Brinly-Hardy BB-56 Owner's manual

Brand: Brinly-Hardy

Model: BB-56

Type: Owner's manual

L-1434 Rev. B

Owner's Manual

42" Grader Blade

MODEL:

BB-56

• Assembly

• Installation

• Operation

• RepairParts

Recommended for use with Garden Tractors with Grader

Blade. Tire chains and wheel weights are recommended.

This manual contains information for the safety

of persons and property. Read it carefully before

assembly and operation of the equipment!

Visit us on the web!

www.brinly.com

For the latest product updates and setup tips:

IMPORTANT

L-1434 Rev. B

INTRODUCTION

SAFETY

CONGRATULATIONSonthepurchaseofyournewBrinly-HardyGrader

Blade!YourGraderBladeisdesigned,engineeredandmanufacturedto

giveyouthebestpossibledependabilityandperformance.

CUSTOMER RESPONSIBILITIES

Pleasereadandretainthismanual.Theinstructionsenablesyouto

assembleandmaintainyourGraderBladeproperly.Andplease,always

observethe“Safety”instructions.

TABLE OF CONTENTS

SAFETY......................................................................................... 2-3

PARTSBREAKDOWN................................................................. 4-5

ASSEMBLY................................................................................... 5-6

ADJUSTMENT..................................................................................7

OPERATIONANDMAINTENANCE.................................................7

WARRANTY......................................................................Backpage

PRODUCT COMPATIBILITY

ThisGraderBladeisdesignedforusewithgardentractorsequippedwith

SleeveHitch.Also,tirechainsandwheelweightsarerecommended.

RECORD PURCHASE INFORMATION

Recordyourpurchaseinformationinthespacesprovidedbelow:

DATEOFPURCHASE:

COMPANYNAME:

COMPANYPHONE:

SERIALNUMBER:



SAFETY LABELS

UNDERSTANDING THE MACHINE SAFETY LABELS:

Themachinesafetylabelsshowninthissectionareplacedinimportant

areasonyourmachinetodrawattentiontopotentialsafetyhazards.

Onyourmachinesafetylabels,thewordsDANGER,WARNING,and

CAUTIONareusedwiththissafety-alertsymbol.DANGERidentiesthe

mostserioushazards.

Theoperator'smanualalsoexplainsanypotentialsafetyhazards

whenevernecessaryinspecialsafetymessagesthatareidentiedwith

theword,CAUTION,andthesafety-alertsymbol.

SAFETY ALERT SYMBOL

L-1434 Rev. B

SAFETY

TO HELP PREVENT BODILY INJURY DUE TO LOSS

OF STABILITY OR CONTROL:

• Readthevehicle'sowner'smanual,yourtractor'sowner's

manual,andthisowner'smanualbeforeusingthis

GraderBlade.

• Knowcontrolsandhowtostopquickly.

• Donotallowchildrentooperatethevehicle,donotallow

adultstooperatewithoutproperinstructionandwithout

havingreadtheowner'smanual.

• Donotcarrypassengers.Keepchildrenandpetsasafe

distanceaway.

• Alwayswearsubstantialfootwear.Donotwearloose

ttingclothingthatcangetcaughtinmovingparts.

• Keepyoureyesandmindonyourtractor/attachmentand

areabeingcovered.Don'tletotherinterestsdistractyou.

• Stayalertforholesintheterrainandotherhidden

hazards.

• Keepthevehicleandattachmentsingoodoperating

conditionandkeepsafetydevicesinplace.

• Keepallnuts,boltsandscrewstighttobesurethe

equipmentisinsafeworkingcondition.

• Thevehicleandattachmentsshouldbestoppedand

inspectedfordamageafterstrikingaforeignobject.

Thedamageshouldberepairedbeforerestartingand

operatingtheequipment.

• Seetractorequipmentowner'smanualforsafeoperation

oftheequipment.

• Donotdriveclosetocreeks,ditchesandpublic

highways.

• Watchoutfortrafcwhencrossingornearroadways.

• Beforeloweringoroperatinganyattachments,ensure

bystandersarenotnearthevehicle.

• LowertheGraderBladeandimplementwhenleaving

vehicleunattended.

• Stoppingdistanceincreaseswithspeedandweight

ofattachment.Travelslowlyandallowextratimeand

distancetostop.

• Attachmentsintheraisedandloweredpositioncan

causelossoftractionandlossofcontrolonslopes.Stay

offsteepslopes.

SAFETY

Readthegeneralsafetyoperatingprecautionsinyourtowing

vehicleoperator'smanualforadditionalsafetyinformation.

PROTECT BYSTANDERS

• Keepbystandersawaywhenyouoperatethismachine.

Beforeyoubacklookcarefullybehindforbystanders.

• Beforeyouoperateanyfeatureofthismachine,observe

yoursurroundingsandlookforbystanders.

OPERATE SAFELY

• Usethismachineforintendedpurposeonly.

• Travelspeedshouldalwaysbeslowenoughtomaintain

control.Attachmentsinraisedandloweredpositioncan

changestabilityoftractor.

• Travelslowlyoverroughground.

• Donotletchildrenoranuntrainedpersonoperate

machine.

• Donotletanyone,especiallychildren,rideonthis

GraderBladeorthetowingvehicle.

• Checkvehiclebrakeactionbeforeyouoperate.Adjustor

servicebrakesasnecessary.

• Keepallpartsingoodconditionandproperlyinstalled.

Fixdamagedpartsimmediately.Replacewornor

brokenparts.Replaceallwornordamagedsafetyand

instructiondecals.

• DonotmodifytheGraderBladeorsafetydevices.

UnauthorizedmodicationstothevehicleorGrader

Blademayimpairitsfunctionandsafety,andvoidthe

warranty.

• Keepallnuts,boltsandscrewstight.

• AlwaysstopthetractorandraiseGraderBladeto

transportpositionBEFOREchangingbladeangleor

reversingblade.

• Careshouldbetakennotto"hang"theGraderBlade

onsurfaceprojectionssuchascornersofconcrete

driveways.

• LocktractorlifthandleDOWNwheninstallingor

removingGraderBladeonSleeveHitch.

TOWING SAFELY

• Stoppingdistanceincreaseswithspeedandweight

ofattachment.Travelslowlyandallowextratimeand

distancetostop.

• Totaltowingweightmustnotexceedlimitsspeciedin

vehicleoperator'smanual.

KEEP RIDERS OFF HITCH AND ATTACHMENT

• KeepridersoffGraderBladeandattachments.

• RidersonaGraderBladeorattachmentaresubjectto

injury,suchasbeingstruckbyobjectsandbeingthrown

offtheattachmentduringsuddenstarts,stopsandturns.

• Ridersobstructtheoperator'sview,resultinginthe

attachmentbeingusedinanunsafemanner.

KEEP BODY PARTS FROM UNDER Grader Blade

AND ATTACHMENTS

Beforedisconnectingthismachinefromtowingvehiclehitch

plate:

• Stoponlevelground.

• Stoptowingvehicleengine.

• Locktowingvehicleparkbrake.

• Blockwheelsofthemachine.

• MakesurebodypartsarenotunderGraderBladeor

attachments.

L-1434 Rev. B

PARTS REFERENCE

STOP

Installation Questions?

Missing Parts?

Replacement Parts?

Please call Customer Service

Department Toll Free

877.728.8224 or

customerservice@brinly.com

DON’T GO BACK

TO THE STORE!

L-1434 Rev. B

PARTS REFERENCE

Item # Part # Description Qty

1 45M4440P Washer,1-1/4" 1

2 B-1675P Locknut,3/8"-16 1

3 B-2375-10 42"BladeBlack 1

4 B-2376-10 AnglingBarBlack 1

5 B-2578 ClevisPin,7/16"x2-3/8" 1

6 B-3717 VinylGrip 1

7 B-2596-10 BladeMountBlack 1

8 B-5922 BrinlyDecal 1

9 B-4265-10 HitchBlack 1

10 B-4351-10 DrawbarBlack 1

Item # Part # Description Qty

11 2M1620P HexBolt,1/2"x1-1/4" 4

12 10M1216P CarriageBolt,3/8"x1" 4

13 10M1240P CarriageBolt,3/8"x2-1/2" 1

14 30M1200P HexNut,3/8" 4

15 30M1600P HexNut,1/2" 4

16 40M1200P Lockwasher,3/8" 4

17 45M1313P Washer,3/8" 4

18 40M1600P Lockwasher,1/2" 4

19 45M1717P Washer,1/2" 2

20 50M0416P CotterPin,1/8"x1"SS 1

ASSEMBLY

TOOLS REQUIRED:

(1)9/16"Wrench

(2)3/4"Wrenches

(1)PairofSlipJointPliers

(1)Level

1.AssembleBladetoBladeMountasshown.

Assemblehardwareloosely.Youwillfullytighten

inadjustmentsteplater.

2.Installdrawbardownontotheblademountas

shown.

Figure 1

3/8"Washer

Qty.4

3/8"Lockwasher

Qty.4

3/8"x1"CarriageBolt

Qty.4

3/8"HexNut

Qty.4

L-1434 Rev. B

ASSEMBLY

3.InstallLargeFlatWasheroverDrawbarPost.Slide

AnglingLeveroverDrawbarPostandassemblewith

ClevisPinandCotterPininoutermostholes.

4.InstallCarriageBoltandLocknutintoinnermostholes.

5.InstallVinylGripontoLever.

6.AssembleHitchtoDrawbarasshown.

Figure 2

1-1/4"Washer

Qty.1

3/8"Locknut

Qty.1

1/8"x1"CotterPin

Qty.1

ClevisPin

Qty.1

3/8"x2-1/2"CarriageBolt

Qty.1

3/8"Nut

Qty.4

1/2"Lockwasher

Qty.4

1/2"x1-1/4"HexBolt

Qty.4

1/2"Washer

Qty.2

L-1434 Rev. B

ADJUSTMENT

6.Attachthebladetothesleevehitchonyourtractor

usingthemiddleholesinthebladehitch.

7.Positionthetractor(withblade)onahard,levelsurface.

Lowerthebladeandchecktomakesureitislevel,side

toside,andthentightenthe(4)3/8"x1"CarriageBolts

holdingthebladetotheblademount.

8.Placealevelonthetopofthedrawbar.Adjusthitch

assemblyuntildrawbarislevelfronttoback.Tightenthe

(4)1/2"x1-1/4"HexBoltssecurely.

Figure 3

Blade Level Adjustment

(side to side)

(4) 3/8" x 1" Carriage Bolts

Level Drawbar at This Surface

(front to back)

Drawbar Level Adjustment

(front to back)

(4) 1/2" x 1-1/4” Hex Bolts

Point of

Blade Edge

9.Thestabilizerboltsonthehitchshouldbetightened

againsttheyokeondrawbartopreventany"sidesway"

duringtheoperationoftheblade.

10.Theoperatingdepthofthebladeneedstobesetnow.

Makesurethetractorhitchisfreetoallowbladetogo

belowgroundlevel,butstillmaintainingaminimumof5"

transportheightwhenraised.Refertoyourtractorand/or

sleevehitchmanualforanynecessaryadjustments.

OPERATION

MAINTENANCE

Variousbladeangles(leftandright)areobtainedbylifting

lever,rotatingthebladetothedesiredangle,thenlowering

theleverintooneofthelockingholes.

Tousethebladewiththetractorinreversegear,raisethe

lever,rotatetheblade180degreesandlockintothedesired

position.

Therearbladeisdesignedtobeusedinavarietyoflight

jobssuchasleveling,scraping,raking,backlling,snow

removal,etc.

Thetractorspeedwhileoperatingtherearbladeshouldbe

governedbythetasktobeaccomplished.

Whilegrading,donotattempttocutexcessiveamountsof

hardpackedmaterialatahighrateofspeed.

NOTE:Operateataspeedwhichallowsloosematerialthat

haspileduponthefaceofthebladetobedepositedinlow

areas.

Afterthebladeedgehaswornconsiderably,itshould

berotated(frombottomtotop)toprovidea"new"edge.

Removethefour3/8"x1"CarriageBolts,rotatetheblade,

andthenreassembletheunitwiththe"new"edgeonthe

surface.

Lubricateallpivotingpointswithadroportwoof30weight

oil.

L-1434 Rev. B

ThelimitedwarrantysetforthbelowisgivenbyBrinly-Hardy

Companywithrespecttonewmerchandisepurchasedand

usedintheUnitedStates,itspossessionsandterritories.

Brinly-HardyCompanywarrantstheproductslistedbelow

againstdefectsinmaterialandworkmanship,andwillat

itsoption,repairorreplace,freeofcharge,anypartfound

tobedefectiveinmaterialsorworkmanship.Thislimited

warrantyshallonlyapplyifthisproducthasbeenassembled,

operated,andmaintainedinaccordancewiththeOperator’s

manualfurnishedwiththeproduct,andhasnotbeensubject

tomisuse,abuse,commercialuse,neglect,accident,

impropermaintenance,alteration,vandalism,theft,re,

water,ordamagebecauseofotherperilornaturaldisaster.

NormalWearPartsorcomponentsthereofaresubject

toseparatetermsasfollows:Allnormalwearpartsor

componentfailureswillbecoveredontheproductfora

periodof90days.

Partsfoundtobedefectivewithinthewarrantyperiodwill

bereplacedatourexpense.Ourobligationunderthis

warrantyisexpresslylimitedtothereplacementorrepair,

atouroption,ofpartsfoundtobedefectiveinmaterialand

workmanship.

HOW TO OBTAIN SERVICE:Warrantypartsreplacements

areavailable,ONLYWITHPROOFOFPURCHASE,through

ourPullBehindAccessoriesCustomerServiceDepartment.

Call877-728-8224.

Thislimitedwarrantydoesnotprovidecoverageinthe

followingcases:

• Routinemaintenanceitemssuchaslubricantsandlters.

• Normaldeteriorationoftheexteriornishduetouseor

exposure.

• Transportationand/orlaborcharges.

• Thewarrantydoesnotincludecommercialand/orrental

use.

No implied warranty, including any implied warranty

of merchantability of tness for a particular purpose,

applies after the applicable period of express written

warranty above as to the part as identied below.

No other express warranty whether written or oral,

except as mentioned above, given by any person or

entity, including a dealer or retailer, with respect to

any product, shall bind Brinly-Hardy Co. During the

period of the warranty, the exclusive remedy is repair or

replacement of the product as set forth above.

The provisions as set forth in this warranty provide

the sole and exclusive remedy arising from the sale.

Brinly-Hardy Co. shall not be liable for incidental or

consequential loss or damage including, without

limitation, expenses incurred for substitute or

replacement lawn care services or for rental expenses to

temporarily replace a warranted product.

Somestatesdonotallowtheexclusionorlimitationof

incidentalorconsequentialdamages,orlimitationsonhow

longanimpliedwarrantylasts,sotheaboveexclusionsor

limitationsmaynotapplytoyou.

Duringthewarrantyperiod,theexclusiveremedyis

replacementofthepart.Innoeventshallrecoveryofany

kindbegreaterthattheamountofthepurchasepriceofthe

productsold.Alterationofsafetyfeaturesoftheproductshall

voidthiswarranty.Youassumetheriskandliabilityforloss,

damage,orinjurytoyouandyourpropertyand/ortoothers

andtheirpropertyarisingoutofthemisuseorinabilitytouse

thisproduct.

Thislimitedwarrantyshallnotextendtoanyoneotherthan

theoriginalpurchaserortothepersonforwhomitwas

purchasedasagift.

HOW STATE LAW RELATES TO THIS WARRANTY:This

limitedwarrantygivesyouspeciclegalrights,andyoumay

alsohaveotherrightswhichvaryfromstatetostate.

IMPORTANT:TheWarrantyperiodstatedbelowbeginswith

thePROOFOFPURCHASE.Withouttheproofofpurchase,

theWarrantyperiodbeginsfromthedateofmanufacture

determinedbytheserialnumbermanufacturingdate.

Grader Blade WARRANTY PERIOD:

ThewarrantyperiodforthisGraderBladeis2Years.

MANUFACTURER'S LIMITED WARRANTY FOR

Pull Behind Accessories

Brinly-Hardy BB-56 Owner's manual

Brinly-Hardy BB-56 Owner's manual

Brinly-Hardy BB-56 Owner's manual

Related papers

Other documents