2. ORO-Tek
  3. OTI-001B

ORO-Tek OTI-001B User guide

  • Hello! I am an AI chatbot trained to assist you with the ORO-Tek OTI-001B User guide. I’ve already reviewed the document and can help you find the information you need or explain it in simple terms. Just ask your questions, and providing more details will help me assist you more effectively!
Page 1
TPMS Relearn Procedure - Chysler/Dodge/Jeep/RAM
Applications
Required Tools
NONE
Preparation
Review all data in your owner's manual pertaining to the TPMS System
Installation
○ InstallSensors-ProperlyInstalltirepressuresensors.
○ TirePressure-Conrmalltiresareinatedtothepressureindicatedonthetirepressureplacard.(Placard
islocatedonthedriver'ssidedoorjambofvehicle)
This is a sample Tire Pressure Placard. Not for this specic vehicle.
○ EliminateInterference-ToensurethecontrolunitmemorizesthecorrectsensorID's,thevehiclewitha
newsensormustbeatleast3m(10ft.)fromanyotherTPMSpressuresensornotinstalledonthatvehicle.
Relearn
VehiclesTPMSSystemwillRe-LearntheSensorID’swhenthevehicleisdrivenabove30mphfor
approximately15minutes.
DISCLAIMER:
Allinformationistobeusedasareferenceonly.Vehicleinformationiscompiledfromavailablemanufacturersourcesbutaccuracyisnotguaranteed.
Theapplicationinformationpresentedinthisdocumentisaccuratetothebestofourknowledgeandisregularlyupdatedwiththelatestdataavailablein
themarketplace.Duetothevastnumberofcarmodelsandsparepartsfromnumerousvehiclemanufacturerstheexactapplicationofpartsisnotalways
feasible.Alwaysreferenceourwebsiteforthemostuptodatedata.Damageclaimsonthebasisofdatainthiscatalogwillnotbeconsidered.
©RevolutionSupplyCo.Inc.2013
NOTE: ThisStepshouldbeperformedonlybyatechnicianwhohasbeenproperlytrainedintheoperation
andinstallationofTPMSSystems.
For Technical Assistance call 1-877-738-9990 option 4
TPMS Relearn Procedure - Ford/Lincoln/
Mercury Applications
Required Tools
OEMTriggerTool-ASpecialTPMSresettooltoresetFordTPMSisprovidedwithvehiclesthathavedierentfrontandrear
tirepressures.ThetoolisprovidedbythemanufacturerandmaybelocatedinsidetheOwner'sGuideJacket
or
Properlyformattedscantoolcanbeused.
Preparation
1.Reviewalldatainyourowner'smanualpertainingtotheTPMSSystem
2.VerifyvehicleapplicationiscoveredbyTriggerTool
3.UpdateTriggerToolSoftware
4.VerifythattheTriggerToolisworkingproperly(replacebatteryifnecessary)
Installation
○ InstallSensors-ProperlyInstalltirepressuresensors.
○ TirePressure-Conrmalltiresareinatedtothepressureindicatedonthetirepressureplacard.(Placard
islocatedonthedriver'ssidedoorjambofvehicle)
This is a sample Tire Pressure Placard. Not for this specic vehicle.
○ EliminateInterference-ToensurethecontrolunitmemorizesthecorrectsensorID's,thevehiclewitha
newsensormustbeatleast3m(10ft.)fromanyotherTPMSpressuresensornotinstalledonthatvehicle.
Relearn - NOTE: Steps 1-6 must be completed within 60 seconds.
1. PlacetheignitionintheOFFpositionandkeepthekeyintheignition.
2. Pressanreleasebrakepedal
3. CycletheignitionfromOFFtoRUNthree(3)timesendingintheRUNposition
DONOTstarttheengine.
4. Pressandholdthebrakepedalfortwo(2)seconds,thenrelease.
5. TurnignitionOFF-DONOTremovekey.
6. CycletheignitionfromOFFtoRUNthree(3)timesendinginRUN-DONOTstarttheengine.
NOTE: If the reset mode has been entered successfully, the horn will sound once. e TPMS indi-
cator will ash and, (if equipped), the message center will display [TRAIN LEFT FRONT TIRE]. A
double horn chirp will indicate you need to repeat the process
NOTE: ThisStepshouldbeperformedonlybyatechnicianwhohasbeenproperlytrainedintheoperation
andinstallationofTPMSSystems.
TPMS Relearn Procedure - Ford/Lincoln/
Mercury Applications
7. PlacetheActivationToolonthesidewalloftheLeftFrontTireattheValveStemandpressthebuttonontheActivation
Tool.ThehornwillsoundtoindicatethatthetirepressuresensorhasbeenrecognizedbytheEngineControlUnit(ECU).
8. Repeattheprocessoutlinedinstep7onRightFront,RightRear,andLeftRearTires.
9. WhentheResetProcedureiscomplete,thehornwillsoundindicatingtheprocessiscompleteandthemessagecenter,(if
equipped)willdisplay“TIRETRAININGCOMPLETE”.
Reset Procedure with Push Button
1. TurnignitiontoOFFposition.
2. Pushandreleasebrakepedal.
3. UsingthePush-Button,pressoncetoturnON,thepressagaintoputvehicleintoACCmode,
thenpushagaintoturnOFF.Repeatthisprocess2moretimesendingonACC.
4. Pressandreleasebrakepedal,thenpressPush-ButtononcetoturnOFF.
5. UsingthePush-Button,pressoncetoturnON,thepressagaintoputvehicleintoACCmode,
thenpushagaintoturnOFF.Repeatthisprocess2moretimesendingonACC.
6. PlacetheActivationToolonthesidewalloftheLeftFrontTireattheValveStemandpressthebuttonontheActivation
Tool.ThehornwillsoundtoindicatethatthetirepressuresensorhasbeenrecognizedbytheEngineControlUnit(ECU).
NOTE:Donotwaitmorethantwo(2)minutesbetweenresettingeachtiresensororthesys-
temwilltimeoutandtheentireprocedurewillhavetoberepeatedonallfourwheels.
NOTE: IftheECUdoesnotrecognizeanyofthe4tirepressuresensorsduringtheresetprocedure,the
hornwillsoundtwiceandthemessagecenter,(ifequipped)willdisplay"TIRENOTTRAINEDREPEAT".If
thisoccurs,resetproceduremustberepeatedfromthebeginning
TPMS Relearn Procedure - Ford/Lincoln/
Mercury Applications
7. Within2minutesafterthehornsounds,placetheactivationtoolontherightfronttiresidewallatthevalvestem.Press
thebuttonontheActivationTool.Thehornwillsoundtoindicatethatthetirepressuresensorisrecognizedby
theSJB.Repeattheprocedureforrightrearandleftreartires.
9. WhentheResetProcedureiscomplete,themessagecenter,(ifequipped),willdisplay,“TIRETRAININGCOMPLETE.
Forvehiclesnotequippedwithamessagecenter,successfulcompletionoftheResetProcedurewillbeveried
byreturningtheignitiontotheOFFpositionwithoutthehornsounding.Ifthehornsoundstwicewhenignitionisreturned
toOFFposition,thisindicatethattheResetProcedurewasnotsuccessful.Youwillberequiredtorepeatstep1-8.
DISCLAIMER:
Allinformationistobeusedasareferenceonly.Vehicleinformationiscompiledfromavailablemanufacturersourcesbutaccuracyisnotguaranteed.Theapplica-
tioninformationpresentedinthisdocumentisaccuratetothebestofourknowledgeandisregularlyupdatedwiththelatestdataavailableinthemarketplace.Due
tothevastnumberofcarmodelsandsparepartsfromnumerousvehiclemanufacturerstheexactapplicationofpartsisnotalwaysfeasible.Alwaysreferenceour
websiteforthemostuptodatedata.Damageclaimsonthebasisofdatainthiscatalogwillnotbeconsidered.
©RevolutionSupplyCo.Inc.2013
NOTE:Donotwaitmorethantwo(2)minutesbetweenresettingeachtiresensororthesys-
temwilltimeoutandtheentireprocedurewillhavetoberepeatedonallfourwheels.
NOTE: IftheSJBdoesnotrecognizeanyofthe4tirepressuresensorsduringtheresetprocedure,the
hornwillsoundtwiceandthemessagecenter,(ifequipped)willdisplay"TIRENOTTRAINEDREPEAT".If
thisoccurs,resetproceduremustberepeatedfromthebeginning
For Technical Assistance call 1-877-738-9990 option 4
TPMS Relearn Procedure - GM Applications
Required Tools
Properlyformattedscantoolortriggertool.
Preparation
1.Reviewalldatainyourowner'smanualpertainingtotheTPMSSystem
2.VerifyvehicleapplicationiscoveredbyTriggerTool
3.UpdateTriggerToolSoftware
4.VerifythattheTriggerToolisworkingproperly(replacebatteryifnecessary)
Installation
○ InstallSensors-ProperlyInstalltirepressuresensors.
○ TirePressure-Conrmalltiresareinatedtothepressureindicatedonthetirepressureplacard.(Placard
islocatedonthedriver'ssidedoorjambofvehicle)
This is a sample Tire Pressure Placard. Not for this specic vehicle.
○ EliminateInterference-ToensurethecontrolunitmemorizesthecorrectsensorID's,thevehiclewitha
newsensormustbeatleast3m(10ft.)fromanyotherTPMSpressuresensornotinstalledonthatvehicle.
Relearn
STANDARD IGNITION
1. Engageparkingbrake.
2. TurnignitionswitchtoONposition(engineo).
3. EnterRe-LearnMode
Remote Keyless Entry (RKE) Method
Pressandholdthetransmitter’sLOCKandUNLOCKbuttonsatthesametimeforapproximately5seconds.Thehornwill
soundtwiceandtheLeftFrontTurnSignalwillilluminatetoindicatethatthereceiverisinthelearningmode.“TIRELEARN-
INGACTIVE”willbedisplayedontheDIC,Driver’sInformationScreen.Proceedtostep4.
Driver Information Center (DIC) Method
PresstheDriverInformationCenter(DIC)vehicleinformationbuttonuntilthePRESS?TORELEARNTIREPOSITIONS
messagedisplays.ThehornwillsoundtwiceandtheLeftFrontTurnSignalwillilluminatetoindicatethatthereceiverisin
thelearningmode.“TIRELEARNINGACTIVE”willbedisplayedontheDIC,Driver’sInformationScreen.Proceedtostep4
Trip Odometer Method
PressthetripodometerresetstemlocatedontheinstrumentpanelclusteruntilthePRESS?TORELEARNTIREPOSI-
TIONSmessagedisplays.ThehornsoundstwicetosignalthereceiverisinrelearnmodeandTIRELEARNINGACTIVE
messagedisplaysontheDICscreen.Proceedtostep4.
NOTE: ThisStepshouldbeperformedonlybyatechnicianwhohasbeenproperlytrainedintheoperation
andinstallationofTPMSSystems.
TPMS Relearn Procedure - GM Applications
WITH PUSH BUTTON IGNITION
● Pressandholdthepushbuttonstartuntilthevehicleisinaccessorymode.
● PresstheMENUbuttonlocatedontheturnsignalleveruntil"VEHICLEINFORMATIONMENU"isdisplayed.
● OnceyouareintheVEHICLEINFORMATIONMENU,usethearrowbuttonsontheturnsignalleveruntiltheDIC
displaysthevehicle'stireinationpressuresandpositions.
● Pressandholdthebuttonlocatedontheendoftheturnsignalleveruntil"Areyousurethatyouwanttorelearn?
YESorNO"isdisplayed.
● UsethearrowbuttonsontheturnsignallevertohighlightYES.OnceYESishighlighted,pressthebuttonlocated
ontheendoftheturnsignallever.Thehornwillsoundtwiceanftheleftfrontturnsignalwillilluminateto
indicatethatthereceiverisinlearningmode."TIRELEARNINGACTIVE"willbedisplayedontheDIC,
driver'sInformationScreen.ProceedtoStep4.
4. StartingwithLFtire,increase/decreasetirepressureuntilhornsoundsorplacescantoolnearthesensorandpressthe
activate/triggerbutton.
5. Afterhornsounds,repeatthepreviousstepforthenext3sensorsinthefollowingorder:RightFront,RightRear,andLeft
Rear.AfterLeftReartirehasbeenlearned,thehornwillsoundtwiceindicatingthatall4sensorID’shavebeenlearned.Thelearn
modeisnolongeractiveandtheTIRELEARNINGACTIVEmessageontheDICwillgoo.
6. TurnignitiontoOFFposition.Adjustalltirestopressurelistedontirepressureplacard.
NOTE: IfnotireslearnedarelearnedafterenteringtheTPMSintoLearnMode,orifcommunicationwiththereceiverstops,orif
thetimelimithasexpired,turntheIgnitionSwitchtoLOCK/OFFandstartoveratstep2.
DISCLAIMER:
Allinformationistobeusedasareferenceonly.Vehicleinformationiscompiledfromavailablemanufacturersourcesbutaccuracyisnotguaranteed.Theapplica-
tioninformationpresentedinthisdocumentisaccuratetothebestofourknowledgeandisregularlyupdatedwiththelatestdataavailableinthemarketplace.Due
tothevastnumberofcarmodelsandsparepartsfromnumerousvehiclemanufacturerstheexactapplicationofpartsisnotalwaysfeasible.Alwaysreferenceour
websiteforthemostuptodatedata.Damageclaimsonthebasisofdatainthiscatalogwillnotbeconsidered.
©RevolutionSupplyCo.Inc.2013
NOTE:Youmustuseascantooltotrigger/activatetheTPMSsensorsonall2012andnewermodelyearGMvehicles.
Increasing/Decreasingtheairpressurewillnottrigger/activatethesensors.
NOTE:OnCadillacmodelsyouwillknowwhenyouareinaccessory
modewhentheCadillacemblemappearsontheDIC.
For Technical Assistance call 1-877-738-9990 option 4
TPMS Relearn Procedure - Import Applications
Required Tools
Properlyformattedscantoolortriggertool.
Preparation
1.Reviewalldatainyourowner'smanualpertainingtotheTPMSSystem
2.VerifyvehicleapplicationiscoveredbyTriggerTool
3.UpdateTriggerToolSoftware
4.VerifythattheTriggerToolisworkingproperly(replacebatteryifnecessary)
Installation
○ InstallSensors-ProperlyInstalltirepressuresensors.
○ TirePressure-Conrmalltiresareinatedtothepressureindicatedonthetirepressureplacard.(Placard
islocatedonthedriver'ssidedoorjambofvehicle)
This is a sample Tire Pressure Placard. Not for this specic vehicle.
○ EliminateInterference-ToensurethecontrolunitmemorizesthecorrectsensorID's,thevehiclewitha
newsensormustbeatleast3m(10ft.)fromanyotherTPMSpressuresensornotinstalledonthatvehicle.
Relearn
1. Followingtheinstructionssuppliedbythemanufacturerofyourproperlyformattedscantool.ReadthesensorID's
intoyourscantoolstartingwiththeleftfronttire,contacttiresidewallnearairvalveandpresstheswitchtolearnthe
sensorid.
2. PlacetheactivationtoolonthewalloftheLEFTFRONTtireatthevalvestemandpressthetestbuttonontheacti
vationtool.
3. PlacetheactivationtoolonthewalloftheRIGHTFRONTtireatthevalvestemandpressthetestbuttononthe
activationtool.
4. PlacetheactivationtoolonthewalloftheRIGHTREARtireatthevalvestemandpressthetestbuttonontheacti
vationtool.
5. PlacetheactivationtoolonthewalloftheLEFTREARtireatthevalvestemandpressthetestbuttonontheacti
vationtool.
NOTE: ThisStepshouldbeperformedonlybyatechnicianwhohasbeenproperlytrainedintheoperation
andinstallationofTPMSSystems.
TPMS Relearn Procedure - Import Applications
6. PlugtheOBDadapterintotheOBDplugunderyourdash.TurnignitiontoONposition(engineo).Followingtheinstruc
tionssuppliedbythemanufacturerofyourproperlyformattedscantool.ReadthesensorID’sintotheelectronic
controlunit(ECU)ofyourvehicle.
DISCLAIMER:
Allinformationistobeusedasareferenceonly.Vehicleinformationiscompiledfromavailablemanufacturersourcesbutaccuracyisnotguaranteed.Theapplica-
tioninformationpresentedinthisdocumentisaccuratetothebestofourknowledgeandisregularlyupdatedwiththelatestdataavailableinthemarketplace.Due
tothevastnumberofcarmodelsandsparepartsfromnumerousvehiclemanufacturerstheexactapplicationofpartsisnotalwaysfeasible.Alwaysreferenceour
websiteforthemostuptodatedata.Damageclaimsonthebasisofdatainthiscatalogwillnotbeconsidered.
©RevolutionSupplyCo.Inc.2013
NOTE:IftherethesparetirehasaTPMSsensorinstalledthenplacetheactivationtoolonthewall
oftheSPAREtireatthevalvestemandpressthetestbuttonontheactivationtool.
For Technical Assistance call 1-877-738-9990 option 4
/