Global CEG Series Convector User manual

IMPORTANT

Do not obstruct the front of the heater

for at least 48 in. (1200 mm).

INSTALLATION

INSTRUCTIONS

CAUTION: Usesupplywiressuitablefor90°C(194°F).

- For bathroom use, the heater must be installed so that

 switchesandothercontrolscannotbetouchedbyanyone

 inthebathorshower.

SURFACE WALL MOUNTING;

1- Locateapproximatelythepowersupplyleadsbehindthe

planned location of the heater. Recommended clearance

below heater base to oor is 4 in. (102 mm) minimum.

Allow4in.(102mm)minimumclearancebetweensides

ofheaterandanyadjacentwalls.Theleadsshallbeatthe

rightofthewallbracket.

2- Leanthebottomofthewallbracketontheoorandmark

with a pencil the height desired (of the heater bottom)

usingthewholeswithincheswrittenontheside.

3- Securewallbracketwiththe4screwssupplied.Thebottom

ofthekeyholesshallbeinlinewiththepreviousmarks.

Trianglemarkonhorizontalbaristhecenteroftheheater.

Beforeinstallingwallsupport,aligncenterofheaterwith

supportcentermarkandmakesuretheheatersidesareat

least4in.(102mm)fromanyadjacentwalls.

4- Untighten wire holder (for Loomex cable) and make

electrical connections by having the heater the nearest

possibletotheelectricalwire.ForBXcable,removeoneof

thetwoknock-outs,installaconnector(notfurnished)and

have6to8in.(15to20cm)offreewireandgetthemout

oftheholeofthewireholderinordertomakeconnections

fromoutside.Donotforgettoconnectthegreenwireto

groundwireinordertohaveasafegroundedheater.

5- Once connections completed, place bottom T slots in the

base part of support, and clip the upper side of the body in

the upper U shape part of the support.

6- Donotlettheexcessofthesupplywirecomeincontact

withthebackoftheheater,aswellasanyotherobject.

7- Putthemainpoweron.

CAUTION:

Hightemperature,riskofre,keepelectricalcords,drapery,

furnishings, and other combustibles at least 36 in. (915 mm)

fromthefrontoftheheaterandawayfromthesides.Toreduce

theriskofre,donotstoreorusegasolineorotherammable

vapors and liquids in the vicinity of the heater.

1 800 463-7043 • www.globalcommander.ca

INSTALLATION INSTRUCTIONS

Convector “CEG” Series

Read carefully these instructions before installation, operation of the

heater. Failure to adhere to the instructions could result in re, electric

shock, serious personal injury, and death or property damage. Review

frequently for continuing safe operation and instruction of future users,

if necessary.

IMPORTANT

INSTRUCTIONS

1- Read all instructions before installing or using this heater.

2- Thisheaterishotwheninuse.To avoid burns, do not let bare skin

touchhotsurfaces.Keepcombustiblematerials,likefurniture,pillows,

bedding, papers, clothes, and curtains at least 36 in. (915 mm) from the

frontoftheheaterandawayfromthesides.

3- Extreme caution is necessary when any heater is used by or near

children or invalids and whenever the heater is left operating and

unattended.

4- Donotoperateanyheaterafteritmalfunctions.Disconnectpower

at service panel and have heater inspected by a reputable electrician

before reusing.

5- Do not use outdoors.

6- Todisconnectheater,turnopowertoheatercircuitatmaindisconnect

panel.

7- Donotinsertorallowforeignobjectstoenteranyexhaustopeningas

thismaycauseanelectric shockorre,ordamagetheheater.

8- Donotblockairintakesorexhaustinanywaywhatsoever.

9- Thisheaterhashotandarcingorsparkingpartsinside.Donotuseitin

areaswheregasoline,paint,orammableliquidsareusedorstored.

10- Use this heater only as described in this manual. Any other use not

 recommendedbythemanufacturermaycausere,electricshock,or

injury.

11- AMERICAN VERSION ONLY: Some models (up to 240V) include

avisualalarmtowarnthatpartsoftheheateraregettingexcessively

hot.Ifthelightturnson,immediatelyturntheheateroandinspect

for any objects on or adjacent to the heater that may have blocked

the airow or otherwise caused high temperatures to have occured.

If no obstruction is visible, the heater must be checked by a quali-

ed person. DO NOT OPERATE THE HEATER WHEN THE

ALARM LIGHT IS ON.

12- The thermostat should not be considered an infallible device in cases

where maintaining a temperature is considered critical. Examples:

Hazardous material storage, computer server room, etc. In these

particular cases, it is imperative to add a monitoring system to avoid

the consequences of a thermostat failure.

INS420-201402-03

MAINTENANCE

INSTRUCTIONS

1- Once a year, remove the front panel and use a vacuum cleaner

to remove the dust accumulation inside the heater and through

openings of the front panel.

2- Cleaningshouldbedonewhiletheheaterisdisconnectedfrom

the main service panel. Wait until the housing and heating

element cool before performing maintenance.

3- Replace the front panel before energizing.

4- Any other servicing should be performed by a qualified

technician.

WARRANTY

Pleaserefertothespecicationsheetatwww.globalcommander.ca.

WARNING

Whenusingelectricalappliances,basicprecautionsshouldalwaysbetaken

toreducetheriskofre,electricalshockandinjury,includingthefollowing.

OPERATING

INSTRUCTIONS

- The heater must be properly installed before it is used.

- Turnthepoweronatthecircuitbreakerpanel.

- Electronic thermostat: Set the thermostat temperature at the

wantedroomtemperature

CONTROL:

Modelwithbuilt-inelectronicthermostat:

Theelectronicthermostatshallkeeptheroomtemperatureinarange

of±1°C(±2°F)unlesstheroomisnotwellinsulatedortheheater

istooornotenoughpowerfulfortheroom.

Modelwithoutcontrol:

Maintain room temperature by a line-voltage wall thermostat

approved for residential heating. Even if it is not mandatory, an

electronic thermostat gives better performance than a conventional

thermostat.

4 5

4’’

(102 mm)

minimum

4’’ (102 mm)

minimum

4’’

(102 mm)

minimum

TOP

HAUT

TOP

HAUT

HAUT - TOP

CENTRE

DETAIL A

Mark

the height

desired

Center mark

Center

1 2

THERMOSTAT

L1 L2

Load 1Load 2

Wiring Diagram:

Model with built-in

electronic thermostat

American version only

up to 240V

L2/N

Wiring Diagram:

Model without control

American version only

up to 240V

SAVE THESE INSTRUCTIONS

OPTIONS:

All heating equipment and options must be installed in

accordancewithlocalandnationalcodes.

Built-in relay:

-Refertothediagramincludedwiththerelayoptionfor

connections.

-Refertoinstructionssuppliedwiththeoptionformounting.

Global CEG Series Convector User manual

Other documents