PPE 128052000 Installation guide

Brand
PPE
Model
128052000
Type
Installation guide
Standard Prole Transmission Pan
PPEpower.com
Rev: 02/01/22 | v6
Standard Prole
Heavy-Duty Cast Aluminum
Transmission Pan
GM Allison 1000/2000/2400 Series
(128052000, 128052010, 128052020)
Installation Guide
Standard Prole Transmission Pan
NOTICE:
 ThePPETransmissionPanisdesignedtotthefactoryAllison1000transmis-
sion(suppliedasoriginalequipment).However,insomeapplications,orbecauseofthe
useofcertainfactoryoptionsand/orafterequipment,theremaybeclearanceproblems
betweenyourPPETransmissionPanandothervehiclecomponents.Itistheresponsibil-
ityofthevehicleownerandinstallertoensurethatthereisnocontactbetweenthepan
andothermovingorxedvehiclecomponents.Contactwithanyvehiclecomponentorthe
modifyingofthePPETransmissionPanvoidsthepanwarranty.PPEassumesnoliability,
expressedorimplied,fordamageorinjurytopersonsorproperty.
KIT INCLUDES:
(1) TransmissionPan
(1) 1/8”PipePlug(installed)
(1) 1/4”PipePlug(installed)
(1) MagneticDrainPlug(installed)-torque17ft.lbs.
(12) AllenBolts-torque15ft.lbs.
TOOLS AND PARTS REQUIRED:
 TorqueWrench
 1/4”Ratchet
 1/4”Extension
 1/4”Drive6mmAllenSocket
 17mmSocketforService/Draining
 OilDrainPan
 ShopTowels
 Gloves
 EyeProtection
Step 1:
 Drainandrecycleoil.
Removestockbolts.
Cleanmatingsurface.
Step 2:
 Cleanreusablegasket
andsettothesidefor
reassemblyinStep6.
Standard Prole Transmission Pan
Step 3:
 Removelterby
grippingasshownand
pullingstraightout.
Step 4:
 Removeorangelterseal
 fromthetransmission
 housing.
Step 5:
 Insertthenewlter.
 Makesureitisinstraight.
Step 6:
 Placeclean,reusable
gasketonpan.
Standard Prole Transmission Pan
Step 8:
 Installremainingbolts.Torqueboltsto15ft.lbs.
usingthecrossing-patternsequenceshownbelow.
 Fillwithrecommendeduid.Checkforleaks.
Step 7:
 Place2boltsthrugasketand
pantoholdgasketinplace.
Holdassemblyandpositionto
alignwithtransmissioncase.
Tightentwoboltsngertightto
holdinplace.
PPEpower.com
DISCLAIMER OF LIABILITY
Performanceproductscanincreasehorsepoweraboveandbeyondfactoryspecications.
Additionalhorsepowercreatesmorestressonthedrive-traincomponents,whichcouldresultin
drive-trainfailure.
Noteregardingemissions-related,non-E.O.-legalproducts:THESEPRODUCTSARE
LEGALINCALIFORNIAONLYFORRACINGVEHICLESTHATMAYNEVERBEUSED,OR
REGISTEREDORLICENSEDFORHIGHWAYOROFF-ROADUSE.
ThisagreementsetsforththetermsandconditionsfortheuseofPPEproducts.Theinstallation
ofthisproductindicatesthattheBuyerhasreadandunderstandsthisagreementandaccepts
thetermsandconditions.PPE(PacicPerformanceEngineering)Inc.,itsdistributors,
employees,anddealers(the“Seller”)shallnotberesponsiblefortheproduct’sproperuse
andservice.Thebuyerherebywaivesallliabilityclaims.TheBuyerherebyacknowledgesno
relianceontheSeller’sskillorjudgmenttoselectorfurnishgoodssuitableforanyparticular
purposeandthattherearenoliabilitieswhichextendbeyondthedescriptiononthefacehereof,
andtheBuyerherebywaivesallremediesorliabilitiesexpressedorimplied,arisingbylawor
otherwise(includingwithoutanyobligationoftheSellerwithrespecttotness,merchantability
andconsequentialdamages),orwhetherornotoccasionedbytheSeller’snegligence.
TheSellerdisclaimsanywarrantyandexpresslydisclaimsanyliabilityforpersonalinjuryor
damages.TheBuyeracknowledgesandagreesthatthedisclaimerofanyliabilityforpersonal
injuryisamaterialtermforthisagreementandtheBuyeragreestoindemnifytheSellerandto
holdtheSellerharmlessfromanyclaimrelatedtotheitemofequipmentpurchased.Underno
circumstanceswilltheSellerbeliableforanydamagesorexpensesbyreasonofuseorsale
ofanysuchequipment.TheSellerassumesnoliabilityregardingtheimproperinstallationor
misapplicationofitsproducts.Itistheinstaller’sresponsibilitytocheckforproperinstallationand
ifindoubt,contactthemanufacturer.TheBuyerissolelyresponsibleforallwarrantyissuesfrom
themanufacturer.
LIMITATION OF WARRANTY
TheSellergivesLimitedWarrantyastodescription,quality,merchantability,andtnessfora
particularpurpose,productiveness,oranyothermatterofSeller’sproductsoldherewith.The
SellershallnotberesponsiblefortheproductsproperuseandserviceandtheBuyerhereby
waivesallrightsotherthanthoseexpresslywrittenherein.Thiswarrantyshallnotbeextended,
alteredorvariedexceptbyawritteninstrumentsignedbySellerandBuyer.
LimitedlifetimewarrantyonallPPEcastaluminumproducts,andPPETransmissionCoolers.
Three(3)yearlimitedwarrantyonPPEManifoldsandUp-PipesKits,andOEM-Length
Up-Pipes.One(1)yearlimitedwarrantyonallotherPPEproductsfromthedateofsaleto
originalbuyerandlimitedsolelytothepartscontainedwithintheproductskit.Allproductsthat
areinquestionofWarrantymustbereturnedprepaidtotheSellerandmustbeaccompanied
byadatedproofofpurchasereceipt.AllWarrantyclaimsaresubjecttoapprovalbySeller.
UndernocircumstanceswilltheSellerbeliableforanylaborchargedortraveltimeincurred
indiagnosisfordefects,removal,orre-installation-ofthisproductoranyothercontingent
expenses.UndernocircumstanceswilltheSellerbeliableforanydamageorexpensesincurred
byreasonoftheuseorsaleofanysuchequipment.Intheeventthatthebuyerdoesnotagree
withthisagreement:thebuyermaypromptlyreturnthisproduct,inanewandunusedcondition
initsoriginalpackaging,withadatedproofofpurchasetotheplaceofpurchasewithinten(10)
daysfromdateofpurchaseforafullrefund.Theinstallationofthisproductindicatesthatthe
buyerhasreadandunderstandsthisagreementandacceptsitstermsandconditions.
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8

PPE 128052000 Installation guide

Brand
PPE
Model
128052000
Type
Installation guide
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents