Points................................................................................................................................................18

Lifting/Stairways ........................................................................................................................................19

Transferring To and From Other Seats ..............................................................................................20

Reaching, Leaning and Bending - Forward ..........................................................................................21

Reaching and Bending - Backward........................................................................................................22

SECTION 4—SAFETY INSPECTION/TROUBLESHOOTING .................... 23

Safety Inspection Checklists...................................................................................................................23

Troubleshooting Guide ...........................................................................................................................25

Checking Battery Charge Level.............................................................................................................28

SECTION 5—WHEELCHAIR OPERATION ........................................... 29

Operating the Wheelchair......................................................................................................................29

Adjusting the Speed .................................................................................................................................30

Using the Horn..........................................................................................................................................31

Elevating the Seat......................................................................................................................................31

SPJ+ and SPJ+ w/ACC Joystick Switches and Indicators .................................................................33

SECTION 6—ARMS ......................................................................... 36

Removing/Installing the Arms ................................................................................................................36

Adjusting the Arms ..................................................................................................................................36

Installing/Removing Flip Back Armrests ..............................................................................................38

Positioning/Adjusting Flip Back Armrests ...........................................................................................39

SECTION 7—SEAT ........................................................................... 40

Adjusting the Back Angle ........................................................................................................................40

Adjusting the Headrest (Semi-Recline Only) .....................................................................................41

Removing/Installing the Seat Assembly................................................................................................42

Replacing the Seat Positioning Strap ....................................................................................................43

TABLE OF CONTENTS

Pronto® M51™and M61™with SureStep® 4Part No 1125085

TABLE OF CONTENTS

SECTION 8—FOOTBOARD ASSEMBLY .............................................. 45

Removing/Installing the Footboard Assembly....................................................................................45

Adjusting the Footboard Assembly ......................................................................................................46

SECTION 9—FRONT RIGGINGS ........................................................ 48

Installing/Removing Front Riggings .......................................................................................................48

Adjusting Footrest Height ......................................................................................................................49

Replacing Heel Loops ..............................................................................................................................50

Raising/Lowering Elevating Front Riggings..........................................................................................51

Adjusting/Replacing Telescoping Front Rigging Supports................................................................51

SECTION 10—TOP SHROUD AND WHEELS ........................................ 56

Replacing the Flat Free Tires on the Wheel Rim..............................................................................56

Removing/Installing the Top Shroud ....................................................................................................56

Engaging/Disengaging Motor Release Lever .......................................................................................57

Replacing Front/Rear Caster Assemblies............................................................................................58

Adjusting Forks .........................................................................................................................................59

SECTION 11—BATTERIES ................................................................ 60

Warnings For Handling and Replacing Batteries...............................................................................60

Using the Proper Batteries.....................................................................................................................61

Removing/Installing Batteries from/into Battery Tray......................................................................61

Connecting/Disconnecting Battery Cables.........................................................................................63

Charging Batteries....................................................................................................................................66

Battery Charger Operation....................................................................................................................67

SECTION 12—ELECTRONICS ............................................................ 71

Removing/Installing the Joystick ............................................................................................................71

Repositioning the Joystick.......................................................................................................................72

Disconnecting/Connecting the Joystick...............................................................................................74

SECTION 13—ACCESSORIES ............................................................ 76

Installing/Removing the Crutch/Cane Holder....................................................................................76

Installing/Removing the Oxygen Holder .............................................................................................77

Installing/Removing/Using the Walker Holder ..................................................................................78

GLOBAL LIMITED WARRANTY (EXCLUDING CANADA) ................... 79

CANADA LIMITED WARRANTY ...................................................... 80

The benefits of registering include:

1. Safeguarding your investment.

2. Ensuring long-term maintenance and servicing of your product.

3. Receiving updates with product information, maintenance tips and industry news.

Please have your model number and purchase date available to complete your registration.

Any registration information you submit will only be used by Invacare Corporation and protected

as required by applicable laws and regulations.

SPECIAL NOTES

Part No 1125085 5Pronto® M51™and M61™with SureStep®

SPECIAL NOTES

Signalwordsareusedinthismanualandapplytohazardsorunsafepracticeswhich

couldresultinpersonalinjuryorpropertydamage.Refertothetablebelowfor

definitionsofthesignalwords.

NOTICE

THE INFORMATION CONTAINED IN THIS DOCUMENT IS SUBJECT TO

CHANGE WITHOUT NOTICE.

WHEELCHAIR USER

As a manufacturer of wheelchairs, Invacare endeavors to supply a wide variety of

wheelchairs to meet many needs of the end user. However, final selection of the

type of wheelchair to be used by an individual rests solely with the user and his/her

healthcare professional capable of making such a selection.

WHEELCHAIR TIE-DOWN RESTRAINTS AND SEAT RESTRAINTS

Wheelchair users should not be transported in vehicles of any kind while in

wheelchairs. As of this date, the Department of Transportation has not approved

any tie-down systems for transportation of a user while in a wheelchair, in a moving

vehicle of any type.

It is Invacare’s position that users of wheelchairs should be transferred into

appropriate seating in vehicles for transportation and use be made of the restraints

made available by the auto industry. Invacare cannot and does not recommend any

wheelchair transportation systems.

 WARNING

ALWAYS wear your seat positioning strap. The seat positioning strap is a

positioning belt only. It is not designed for use as a safety device withstanding high

stress loads such as auto or aircraft safety belts. If signs of wear appear, the belt

MUST be replaced IMMEDIATELY.

 ACCESSORIES WARNING

Invacare products are specifically designed and manufactured for use in conjunction

with Invacare accessories. Accessories designed by other manufacturers have not

been tested by Invacare and are not recommended for use with Invacare products.

SIGNAL WORD MEANING

DANGER Danger indicates an imminently hazardous situation which,

if not avoided, will result in death or serious injury.

WARNING Warning indicates a potentially hazardous situation which, if

not avoided, could result in death or serious injury.

CAUTION

Caution indicates a potentially hazardous situation which, if

not avoided, may result in property damage or minor injury

or both.

SPECIAL NOTES

Pronto® M51™and M61™with SureStep® 6Part No 1125085

 WARNING CONTINUED

The drive behavior initially experienced by the user may be different from other

chairs previously used. This power wheelchair has Invacare’s SureStep technology, a

feature that provides the chair with optimum traction and stability when driving

forward over transitions and thresholds of up to 2-inches.

The following warnings apply specifically to the SureStep Feature.

• DO NOT use on inclines greater than 9°.

• DO NOT use on inclines with wet, slippery, icy or oily surfaces. This may include

certain painted or otherwise treated wood surfaces.

• DO NOT traverse down ramps at high speed. Doing so will reduce traction and

increase stopping distance.

• The end user’s weight can materially affect traction on sloped surfaces. Great

care should be taken when traversing such slopes.

To determine and establish your particular safety limits, practice use of this product

on various sloping surfaces in the presence of a qualified healthcare provider before

attempting active use of this wheelchair. Other general warnings listed within this

document also apply.

Wheelchairs should be examined during maintenance for signs of corrosion (water

exposure, incontinence, etc.). Electrical components damaged by corrosion should

be replaced IMMEDIATELY.

Wheelchairs that are used by incontinent users and/or are frequently exposed to

water may require replacement of electrical components more frequently.

LABEL LOCATION

Part No 1125085 7Pronto® M51™and M61™with SureStep®

LABEL LOCATION

M51 Wheelchairs

M61 Wheelchairs

Serial label located inside

the wheelchair frame

TYPICAL PRODUCT PARAMETERS

Pronto® M51™and M61™with SureStep® 8Part No 1125085

TYPICAL PRODUCT PARAMETERS

MEDIUM

BACK

SEMI-RECLINE

BACK

OFFICE STYLE,

SEMI-RECLINE

BACK

ASBA

SEAT WIDTH RANGE: 18 inches 16

inches

18 inches 16 to 20 inches

SEAT DEPTH: 16 to 18

inches

16 to 18 inches 18 to

inches

16 to 18 inches 16 to 20 inches

BACK HEIGHT: 16½ inches 19 inches 23½ inches

(w/ headrest)

18¾ inches

(w/o headrest)

16 to 20 inches

BACK ANGLE RANGE: 95° to 100°

in 5°

increments

90 to 114° 90 to 115° 80° to 100° in 5°

increments

UPHOLSTERY: Light Grey

Vinyl

Light Grey Vinyl, Grey

Cloth, Tan Vinyl

Charcoal Grey Vinyl Black Nylon

Back with Seat

Pan

SEAT-TO-FLOOR

WITH FOOTBOARD

(M51):

WITH FRONT RIGGINGS

(M51):

WITH ELEVATING SEAT

(M61):

20 to 24 inches

22 to 24 inches

21 to 23 inches + up to 5 inches of

Elevate

19 to 23 inches

19 to 21 inches + up

to 5 inches of

Elevate

17 to 21 inches

19 to 21 inches

17 to 19 inches

+ up to 5 inches

of Elevate

OVERALL WIDTH: 24 inches (Without Joystick)

OVERALL HEIGHT: 35 to 43¾ inches 41½ inches

OVERALL LENGTH: 34 inches (With Footboard Folded)

39½ inches (With Footboard Extended)

DRIVE WHEELS/

TIRES:

10 x 3-inch (Flat Free inserts)

CASTER: 6 x 2-inch Front/Rear w/Precision Sealed Bearings

FOOTRESTS/

LEGRESTS:

Flip Up, Depth and Height Adjustable, Footboard,

Swingaway Front Rigging, Elevating Legrest

*WEIGHT

W/O BATTERIES:

W/BATTERIES (U1):

145 to 170 lbs

192 to 217 lbs

TYPICAL PRODUCT PARAMETERS

Part No 1125085 9Pronto® M51™and M61™with SureStep®

*NOTE:Includesseatingsystemsandaccessories.

**NOTE:Valuesforrangearecalculatedformaximumchairweightratingusinglargestbatteries

applicable(U1),pertestproceduresdescribedinANSI/RESNAWC/VOL2‐1998Section4and

meetfederalreimbursementrequirementsforthisproduct.Whileconsideredtypical,theyare

derivedbasedoncertainidealconditions.Variancesinbatterycondition,userweight,usage

patternoroverallterrainconditionswillresultinactualvaluesforrangethatdifferfromthese

statedvalues.Usersshouldbecomeaccustomedtohowtheiruniqueconditionsimpacttheir

individualresults.Usersshouldbecomefamiliarwiththebatterydischargeindicatoronthe

joysticktodeterminetherangeoftheirwheelchair.RefertoBatteryChargerOperationonpage 67

formoreinformationaboutthebatterydischargeindicator.

SHIPPING

BASE W/O BATTERIES:

BASE WITH BATTERIES:

MEDIUM BACK:

SEMI-RECLINE:

OFFICE STYLE:

ASBA (20 X 20 X 20):

107 lbs

154 lbs

40 lbs

64 lbs

44 lbs

48 lbs

ARMRESTS: Adjustable Width, Angle, Heights and Depth

BATTERIES: U1 - Quantity 2

WEIGHT LIMITATION: 300 lbs

PERFORMANCE

SPEED:

TURNING RADIUS:

**RANGE (VARIABLE):

0 to 4.3 m.p.h.

19½ inches

up to 12 miles

MEDIUM

BACK

SEMI-RECLINE

BACK

OFFICE STYLE,

SEMI-RECLINE

BACK

ASBA

SECTION 1—GENERAL GUIDELINES

Pronto® M51™and M61™with SureStep® 10 Part No 1125085

SECTION 1—GENERAL GUIDELINES

 WARNING

SECTION 1 - GENERAL GUIDELINES contains important information for the safe

operation and use of this product.

Controller Settings/Repair or Service

Set‐upoftheElectronicControlUnitistobeperformedonlybyaqualifiedtechnician.

Thefinaladjustmentsofthecontrollermayaffectotheractivitiesofthewheelchair.

Damagetotheequipmentcouldoccurifimproperlyset‐uporadjusted.

Wheelchairsshouldbeexaminedduringmaintenanceforsignsofcorrosion(water

exposure,incontinence,etc.).Electricalcomponentsdamagedbycorrosionshouldbe

replacedIMMEDIATELY.

Wheelchairsthatareusedbyincontinentusersand/orarefrequentlyexposedtowater

mayrequirereplacementofelectricalcomponentsmorefrequently.

Accessories

Extremecareshouldbeexercisedwhenusingoxygenincloseproximitytoelectriccircuits

andothercombustiblematerials.Contactyouroxygensupplierforinstructionintheuse

ofoxygen.

Operation Information

Performanceadjustmentsshouldonlybemadebyprofessionalsofthehealthcarefieldor

personsfullyconversantwiththisprocessandthedriverʹscapabilities.Incorrectsettings

couldcauseinjurytothedriver,bystanders,damagetothechairandtosurrounding

property.

Afterthewheelchairhasbeenset‐up,checktomakesurethatthewheelchairperformsto

thespecificationsenteredduringtheset‐upprocedure.Ifthewheelchairdoesnot

performtospecifications,turnthewheelchairOffimmediatelyandreenterset‐up

specifications.Repeatthisprocedureuntilthewheelchairperformstospecifications.

ALWAYSshiftyourweightinthedirectionyouareturning.DONOTshiftyourweight

intheoppositedirectionoftheturn.Shiftingyourweightintheoppositedirectionofthe

turnmaycausetheinsidedrivewheeltolosetractionandthewheelchairtotipover.

DONOTshiftyourweightorsittingpositiontowardthedirectionyouarereachingasthe

wheelchairmaytipover.

DONOTmakesharpturnsintheforwardorreversedirectionatexcessivespeed.Failure

toobservethiswarningcancausethewheelchairtotipoverandmayresultininjuryto

users,bystandersand/ordamagetoproduct.

SECTION 1—GENERAL GUIDELINES

Part No 1125085 11 Pronto® M51™and M61™with SureStep®

DONOToperateonroads,streetsorhighways.

DONOTclimb,goupordownrampsortraverseslopesgreaterthan9°.

DONOTattempttomoveupordownaninclinewithawater,iceoroilfilm.

DONOTattempttodriveovercurbsorobstacles.Doingsomaycauseyourwheelchair

toturnoverandcausebodilyharmordamagetothechair.

DONOTleavethepowerbuttonintheOnpositionwhenenteringorexitingyour

wheelchair.

DONOTstandontheframeofthewheelchair.

DONOTstandontheflip‐upfootboard,otherwisedamagemayoccur.Whengettingin

oroutofthewheelchair,makesurethattheflip‐upfootboardisintheupwardposition.

DONOTstandonthefrontriggings,otherwisedamagemayoccur.Whengettinginor

outofthewheelchair,makesurethatthefootplatesonthefrontriggingsareinthe

upwardpositionormovedoutoftheway.

Whendeterminingthedepthofthetelescopingfrontframetubes,makesuretherearof

thefootrestsdonotinterferewiththemovementofthefrontcasters.Otherwisedamage

tothewheelchairmayresultormayimpedeproperoperation.

ALWAYSwearyourseatpositioningstrap.Theseatpositioningstrapisapositioningbelt

only.Itisnotdesignedforuseasasafetydevicewithstandinghighstressloadssuchas

autooraircraftsafetybelts.Ifsignsofwearappear,beltMUSTbereplaced

IMMEDIATELY.

Usetheseatswiveloptionwithcautionwhenaccessoriesareinstalled(suchassafetyflag,

crutch/caneholder,etc.).Otherwise,propertydamagemayoccur.

DONOTengageordisengagethemotorreleaseleversuntilthepowerisintheOff

position.

Beforeperforminganymaintenance,adjustmentorserviceverifythatOn/Offswitchon

thejoystickisintheOffposition.

Avoidstoringorusingthewheelchairnearopenflameorcombustibleproducts.Serious

injuryordamagetopropertymayresult.

ALWAYSkeephandsandfingersclearofmovingpartstoavoidinjury.

NEVERleaveanunoccupiedwheelchaironanincline.

DONOTattempttoliftthewheelchairbyanyremovable(detachable)parts.Liftingby

meansofanyremovable(detachable)partsofthewheelchairmayresultininjurytothe

userordamagetothewheelchair.

Makesurethedetentballsofthequick‐releasepinarefullyreleasedbeyondtheouter

edgeofthetubebeforeoperatingthewheelchair.Otherwise,injuryand/ordamagemay

result.

Keepdetentballsclean.

SECTION 1—GENERAL GUIDELINES

Pronto® M51™and M61™with SureStep® 12 Part No 1125085

M61 Wheelchairs Only

DONOToperatewheelchaironaninclinewhileinanelevatedposition.Otherwise,the

wheelchairmaytipoverandinjuryordamagemayoccur.

Batteries

Thewarrantyandperformancespecificationscontainedinthismanualarebasedonthe

useofdeepcyclegelcellorsealedleadacidbatteries.Invacarestronglyrecommendstheir

useasthepowersourceforthisunit.

Carefullyreadbattery/batterychargerinformationpriortoinstalling,servicingor

operatingyourwheelchair.

Charging Batteries

 DANGER

When using an extension cord, use only a three wire extension cord having at least

16 AWG (American Wire Gauge) wire and the same or higher electrical rating as

the device being connected. Use of improper extension cord could result in risk of

fire and electric shock. Three prong to two prong adapters should not be used. Use

of three prong adapters can result in improper grounding and present a shock

hazard to the user.

Theuseofrubberglovesisrecommendedwhenworkingwithbatteries.

NEVERattempttorechargethebatteriesbyattachingcablesdirectlytothebattery

terminals.

DONOTattempttorechargethebatteriesandoperatethewheelchairatthesametime.

DONOToperatewheelchairwithextensioncordattachedtotheACcable.

DONOTattempttorechargethebatterieswhenthewheelchairhasbeenexposedtoany

typeofmoisture.

DONOTattempttorechargethebatterieswhenthewheelchairisoutside.

DONOTsitinthewheelchairwhilechargingthebatteries.

DONOTattempttorechargebatteriesusingboththeon‐boardbatterychargerandan

independentbatterycharger(pluggedintothejoystickchargerport)atthesametime.

Doingsowillreducethelifeofthebatteries.

Readandcarefullyfollowthemanufacturer’sinstructionsforeachcharger(suppliedor

purchased).Ifcharginginstructionsarenotsupplied,consultaqualifiedtechnicianfor

properprocedures.

Ensurethepinsoftheextensioncordplugarethesamenumber,size,andshapeasthose

onthecharger.

DONOTunderanycircumstancescutorremovetheroundgroundingplugfromthe

chargerACcableplugortheextensioncordplug.

SECTION 1—GENERAL GUIDELINES

Part No 1125085 13 Pronto® M51™and M61™with SureStep®

Grounding Instructions

DONOT,underanycircumstances,cutorremovetheroundgroundingprongfromany

plugusedwithorforInvacareproducts.Somedevicesareequippedwiththree‐prong

(grounding)plugsforprotectionagainstpossibleshockhazardsandfire.Whereatwo‐

prongwallreceptacleisencountered,itisthepersonalresponsibilityandobligationofthe

customertocontactaqualifiedelectricianandhavethetwo‐prongreceptaclereplaced

withaproperlygroundedthree‐prongwallreceptacleinaccordancewiththeNational

ElectricalCode.Ifyoumustuseanextensioncord,useonlyathree‐wireextensioncord

havingthesameorhigherelectricalratingasthedevicebeingconnected.Inaddition,

InvacarehasplacedRED/ORANGEwarningtagsonsomeequipment.DONOTremove

thesetags.

Rain Test

InvacarehastesteditspowerwheelchairsinaccordancewithISO7176“RainTest.”This

providestheenduserorhis/herassistantsufficienttimetoremovehis/herpower

wheelchairfromarainstormandretainwheelchairoperation.

DONOTleavepowerwheelchairinarainstormofanykind.

DONOTusepowerwheelchairinashower.

DONOTstorepowerwheelchairinadampareaforanextendedperiodoftime.

Directexposuretoexcessiverainordampnessmaycausethechairtomalfunction

electricallyandmechanically,maycausethechairtoprematurelyrustormaydamagethe

upholstery.

ChecktoensurethattheREDandGREYbatteryterminalcapsaresecuredinplace,

joystickbootisnottornorcrackedwherewatercanenterandthatallelectrical

connectionsaresecureatalltimes.

DONOTusethewheelchairifthejoystickbootistornorcracked.Ifthejoystickboot

becomestornorcracked,replaceimmediately.

Weight Training

Invacaredoesnotrecommendtheuseofitswheelchairsasaweighttrainingapparatus.

Invacarewheelchairshavenotbeendesignedortestedasaseatforanykindofweight

training.Ifoccupantusessaidwheelchairasaweighttrainingapparatus,Invacareshall

notbeliableforbodilyinjuryandthewarrantyisvoid.

Weight Limitation

TheM51andM61wheelchairswithSureStephaveaweightlimitationof300lbs.

SECTION 2—EMI INFORMATION

Pronto® M51™and M61™with SureStep® 14 Part No 1125085

SECTION 2—EMI INFORMATION

 WARNING

CAUTION: IT IS VERY IMPORTANT THAT YOU READ THIS INFORMATION

REGARDING THE POSSIBLE EFFECTS OF ELECTROMAGNETIC

INTERFERENCE ON YOUR POWERED WHEELCHAIR.

Electromagnetic Interference (EMI) From Radio Wave Sources

Powered wheelchairs and motorized scooters (in this text, both will be referred to

as powered wheelchairs) may be susceptible to electromagnetic interference (EMI),

which is interfering electromagnetic energy (EM) emitted from sources such as

radio stations, TV stations, amateur radio (HAM) transmitters, two way radios, and

cellular phones. The interference (from radio wave sources) can cause the powered

wheelchair to release its brakes, move by itself, or move in unintended directions. It

can also permanently damage the powered wheelchair's control system. The

intensity of the interfering EM energy can be measured in volts per meter (V/m).

Each powered wheelchair can resist EMI up to a certain intensity. This is called its

"immunity level." The higher the immunity level, the greater the protection. At this

time, current technology is capable of achieving at least a 20 V/m immunity level,

which would provide useful protection from the more common sources of radiated

EMI.

There are a number of sources of relatively intense electromagnetic fields in the

everyday environment. Some of these sources are obvious and easy to avoid.

Others are not apparent and exposure is unavoidable. However, we believe that by

following the warnings listed below, your risk to EMI will be minimized.

The sources of radiated EMI can be broadly classified into three types:

1) Hand-held Portable transceivers (transmitters-receivers with the antenna

mounted directly on the transmitting unit. Examples include: citizens band (CB)

radios, "walkie talkie", security, fire and police transceivers, cellular telephones,

and other personal communication devices).

NOTE: Some cellular telephones and similar devices transmit signals while they are ON,

even when not being used.

2) Medium-range mobile transceivers, such as those used in police cars, fire trucks,

ambulances and taxis. These usually have the antenna mounted on the outside of

the vehicle; and

3) Long-range transmitters and transceivers, such as commercial broadcast

transmitters (radio and TV broadcast antenna towers) and amateur (HAM)

radios.

NOTE: Other types of hand-held devices, such as cordless phones, laptop computers,

AM/FM radios, TV sets, CD players, cassette players, and small appliances, such as elec-

tric shavers and hair dryers, so far as we know, are not likely to cause EMI problems to

your powered wheelchair.

SECTION 2—EMI INFORMATION

Part No 1125085 15 Pronto® M51™and M61™with SureStep®

 WARNING

Powered Wheelchair Electromagnetic Interference (EMI)

Because EM energy rapidly becomes more intense as one moves closer to the

transmitting antenna (source), the EM fields from hand-held radio wave sources

(transceivers) are of special concern. It is possible to unintentionally bring high

levels of EM energy very close to the powered wheelchair's control system while

using these devices. This can affect powered wheelchair movement and braking.

Therefore, the warnings listed below are recommended to prevent possible

interference with the control system of the powered wheelchair.

Electromagnetic interference (EMI) from sources such as radio and TV stations,

amateur radio (HAM) transmitters, two-way radios, and cellular phones can affect

powered wheelchairs and motorized scooters.

FOLLOWING THE WARNINGS LISTED BELOW SHOULD REDUCE THE

CHANCE OF UNINTENDED BRAKE RELEASE OR POWERED WHEELCHAIR

MOVEMENT WHICH COULD RESULT IN SERIOUS INJURY.

1) Do not operate hand-held transceivers (transmitters receivers), such as citizens

band (CB) radios, or turn ON personal communication devices, such as cellular

phones, while the powered wheelchair is turned ON;

2) Be aware of nearby transmitters, such as radio or TV stations, and try to avoid

coming close to them;

3) If unintended movement or brake release occurs, turn the powered wheelchair

OFF as soon as it is safe;

4) Be aware that adding accessories or components, or modifying the powered

wheelchair, may make it more susceptible to EMI (NOTE: There is no easy way

to evaluate their effect on the overall immunity of the powered wheelchair); and

5) Report all incidents of unintended movement or brake release to the powered

wheelchair manufacturer, and note whether there is a source of EMI nearby.

Important Information

1) 20 volts per meter (V/m) is a generally achievable and useful immunity level

against EMI (as of May 1994) (the higher the level, the greater the protection);

2) This device has been tested to a radiated immunity level of 20 volts per meter.

3) The immunity level of the product is unknown.

Modification of any kind to the electronics of this wheelchair as manufactured by

Invacare may adversely affect the EMI immunity levels.

SECTION 3—SAFETY/HANDLING OF WHEELCHAIRS

Pronto® M51™and M61™with SureStep® 16 Part No 1125085

SECTION 3—SAFETY/HANDLING OF

WHEELCHAIRS

“SafetyandHandling”ofthewheelchairrequiresthecloseattentionofthewheelchair

useraswellastheassistant.Thismanualpointsoutthemostcommonproceduresand

techniquesinvolvedinthesafeoperationandmaintenanceofthewheelchair.Itis

importanttopracticeandmasterthesesafetechniquesuntilyouarecomfortablein

maneuveringaroundthefrequentlyencounteredarchitecturalbarriers.

Usethisinformationonlyasa“basic”guide.Thetechniquesthatarediscussedonthe

followingpageshavebeenusedsuccessfullybymany.

Individualwheelchairusersoftendevelopskillstodealwithdailylivingactivitiesthat

maydifferfromthosedescribedinthismanual.Invacarerecognizesandencourageseach

individualtotrywhatworksbestforhim/herinovercomingarchitecturalobstaclesthat

theymayencounter,howeverallWARNINGSandCAUTIONSgiveninthismanual

MUSTbefollowed.Techniquesinthismanualareastartingpointforthenewwheelchair

userandassistantwith“safety”asthemostimportantconsiderationforall.

Stability and Balance

 WARNING

ALWAYS wear your seat positioning strap. The seat positioning strap is a

positioning belt only. It is not designed for use as a safety device withstanding high

stress loads such as auto or aircraft safety belts. If signs of wear appear, belt MUST

be replaced IMMEDIATELY.

Be aware that carrying heavy objects on your lap while occupying the wheelchair

may adversely affect the stability of the wheelchair, resulting in serious bodily injury

to the user, damage to the wheelchair and surrounding property.

This wheelchair has been designed to accommodate one individual. If more than

one individual occupies the wheelchair this may adversely affect the stability of the

wheelchair, resulting in serious bodily injury to the user and passenger and damage

to the wheelchair and surrounding property.

Toassurestabilityandproperoperationofyourwheelchair,youmustatalltimes

maintainproperbalance.Yourwheelchairhasbeendesignedtoremainuprightand

stableduringnormaldailyactivitiesaslongasyoudonotmovebeyondthecenterof

gravity.DONOTleanforwardoutofthewheelchairanyfurtherthanthelengthofthe

armrests.

SECTION 3—SAFETY/HANDLING OF WHEELCHAIRS

Part No 1125085 17 Pronto® M51™and M61™with SureStep®

Coping With Everyday Obstacles

 WARNING

DO NOT attempt to reach objects if you have to move forward in the seat or pick

them up from the floor by reaching down between your knees.

Proper positioning is essential for your safety. When reaching, leaning, bending or

bending forward, it is important to use the casters as a tool to maintain stability and

balance.

Many activities require the wheelchair user to reach, bend and transfer in and out of

the wheelchair. These movements will cause a change to the normal balance, cen-

ter of gravity, and weight distribution of the wheelchair. To determine and establish

your particular safety limits, practice bending, reaching and transferring activities in

several combinations in the presence of a qualified healthcare professional before

attempting active use of the wheelchair.

NOTE:Forthisinformation,refertoFIGURE 3.1.

Copingwiththeirritationofeverydayobstaclescanbealleviatedsomewhatbylearning

howtomanageyourwheelchair.Keepinmindyourcenterofgravitytomaintainstability

andbalance.

Whilethewalkingbeamallowstotraverseuptoa2‐inchbumporthreshold,stopping

afterthewheelscrossthebumpposesaproblem.Thechaircannotreverseoverthebump

atthispoint.Continueforwardandthenturnaround.

Whilethewheelchairisdesignedforuse

primarilyinandaroundthehome,the

providershoulddeterminewhetherthis

chairissuitablefortheactualenvironment

thechairwillbeusedin.

DONOTgodownrampatfullspeed.

Someseat/backpositionswillcause

wheelchairtofeelunstable.

FIGURE 3.1 Coping With Everyday

Obstacles

CAUTION

Be aware of condition of ramp. Traction will be diminished/nonexistent on a

slippery surface. Proceed with caution.

2-inch Bump

or Threshold

SECTION 3—SAFETY/HANDLING OF WHEELCHAIRS

Pronto® M51™and M61™with SureStep® 18 Part No 1125085

A Note to Wheelchair Assistants

Whenassistancetothewheelchairuserisrequired,remembertousegoodbody

mechanics.Keepyourbackstraightandbendyourkneeswhenevertiltingwheelchairor

traversingcurbsorotherimpediments.

Also,beawareofdetachablepartssuchasarmsorlegrests.ThesemustNEVERbeused

tomovethewheelchairorasliftingsupports,astheymaybeinadvertentlyreleased,

resultinginpossibleinjurytotheuserand/orassistant(s).

Whenlearninganewassistancetechnique,haveanexperiencedassistanthelpyoubefore

attemptingitalone.

Pinch Points

 WARNING

M61 WHEELCHAIRS ONLY - Pinch point may occur when lowering the elevating

seat. Make sure the hands and body of both the occupant and attendants/bystanders

are clear of all pinch points before lowering seat.

DO NOT store or place items under the seat.

NOTE:Forthisprocedure,refertoForthisprocedure,refertoFIGURE 3.2andFIGURE 3.3on

page 19.

FIGURE 3.2 Pinch Points

Fully Elevated Seat

Pinch

Point

SECTION 3—SAFETY/HANDLING OF WHEELCHAIRS

Part No 1125085 19 Pronto® M51™and M61™with SureStep®

 WARNING

Pinch point may occur when adjusting the arm angle position (Detail “A”).

Pinch point may occur when rotating the footboard assembly (Detail “B”).

FIGURE 3.3 Pinch Points

Lifting/Stairways

 WARNING

DO NOT attempt to move an occupied power wheelchair between floors using a

stairway. Use an elevator to move an occupied power wheelchair between floors. If

moving a power wheelchair between floors by means of a stairway, the occupant

MUST be removed and transported independently of the power wheelchair.

Extreme caution is advised when it is necessary to move an unoccupied power

wheelchair up or down the stairs. Invacare recommends using two assistants and

making thorough preparations.

Use only secure, nondetachable parts for hand-hold supports.

It is strongly recommended to lift the wheelchair only by the rear frame and the

front forks - otherwise injury or damage may occur.

DO NOT attempt to lift the wheelchair by any removable (detachable) parts.

Lifting by means of any removable (detachable) parts of a wheelchair may result in

injury to the user or damage to the wheelchair.

The weight of the wheelchair with batteries and without the user is 212 lbs. Use

proper lifting techniques (lift with your legs) to avoid injury.

NOTE:Forthisprocedure,refertoFIGURE 3.4onpage 20.

Followthisprocedureformovingthewheelchairbetweenfloorswhenanelevatorisnot

availableorliftingthewheelchairisnecessary:

NOTE:Whenusingastairwaytomovethewheelchair,seatandanyaccessories,moveall

wheelchaircomponentsawayfromthestairwaypriortoreassembly.

Pinch

Point

Pinch

Point

DETAIL “A” DETAIL “B”

SECTION 3—SAFETY/HANDLING OF WHEELCHAIRS

Pronto® M51™and M61™with SureStep® 20 Part No 1125085

NOTE:Thisprocedureneedstwoassistantstoliftthewheelchairtotransportit.

1. Removetheoccupantfromthewheelchair.

2. Removetheseat.RefertoRemoving/InstallingtheSeatAssemblyonpage 42.

3. Removeanyaccessoriesonthewheelchair.

4. Bendyourkneesandkeepyourbackstraight.

5. EnsurethatthecastersareorientedasshowninFIGURE 3.4.

6. Usingtherearandfrontforksashandholdsupports,transferthewheelchairbaseto

desiredlocation.RefertoFIGURE 3.4.

7. Usingnon‐removable(nondetachable)parts,transfertheseatandanyaccessoriesto

desiredlocation.

8. ReinstallanyaccessoriesthatwereremovedinSTEP3.

9. Reinstalltheseat.RefertoRemoving/InstallingtheSeatAssemblyonpage 42.

FIGURE 3.4 Lifting/Stairways

 WARNING - ESCALATORS

DO NOT use an escalator to move a wheelchair between floors. Serious bodily

injury may occur.

Transferring To and From Other Seats

 WARNING

ALWAYS turn the wheelchair power Off and engage the Motor Release Levers to

prevent the wheels from moving before attempting to transfer in or out of the

wheelchair. Also, make sure every precaution is taken to reduce the gap distance by

aligning both the front and rear casters parallel with the object you are transferring

onto.

CAUTION

When transferring, position yourself as far back as possible in the seat. This will pre-

vent broken screws, damaged upholstery and the possibility of the wheelchair tip-

ping forward.

Front Fork

(Front Edge)

Rear

Frame

Page is loading ...

Invacare Pronto M61 User manual

Brand: Invacare

Model: Pronto M61

Category: Oxygen Equipment

Type: User manual

Download PDF

report

Invacare Pronto M61 User manual

Invacare Pronto M61 User manual

Related papers

Other documents